Deoxynivalenol concentrations in feed ingredients and swine diets measured by enzyme-linked immunosorbent assay and high-performance liquid chromatography

The objective was to compare deoxynivalenol (DON) concentrations in feed ingredients and commercial swine diets measured by enzyme-linked immunosorbent assay (ELISA) and high-performance liquid chromatography (HPLC). Seventy feed ingredient samples consisted of corn, corn dried distillers grains with solubles, corn gluten feed, corn gluten meal, palm kernel expellers, rice bran, soy hulls, soybean meal, and wheat. Commercial swine diet samples (n = 92) were collected from 23 swine farms of varying regions in Korea and different growth stages of pigs. The DON concentration of all samples was determined in duplicate. Statistical comparisons were performed to compare the analytical methods (ELISA vs. HPLC), diet phases, and regions. The DON concentrations in most ingredients and all diets determined by ELISA method were greater than those determined by HPLC. The DON concentrations determined by the ELISA method were less than 1 mg/kg in all ingredients except corn dried distillers grains with solubles and corn gluten feed, and those determined by the HPLC were less than 0.5 mg/kg in all ingredients. The DON concentrations in complete diets did not vary by region or growth stages of pigs. The DON concentrations in most feed ingredients and commercial swine diets determined by ELISA method are greater than those determined by HPLC, but does not vary by regions in Republic of Korea or pig growth stages.

Optimizing gilt mammary development to increase future milk yield

Sows do not produce enough milk to sustain optimal growth of their litters. This is particularly important when considering the current hyperprolific sow genetic lines. Mammary development needs to be considered to improve potential milk yield. One can only attempt to stimulate mammogenesis during periods when rapid mammary development is already ongoing. There are two such periods before lactation starts, namely, from three months of age until puberty, and from 90 days of gestation until farrowing. Early studies showed that a 20% feed restriction from 90 days of age until puberty drastically reduces mammary parenchymal tissue mass. Yet, in a more recent study, sow milk yield was not altered following a 10% or 20% feed restriction, or a 25% dietary fibre addition from 90 days of age to breeding. This absence of effect was likely due to the greater feed intake of control gilts in that recent study compared with the older studies, and suggested that feed intake of growing gilts can be reduced to 2.7 kg/d (but not 2.1 kg/d) without detrimental effects on future milk yield. During prepuberty, inclusion of the phytoestrogen genistein in the diet increases the number of mammary parenchymal cells. During late gestation, feeding very high energy levels may have detrimental effects on mammary development and subsequent milk production. Feed intake throughout gestation is also important because of its effect on body condition, with gilts that are too thin (< 16 mm backfat thickness) in late gestation showing less mammary development. A 40% increase in lysine intake via inclusion of additional soybean meal to the diet of gilts from days 90 to 110 of gestation increased mammary parenchymal mass by 44%. Increasing circulating concentrations of the growth factor IGF-1 during late gestation also increased mammary parenchymal mass by 22%. Current data clearly demonstrate that feeding management before lactation can be used to enhance mammary development, hence future milk yield.(AU)

Effects of functional oil blend on performance, blood metabolites, organ biometry and intestinal morphometry in nursery piglets / Efeitos da mistura de óleo funcional no desempenho, metabólitos sanguíneos, biometria de órgãos e morfometria intestinal em leitões de creche

This study was conducted to assess the effects of functional oil (FO) blend on performance, blood metabolites, organ biometry and intestinal morphometry in piglets. A total of 128 crossbreed piglets (Landrace × Large White, 64 uncastrated males and 64 females, 21 d of age, and 6.79 ± 1.76 kg BW) were allocated in a randomized complete block design with two dietary treatments: a FO-free (FOF) diet or a diet based on added FO (1,500 mg/kg of diet with castor oil plus cashew nutshell oil). Piglets fed FO showed higher (p ≤ 0.05) average daily feed intake, daily body weight gain and final body weight after 23 d of study. For the total period, piglets fed FO showed greater (p = 0.007) feed conversion ratio. On d 23, higher serum total protein (p = 0.026) and globulin (p = 0.050) concentration, lower liver (p = 0.042) and stomach (p = 0.074) weight, and greater (p = 0.082) villi height (VH) in duodenum were observed in piglets fed FO. Nonetheless, piglets fed FOF showed greater (p = 0.054) ileal VH, but greater (p = 0.004) crypt depth (CD) in jejunum. Piglets fed FO showed higher VH to CD ratio in jejunum (p = 0.068) and duodenum (p = 0.074) on d 23 and 37, respectively. Based on the results, FO blend improved the performance of weaned piglets; however, it negatively affected the feed conversion ratio in the total period. Moreover, FO blend promoted changes in total protein concentrations and improvements in digestive and absorptive capacity assessed through VH to CD ratio, with a significant reduction in organs.

Este estudo foi conduzido para avaliar os efeitos de uma mistura de óleo funcional (OF) no desempenho zootécnico, nos metabólitos sanguíneos, na biometria de órgãos e na morfometria intestinal de leitões. Um total de 128 leitões mestiços (Landrace × Large White, 64 machos inteiros e 64 fêmeas; 21 dias de idade e peso corporal de 6,79 ± 1,76 kg) foram alocados em um delineamento de blocos casualizados completos, com dois tratamentos dietéticos: uma dieta sem OF (SOF) ou uma dieta baseada na adição de OF (1.500 mg/kg de dieta com OF de mamona e castanha de caju). Os leitões alimentados com OF apresentaram maior (p ≤ 0,05) consumo de ração diário médio, ganho de peso corporal diário e peso corporal aos 23 dias de experimento. Entretanto, os leitões que consumiram dietas com OF tiveram conversão alimentar superior (p = 0,007) no período total. No dia 23, houve aumento na concentração de proteína total (p = 0,026) e globulina (p = 0,050), menor peso de fígado (p = 0,042) e estômago (p = 0,074), e maior (p = 0,082) altura de vilosidade (AV) no duodeno em leitões que consumiram OF; entretanto, os leitões SOF tiveram (p = 0,054) AV superior no íleo, mas apresentaram (p = 0,004) profundidade de cripta (PC) superior no jejuno. Uma maior relação AV:PC no jejuno (p = 0,068) e duodeno (p = 0,074) foi observada em leitões com OF nos dias 23 e 37, respectivamente. Com base nos resultados, a mistura de OF melhorou o desempenho dos leitões desmamados; no entanto, afetou negativamente a taxa de conversão alimentar no período total. Além disso, a mistura de OF promoveu alterações nas concentrações proteínas totais e melhorias na capacidade digestiva e absortiva avaliadas através da relação AV:PC, com uma redução significativa nos órgãos.

