Outbreak of Escherichia coli O157:H7 Infections Linked to Aged Raw Milk Gouda Cheese, Canada, 2013.

Between 12 July and 29 September 2013, 29 individuals in five Canadian provinces became ill following infection with the same strain of Escherichia coli O157:H7 as defined by molecular typing results. Five case patients were hospitalized, and one died. Twenty-six case patients (90%) reported eating Gouda cheese originating from a dairy plant in British Columbia. All of the 22 case patients with sufficient product details available reported consuming Gouda cheese made with raw milk; this cheese had been produced between March and July 2013 and was aged for a minimum of 60 days. The outbreak strain was isolated from the implicated Gouda cheese, including one core sample obtained from an intact cheese wheel 83 days after production. The findings indicate that raw milk was the primary source of the E. coli O157:H7, which persisted through production and the minimum 60-day aging period. This outbreak is the third caused by E. coli O157:H7 traced to Gouda cheese made with raw milk in North America. These findings provide further evidence that a 60-day ripening period cannot ensure die-off of pathogens that might be present in raw milk Gouda cheese after production and have triggered an evaluation of processing conditions, physicochemical parameters, and options to mitigate the risk of E. coli O157:H7 infection associated with raw milk Gouda cheese produced in Canada.

Inhibitory effects of microencapsulated allyl isothiocyanate (AIT) against Escherichia coli O157:H7 in refrigerated, nitrogen packed, finely chopped beef.

Allyl isothiocyanate (AIT) is an effective inhibitor of various pathogens, but its use in the food industry is limited by its volatility and pungency. The objective of this study was to overcome the volatility of AIT by microencapsulation and evaluate its antimicrobial effectiveness against Escherichia coli O157:H7 in chopped beef. Chopped beef was aseptically prepared and inoculated with a five-strain cocktail of E. coli O157:H7 to yield 4 or 8 log10 cfu/g. AIT was microencapsulated in gum acacia to yield 3.7-54.8 mg AIT/g at a ratio of 1:4 and freeze dried. Microcapsules at 5% or 10% (w/w) were then added to experimental samples that were packed under nitrogen, and stored at 4 degrees C for 18 days. Samples were analyzed for numbers of E. coli O157:H7 and the aerobic mesophilic bacteria (TAC) at 3-day intervals. AIT at 4980 ppm eliminated both low and high levels of inoculated E. coli O157:H7 after 15 and 18 days of storage, respectively. AIT at 2828 ppm reduced E. coli by 2.7 log10 cfu/g by 18 days of storage. AIT levels <1000 ppm were not more effective in reducing E. coli survival than the control treatment without AIT addition. AIT at 170-1480 ppm had negligible effects on the TAC, and while 4980 ppm kept TAC levels

Elimination of Escherichia coli O157:H7 from fermented dry sausages at an organoleptically acceptable level of microencapsulated allyl isothiocyanate.

Four sausage batters (17.59% beef, 60.67% pork, and 17.59% pork fat) were inoculated with two commercial starter culture organisms (>7 log(10) CFU/g Pediococcus pentosaceus and 6 log(10) CFU/g Staphylococcus carnosus) and a five-strain cocktail of nonpathogenic variants of Escherichia coli O157:H7 to yield 6 to 7 log(10) CFU/g. Microencapsulated allyl isothiocyanate (AIT) was added to three batters at 500, 750, or 1,000 ppm to determine its antimicrobial effects. For sensory analysis, separate batches with starter cultures and 0, 500, or 750 ppm microencapsulated AIT were produced. Sausages were fermented at < or =26 degrees C and 88% relative humidity (RH) for 72 h. Subsequently sausages were dried at 75% RH and 13 degrees C for at least 25 days. The water activity (a(w)), pH, and levels of starter cultures, E. coli O157:H7, and total bacteria were monitored during fermentation and drying. All sausages showed changes in the initial pH from 5.57 to 4.89 and in a(w) from 0.96 to 0.89 by the end of fermentation and drying, respectively. Starter culture numbers were reduced during sausage maturation, but there was no effect of AIT on meat pH reduction. E. coli O157:H7 was reduced by 6.5 log(10) CFU/g in sausages containing 750 and 1,000 ppm AIT after 21 and 16 days of processing, respectively. E. coli O157:H7 numbers were reduced by 4.75 log(10) CFU/g after 28 days of processing in treatments with 500 ppm AIT, and the organism was not recovered from this treatment beyond 40 days. During sensory evaluation, sausages containing 500 ppm AIT were considered acceptable although slightly spicy by panelists.