Polymerase Chain Reaction-Based Prevalence of Serogroups of Escherichia coli Known to Carry Shiga Toxin Genes in Feces of Finisher Pigs.

Shiga toxin-producing Escherichia coli (STEC) are major foodborne pathogens and seven serogroups, O26, O45, O103, O111, O121, O145, and O157, that account for the majority of the STEC-associated illness in humans. Similar to cattle, swine also harbor STEC and shed them in the feces and can be a source of human STEC infections. Information on the prevalence of STEC in swine feces is limited. Therefore, our objective was to utilize polymerase chain reaction (PCR) assays to determine prevalence of major virulence genes and serogroups of STEC. Fecal samples (n = 598), collected from finisher pigs within 3 weeks before marketing in 10 pig flows located in 8 states, were included in the study. Samples enriched in E. coli broth were subjected to a real-time PCR assay targeting three virulence genes, Shiga toxin 1 (stx1), Shiga toxin 2 (stx2), and intimin (eae), which encode for Shiga toxins 1 and 2, and intimin, respectively. A novel PCR assay was designed and validated to detect serogroups, O8, O20, O59, O86, O91, O100, O120, and O174, previously reported to be commonly present in swine feces. In addition, enriched fecal samples positive for Shiga toxin genes were subjected to a multiplex PCR assay targeting O26, O45, O103, O104, O111, O121, O145, and O157 serogroups implicated in human clinical infections. Of the 598 fecal samples tested by real-time PCR, 25.9%, 65.1%, and 67% were positive for stx1, stx2, and eae, respectively. The novel eight-plex PCR assay indicated the predominant prevalence of O8 (88.6%), O86 (35.5%), O174 (24.1%), O100 (20.2%), and O91 (15.6%) serogroups. Among the seven serogroups relevant to human infections, three serogroups, O121 (17.6%), O157 (14%), and O26 (11%) were predominant. PCR-based detection indicated high prevalence of Shiga toxin genes and serogroups that are known to carry Shiga toxin genes, including serogroups commonly prevalent in cattle feces and implicated in human infections and in edema disease in swine.

Infectious Dose of African Swine Fever Virus When Consumed Naturally in Liquid or Feed.

African swine fever virus (ASFV) is a contagious, rapidly spreading, transboundary animal disease and a major threat to pork production globally. Although plant-based feed has been identified as a potential route for virus introduction onto swine farms, little is known about the risks for ASFV transmission in feed. We aimed to determine the minimum and median infectious doses of the Georgia 2007 strain of ASFV through oral exposure during natural drinking and feeding behaviors. The minimum infectious dose of ASFV in liquid was 100 50% tissue culture infectious dose (TCID50), compared with 104 TCID50 in feed. The median infectious dose was 101.0 TCID50 for liquid and 106.8 TCID50 for feed. Our findings demonstrate that ASFV Georgia 2007 can easily be transmitted orally, although higher doses are required for infection in plant-based feed. These data provide important information that can be incorporated into risk models for ASFV transmission.

Effects of Tylosin Administration Routes on the Prevalence of Antimicrobial Resistance Among Fecal Enterococci of Finishing Swine.

Antibiotics can be administered orally or parenterally in swine production, which may influence antimicrobial resistance (AMR) development in gut bacteria. A total of 40 barrows and 40 gilts were used to determine the effects of tylosin administration route on growth performance and fecal enterococcal AMR. The antibiotic treatments followed Food and Drug Administration label directions and were as follows: (1) no antibiotic (CON), (2) 110 mg tylosin per kg feed for 21 d (IN-FEED), (3) 8.82 mg tylosin per kg body weight through intramuscular injection twice daily for the first 3 d of each week for 3 weeks (IM), and (4) 66 mg tylosin per liter of drinking water (IN-WATER). Antibiotics were administered during d 0 to 21 and all pigs were then fed the CON diet from d 21 to 35. Fecal samples were collected on d 0, 21, and 35. Antimicrobial susceptibility was determined by microbroth dilution method. No evidence of route × sex interaction (p > 0.55) was observed for growth performance. From d 0 to 21, pigs receiving CON and IN-FEED had greater (p < 0.05) average daily gain (ADG) than those receiving IM, with the IN-WATER group showing intermediate ADG. Pigs receiving CON had greater (p < 0.05) gain-to-feed ratio (G:F) than IM and IN-WATER, but were not different from pigs receiving IN-FEED. Overall, enterococcal isolates collected from pigs receiving IN-FEED or IM were more resistant (p < 0.05) to erythromycin and tylosin than CON and IN-WATER groups. Regardless of administration route, the estimated probability of AMR to these two antibiotics was greater on d 21 and 35 than on d 0. In summary, IM tylosin decreased ADG and G:F in finishing pigs, which may be because of a response to the handling during injection administration. Tylosin administration through injection and feed resulted in greater probability of enterococcal AMR to erythromycin and tylosin compared with in-water treatment.

Nasal carriage of mecA-positive methicillin-resistant Staphylococcus aureus in pigs exhibits dose-response to zinc supplementation.

