RESUMEN
The objective of this study was to assess the long-term stability of pesticide residues in brown rice and soybean. The long-term stability of pesticide residues in brown rice and soybean was assessed for 5415 days (over 14 years) and 1801 days (about 5 years), respectively. The samples-certified reference materials (CRMs) 7504-a (brown rice) and 7509-a (soybean) -were prepared by freeze-pulverization. Two target pesticides (etofenprox and fenitrothion) were selected for brown rice and four (chlorpyrifos, diazinon, fenitrothion, and permethrin) for soybean. Our analytical results for long-term stability based on highly reliable isotope dilution mass spectrometry were in the range of expanded uncertainty (k=2) for the certified values of each CRM. The concentration showed a decreasing trend in none of the target pesticides when the samples were stored at temperatures between -20 °C and -30 °C, which indicated that the target pesticides were stable for the tested long terms.
RESUMEN
Chlorinated paraffins are primary industrial chemical products used for metalworking fluids and flame retardants. However, short-chain chlorinated paraffins (SCCPs) are registered in Annex A of the Stockholm Convention on Persistent Organic Pollutants. Therefore, since an accurate quantitative determination of SCCPs is crucial to monitor the level of pollution, analysis quality assurance with reference materials is needed. In this study, a reference material (RM), NMIJ RM 4076-a, was developed by the National Metrology Institute of Japan at the National Institute of Advanced Industrial Science and Technology (NMIJ/AIST) for the quantification of SCCPs. We determined the mass fraction of SCCPs by subtracting the impurities quantified using the mass-balance method, a combination of gas chromatography-flame ionization detection, Karl Fischer titrations, headspace-gas chromatography-mass spectrometry, and thermal gravimetric analysis. The mass fraction value of NMIJ RM 4076-a was concluded to be 0.9996 kg/kg. The standard uncertainty of this mass fraction was evaluated on the basis of the mass-balance method, the sample homogeneity, and stability obtained using the above analytical techniques. Accordingly, the expanded uncertainty estimated using a coverage factor of k = 2 was found to be 0.0013 kg/kg. The mass fraction of chlorine and the homologue compositional ratios are also given for this RM as supplementary technical information. This RM is expected to be applicable for use in the calibration of instruments, or for checking the validity of analytical methods or instruments for estimating the comparability of SCCP analyses.
Asunto(s)
Hidrocarburos Clorados , Parafina , China , Monitoreo del Ambiente/métodos , Ionización de Llama , Cromatografía de Gases y Espectrometría de Masas/métodos , Hidrocarburos Clorados/análisis , Parafina/análisisRESUMEN
From 2012 to 2018, proficiency testings (PTs) were carried out to support the analytical skill development of participants. Grains were sprayed with various target pesticides and used as material samples for PTs. It was found that 27-56% and 10-43% of participants used the Japanese official multiresidue method and a solid-phase extraction technique with the Quick, Easy, Cheap, Effective, Rugged, and Safe (modified QuEChERS, known as "STQ" in Japan) method, respectively. Reported results were evaluated using two types of z-scores: one was based on consensus values calculated from the analytical results reported by the participants, and the other was based on values obtained by the National Metrology Institute of Japan (NMIJ). Acceptable z-scores based on the consensus values and NMIJ reference values were achieved by 78-95% and 67-94% of the participants, respectively. Many laboratories improved their z-scores by continuing participation in our PT.
RESUMEN
The Hatano Research Institute (HRI) at the Food and Drug Safety Center has recently organized a series of proficiency-testing (PT) programs called the "External Quality Control for Food Hygiene" in order to evaluate the analytical capability of testing laboratories that inspect food samples in accordance with the Food Sanitation Act. In one of these programs, Pesticide I, consensus values calculated from the participants' analytical results were used as assigned values, and the spiked concentrations of the prepared test samples were used for evaluating variation among individual participants. In the present study, the values obtained in the 2013-2015 rounds have been assessed by comparing the analytical results of the target pesticides obtained by using two different isotope-dilution MS (IDMS) methods. These two IDMS methods are based on a combination of different pretreatment protocols and different GC separation columns. The weighted means of the observed analytical results were higher than the corresponding assigned values, but showed good agreement with the spiked concentrations. These results indicate that the spiking concentrations of the test sample from HRI are reliable, and therefore, these values can be used to evaluate the trueness of the participants' analytical method.