The use of sugar beet pulp in pig diet to control skatole analysed by HPLC quantification method

This study aimed to determine the efficacy of a finishing diet added with sugar beet pulp to reduce backfat skatole of entire male pigs, using the optimised high-performance liquid chromatographic (HPLC) method. The study comprised 72 males Pietrain (Large White × Landrace), divided into two groups of 36 animals each. Pigs in group A (treatment) were fed a supplemented formula (addition of 10 % beet pulp). while animals in group B (control) received a commercial feed, both for a period of 14 days before slaughter. The isocratic HPLC method achieved the chromatographic separation of indolic compounds in approximately 3 min. Skatole was significantly lower ( p = 0.002) in group A, showing that beet root supplementation reduced skatole levels in pig fat. In addition, the optimised HPLC method was reliable, less time-consuming, and showed a resolution suitable for small amounts of skatole.(AU)

'Beer yeast' (liquid brewery waste) for sheep and pig feeding: epidemiological and clinical aspects of the poisoning, safety margin and prevention / "Levedo de cerveja" (resíduo líquido de cervejaria) para alimentação de ovinos e suínos: aspectos epidemiológicos e clínicos da intoxicação, margem de segurança e prevenção

Considering the practice of using 'brewer's yeast' (BY) - liquid brewery yeast waste from the brewing industry - in animal feed in some establishments in the south of the State of Rio de Janeiro in Brazil, this study was conducted to establish safety margins and to determine epidemiological and clinical aspects. In addition, this study suggested prophylactic measures that can prevent or minimise alcohol intoxication due to BY in sheep and swine. The main characteristics of the clinical features in both natural poisoning and controlled spontaneous ingestion in swine as well as intoxication by controlled ingestion of BY using a ruminal probe in sheep were found to be staggering gait, tripping and falls. Overall, 3.8 and 8.875mL/kg of ethanol content in the BY caused mild-moderate and severe clinical conditions, respectively, in swine and sheep. The following prophylactic measures are suggested: 1. BY must be adequately diluted in water, whey, or with BY that has been previously stored in the property (old BY); 2. It must be administered in proportion to the animals' weight and size. 3. It must be administered continuously, without interruptions, and with the provision of other food in the trough (such as soybean meal or cornmeal and water ad libitum). In conclusion, although BY is increasingly used in sheep and swine breeding properties - in the south of the State of Rio de Janeiro - many owners use one or more of the suggested prophylactic measures. Hence, ethanol intoxications because of BY are infrequent and rarely cause deaths; therefore, BY can be used provided adequate prophylactic measures are followed.

Considerando-se à prática de utilizar "levedo de cerveja" (LC) - resíduo líquido da indústria cervejeira - na alimentação de animais, em alguns estabelecimentos no sul do Estado do Rio de Janeiro, esse estudo foi realizado para estabelecer as margens de segurança e os quadros epidemiológico e clínico, bem como sugerir medidas profiláticas que impeçam ou minimizem esse tipo de intoxicação alcoólica para ovinos e suínos. Verificou-se que o quadro clínico na intoxicação por ingestão controlada de LC por sonda em ovinos e na intoxicação natural e ingestão espontânea controlada em suínos, caracterizou-se principalmente por andar cambaleante, tropeços e quedas. Concentrações de 3,8 e 8,875mL/kg de etanol contido no LC, causaram quadros clínicos leve a moderado e grave em suínos e ovinos, respectivamente. Como medidas profiláticas sugere-se: diluição adequada do LC com água, soro de leite ou com o LC já estocado na propriedade (LC antigo); administração do LC proporcional ao peso/tamanho dos animais, administração contínua, sem interrupções, disponibilizar outro alimento no cocho, como farelo de soja ou fubá de milho e água à vontade. Conclui-se que apesar de o LC ser cada vez mais utilizado nas propriedades criadoras de ovinos e suínos no sul do Estado do Rio de Janeiro já que, muitos proprietários aplicam uma ou mais medidas profiláticas aqui sugeridas, as intoxicações pelo etanol, contido no LC são pouco frequentes e raramente ocorrem mortes, de forma que esse produto deve ser utilizado, desde que as medidas profiláticas sejam observadas.

Complexo enzimático em rações para leitões nas fases pré-inicial e inicial / Enzymatic complex in piglet feeds in the pre-initial and initial phases

Objetivou-se, com este trabalho, avaliar o efeito da utilização de complexo enzimático em rações para leitões sobre o desempenho zootécnico nas fases pré-inicial e inicial. Foram utilizados, para isso, 292 leitões, machos castrados e fêmeas, de linhagem comercial. O período de suplementação da enzima, na maternidade, foi do sétimo ao vigésimo primeiro dia de idade, e, na creche, foi do desmame até a saída para a fase de crescimento. O delineamento utilizado foi inteiramente casualizado, sendo a matriz e sua leitegada consideradas a unidade experimental durante a maternidade e uma baia com dez leitões na creche. Na maternidade, os tratamentos consistiram em: T1 - ração controle, sem complexo enzimático; T2 - ração controle com adição on top do complexo enzimático com inclusão de 5%. Na creche, foram definidos três tratamentos: T1 - ração controle; T2 - ração controle com inclusão on top de 5% do complexo enzimático na fase de maternidade; T3 - ração controle com inclusão de 5% de complexo enzimático nas fases de maternidade e creche. A suplementação durante a lactação não influenciou o desempenho da leitegada na maternidade até o 21º dia. Na creche, leitões alimentados com ração controle apresentaram maior peso inicial em relação aos suplementados na fase de maternidade e creche. Ao término da fase, os leitões mostraram desempenho semelhante, independente da dieta. Conclui-se que a inclusão do complexo enzimático na forma on top em dietas para leitões não influenciou parâmetros de desempenho na maternidade, porém, favoreceu a recuperação de leitões desmamados com menor peso.