Zinc (Zn) is often supplemented at elevated concentrations in swine diets, particularly in piglets, to prevent enteric infections and promote growth. Previous studies from Denmark have suggested a genetic linkage and a phenotypic association between Zn resistance, encoded by czrC, and methicillin-resistance conferred by mecA in Staphylococcus aureus. Such an association has not been reported in the U.S. swine population. We conducted an analysis of the effects of Zn, supplemented as zinc oxide (ZnO), on the nasal carriage of methicillin-resistant Staphylococcus aureus (MRSA) in nursery (n=40) and finisher pigs (n=40) enrolled in a nutritional study. Nasal swabs, collected from nursery and finisher pigs, were inoculated onto MRSA CHROMagar and presumptive MRSA colonies were tested for the presence of mecA and czrC genes by polymerase chain reaction. Zinc susceptibility was determined by the agar dilution method. The prevalence of mecA-positive MRSA was 10% (4/40) and 20% (8/40) among nursery and finisher pigs, respectively. Of the 12 mecA-positive S. aureus isolates, 7 had the czrC gene (58.3%) compared to none among the 68 mecA-negative isolates. The presence of both mecA (p=0.002) and czrC (p=0.006) genes were positively associated with higher levels of Zn supplementation. The median minimum inhibitory concentrations of Zn for czrC-positive and czrC-negative isolates were 12 and 2 mM, respectively (p<0.0001). The link between czrC and mecA genes suggests the importance of elevated Zn supplementation in the co-selection and propagation of methicillin resistance among S. aureus in pigs.

Effects of In-Feed Copper, Chlortetracycline, and Tylosin on the Prevalence of Transferable Copper Resistance Gene, tcrB, Among Fecal Enterococci of Weaned Piglets.

Heavy metals, such as copper, are increasingly supplemented in swine diets as an alternative to antibiotics to promote growth. Enterococci, a common gut commensal, acquire plasmid-borne, transferable copper resistance (tcrB) gene-mediated resistance to copper. The plasmid also carried resistance genes to tetracyclines and macrolides. The potential genetic link between copper and antibiotic resistance suggests that copper supplementation may exert a selection pressure for antimicrobial resistance. Therefore, a longitudinal study was conducted to investigate the effects of in-feed copper, chlortetracycline, and tylosin alone or in combination on the selection and co-selection of antimicrobial-resistant enterococci. The study included 240 weaned piglets assigned randomly to 6 dietary treatment groups: control, copper, chlortetracycline, tylosin, copper and chlortetracycline, and copper and tylosin. Feces were collected before (day 0), during (days 7, 14, 21), and after (days 28 and 35) initiating treatment, and enterococcal isolates were obtained from each fecal sample and tested for genotypic and phenotypic resistance to copper and antibiotics. A total of 2592 enterococcal isolates were tested for tcrB by polymerase chain reaction. The overall prevalence of tcrB-positive enterococci was 14.3% (372/2592). Among the tcrB-positive isolates, 331 were Enterococcus faecium and 41 were E. faecalis. All tcrB-positive isolates contained both erm(B) and tet(M) genes. The median minimum inhibitory concentration of copper for tcrB-negative and tcrB-positive enterococci was 6 and 18 mM, respectively. The majority of isolates (95/100) were resistant to multiple antibiotics. In conclusion, supplementing copper or antibiotics alone did not increase copper-resistant enterococci; however, supplementing antibiotics with copper increased the prevalence of the tcrB gene among fecal enterococci of piglets.

Sampling and detection of African swine fever virus within a feed manufacturing and swine production system.

Transmission of biological hazards capable of causing disease in livestock can occur through a wide variety of direct and indirect routes. In swine production, there are a large number of possible routes of exposure of a pathogen into a susceptible population. African swine fever virus (ASFV) has been a significant challenge for Southeast Asia since first detected in China in 2018 and has spread through many countries within the region. In order to understand potential transmission pathways within an ASFV endemic region, a diagnostic investigation was performed to determine the level of contamination on a wide variety of surface types within a live animal production, feed manufacturing, and feed distribution system located in Vietnam. All diagnostic testing was performed locally by the production system's internal diagnostic laboratory using real-time polymerase chain reaction (rt-PCR) analysis. Early in the diagnostic investigation, it became clear that feed trucks were a common site of ASFV surface contamination detection. This information resulted in biosecurity-focused actions for feed trucks arriving back at the feed mill, including decontamination of interior truck cab surfaces and washing of exterior truck surfaces with high-pressure water prior to application of surface disinfectants. Additionally, a low number of rt-PCR positive samples were detected within the feed production system, with the greatest number coming from transient surfaces such as high traffic areas and worker clothing. This illustrates the importance of managing employee traffic through procedures such as zoning and separation between clean-dirty areas to reduce the likelihood of pathogen transmission. In conclusion, this report illustrates the importance of routine data capture regarding efficacy of biosecurity procedures which allows for real-time updates and improvement as biosecurity gaps are identified.

Differences in carcass chilling rate underlie differences in sensory traits of pork chops from pigs with heavier carcass weights.