Asunto(s)
Ensayos de Aptitud de Laboratorios , Espectrometría de Masas/normas , Residuos de Plaguicidas/análisis , Técnica de Dilución de Radioisótopos/normas , Análisis de los Alimentos/normas , Contaminación de Alimentos/análisis , Control de CalidadRESUMEN
Proficiency testing was organized by the National Metrology Institute of Japan (NMIJ) as a measure of analytical competency in the quantification of pesticide residues in husked wheat powder. Seventy-one participants submitted analytical concentrations of the target pesticides (diazinon, fenitrothion, malathion, and etofenprox) along with details of the analytical method employed. Two types of assigned values were obtained for each target pesticide, i.e., the participants' analytical results and the results obtained by NMIJ based on isotope-dilution mass spectrometry (IDMS). The former values were lower than the latter due to the incomplete recovery yield of the target pesticides during the pretreatment process. The discrepancy between the two assigned values was particularly pronounced for malathion because of the longer duration of water-soaking used for the test samples. Two corresponding types of z-scores were then calculated to evaluate the analytical performance of the participants, where the z1-score indicates the performance of a participant relative to all participants, and the z2-score indicates the relative deviation of the analytical results of the participant from the IDMS value.
Asunto(s)
Ensayos de Aptitud de Laboratorios , Malatión/análisis , Espectrometría de Masas/normas , Residuos de Plaguicidas/análisis , Triticum/química , Consenso , Humanos , Isótopos/análisis , Japón , Legislación Alimentaria , Proyectos de InvestigaciónRESUMEN
The impact of the matrix effect in GC-MS quantification of pesticides in food using the corresponding isotope-labeled internal standards was evaluated. A spike-and-recovery study of nine target pesticides was first conducted using paste samples of corn, green soybean, carrot, and pumpkin. The observed analytical values using isotope-labeled internal standards were more accurate for most target pesticides than that obtained using the external calibration method, but were still biased from the spiked concentrations when a matrix-free calibration solution was used for calibration. The respective calibration curves for each target pesticide were also prepared using matrix-free calibration solutions and matrix-matched calibration solutions with blank soybean extract. The intensity ratio of the peaks of most target pesticides to that of the corresponding isotope-labeled internal standards was influenced by the presence of the matrix in the calibration solution; therefore, the observed slope varied. The ratio was also influenced by the type of injection method (splitless or on-column). These results indicated that matrix-matching of the calibration solution is required for very accurate quantification, even if isotope-labeled internal standards were used for calibration.
Asunto(s)
Análisis de los Alimentos/métodos , Residuos de Plaguicidas/análisis , Calibración , Cromatografía de Gases y Espectrometría de Masas/métodos , Cromatografía de Gases y Espectrometría de Masas/normas , Marcaje Isotópico , Verduras/químicaRESUMEN
Proficiency testing (PT) for the determination of pesticide residues in soybean samples was organized by the National Metrology Institute of Japan (NMIJ). The candidate certified reference material, NMIJ CRM 7509-a, that was prepared from the raw soybeans containing target pesticides (diazinon, fenitrothion, chlorpyrifos, and permethrin) was used as the test sample. Forty participants submitted two sets of analytical results along with the details of the analytical method and conditions they applied. Two types of assigned values were established for each target pesticide: one was derived from the analytical results of the participants, and the other was provided from the analytical results by isotope-dilution mass spectrometry (IDMS). The latter values were 7.4-16% higher than the former values, plausibly because the analytical values from the IDMS measurements were not affected by the recovery ratio of the target pesticides during the analytical process. Thus, two kinds of z-scores were calculated for individual participants using the corresponding assigned values: one (z1-score) showed the relative performance score for the present PT and the other (z2-score) could be used for evaluation of the trueness of their analytical methods.