This study aimed to evaluate the effect of using an enzymatic complex in piglet feeds on the zootechnical performance in the pre-starter and initial phases. For this purpose, 292 piglets, castrated males and females, of commercial lineage were used. The enzyme supplementation period in the maternity hospital was from the seventh to the twenty-first day of age, and in the nursery, it was from the waning until the exit for the growth phase. The design used was completely randomized, with the mother and her litter considered the experimental unit during maternity and a stall with 10 piglets in the nursery. In maternity, the treatments consisted of: T1 - control feed, without the enzymatic complex; T2 - control diet with on top addition of the enzymatic complex with 5% inclusion. Three treatments were defined at the nursery: T1 - control feed; T2 - control diet with inclusion on top of 5% of the enzymatic complex in the maternity phase; T3 - control feed with the inclusion of 5% enzymatic complex in the maternity and nursery phases. Supplementation during lactation did not influence litter performance in the maternity unit until 21 days. In the nursery, piglets fed with control feed had higher initial weight compared to those supplemented in the maternity and nursery phases. At the end of the phase, the piglets showed similar performance, regardless of diet. It is concluded that the inclusion of the enzymatic complex used in the on top form in diets for piglets did not influence performance parameters in maternity; however, it favored the recovery of weaned piglets with lower weight.

Effect of increasing levels of fat-soluble and water-soluble vitamins on improving performance and plasma vitamin concentration in modern hybrids pig's growth and finishing phase / Efeito do aumento dos níveis de vitaminas lipossolúveis e hidrossolúveis na melhoria do desempenho e na concentração plasmática de vitaminas em suínos híbridos modernos nas fases de crescimento e terminação

The objective was to evaluate the supplementation of fat-soluble and water-soluble vitamins on the performance and plasma concentrations of vitamins in modern hybrids pigs. A total of 144 commercial hybrid castrated male, 43.531 ± 1.099kg, were used in a randomized block design with six treatments, eight replicates and three animals per pen. The experimental treatments were different vitamin supplementation levels - 0, 25, 50, 75, 100, and 125% of the recommended by Rostagno et al. (2011) for male pigs in growth I (40 to 50kg), growth II (50 to 70kg), and finishing I (70 to 90kg) phases. For growth phases I and II, a linear effect (P<0.05) due to increase in vitamin supplementation was observed on performance. For finishing phase I and total phase, a linear effect (P<0.05) was observed with increased final average weight (FAW) and improved feed conversion ratio (FCR). For average daily weight gain (ADWG) and average daily feed intake (ADFI) a quadratic effect was observed (P<0.05). A linear (P<0.05) increase in plasmatic α-tocopherol and B12 was observed with the 125%. Thus, it is concluded that the 125% vitamin supplementation improved performance of modern hybrids pigs (40 to 90kg).

Objetivou-se avaliar a suplementação de vitaminas lipossolúveis e hidrossolúveis sobre o desempenho e as concentrações plasmáticas de vitaminas em suínos híbridos modernos. Um total de 144 híbridos machos castrados, 43,531 ± 1,099kg, foram distribuídos em delineamento de blocos ao acaso, com seis tratamentos, oito repetições e três animais por baia. Os tratamentos foram diferentes níveis de vitaminas - 0, 25, 50, 75, 100 e 125% do recomendado por Rostagno et al. (2011) para suínos machos nas fases de crescimento I (40 a 50kg), crescimento II (50 a 70kg) e terminação I (70 a 90kg). Para as fases de crescimento I e II, observou-se efeito linear (P<0,05) devido ao aumento na suplementação vitamínica sobre o desempenho. Para a fase de terminação I e a fase total, observou-se efeito linear (P<0,05) com o aumento do peso médio final (PMF) e melhoria da conversão alimentar (CA). Já para as variáveis de ganho de peso médio diário (GPMD) e consumo de ração médio diário (CRMD,) observou-se efeito quadrático (P<0,05). Houve aumento linear (P<0,05) em α-tocoferol e cobalamina plasmáticos devido à suplementação de 125%. Assim, conclui-se que a suplementação com 125% de vitaminas melhorou o desempenho de suínos híbridos modernos (40 a 90kg).

Performance and behavior of piglets fed diets with different metabolizable energy levels / Desempenho e comportamento de leitões alimentados com dietas com diferentes níveis de energia metabolizável

This study evaluated the effect of different metabolizable energy (ME) levels in diets on digestibility, performance, and feeding behavior of weaned piglets. A digestibility study to determine ME levels was performed using 12 male piglets with 11.5 ± 0.5 kg body weight (BW), in a cross-over design fed with different ME levels (treatments). In the performance study were used 64 female piglets with 7.5 ± 0.8 kg BW, in a randomized block design with four treatments (3.30, 3.40, 3.50, and 3.60 Mcal.kg-1 ME levels), and feeding program with three phases (pre-initial I, pre-initial II, and initial). For feeding behavior, four pens of each treatment were monitored with cameras. The crude-protein digestibility coefficient reduced as dietary ME level increased (P <0.05). In pre-initial I animal performance was not influenced (P <0.05) by ME diet levels, and in the pre-initial II and initial phases, increases in ME caused quadratic (r² 0.99) and linear (r² 0.99) effects on daily feed intake, respectively. When ME levels increased, feed conversion ratio decreased linearly in the pre-initial II phase (r² =0.98), and quadratically in the initial phase (r²= 0.99). The number and duration of feeder visits linearly decreased as the diet energy levels increased (P <0.05). Weaned piglets can regulate feed intake according to dietary ME levels. The performance of weaned piglets can be maintained using diets containing metabolizable energy levels between 3.30 at 3.60 Mcal.ME.kg-1 if the ratio of nutrients to energy is maintained constant.The feed intake behavior of weaned piglets is influenced by increases in dietary metabolizable energy levels evaluated, resulting in fewer and shorter visits to the feeder.