Pork hot carcass weights (HCW) have been increasing 0.6 kg per year, and if they continue to increase at this rate, they are projected to reach an average weight of 118 kg by the year 2050. This projection in weight is a concern for pork packers and processors given the challenges in product quality from heavier carcasses of broiler chickens. However, previous work demonstrated that pork chops from heavier carcasses were more tender than those from lighter carcasses. Therefore, the objective was to determine the effects of pork hot carcass weights, ranging from 90 to 145 kg with an average of 119 kg, on slice shear force and sensory traits of Longissimus dorsi chops when cooked to 63 or 71 °C, and to assess if differences in chilling rate can explain differences in sensory traits. Carcasses were categorized retrospectively into fast, medium, or slow chilling-rates based on their chilling rate during the first 17 h postmortem. Loin chops cut from 95 boneless loins were cooked to either 63 or 71 °C and evaluated for slice shear force and trained sensory panel traits (tenderness, juiciness, and flavor) using two different research laboratories. Slopes of regression lines and coefficients of determination between HCW and sensory traits were calculated using the REG procedure in SAS and considered different from 0 at P ≤ 0.05. As hot carcass weight increased, chops became more tender as evidenced by a decrease in SSF (63 °C ß = -0.0412, P = 0.01; 71 °C ß = -0.1005, P < 0.001). Furthermore, HCW explained 25% (R2 = 0.2536) of the variation in chilling rate during the first 5 h of chilling and 32% (R2 = 0.3205) of the variation in chilling rate from 5 to 13 h postmortem. Slow- and medium-rate chilling carcasses were approximately 12 kg heavier (P < 0.05) than fast chilling carcasses. Slice shear force of chops cooked to 63 and 71 °C was reduced in slow and medium chilling compared with fast chilling carcasses. Carcass temperature at 5 h postmortem explained the greatest portion of variation (R2 = 0.071) in slice shear force of chops cooked to 63 °C. These results suggest that carcasses tend to chill slower as weight increases, which resulted in slight improvements in sensory traits of boneless pork chops regardless of final degree of doneness cooking temperature.

Pork carcass weights have increased year over year for at least the past 25 yr. The poultry industry has experienced similar increases in carcass weights in the recent past. The increases in broiler carcass weights have resulted in detrimental impacts on quality. Contrary to the poultry industry, increases in pork carcass weights have resulted in a general improvement in pork quality, including tenderness. The underlying cause of these improvements has not been explained. In the present study, chilling rate was associated with carcass weights, particularly during the first 5 h postmortem. In fact, carcass temperature measured in the Longissimus dorsi muscle at 5 h postmortem was the most predictive of instrumental tenderness values when boneless pork chops were cooked according to UDSA guidelines for whole-muscle pork products. The metabolic conversion of muscle to meat is most active during this initial chilling period. Therefore, chilling rate, which is associated with carcass weight, may be influencing the conversion of muscle to meat and provide some explanation as to why heavy carcasses result in more tender pork chops.

Effects of feeding diets containing low crude protein and coarse wheat bran as alternatives to zinc oxide in nursery pig diets.

Two experiments were conducted to determine the effects of crude protein (CP) level in diets containing coarse wheat bran (CWB) with or without pharmacological levels of Zn (provided by zinc oxide: ZnO) on growth performance and fecal DM of nursery pigs. In experiment 1, 360 barrows (Line 200 × 400, DNA, Columbus, NE, initially 5.6 kg) were allotted to 1 of 6 dietary treatments from d 0 to 21 after weaning with 5 pigs per pen and 12 pens per treatment. Treatments included a positive control diet (21% CP) with 3,000 mg/kg Zn in phase 1 and 2,000 mg/kg in phase 2; negative control (21% CP) with 110 mg/kg added Zn, and 4 diets containing 4% CWB and 110 mg/kg added Zn formulated to contain 21%, 19.5%, 18%, or 16.5% CP. The 2 control diets and 21% CP CWB diet contained 1.40% standardized ileal digestible (SID) Lys in phase 1 and 1.35% SID Lys in phase 2, while the 19.5%, 18%, and 16.5% CP diets contained 1.33, 1.25 and 1.20% Lys, respectively, in both phases. Pigs fed the positive control diet containing pharmacological ZnO had increased (P < 0.05) ADG and G:F compared with the negative control and the 21% CP CWB diet. Reducing CP (concurrently with SID Lys) in diets containing CWB decreased ADG and G:F (linear, P = 0.002); however, fecal DM increased (linear, P = 0.005). In experiment 2, two groups of 300 and 350 pigs, initially 7.0 and 6.2 kg, respectively, were used with 5 pigs per pen and 26 pens per treatment. The objective was to determine if adding back essential AA would improve growth performance of pigs fed the low CP diets. All dietary treatments were fed for 13 days, contained 4% CWB, and consisted of: (1) positive control with 2,000 mg/kg of Zn and 21% CP (1.35% SID Lys); (2) no ZnO and 21% CP; and 3 diets with no ZnO formulated to 18% CP and (3) 1.2% SID Lys; (4) 1.35% SID Lys by the addition of feed grade amino acids (AA), and (5) diet 4 with non-essential amino acids (NEAA; Gly and Glu). Pigs fed 21% CP with ZnO had increased (P = 0.001) ADG compared to those fed 18% CP (1.35% SID Lys) with high levels of feed grade amino acids or those fed the reduced SID Lys (1.2%) diet. Overall, G:F was improved (P < 0.001) for pigs fed 21% CP diets and those fed the 18% CP diet with NEAA compared to pigs fed 1.2% SID Lys and pigs fed high levels of feed grade amino acids. Fecal DM was increased for pigs fed the reduced SID Lys diet. In summary, pharmacological levels of Zn improve pig growth performance, but reducing CP (and subsequently SID Lys) decreased nursery pig growth performance.

Evaluation of Enogen Feed Corn on growth performance and carcass characteristics of finishing pigs.