Asunto(s)
Glycine max/química , Ensayos de Aptitud de Laboratorios/estadística & datos numéricos , Plaguicidas/análisis , Cloropirifos/análisis , Diazinón/análisis , Fenitrotión/análisis , Contaminación de Alimentos , Humanos , Variaciones Dependientes del Observador , Permetrina/análisis , Técnica de Dilución de Radioisótopos , Estándares de Referencia , Proyectos de InvestigaciónRESUMEN
A proficiency test for the analysis of pesticide residues in brown rice was carried out to support upgrading in analytical skills of participant laboratories. Brown rice containing three target pesticides (etofenprox, fenitrothion, and isoprothiolane) was used as the test samples. The test samples were distributed to the 57 participants and analyzed by appropriate analytical methods chosen by each participant. It was shown that there was no significant difference among the reported values obtained by different types of analytical method. The analytical results obtained by National Metrology Institute of Japan (NMIJ) were 3 % to 10 % greater than those obtained by participants. The results reported by the participant were evaluated by using two types of z-scores, that is, one was the score based on the consensus values calculated from the analytical results of participants, and the other one was the score based on the reference values obtained by NMIJ with high reliability. Acceptable z-scores based on the consensus values and NMIJ reference values were achieved by 87 % to 89 % and 79 % to 94 % of the participants, respectively.
Asunto(s)
Técnicas de Laboratorio Clínico/estadística & datos numéricos , Técnicas de Laboratorio Clínico/normas , Análisis de los Alimentos/normas , Cromatografía de Gases y Espectrometría de Masas/métodos , Oryza/química , Residuos de Plaguicidas/análisis , Estándares de Referencia , Extracción en Fase SólidaRESUMEN
A soybean certified reference material for pesticide residue analysis was developed by the National Metrology Institute of Japan. Three organophosphorus (diazinon, fenitrothion, chlorphyrifos) and one pyrethroid (permethrin) pesticides were sprayed on soybeans three times before harvest. These soybeans were freeze pulverized, homogenized, bottled, and sterilized by γ-irradiation to prepare the candidate material. Three isotope-dilution mass spectrometric methods that varied in terms of the solvents used for extraction of the target pesticides, the clean-up procedure, and the injection techniques and columns used for quantification via gas chromatography/mass spectrometry were applied to the characterization. Each target pesticide was quantified by two of these analytical methods, and the results were in good agreement. Homogeneity and stability assessment of the material demonstrated that the relative standard uncertainties due to the inhomogeneity and the instability for an expiry date of 55 months were 1.89-4.00% and 6.65-11.5%, respectively. The certified pesticide concentrations with expanded uncertainties (coverage factor k=2, approximate 95% confidence interval) calculated using the results of the characterization and the homogeneity and stability assessment were 21.7 ± 3.2 µg/kg for diazinon, 88 ± 21 µg/kg for fenitrothion, 11.1 ± 3.2 µg/kg for chlorpyrifos, and 20.1 ± 4.3 µg/kg for permethrin (as the sum of the constituent isomers).
Asunto(s)
Glycine max/química , Residuos de Plaguicidas/análisis , Estándares de Referencia , Espectrometría de Masas/métodos , IncertidumbreRESUMEN
A superheated water chromatography (SWC) method for the separation of alkyl esters of 4-hydroxybenzoic acid (parabens) using a zirconia-based stationary phase was developed and applied to real sample analysis. First, the SWC system was optimized in terms of the proper length of the preheating coil for establishing thermal equilibration of the mobile phase entering the column at the oven temperature. Next, the effect of the column temperature on the retention was investigated at 100-180°C. The elution time for all parabens decreased with increasing column temperature, and linear relationships between ln k and 1/T were obtained. At higher column temperatures, the elution time was further shortened because of the increased mobile-phase flow rate. Nevertheless, the loss of column efficiency at the higher flow rates was not significant. The application of the present method to the analysis of commercial lotions was then demonstrated. The quantification results obtained from SWC showed good agreement with those from a conventional HPLC method.