Este estudo avaliou o efeito de diferentes níveis de energia metabolizável (EM) em dietas sobre a digestibilidade, desempenho e comportamento alimentar de leitões desmamados. Um estudo de digestibilidade para determinação dos níveis de EM foi realizado com 12 leitões machos com 11,5 ± 0,5 kg de peso corporal, em delineamento cruzado, alimentados com diferentes níveis de EM (tratamentos). No estudo de desempenho foram utilizadas 64 leitões fêmeas com peso corporal de 7,5 ± 0,8 kg, em delineamento de blocos casualizados com quatro tratamentos (níveis de 3,30, 3,40, 3,50 e 3,60 Mcal.kg-1 ME), e programa de alimentação com três fases (pré- inicial I, pré-inicial II e inicial). Para o comportamento alimentar, quatro baias de cada tratamento foram monitorados com câmeras. O coeficiente de digestibilidade da proteína bruta diminuiu com o aumento do nível de EM da dieta (P <0,05). No pré-inicial I o desempenho dos animais não foi influenciado (P <0,05) pelos níveis da dieta de EM, e nas fases pré-inicial II e inicial, o aumento de EM causou efeitos quadráticos (r² 0,99) e lineares (r² 0,99) na alimentação diária ingestão, respectivamente. Quando os níveis de EM aumentaram, a conversão alimentar diminuiu linearmente na fase pré-inicial II (r² = 0,98), e quadraticamente na fase inicial (r² = 0,99). O número e a duração das visitas aos comedouros diminuíram linearmente à medida que os níveis de energia da dieta aumentaram (P <0,05). Leitões desmamados podem regular o consumo de ração de acordo com os níveis de EM da dieta, o desempenho de leitões desmamados pode ser mantido usando dietas contendo níveis de energia metabolizável entre 3.30 a 3.60 Mcal.EM.kg-1 se a proporção de nutrientes para energia for mantida constante. O comportamento de consumo de ração de leitões desmamados é influenciado pelo aumento nos níveis de energia metabolizável da dieta avaliados, resultando em menos e mais curtas visitas ao comedouro.

Effect of partially replacing corn with sugar cane molasses on blood parameters and composition of the M. longissimus thoracis of growing pigs / Efeito da substituição parcial do milho por melaço de cana-de-açúcar sobre parâmetros sanguíneos e a composição do músculo longissimus thoracis de suínos em crescimento

The effect of sugar cane molasses, as a partial replacement to corn in the diet, on blood parameters and composition of the M. longissimus thoracis (LT) in growing pigs was explored in this study. Twenty female pigs aged 63 days, and weighing 28.98 ± 3.56 kg, were randomly assigned to either the control or sugar cane molasses treatments. Molasses was included at the 3% level to partially replace corn in their diet. Blood samples were collected at the beginning and end of the experiments. The animals were slaughtered at 110 days of age after 47 days in the experiment, weighing 67.9 ± 5.58 kg, and an LT muscle sample was extracted and evaluated. Each animal was considered an experimental unit. The treatment had no effect on the length and area of the LT muscle. Backfat thickness was reduced when using the sugar cane molasses treatment (5.80 mm) compared to the control treatment (8.90 mm) (P < 0.05). Higher enzyme gamma-glutamyl transferase (GGT) levels were observed in animals of the control treatment (67.10 IU/L) compared to animals treated with the sugar cane molasses treatment (49.90 IU/L) (P < 0.05). Moreover, the proximal composition, fatty acid profile, and quality were not influenced by treatment. Sugar cane molasses, used as an energy source to partially replace corn in the diet of growing pigs at a level of 3%, reduced the backfat thickness of the pig carcass and improved the serum concentration of the enzyme gamma-glutamyl transferase in pigs.(AU)

Neste estudo foi explorado o efeito do melaço de cana-de-açúcar em substituição parcial ao milho na dieta sobre os parâmetros sanguíneos e a composição do músculo longissimus thoracis (LT) de suínos em crescimento. Vinte leitoas com 63 dias de idade, pesando 28,98 ± 3,56 kg foram aleatoriamente distribuídas nos tratamentos controle ou melaço de canade-açúcar. O melaço foi incluído ao nível de 3% em substituição parcial ao milho na dieta. Ao início e ao final do experimento foram coletadas amostras de sangue dos animais. Os animais foram abatidos aos 110 dias de idade após 47 dias de experimento pesando 67,9 ± 5,58 kg e uma amostra do músculo LT foi extraída e avaliada. Cada animal foi considerado uma unidade experimental. Não houve diferença entre os tratamentos sobre o comprimento e a área do músculo LT. A espessura de toucinho foi reduzida ao utilizar o tratamento melaço de cana-de-açúcar (5,80 mm) em relação ao tratamento controle (8,90 mm) (P < 0,05). Níveis mais elevados da enzima gama-glutamil transferase (GGT) foram observados nos animais do tratamento controle (67,10 UI/L) em comparação aos animais do tratamento melaço de cana-de-açucar (49,90 UI/L) (P < 0,05). A composição proximal e o perfil e qualidade dos ácidos graxos não foram influenciados pelo tratamento. O melaço de cana-de-açúcar utilizado como fonte energética em substituição parcial ao milho na dieta de suínos em crescimento ao nível de 3% reduziu a espessura de toucinho da carcaça de suínos e melhorou a concentração sérica da enzima gama-glutamil transferase de suínos.(AU)

Performance and feed preference of weaned piglets fed with corn grain silage subjected to different rehydration sources / Desempenho e preferência alimentar de leitões desmamados alimentados com silagem de grão de milho submetido a diferentes fontes de reidratação

The objective of this study was to evaluate the effects of diets composed of corn grain silage rehydrated with water and acid whey on the productive performance and feed preference of weaned piglets. We evaluated 120 piglets weaned in the pre-initial phase I for productive performance, and diarrhea, depression, and thinness states using the following diets: control ration with dry corn grain (CR); and corn grain silage rehydrated with water (CGSR+W); water and inoculant (CGSR+WI); and acid whey (CGSR+AW). To determine feed preference, 20 weaned piglets received reference (CR) and test (CGSR+AW) diets in two phases, restricted and free-choice. Analysis of variance, chi-square test, and t-test were applied at 5% of significance. There were no differences (p>0.05) in growth performance among piglets fed the four experimental diets. Severe thinness and depression were recorded among piglets fed CGSR+W and CR (p<0.05). In the restricted phase, consumption of CGSR+AW resulted in higher daily feed intake (DFI) (p<0.05), while piglets in the free-choice phase showed a higher DFI and spent more time consuming CR, with a 56.39% preference (p<0.05). Rehydrated corn grain silage promoted feed acceptability and performance of piglets in the first weeks post-weaning.