Enogen Feed Corn (EFC; Syngenta Seeds, LLC, Downers Grove, IL) hybrids contain a trait for expression of heat-stable α-amylase in the grain. α-Amylase is an enzyme responsible for breakdown of starch in the small intestine; supplementation of exogenous α-amylase to pigs may result in greater starch digestibility and thus improved gain efficiency. A total of 288 pigs (Line 600 × 241, DNA, Columbus, NE; initially 41.6 kg) were utilized in an 82-d trial to determine if replacing conventional yellow dent corn (CONV) with EFC in diets with or without distillers dried grains with solubles (DDGS) influences growth performance and carcass characteristics. Pens of pigs were randomly assigned to one of four dietary treatments balancing for initial body weight. There were nine pens per treatment with eight pigs per pen (an equal number of barrows and gilts per pen). Treatments were arranged in a 2 × 2 factorial with main effects of corn source (CONV or EFC) and DDGS (0% or 25%). Experimental diets were fed in meal form in three phases: days 0 to 29, 29 to 47, and 47 to 82. Pigs were weighed approximately every 2 wk and at the beginning of each phase. On day 82, pigs were transported to a commercial abattoir for processing and carcass data collection. Data were analyzed using PROC GLIMMIX procedure of SAS with pen as the experimental unit. There were no corn source by DDGS interactions (P > 0.05) observed for overall performance or carcass characteristics. Overall, average daily gain (ADG) was marginally greater (P < 0.089) for pigs fed EFC than CONV with no evidence (P > 0.196) for difference in average daily feed intake (ADFI), gain:feed ratio (G:F), hot carcass weight (HCW), or other carcass traits. Addition of DDGS decreased (P < 0.047) overall ADG and G:F. Pigs fed DDGS had marginally lower (P < 0.071) HCW, less (P < 0.050) backfat depth, greater (P < 0.026) loin depth, and greater (P < 0.020) percentage lean and carcass fat iodine value (IV). In summary, addition of 25% DDGS to the diet decreased ADG and increased carcass fat IV. Pigs fed EFC tended to have improved overall ADG; however, G:F and carcass characteristics were not different between corn sources. These results suggest that EFC, although not beneficial, may be used as a substitute for CONV without any deleterious effects on growth performance. Further research should be conducted to understand whether addition of EFC to swine diets could be beneficial in younger pigs exhibiting decreased pancreatic α-amylase secretion following weaning or whether heat treatment of diets, such as pelleting, may influence the response to EFC.

Determining the effects of manganese source and level on growth performance and carcass characteristics of growing-finishing pigs.

Two experiments were conducted to determine the effects of Mn source and level on finishing pig growth performance and carcass characteristics. Dietary treatments were arranged in a 2 × 3 factorial with main effects of Mn source (MnSO4; Eurochem, Veracruz, Mexico, or Mn hydroxychloride (IBM); Micronutrients, Indianapolis, IN) and increasing added Mn (8, 16, and 32 mg/kg of complete diet). The trace mineral premix was formulated without added Mn. Copper was added to all diets at 10 and 150 mg/kg in Exp. 1 and 2, respectively. In both experiments, 1,994 pigs (PIC; 337 × 1050; initially 34.5 ± 0.50 and 40.0 ± 0.77 kg) were used with 27 pigs per pen and 12 replicates per treatment. Diets were corn-soybean meal-distillers dried grains with solubles-based and were fed in four phases. In Exp. 1, there was a marginal Mn source × level interaction (quadratic, Ρ = 0.057) for overall feed efficiency (G:F), with a decrease then increase in pigs fed IBM, but G:F increased with increasing Mn from MnSO4. There was no evidence for Mn source differences for average daily gain (ADG), average daily feed intake (ADFI), or body weight (BW), but pigs fed 16 mg/kg Mn, regardless of source, tended to have decreased (quadratic, Ρ < 0.05) ADG and final BW compared with other levels. For carcass yield, there was a tendency for Mn source × level interaction (quadratic, Ρ = 0.075), where carcass yield did not change by increasing MnSO4 but was greatest for 16 mg/kg Mn from IBM. Loin depth increased (source × level, Ρ = 0.041) for pigs fed increasing Mn from MnSO4 but decreased when Mn was increased from IBM. Pigs fed the intermediate level of Mn tended to have the lightest HCW (quadratic, Ρ = 0.071) and decreased loin depth (quadratic, Ρ = 0.044). Liver Mn concentration increased (linear, Ρ = 0.015) as added Mn increased and tended to be greater (P = 0.075) when supplied by MnSO4 compared with IBM. In Exp. 2, there was no (P > 0.10) Mn source × level interaction observed for ADG, ADFI, and G:F. Pigs fed IBM had increased (P < 0.05) final BW, ADG, and ADFI compared with pigs fed MnSO4. Pigs fed 16 mg/kg of Mn tended (P = 0.088) to have reduced ADFI when compared with pigs fed 8 and 32 mg/kg of Mn. In conclusion, there appears to be little benefit in growth performance by feeding more than 8 mg/kg of added Mn. When high levels of Cu were fed in Exp. 2, pigs fed IBM had improved growth performance when compared with those fed MnSO4. Further research is needed to understand the potential benefits of Mn hydroxychloride fed in conjunction with high levels of Cu on pig growth performance.

Using environmental sampling to evaluate the effectiveness of decontamination methods to reduce detection of porcine epidemic diarrhea virus RNA on feed manufacturing surfaces.