Asunto(s)
Fraccionamiento Químico/métodos , Cromatografía/métodos , Calor , Parabenos/aislamiento & purificación , Agua/química , Circonio/química , Cosméticos/químicaRESUMEN
An apple certified reference material for the analysis of pesticide residues was issued by the National Metrology Institute of Japan. Organophosphorus and pyrethroid pesticides were sprayed on apples, and these were used as raw materials of certified reference material. The harvested apples were cut into small pieces, freeze-dried, pulverized, sieved, placed into 200 brown glass bottles (3g each), and sterilized by γ-irradiation. Stability and homogeneity assessment was performed, and the relative uncertainties due to instability (for an expiry date of 32 months) and inhomogeneity were 10.3-25.0% and 4.0-6.8%, respectively. The characterization was carried out using multiple analytical methods to ensure the reliability of analytical results; the values of target pesticides were obtained by isotope dilution mass spectrometry. Certified values were 2.28 ± 0.82 mg/kg for diazinon, 3.14 ± 0.79 mg/kg for fenitrothion, 1.55 ± 0.81 mg/kg for cypermethrin, and 2.81 ± 0.70 mg/kg for permethrin.
Asunto(s)
Malus/química , Espectrometría de Masas/normas , Compuestos Organofosforados/análisis , Residuos de Plaguicidas/análisis , Piretrinas/análisis , Contaminación de Alimentos/análisis , Espectrometría de Masas/métodos , Estándares de ReferenciaRESUMEN
The purpose of this study was to develop an analytical method for the determination of organophosphorus and pyrethroid pesticides in soybean by pressurized liquid extraction (PLE). Two organic solvents, acetone and acetonitrile, were evaluated as extraction solvents. In both cases, the amount of extract was enhanced with increasing extraction temperature. The extracts obtained using acetonitrile were measured by gas chromatography/mass spectrometry after a cleanup process based on the analytical method for the Japanese Positive List System for Agricultural Chemicals Remaining in Foods. The effect of extraction temperature (range: 40- 130°C) on extraction efficiency was evaluated by a recovery study using 21 organophosphorus pesticides and 10 pyrethroid pesticides as target analytes and acetonitrile as the solvent. The results indicated that at 130°C, some organophosphorus pesticides might be degraded, whereas extraction temperatures between 70°C and 100°C were optimal. Next, a prepared sample containing fenitrothion and permethrin was analyzed. Although the sample was not soaked in water prior to analysis, PLE provided analytical results comparable to those obtained by solvent extraction with homogenization. Therefore, PLE is considered a simple and alternative technique for the extraction of organophosphorus and pyrethroid pesticides in soybean.
Asunto(s)
Contaminación de Alimentos/análisis , Glycine max/química , Extracción Líquido-Líquido/métodos , Compuestos Organofosforados/aislamiento & purificación , Plaguicidas/aislamiento & purificación , Piretrinas/aislamiento & purificación , Calor , Extracción Líquido-Líquido/instrumentación , Compuestos Organofosforados/análisis , Plaguicidas/análisis , Presión , Piretrinas/análisisRESUMEN
The aim of this study was to evaluate the efficiency of microwave-assisted extraction (MAE) for the analysis of organophosphorus (OP) and pyrethroid (PYR) pesticides in green onions by GC/MS. We optimized MAE extraction solvent, temperature, and time by using a certified reference material. As a result, the concentrations of two OP and two PYR target pesticides obtained by MAE with acetonitrile at 110 degrees C for 10 min were in good agreement with certified concentrations and comparable to the results by homogenization used as reference extraction technique. When the recovery test, performed by spiking the target pesticides into blank samples (5.0 g), was carried out with our optimized MAE conditions, mean recoveries of 16 OP and 10 PYR pesticides were 72-108% for a 1.0 pg spiking level and 70-119% for a 0.2 microg level. These results were acceptable according to the validation guideline for testing method of agricultural chemicals in food by Ministry of Health, Labour, and Welfare in Japan. The results suggested that MAE can be used for the analysis of OP and PYR pesticides in green onions.
