RESUMO
The population growth is causing an increase in the generation of effluents (mainly organic fraction of municipal solid waste (OFMSW) and agro-industrial waste), which is an old problem in agro-industrial countries such as Brazil. Contrastingly, it is possible to add value to these residual biomasses (residues) through the application of new technologies for the production of bioenergy. Anaerobic digestion (AD) of sewage sludge is being applied in many effluent treatment plants for the sustainable and economically viable production of biogas. However, the biogas produced from AD (sludge) or co-digestion (sludge with other residues) presents a concentration of methane between 60 and 70% on average, which is relatively low. This review is aimed at analyzing studies involving (i) production of lipases by solid-state fermentation (SSF) by different microorganisms for the application in enzymatic pretreatments prior to the anaerobic treatment of effluents; (ii) pretreatment followed by AD of various residues, with an emphasis on OFMSW and sewage sludge; and (iii) more recent studies on anaerobic co-digestion (AcoD) and hybrid technologies (pretreatment + AD or AcoD). There are many studies in the literature that demonstrate the enzymatic pretreatment or AcoD applied to the optimization of methane production. Nevertheless, few studies report the combination of these two technologies, which can improve the process and reduce or eliminate the costs of biogas purification, which are major challenges for the viability of this route of bioenergy production. KEY POINTS: ⢠Municipal and agro-industrial wastes have potential as medium for lipase production. ⢠Enzymatic pretreatment and anaerobic co-digestion are low cost for high-methane production. Graphical abstract Interactions among various factors optimization methane production from enzymatic pretreatment and AcoD.
Assuntos
Fenômenos Fisiológicos Bacterianos , Fermentação , Metano/biossíntese , Esgotos/microbiologia , Anaerobiose , Biocombustíveis/análise , Biomassa , Reatores Biológicos , Brasil , Meios de Cultura , Ativação Enzimática , Resíduos Industriais , Lipase/análiseRESUMO
Star fruit (Averrhoa carambola) is a nutritious tropical fruit. The aim of this study was to evaluate the production of a star fruit alcoholic fermented beverage utilizing a lyophilized commercial yeast (Saccharomyces cerevisiae). The study was conducted utilizing a 23 central composite design and the best conditions for the production were: initial soluble solids between 23.8 and 25 °Brix (g 100 g-1), initial pH between 4.8 and 5.0 and initial concentration of yeast between 1.6 and 2.5 g L-1. These conditions yielded a fermented drink with an alcohol content of 11.15 °GL (L 100 L-1), pH of 4.13-4.22, final yeast concentration of 89 g L-1 and fermented yield from 82 to 94 %. The fermented drink also presented low levels of total and volatile acidities.
RESUMO
Kefir grains are a symbiotic biomass (yeast and bacteria) commonly used to produce milk probiotic fermented beverages. The aim of this study was to produce a mixed beverage of whole milk and açaí (Euterpe oleracea) berry pulp fermented by two different kefir cultures: one specific for milk and one specific for sugared water, adapted to milk. Based on the fermentation yield, pH and sensory analysis, the culture adapted to milk obtained the best results in a composition (g 100 g-1) of 70 of whole milk and 30 of açaí berry pulp, at room temperature (~25°C), without agitation and fermented for 24 h. The results obtained by this formulation were an increase of 12% in the kefir biomass, 93% of fermentation yield, pH 5.10 and overall sensory acceptance of 7.05.
Kefir é uma biomassa simbiótica (leveduras e bactérias) comumente aplicada na obtenção de bebidas fermentadas probióticas de leite. O objetivo deste trabalho foi produzir uma bebida fermentada mista de leite integral e polpa de açaí (Euterpe oleracea) a partir de duas culturas diferentes de kefir: uma original de leite e outra original de água açucarada e adaptada ao leite. Com base na conversão, pH e análise sensorial, os melhores resultados foram obtidos com a cultura adaptada na composição (g 100 g-1) de 70% de leite e 30% de polpa de açaí, sem controle de temperatura (temperatura ambiente ~25° C) e sem agitação e por 24 h de fermentação. Esta formulação apresentou 12% de aumento da biomassa, 93% de conversão, pH 5,10 e uma aceitação global de 7,05.