Porcine epidemic diarrhea virus (PEDV) is a possible biological hazard in feed mills. If the virus enters a feed mill, it becomes widely distributed and is difficult to decontaminate from both feed contact and non-feed contact surfaces. The objective of this study was to evaluate a variety of liquid and dry decontamination treatments that could be used to reduce the amount of PEDV found on feed manufacturing surfaces. This experiment was designed as a 5 × 10 factorial with five different feed manufacturing surfaces and 10 decontamination treatments with three replicates of each combination. Surfaces included stainless steel, solid polyethylene, woven polypropylene tote bag, rubber, and sealed concrete coupons. One mL (1×105 TCID50/mL) of stock PEDV was applied to each surface and allowed to dry completely for 60 min. Next, for decontamination requiring surface application, the application was performed and allowed 15 min contact time. The quantity of PEDV RNA was determined using quantitative reverse transcription PCR. A decontamination treatment × surface interaction was observed (P < 0.0001), indicating the efficacy of treatment is dependent upon the surface in which it is applied. Within the cement surfaces, the sodium hypochlorite resulted in the greatest (P < 0.05) cycle threshold (Ct) value, followed by formaldehyde which had a greater (P < 0.05) Ct value compared to remaining treatments. Within polyethylene, rubber, and stainless steel surfaces, the formaldehyde treated surfaces had the greatest Ct values (P < 0.05), followed by the sodium hypochlorite treatment, with other treatments all having lower Ct values (P < 0.05). For the woven polyethylene surfaces, the formaldehyde and sodium hypochlorite treatments had greater Ct values compared to all other treatments (P < 0.05). Additional research is necessary to identify the role of decontamination treatment on PEDV infectivity and develop methods for decontamination of feed manufacturing facilities.

Effect of high-phytase supplementation in lactation diets on sow and litter performance.

A total of 109 sows (Line 241; DNA, Columbus, NE) were used to evaluate the effect of increasing dietary phytase in lactation diets, already adequate in P, on sow and litter performance. On d 107 of gestation, sows were blocked by body weight and parity and allotted to 1 of 3 dietary treatments of increasing phytase concentration (0, 1,000, or 3,000 FYT/kg; Ronozyme HiPhos GT 2700, DSM Nutritional Products, Inc., Parsippany, NJ). The control diet contained no phytase and was formulated to contain 0.50% standardized total tract digestible phosphorus (STTD P; 0.45% available P) and 0.62% STTD calcium (0.90% total Ca). The phytase diets that contained 1,000 or 3,000 FYT/kg were also formulated to 0.50% STTD P and 0.62% STTD Ca including the release of 0.132% STTD P and 0.096% STTD Ca. Diets were balanced for net energy and fed from d 107 of gestation until weaning (d 18 ± 3). All farrowings were monitored, with farrowing duration starting at the time the first pig was born until the first dispersal of placental tissues with no subsequent pigs born. Litters were cross-fostered within treatment until 48 h postfarrowing to equalize litter size. There were no differences among treatments in sow body weight at d 107 of gestation, 24 h after farrowing, or at weaning. Sow average daily feed intake from farrowing to weaning tended to increase (linear, P = 0.093) as phytase increased. There was no evidence for difference in the number of total born pigs, as well as the percentage of stillborns, mummies, and born alive pigs at the completion of farrowing. Similarly, phytase supplementation did not influence (P > 0.05) wean-to-estrus interval or litter size after cross-fostering among dietary treatments. Although not significant (linear, P = 0.226), farrowing duration decreased as added phytase increased with a decrease of 47 min (12%) for 3,000 FYT compared with the control. There were no differences in pig weight at weaning, but as a result of increased survivability (linear, P = 0.002), litter weaning weight and overall litter weight gain increased (quadratic, P < 0.05) up to 1,000 FYT of added phytase with no further benefit observed in sows fed 3,000 FYT. In conclusion, sow feed intake tended to increase linearly with increasing added phytase. Feeding 1,000 FYT/kg maximized overall litter gain and weaning weight; however, a larger-scale study with more sows is needed to determine the addition of phytase in lactation diets to reduce farrowing duration.

Effects of high-protein distillers dried grains on growth performance of nursery pigs.

A total of 300 pigs (DNA 400 × 200, Columbus, NE), initially 11.1 kg, were used in a study to evaluate the effects of increasing amounts of high-protein distillers dried grains (HP DDG) on growth performance and to estimate its energy value relative to corn. Pigs were weaned, placed in pens with five pigs each, and fed a common diet for 21 d after weaning. Then, pens were assigned to treatments in a randomized complete block design. There were 5 treatments with 12 replicates per treatment. Treatments consisted of 0, 10, 20, 30, or 40% HP DDG, formulated by changing only the amounts of corn and feed-grade amino acids. Pigs were weighed weekly for 21 d to evaluate average daily gain (ADG), average daily feed intake (ADFI), and gain-to-feed ratio (G:F). Caloric efficiency was obtained by multiplying ADFI by kcal of net energy (NE) per kg of diet and dividing by ADG. The NE values for corn and soybean meal were obtained from NRC (2012), and initial estimates for HP DDG NE were derived from the Noblet et al. (1994) equation. The energy of HP DDG was estimated based on caloric efficiency relative to the diet without HP DDG. Pigs fed diets with increasing HP DDG had a linear decrease (P < 0.01) in ADG, ADFI, and final body weight. There was a tendency for a quadratic response (P = 0.051) in G:F, with the greatest G:F observed for pigs fed diets with 40% HP DDG. There was a linear reduction (P < 0.05) in caloric efficiency with increasing amounts of HP DDG, indicating the initial NE estimate of HP DDG was underestimated. The use of caloric efficiency to estimate the energy value of HP DDG presents several limitations. This approach assumes that the NE values of corn and soybean meal are accurate and does not take into account possible changes in body composition, which can influence the G:F response as leaner pigs are more efficient. In conclusion, increasing HP DDG in the diet linearly decreased ADG and ADFI. Using caloric efficiency to estimate energy content relative to corn, the HP DDG used in this study was estimated to be 97.3% of the energy value of corn. Direct or indirect calorimetry is needed to confirm this value.