O objetivo do presente estudo foi avaliar os efeitos de dietas compostas de silagem de grão de milho reidratado com água e soro de leite no desempenho produtivo e preferência alimentar de leitões desmamados. Foram avaliados 120 leitões desmamados durante a fase pré-inicial I para o desempenho de crescimento, escores de diarreia, depressão e magreza submetidos às dietas: grão de milho seco (CR); silagem de grão de milho reidratado com água (CGSR+W); água e inoculante (CGSR+WI); soro de leite (CGSR+AW). Para avaliar a preferência alimentar, 20 leitões desmamados receberam dieta referência (CR) e dieta teste (CGSR+AW) em duas fases, restrita e livre escolha. Foi aplicado análise de variância, teste de qui-quadrado e t-test à 5% de significância. Não houve diferenças (p>0,05) no desempenho de crescimento entre os leitões alimentados com as quatro dietas experimentais. Leitões alimentados com CGSR+W e CR foram severamente magros e apresentaram escore de depressão (p<0,05). Na fase restrita o CDR foi maior para CGSR+AW (p<0.05), enquanto na fase de livre escolha os leitões mostraram maior CDR e passaram maior tempo consumindo a CR, com preferência de 56,39% (p<0.05). A CGSR promoveu melhor aceitabilidade e desempenho dos leitões nas primeiras semanas pós-desmame.

Evaluation of iron dextran application programs to prevent iron deficiency anemia in piglets / Avaliação de programas para aplicação de ferro dextrano na prevenção da anemia ferropriva de leitões

To evaluate the effect of different iron dextran application programs on the performance, fecal score, and skin color of suckling piglets, as well as sow performance, 288 piglets from 24 sows were allocated to four treatments in six replications with 12 piglets per experimental unit, in a block design. The treatments were as follows: T200_000, T200_100, T200_200, and T100_100, whose respective values (in mg) corresponded to the applications of the first dose of iron dextran on the second day of life and of the second dose on the 10th day. Piglets on T200_000 and T200_200 showed the highest feed intake. In the period from 10 to 22 days, piglets receiving T100_100 exhibited the highest fecal score. On the 10th day of age, the lowest lightness (L*) value on the ear was obtained with T200_100, and the highest with T100_100. Treatments T200_000, T200_100, and T200_200 generated the highest red color (a*) intensity on the ear, whereas T100_100 provided the lowest hue and parameter b* values on the leg and snout. On the 22nd day of age, the highest b* and hue values of the ear and snout were found in the group fed T100_100. In conclusion, all evaluated programs were efficient in preventing iron deficiency anemia in newborn piglets. To reduce expenses, we recommend administering a single dose of 200 mg of iron dextran to piglets on the second day of life.(AU)

Foram utilizados 288 leitões de 24 matrizes, distribuídos em delineamento em blocos com quatro tratamentos, seis repetições, com 12 leitões por unidade experimental com objetivo de avaliar diferentes programas de aplicação de ferro dextrano sobre desempenho, escore fecal e coloração de pele de leitões em aleitamento, assim como as repercussões sobre o desempenho das matrizes. Os tratamentos consistiram em: T200_000; T200_100; T200_200; e T100_100; nos quais os valores corresponderam, respectivamente (em mg), à aplicação da primeira dose de ferro dextrano no segundo dia de vida e à aplicação da segunda dose no 10º dia. Os leitões que foram submetidos a T200_000 e a T200_200 tiveram maior consumo de ração. No período de 10 a 22 dias, os leitões de T100_100 obtiveram maior escore fecal. Ao 10º dia de idade dos leitões, o menor valor de luminosidade (L*) da orelha foi em T200_100 e o maior valor em T100_100. A maior intensidade da cor vermelha (a*) na orelha foi obtida em T200_000, T200_100 e T200_200. Na tonalidade e no parâmetro b* do pernil e do focinho, T100_100 foi aquele que apresentou menor valor. No 22º dia de idade dos leitões, o maior valor de b* e da tonalidade da orelha e do focinho foi verificado em T100_100. Conclui-se que todos os programas avaliados foram eficientes na prevenção da anemia ferropriva em leitões neonatos. Visando a redução de gastos, recomenda-se a administração de uma única dose de 200 mg de ferro dextrano no segundo dia de vida dos leitões.(AU)

Dietary net energy mainly affects growth performance and pork quality of finishing pigs

The present study was carried out to evaluate the effect of net energy levels in diets for barrows, from 70 to 100 kg, on performance, plasma parameters and carcass characteristics. Two experiments were carried out: in the first (Experiment I), a metabolism assay was carried out to estimate the net energy (NE) of experimental diets. Twelve crossbred barrows, averaging 85.74 ± 6.80 kg initial body weight, were distributed in a randomized block design with two metabolizable energy (ME) levels (3100 and 3500 kcal kg–¹) with six replicates and one animal per experimental unit. In the second (Experiment II), 45 castrated male pigs were used, averaging 70.10 ± 1.26 kg of initial body weight distributed in a randomized block design, with five NE levels (2345, 2425, 2505, 2585, 2665 kcal kg–¹), nine replicates and one animal per experimental unit. The increase in diet NE levels provided a linear reduction (p ≤ 0.00039) in average daily feed intake (ADFI). There was a quadratic effect on NE efficiency (p ≤ 0.0027), average daily gain (ADG), (p ≤ 0.0352) and the feed:gain ratio (F:G), (p ≤ 0.0024), the optimal levels being estimated at 2485, 2493 and 2533 kcal kg–¹, respectively. Drip loss (DL) decreased (p ≤ 0.0001) as NE levels increased. There was also a linear decrease (p ≤ 0.0462) in the Minolta color parameter (+a*), due to the NE levels. Plasma parameters were not affected (p > 0.05) by NE levels. The dietary net energy levels affected the performance and meat quality of finishing pigs and the level of 2493 kcal kg–¹ provided the best ADG.

