Compost Dairy Barn Layout and Management Recommendations in Kentucky: A Descriptive Study.

This study was conducted to describe the building layout and dimensions, characterize the bedding material, and observe the management practices in 42 compost-bedded pack (CBP) barns in Kentucky (USA). The average herd size found in the study was 90 cows and the breeds consisted of Jersey (6.8%), Holstein (72.7%), and mixed (20.5%). The average CBP barn dimensions were 49.1 m (length) by 21.9 m (width). Many of these barns had feed alleys and driveways; overshot ridges with frequent orientation from NE to SW; and green sawdust, kiln-dried sawdust, or a mixture of both as the most common bedding materials. The bed-turning process was performed mechanically at depths of less than 0.25 m, and the loading of fresh material was performed every one to five weeks, varying by season, weather conditions, barn size, and cow density. The average bedding moisture content was found to be 59.0% (wet bulb-w.b.) and ranged from 36.2 to 71.8%. Coliforms were not present in barns that had a higher compost temperature, and the E. coli, Bacillus, and Streptococcus counts were higher in the barns that had a lower moisture content. In conclusion, it was observed that heterogeneous management was used among the barns and that the producers were satisfied with the compost barn system.

Determination of Thermal, Chemical and Physical Properties of Bedding Materials for Compost Dairy Barns.

The thermal, chemical, and physical properties of compost bedding materials play an important role in every phase of compost production. Based on this, we aimed to assess the thermal, chemical and physical properties of bedding materials for compost-bedded pack (CBP) barns. The database for this study was registered from 42 CBP barns, distributed throughout the state of Kentucky (USA). The thermal conductivity showed a linear relationship with moisture content and bulk density, while thermal resistivity decreased with increasing particle size. The bedding moisture average was 46.8% (±11.5). The average finer index (p < 0.05) was the highest weight percentage (30.1%) in the samples studied. Water-holding capacity (WHC) increased with increasingly fine particle size. The higher bulk density value was 3.6 times that of the lowest bulk density value. The chemical characterization of the bedding material provided the following results: 42.7% (±3.8%) C, 1.6% (±0.4%) N, and 28.2 (±8.0) C:N ratio. However, thermal properties are strongly dependent on particle size. Producers can use the bedding material as fertilizer in their crops, due to the chemical characteristics of the materials. Beds with good physical and chemical properties improve their moisture content.

Moisture effects on greenhouse gases generation in nitrifying gas-phase compost biofilters.

Gas-phase compost biofilters are extensively used in concentrated animal feeding operations to remove odors and, in some cases, ammonia from air sources. The expected biochemical pathway for these predominantly aerobic systems is nitrification. However, non-uniform media with low oxygen levels can shift biofilter microbial pathways to denitrification, a source of greenhouse gases. Several factors contribute to the formation of anoxic/anaerobic zones: media aging, media and particle structure, air velocity distribution, compaction, biofilm thickness, and moisture content (MC) distribution. The present work studies the effects of media moisture conditions on ammonia (NH(3)) removal and greenhouse gas generation (nitrous oxide, N(2)O and methane, CH(4)) for gas-phase compost biofilters subject to a 100-day controlled drying process. Continuous recordings were made for the three gases and water vapor (2.21-h sampling cycle, each cycle consisted of three gas species, and water vapor, for a total of 10,050 data points). Media moisture conditions were classified into three corresponding media drying rate (DR) stages: Constant DR (wetter media), falling DR, and stable-dry system. The first-half of the constant DR period (0-750 h; MC=65-52%, w.b.) facilitated high NH(3) removal rates, but higher N(2)O generation and no CH(4) generation. At the drier stages of the constant DR (750-950 h; MC=52-48%, w.b.) NH(3) removal remained high but N(2)O net generation decreased to near zero. In the falling DR stage (1200-1480 h; MC=44-13%) N(2)O generation decreased, CH(4) increased, and NH(3) was no longer removed. No ammonia removal or greenhouse gas generation was observed in the stable-dry system (1500-2500 h; MC=13%). These results indicate that media should remain toward the drier region of the constant DR (in close proximity to the falling DR stage; MC=50%, approx.), to maintain high levels of NH(3) removal, reduced levels of N(2)O generation, and nullify levels of CH(4) generation.