Effects of iron injection timing on suckling and subsequent nursery and growing-finishing performance and hematological criteria.

Two experiments were conducted to evaluate the effects of Fe injection timing after birth on suckling and subsequent nursery and growing-finishing pig performance. The injectable Fe source used in both experiments was GleptoForte (Ceva Animal Health, LLC., Lenexa, KS). GleptoForte contains gleptoferron which is a Fe macromolecule complex. In Exp. 1, a total of 324 newborn pigs (DNA 241 × 600, initially 1.6 ± 0.04 kg body weight [BW]) within 27 litters were used. Two days after birth, all piglets were weighed, and six barrows and six gilts per litter were allotted to 1 of 6 treatments consisting of no Fe injection or 200 mg of injectable Fe provided in a single injection on d 2, 4, 6, 8, or 10 of age. Pigs were weaned (~21 d of age) and allotted to nursery pens with all pigs in each pen having received the same Fe treatment. In Exp. 2, a total of 1,892 newborn pigs (PIC 359 × C40; initially 1.5 ± 0.02 kg BW) within 172 litters were used. One day after birth, piglets were weighed, and 11 pigs within each litter were allotted to 1 of 6 treatments consisting of no Fe injection or 200 mg of injectable Fe provided on d 1, 3, 5, or 7 of age, or 200 mg on d 1 plus 200 mg on d 12 of age. Pigs were weaned (19 d of age) and placed in a commercial wean-to-finish facility in a total of 15 pens with equal representation of treatments in each pen. In both experiments, not providing an Fe injection after birth decreased (P < 0.05) preweaning average daily gain (ADG), weaning weight, and hemoglobin and hematocrit values compared with all other treatments. In Exp. 1, increasing the age that piglets received an Fe injection until 4 or 6 d after birth provided marginal evidence for an improvement (quadratic; P = 0.070) in preweaning ADG. For the nursery period, increasing the age that piglets received an Fe injection improved (quadratic; P = 0.013) d 80 BW, but there was no evidence of a difference (P > 0.10) in d 173 BW at the end of the grow-finish period. In Exp. 2, increasing the age that piglets received a 200 mg Fe injection showed no evidence of difference (P > 0.10) for subsequent nursery and growing-finishing ADG. In both experiments, hemoglobin and hematocrit values were decreased (linear; P < 0.05) at weaning with increasing age when pigs received an Fe injection. These experiments suggest that providing a 200 mg Fe injection within 7 d after farrowing is sufficient for optimizing preweaning and subsequent growth performance.

Improving performance of finishing pigs with added valine, isoleucine, and tryptophan: validating a meta-analysis model.

Based on results of a recent meta-analysis, we hypothesized that increased dietary Val, Ile, or Trp could correct possible amino acid interactions because of excess Leu in diets containing high levels of corn protein, namely dried distiller's grains with solubles (DDGS). A total of 1,200 pigs (PIC TR4 × (Fast LW × PIC L02); initially 33.6 ± 0.6 kg) were used in a 103-d study. The 6 dietary treatments were corn-soybean meal (SBM)-DDGS-based as follows: (1) high SBM and low level of l-Lys HCl (HSBM), (2) high l-Lys HCl and moderate Ile, Val, Trp (AA above NRC 2012 estimates; NC), (3) moderate l-Lys HCl and high Ile, Val, and Trp (PC), and PC with either increased (4) L-Val (PC+Val), (5) L-Ile (PC+Ile), or (6) L-Trp (PC+Trp). Pigs fed the NC diet were predicted to have the poorest average daily gain (ADG), the PC diet to be intermediate, and pigs fed the HSBM, PC+Val, PC+Ile, and PC+Trp have the same and highest predicted ADG. In the grower period (34 to 90 kg), ADG was greater (Ρ < 0.05) for the pigs fed HSBM and PC+Val diets than the NC with pigs fed other diets intermediate. Pigs fed HSBM were more (Ρ < 0.05) efficient (G:F) than the NC and PC with pigs fed other diets intermediate. In the finisher period (90 to 136 kg), ADG was greater (Ρ < 0.05) for pigs fed PC+Ile than that of the NC with pigs fed other diets intermediate. Pigs fed PC+Val had greater (Ρ < 0.05) average daily feed intake (ADFI) than the NC with pigs fed other diets intermediate. However, PC+Ile pigs were more (Ρ < 0.05) efficient than PC+Val with pigs fed other diets intermediate. Overall, ADG was greater (Ρ < 0.05) for pigs fed HSBM, PC+Val, and PC+Ile diets than the NC with pigs fed other diets intermediate. Pigs fed the PC+Val diet had greater (Ρ < 0.05) ADFI than the NC with pigs fed other diets intermediate. No differences were detected between treatments for overall G:F or other carcass characteristics. In conclusion, increasing Val or Ile in high l-Lys-HCl-DDGS-based diets improved growth performance compared with pigs fed diets containing high levels of l-Lys HCl without added Val and Ile. These results present evidence that the recently developed meta-analysis can predict the relative differences in overall ADG for pigs fed the NC, PC, PC+Val, and PC+Ile diets; however, the predicted G:F was less accurate. The data demonstrate that the negative effects of high Leu concentrations in corn-DDGS-based diets can be reversed by increasing the ratios of Val and Ile relative to Lys.

Effects of different diet alternatives to replace the use of pharmacological levels of zinc on growth performance and fecal dry matter of weanling pigs.