Influence of housing air temperature on the behavioural acts, physiological parameters and performance responses of fattening pigs

The objective of the present study was to investigate the influence of housing air temperature on the behavioural acts, physiological parameters and performance responses of fattening pigs. Animals were randomly allocated to 3 groups with 30 heads in each. During eight weeks of fattening, the animals of the two experimental groups were subjected to longterm technological temperature stress, provoked by a significant deviation of the microclimate parameters. The first control group of animals was kept following the Departmental Norms for Technological Design - Agro-Industrial Complex - 02.05 «Pig-breeding enterprises (complexes, farms, small farms)¼ at an air temperature of +17…+21 °C; pigs of the second experimental group were kept at a temperature of - +5…+8 °C, and the third experimental group - +28…+31 °C. During the experiment, the timing of behavioural acts and their index assessment, physiological parameters and productive characteristics of fattening pigs were studied. The experiment results showed that the thermoneutral zone for fattening pigs is + 17… + 21 °C. Animals 2nd experimental group showed less movement (P < 0.001), used huddling for decreasing body heat loss, more feed intake (P < 0.01), which increased its conversion, had reduced HR, RR, RT. Pigs of the 3rd experimental group showed increased movement (P < 0.001). This can be explained by their desire to find a cool place and rest lying on the side, consuming more water, having high HR, RR, and RT, showing signs of hyperthermia and were characterized by low-performance responses.

Prepartum supplementation of soybean oil as an energy source for sows and their litters

The objective of this study was to evaluate the effect of pre-farrowing lipid supplementation for three days on performance parameters of sows and piglets and the survival rate of litters. Four hundred hyperprolific sows were randomly distributed in blocks according to their body condition score, weight, and parity order. Three levels of soybean oil were added on top at the time of feed supply and compared to the control treatment. The levels were: 250 mL, 500 mL, and 1,000 mL, in addition to the control that contained only the crude fat present in the feed (5.04%). Sows were weighed and evaluated for their body condition score at the beginning and end of the lactation period, and their piglets were weighed at birth, after 24 h, and at weaning to determine colostrum yield of the sow and daily weight gain of piglets during the lactation period. Survival rate of litters was also evaluated. Weight loss of gilts decreased linearly as the level of supplemented oil increased. The other parameters evaluated were not affected by treatments, suggesting that the supplemented soybean oil was used for growth rather than milk production of gilts. Additionally, it had no effect on the performance of multiparous females. Under the experimental conditions of this study, soybean oil supplementation for gilts in the first three days before farrowing decrease their weight loss but does not change their body condition score, colostrum yield, and performance and survival of their litters.(AU)

Comparison of chemical composition, energy content, and digestibility of different sources of distillers corn oil and soybean oil for pigs

The objective of this study was to determine and compare the chemical composition; oxidation indicators; ether extract (EE) digestibility; and digestible, metabolizable, and net energy (DE, ME, and NE, respectively) content of distillers corn oil (DCO) from Brazil (CBR) and the United States (CUS), with refined (RSB) and degummed soybean oil (DSB) from Brazil offered to pigs. Fifty crossbred barrows (23.1±3.4 kg body weight) were fed a corn-soybean meal basal diet, or diets composed of 90% basal diet and 10% of one of the four oil sources (CBR, CUS, RSB, or DSB). Pigs were fed an amount of their respective experimental diets equivalent to 2.8 times the maintenance DE requirement for 9 d (sequentially 7 d for adaptation and 2 d for partial collection of feces). Distillers corn oil from Brazil contained lower linoleic acid (47.4%) than CUS (53.9%), RSB (54.2%), and DSB (51.5%), but greater contents of oleic (32.1%) and palmitic (14.6%) acids compared to CUS (27.0 and 12.9%), RSB (22.9 and 11.2%), and DSB (23.5 and 11.2%). The moisture and unsaponifiable contents of CBR (0.17 and 1.64%) and CUS (0.20 and 1.64%) were similar, but greater than the values found for RSB (0.05 and 1.20%) and DSB (0.12 and 1.02%). The anisidine value, free fatty acid content, and acidity of DCO samples were higher than soybean oils. The peroxide value and thiobarbituric reactive substances content increased in the oil samples over time. The apparent total tract digestibility (ATTD) of gross energy and the DE, ME and NE values of the oils did not differ among oil sources and ranged from 87.8 to 91.5%, and from 8280 to 8630, 8139 to 8459, and 7162 to 7444 kcal/kg, respectively. The ATTD of EE was greater in RSB and DSB than for CBR, but similar to CUS. The DCO produced in Brazil is an excellent energy source for pigs, with DE, ME, and NE values similar to those of DCO from the US and soybean oils.(AU)

Dietary net energy mainly affects growth performance and pork quality of finishing pigs

The present study was carried out to evaluate the effect of net energy levels in diets for barrows, from 70 to 100 kg, on performance, plasma parameters and carcass characteristics. Two experiments were carried out: in the first (Experiment I), a metabolism assay was carried out to estimate the net energy (NE) of experimental diets. Twelve crossbred barrows, averaging 85.74 ± 6.80 kg initial body weight, were distributed in a randomized block design with two metabolizable energy (ME) levels (3100 and 3500 kcal kg­1) with six replicates and one animal per experimental unit. In the second (Experiment II), 45 castrated male pigs were used, averaging 70.10 ± 1.26 kg of initial body weight distributed in a randomized block design, with five NE levels (2345, 2425, 2505, 2585, 2665 kcal kg­1), nine replicates and one animal per experimental unit. The increase in diet NE levels provided a linear reduction (p ≤ 0.00039) in average daily feed intake (ADFI). There was a quadratic effect on NE efficiency (p ≤ 0.0027), average daily gain (ADG), (p ≤ 0.0352) and the feed:gain ratio (F:G), (p ≤ 0.0024), the optimal levels being estimated at 2485, 2493 and 2533 kcal kg­1, respectively. Drip loss (DL) decreased (p ≤ 0.0001) as NE levels increased. There was also a linear decrease (p ≤ 0.0462) in the Minolta color parameter (+a*), due to the NE levels. Plasma parameters were not affected (p > 0.05) by NE levels. The dietary net energy levels affected the performance and meat quality of finishing pigs and the level of 2493 kcal kg­1 provided the best ADG.(AU)