A total of 300 weanling pigs (Line 400 × 200, DNA, Columbus, NE, initially 4.83 kg) were used in a 46-d trial to evaluate the effects of different nutritional strategies to replace pharmacological levels of Zn, provided by zinc oxide (ZnO), in nursery diets on growth performance and fecal dry matter (DM). Six treatments with 10 replicate pens per treatment and 5 pigs per pen were used. Diets consisted of: (1) positive control (ZnO providing 3,000 mg/kg added Zn from d 0 to 7 and 2,000 mg/kg added Zn from d 8 to 25 and 21% crude protein, CP); (2) negative control (NC; no added ZnO); (3) NC plus 1.2% Na diformate; (4) NC with 4% coarse ground wheat bran; (5) NC but formulated to 18% CP; and (6) the combination of NC with 18% CP, 1.2% Na diformate, and 4% coarse ground wheat bran. The diets formulated to 18% CP contained 1.2% standardized ileal digestible (SID) Lys from d 0 to 25, whereas the 21% CP diets contained 1.4% SID Lys from d 0 to 7 and 1.35% SID Lys from d 7 to 25. From d 25 to 46, all pigs were fed a common diet. From d 0 to 7, no differences in any variables were observed between treatments. From d 7 to 25, pigs fed the diet with added ZnO had greater (P < 0.01) average daily gain (ADG) and average daily feed intake (ADFI) than all other treatments. Pigs fed the diet formulated to 18% CP had decreased (P < 0.01) ADG when compared with pigs fed the other diets. From d 25 to 46, no previous treatment effects on ADG or gain to feed ratio (G:F) were observed. Overall (d 0 to 46), pigs fed the diet with added ZnO from d 0 to 25 had greater (P < 0.01) ADG, ADFI, and final body weight than pigs fed added Na Diformate, or 4% coarse ground wheat bran, or with the 18% CP diet, or with pigs fed the combination of the additives intermediate. There was no evidence for differences in overall G:F. Pigs fed the NC diet had the lowest fecal DM and highest fecal scores (P < 0.05), indicating the greatest incidence of loose stools. Pigs fed added ZnO had greater fecal DM than pigs fed the NC, 4% added wheat bran, or 18% CP diets, or with pigs fed the combination of additives intermediate (P < 0.01). These results suggest that adding pharmacological levels of Zn from ZnO improves nursery pig performance and increases DM content of feces when compared with pigs fed diets with either Na diformate, 4% course wheat bran, or 18% CP alone. However, a combination of all three alternatives appeared to be additive and partially restored growth performance similar to adding pharmacological levels of Zn.

Effects of dietary chromium propionate and space allowance on performance and carcass responses of growing-finishing pigs.

In a 72-d trial, 256 pigs (Line 600 × 241, DNA Columbus, NE) were used to determine the effect of dietary Cr (Cr propionate; Kemin Industries, Des Moines, IA) and physical space restriction on performance and carcass characteristics of finishing pigs. Pens were blocked by initial weight and randomly assigned to treatments with eight pigs per pen and eight pens per treatment. Treatments were arranged in a 2 × 2 factorial with main effects of Cr (control and Cr propionate, 200 µg/kg added Cr) and space allowances (0.91 m2/animal: normal and 0.63 m2/animal: restricted). Pigs were fed in three dietary phases and pigs were weighed approximately every 14 d throughout the study. Feed efficiency was calculated as both a standard gain to feed ratio and as an adjusted G:F ratio at a common final bodyweight. There were no evidence of space allocation × Cr interactions for any measured responses (P > 0.05). Space restriction decreased (P < 0.001) daily weight gain, final body weight, hot carcass weight, and daily feed intake, but increased carcass yield (P = 0.009) and decreased backfat depth (P = 0.003). Feed efficiency was greater for pigs provided a normal space allowance when adjusted for a common final bodyweight (P = 0.021), although no evidence of a difference was observed for unadjusted G:F (P = 0.687). Adding Cr to the diet reduced G:F on both an adjusted and unadjusted basis (P ≤ 0.021). There was marginally significant evidence that pigs provided Cr had lower average daily gain (P = 0.079) and final bodyweight (P = 0.056) compared to pigs not provided added Cr. There was marginally significant evidence that Cr resulted in greater backfat depth (P = 0.069), although no evidence of a difference in other carcass parameters were observed (P > 0.10). These results demonstrated that there were no interactions between Cr propionate and space allocation, illustrating that under the conditions of this study Cr propionate did not provide an advantage in growth performance or carcass characteristics in either adequate or restricted space allocation.

Effects of increasing standardized ileal digestible lysine during gestation on reproductive performance of gilts and sows.