Chromium and energy restriction as substitutes for ractopamine in finishing gilts diet / Cromo e restrição energética em substituição a ractopamina na dieta de leitoas em terminação tardia

This study evaluated chromium supplements and energy restriction as substitutes for ractopamine in the diets of late finishing gilts. Sixty gilts were used, with initial weights of 98.87 ± 0.25 kg and final weights of 122.69 ± 10.97 kg, distributed in a randomized block design with five diets: control; yeast chromium (0.8 ppm); chromium picolinate (0.48 ppm); ractopamine (20 ppm) and energy restriction (reduction of 150 kcal of EM kg-1 of feed), with six replicates and two animals per experimental unit. Feeding diet containing ractopamine enabled better (P<0.05) feed conversion and greater weights of the hot carcass of the gilts. The diet containing ractopamine exhibited a lower (P<0.05) cost of feed per kilogram of gain and higher economic efficiency, when compared to diets containing chromium and energy restriction; these exhibited better outcomes, compared to the control diet. Diets supplemented with chromium and ractopamine resulted in a higher (P<0.05) percentage and quantity of lean meat and a higher rate of carcass bonus, when compared to the control diet and energy restriction. The energy reduction did not harm the gilts' responses, compared to the control diet. Ractopamine supplementation allowed for a better feed conversion, lower feed cost per kilogram of gain, and a higher economic efficiency index. Supplements of chromium and ractopamine increased the percentage and quantity of lean meat and the bonus index of the carcasses. Therefore, chromium picolinate and chromium yeast are potential substitutes for ractopamine for optimizing the gilts carcass characteristics.

Realizou-se este estudo com o objetivo de avaliar as suplementações de cromo e a restrição energética em substituição a ractopamina para leitoas em terminação tardia. Foram utilizadas 60 leitoas, com pesos inicial de 98,87±0,25 kg e final de 122,69 ± 10,97 kg, distribuídas em delineamento de blocos ao acaso com cinco dietas: controle; cromo levedura (0,8 ppm); picolinato de cromo (0,48 ppm); ractopamina (20 ppm) e restrição energética (redução de 150 kcal de EMkg-1 de ração), com seis repetições e dois animais por unidade experimental. A dieta contendo ractopamina proporcionou melhor (P<0,05) conversão alimentar e maior peso de carcaça quente das leitoas. A dieta contendo ractopamina apresentou menor (P<0,05) custo de ração por quilograma de ganho e maior índice de eficiência econômica em relação as dietas contendo cromo e restrição energética que, por sua vez, foram superiores em comparação a dieta controle. Dietas suplementadas com cromo e ractopamina apresentaram maior (P<0,05) percentual e quantidade de carne magra e maior índice de bonificação de carcaça em relação a dieta controle e restrição energética. Concluiu-se que a redução energética não prejudica as respostas das leitoas em relação a dieta controle. A suplementação de ractopamina possibilita melhor conversão alimentar, menor custo de ração por quilograma de ganho e maior índice de eficiência econômica. As suplementações de cromo e ractopamina expressam aumento do percentual e quantidade de carne magra e do índice de bonificação das carcaças. O picolinato de cromo e o cromo levedura são potenciais substitutos a ractopamina para otimizar as características de carcaça das leitoas.

Association of porcine circovirus infection with mycotoxicosis: a case report / Infecção por circovírus suíno associado a micotoxicose: relato de caso

Circovirus is widespread in pig farming, and mainly affects piglets increasing morbidity and mortality rates, being vaccination the most effective strategy to control one. However, for an effective vaccine response, certain factors must be considered, such as the adoption of good practices during the conservation and handling of vaccines, environmental challenges, nutritional and health status of the animals, and presence of immunosuppressive agents, such as mycotoxins, in the feed. Here, we describe a circovirus outbreak associated with mycotoxin immunosuppression that occurred in the piglets during the nursery phase at a commercial farm, which initiated with a sudden increase in the mortality of vaccinated piglets. Blood samples were collected and analyzed using RT-PCR, while the feed was subjected to mycotoxicological analysis. RT-PCR analysis revealed the presence of porcine circovirus type 2 (PCV-2) in the blood serum samples, thereby confirming the circovirus outbreak. The feed analysis revealed elevated levels of mycotoxins (deoxynivalenol, aflatoxins, and fumonisins), which were above the levels tolerated by the piglets during the nursery phase. Therefore, the contaminated feed was discarded, and a new ration was made available. Concurrently, the vaccination program was amended to normalize the mortality rate. The presence of mycotoxins in the feed could be the predisposed factor for piglet infection caused by PCV-2 and other diseases. This is an important aspect because the immunosuppressive effect of mycotoxins can alter the vaccine response, thereby making the piglets more susceptible to the diseases even after being vaccinated, although they should be immunologically protected.(AU)