Limited information is available on lysine requirement estimates of modern, high-producing gestating sows Therefore, the objective of this study was to evaluate the effects of increasing standardized ileal digestible (SID) lysine during gestation on piglet birthweight and reproductive performance of gilts and sows. A total of 936 females (498 gilts, 438 sows; Camborough®, PIC, Hendersonville, TN) were group-housed (approximately 275 females per pen) and individually fed with electronic sow feeders. Females were moved from the breeding stall to pens on d 4 of gestation and allotted to one of four dietary treatments on d 5. Dietary treatments included increasing SID lysine intake (11.0, 13.5, 16.0, and 18.5 g/d). Gilts (parity 1) and sows (parity 2+) received 2.1 and 2.3 kg (22.2 and 24.3 MJ net energy per day) of feed throughout the entire gestation period, respectively. Dietary treatments were achieved by different blends of low (0.48% SID lysine) and high (0.88% SID lysine) lysine diets, prepared by changing the amount of corn and soybean meal in these two diets. Female weight and backfat were recorded on d 4 and 111 of gestation. Individual piglet weight was obtained within 12 h of birth on litters from 895 females. Final weight, and calculated maternal BW, body lipid, and body lean at d 111 of gestation increased (linear, P < 0.01) for gilts and sows as SID lysine increased. There was no evidence for differences in final backfat depth. Average total born for gilts and sows was 15.3 and 16.0 pigs with no evidence for differences among treatments. The percentage of pigs born alive increased (P = 0.01) with increasing SID lysine intake for sows, but not in gilts as a result of a treatment by parity group interaction (P = 0.04) for percentage of stillborn pigs. Increasing SID lysine intake during gestation did not affect the percentage of mummified fetuses, total born, or birthweight of piglets born alive in this study. In addition, increasing SID lysine intake during gestation did not affect subsequent reproductive performance. In conclusion, increasing dietary SID lysine intake in gestation increased female BW, without changing backfat depth. The minimal effects on female reproductive performance and piglet birthweight suggest that 11 g/day of SID lysine intake appears to be adequate for gestating gilts and sows; however, providing sows with 18.5 g/d SID lysine reduced (P = 0.01) stillbirth rate by 2.3 percentage points.

Influence of particle size of Enogen Feed corn and conventional yellow dent corn on lactating sow performance.

Enogen Feed corn is a variety developed by Syngenta Seeds (Downers Grove, IL) that has been genetically modified to contain an -amylase enzyme trait (SYT-EFC). Originally, Enogen feed corn was developed for the ethanol industry due to its properties for reducing the viscosity of its corn mash. There is potential application for Enogen Feed corn to be used in livestock diets due to the potential for the increase in - amylase enzyme to increase the starch digestibility. Because of this, it may be possible to increase the particle size of ground Enogen Feed corn and maintain the same starch digestibility as finely ground conventional yellow dent corn. Therefore, our hypothesis was that an interaction between corn source and particle size would exist such that the performance of sows fed fine ground conventional yellow dent corn would be similar to sows fed coarse ground Enogen Feed corn. A total of 107 sows (Line 241; DNA, Columbus, NE) across four batch farrowing groups were used to evaluate sow and litter performance. Treatments were arranged in a 2 2 factorial with main effects of corn source (Enogen Feed corn or conventional yellow dent corn) and ground corn particle size (600 or 900 m). From farrowing to weaning, there was a tendency for a corn source particle size interaction (P = 0.065) in sow body weight (BW) change. Sows fed 900 m Enogen Feed corn had decreased BW loss compared to sows fed other treatments, which were similar in weight loss. For sow average daily feed intake from farrowing to weaning, there was a corn source particle size interaction (P = 0.048) with sows fed 900 m conventional yellow dent corn having lower feed intake than the sows fed 600 m conventional yellow dent corn, whereas sows fed 900 m Enogen Feed corn had greater feed intake compared to the sows fed 600 m Enogen Feed corn. There was a tendency for a particle size main effect (P < 0.10) for litter average daily gain (ADG) and total litter gain, with sows fed corn ground to 600 m having increased litter ADG and total litter gain compared to sows fed corn ground to 900 m. In summary, there were few differences in sow or litter characteristics among those fed Enogen Feed corn or conventional yellow dent corn. Reducing particle size of both corn sources tended to increase litter ADG and weaning weights.

Evaluation of high-protein distillers dried grains on growth performance and carcass characteristics of growing-finishing pigs.

A total of 1,890 growing-finishing pigs (PIC; 359 × 1,050; initially 27.1 kg) were used in a 124-d growth trial to compare the effects of high-protein distillers dried grains (HPDDG; 39% crude protein [CP]) or conventional distillers dried grains with solubles (DDGS; 29% CP) on growth performance and carcass characteristics. Treatments were arranged in a 2 × 2 + 1 factorial with main effects of distillers dried grains source (conventional DDGS or HPDDG) and level (15% or 30%). A corn-soybean meal-based diet served as the control and allowed linear and quadratic level effects to be determined within each distillers dried grains (DDG) source. All diets were formulated on an equal standardized ileal digestible (SID) Lys-basis with diets containing HPDDG having less soybean meal than diets with conventional DDGS. Pens were assigned to treatments in a randomized complete block design with initial weight as the blocking factor. There were 27 pigs per pen and 14 pens per treatment. Overall, increasing conventional DDGS decreased (linear, P < 0.04) final body weight (BW), whereas increasing HPDDG tended to decrease (linear, P = 0.065) final BW. The decreased final BW was a result of decreased (linear, P < 0.01) ADG in the grower phase of the study as either DDG source increased. However, there were no differences observed in the finisher phase or overall ADG between pigs fed either DDG source or either inclusion level. Pigs fed HPDDG had decreased (P < 0.001) ADFI and increased (P < 0.001) G:F compared with those fed conventional DDGS. For carcass traits, increasing either conventional DDGS or HPDDG decreased carcass yield and HCW (linear, P < 0.02); however, there were no differences between pigs fed HPDDG or conventional DDGS. Iodine value (IV) increased (linear, P < 0.02) with increasing DDG and was greater (P < 0.001) in pigs fed HPDDG than conventional DDGS. In summary, pigs fed HPDDG had no evidence of difference in overall ADG compared to pigs fed conventional DDGS, but had greater overall G:F. Carcass fat IV was also greater in pigs fed HPDDG compared with pigs fed conventional DDGS. These differences were probably due to the difference in oil content.