O circovírus é muito difundido na suinocultura e atinge principalmente leitões, aumentando as taxas de morbi-mortalidade, sendo a vacinação a estratégia mais eficaz de controle. No entanto, para uma resposta vacinal eficaz, alguns fato-res devem ser considerados, como a adoção de boas práticas durante a conservação e manuseio de vacinas, desafios ambientais, estado nutricional e de saúde dos animais e presença de agentes imunossupressores, como micotoxinas, na ração. Descreveu-se um surto de circovírus associado à imunossupressão por micotoxinas que ocorreu em leitões durante a fase de creche em uma granja comercial, que começou com um aumento repentino na mortalidade de leitões vacinados. Amostras de sangue foram coletadas e analisadas por RT-PCR, enquanto a ração foi submetida à análise micotoxicológica. A análise de RT-PCR revelou a presença de circovírus suíno tipo 2 (PCV-2), confirmando assim o surto de circovírus. A análise da ração revelou níveis de micotoxinas (desoxinivalenol, aflatoxinas e fumonisinas) acima dos tolerados pelos leitões nesta fase. Portanto, o alimento con-taminado foi descartado e uma nova ração foi disponibilizada. Simultaneamente, o programa de vacinação foi alterado para normalizar a taxa de mortalidade. A presença de micotoxinas na ração pode ser o fator predisponente para infecção de leitões causada por PCV-2 e outras doenças. Esse é um aspecto importante, pois o efeito imunossupressor das micotoxinas pode alte-rar a resposta vacinal, tornando os leitões mais suscetíveis às doenças mesmo após vacinação.(AU)

Eficiência técnica da bandeja economizadora de ração para leitões na fase de creche / Technical efficiency of the feed-saving tray for piglets in the nursery phase / Eficiencia técnica de la bandeja de ahorro de ración para cerdos en fase de levante

A bandeja economizadora de ração é um acessório disponível no mercado, deve ser acoplado em comedouros para suínos com o objetivo de reduzir o desperdício de ração pelos animais. Entretanto pouco se conhece sobre os reais benefícios deste acessório no desempenho de leitões na fase de creche. Com isso, o objetivo deste estudo foi verificar a influência da bandeja economizadora de ração no desempenho zootécnico de leitões na fase de creche. Para isso, foram dispostos um comedouro circular com a bandeja economizadora acoplada (Tratamento 1) e um comedouro retangular (Tratamento 2) em duas baias. Em dois lotes de leitões desmamados aos 28 dias foram medidos o consumo de ração, ganho de peso, ganho de peso médio diário e a conversão alimentar. Os dados obtidos não apresentaram diferença estatística entre os tratamentos. Em conclusão, a bandeja economizadora de ração não influenciou o desempenho zootécnico de leitões na fase de creche. Palavras-chaves: desempenho zootécnico, conversão alimentar, desperdício de ração.

The feed-saving tray is an accessory available on the market, it must be attached to feeders for pigs to reduce feed waste by animals. However, little is known about the real benefits of this accessory in the performance of piglets in the nursery phase. Thus, this study aims to verify the influence of the feed-saving tray on the zootechnical performance of piglets in the nursery phase. For this, a circular feeder with the feed-saving tray coupled (Treatment 1) and a rectangular feeder (Treatment 2) were arranged in two stalls. In two lots of piglets weaned at 28 days, feed intake, weight gain, average daily weight gain and feed conversion were measured. The data obtained showed no statistical difference between treatments. In conclusion, the feed-saving tray did not influence the zootechnical performance of piglets in the nursery phase.

La bandeja de ahorro de ración es un accesorio disponible en el mercado, debe acoplarse a los comederos para cerdos para reducir el desperdicio de alimento por parte de los animales. Sin embargo, poco se sabe sobre los beneficios reales de este accesorio en el rendimiento de los cerdos en fase de levante. Así, el objetivo de este estudio fue verificar la influencia de la bandeja ahorradora de ración en el desempeño zootécnico de cerdos en fase de levante. Para esto, se dispuso un comedero circular con la bandeja de ahorro adjunta (Tratamiento 1) y un comedero rectangular (Tratamiento 2) en dos puestos. En dos lotes de cerdos destetados a los 28 días se midió el consumo de alimento, ganancia de peso, ganancia de peso promedio diaria y conversión alimenticia. Los datos obtenidos no mostraron diferencia estadística entre tratamientos. En conclusión, la bandeja ahorradora de ración no influyó en el desempeño zootécnico de los cerdos en fase de levante.

Maize grain supply and demand for the animal protein chain in the Rio Grande do Sul State, Brazil / Oferta e demanda de milho para a cadeia da proteína animal no Rio Grande do Sul

The animal production system has been affected in the Rio Grande do Sul State by low maize production, mainly non-ruminants. The total demand is not well known and official data are inaccurate and underestimated. This research characterized and analyzed the maize grain demand and supply for animal feed in the last 15 years at the Rio Grande do Sul State. The state supply was obtained from governmental harvests measurement. The demand was obtained by the total animals (swine, poultry and dairy and beef cattle), while the total state demand was obtained using the relative national consumption from these segments in relation to the total. The current maize grain demand was at the order of 6 million tons for the feeding of swine, poultry and cattle, while total demand was between 9 to 12 million tons in the Rio Grande do Sul State. The state maize production supplied near half of the total demand for the animal protein chain, characterizing a significant deficit for this sector, providing instability and making this productive chain economically unfeasible in the state.

Os sistemas de produção animal tem sido severamente afetada no estado do Rio Grande do Sul pela baixa oferta de milho produzido a nível estadual, especialmente não-ruminantes. A demanda do setor não é conhecida e as estimativas oficiais são imprecisas e subestimadas. Assim, o objetivo deste trabalho foi caracterizar e analisar a demanda e a oferta do milho produzido no estado para a alimentação animal nos últimos 15 anos. A oferta estadual foi obtida pelo acompanhamento governamental das safras. A demanda por segmento (aves, suínos e bovino de leite e corte) foi obtida pelo tamanho do rebanho gaúcho, enquanto que a demanda total foi utilizando a mesma proporção do consumo nacional de milho em relação aos segmentos avaliados. A demanda atual de milho para a alimentação de suínos, aves e bovinos no Rio Grande do Sul é da ordem de 6 milhões de toneladas e a demanda total do estado situa-se entre 9 a 12 milhões de toneladas. A oferta estadual de milho supre pouco mais da metade da necessidade para a cadeia da proteína animal, caracterizando um déficit significativo para este setor, proporcionando instabilidade e inviabilizando economicamente esta cadeia produtiva no estado, uma vez que há alta demanda de importação de milho de outros estados.