Asunto(s)
Cebollas/química , Compuestos Organofosforados/análisis , Plaguicidas/análisis , Piretrinas/análisis , Calibración , Diazinón/análisis , Fenitrotión/análisis , Análisis de los Alimentos , Cromatografía de Gases y Espectrometría de Masas/métodos , Indicadores y Reactivos , Marcaje Isotópico , Límite de Detección , Microondas , Compuestos Organofosforados/aislamiento & purificación , Permetrina/análisis , Plaguicidas/aislamiento & purificación , Piretrinas/aislamiento & purificación , Estándares de Referencia , Extracción en Fase Sólida , SolventesRESUMEN
The National Metrology Institute of Japan has issued a certified reference material of tunnel dust for polycyclic aromatic hydrocarbons (PAHs) and toxic element analyses. PAH certification was performed using isotope dilution mass spectrometry with deuterium-labeled PAHs as internal standards. Three extraction techniques (microwave-assisted extraction with toluene/methanol, Soxhlet extraction with toluene, and pressurized liquid extraction with toluene) were used, and the extracts were measured by gas chromatography/mass spectrometry with two different columns. For values of PAHs, 11 PAHs are provided as certified values between 0.294 and 20.3 mg/kg, and five PAHs are provided as information values. Certified values of five toxic elements (Cr, Ni, Pb, Mn, and Cd) obtained from microwave-assisted digestions and a combination of measurement techniques are also provided between 43.4 and 10.71 × 10(3) mg/kg.
RESUMEN
Green onion and cabbage certified reference materials for the analysis of pesticide residues were issued by the National Metrology Institute of Japan, part of the National Institute of Advanced Industrial Science and Technology. Green onion and cabbage samples were grown so as to contain several kinds of organophosphorus and pyrethroid pesticides, and those were collected from a field in the Kochi Prefecture in Japan. The certification was carried out by using multiple analytical methods to ensure the reliability of analytical results; the values of target pesticides (diazinon, fenitrothion, cypermethrin, etofenprox, and permethrin for green onion and chlorpyrifos, fenitrothion, and permethrin for cabbage) were obtained by isotope dilution mass spectrometry. Certified values of target pesticides were 0.96-13.9 and 2.41-6.9 mg/kg for green onion and cabbage, respectively. These are the first green onion and cabbage powder certified reference materials in which organophosphorus and pyrethroid pesticides are determined.
Asunto(s)
Brassica/química , Cebollas/química , Compuestos Organofosforados/análisis , Residuos de Plaguicidas/análisis , Piretrinas/análisis , Técnicas de Dilución del Indicador , Japón , Espectrometría de Masas/métodos , Estándares de Referencia , Reproducibilidad de los ResultadosRESUMEN
For accurate quantification of polycyclic aromatic hydrocarbons (PAHs) in dust samples, we investigated the use of microwave-assisted solvent extraction (MAE) combined with isotope-dilution mass spectrometry (IDMS) using deuterium-labelled PAHs (D-PAHs). Although MAE with a methanol/toluene mixture (1:3 by volume) at 160°C for 40 min was best for extracting PAHs from tunnel dust among examined, the recovery yields of D-PAHs decreased with increasing molecular weight (<40% for MW≥264; that of deuterium-labelled indeno[123-cd]pyrene (D-IcdP) was only 7.1%). Although the residues were extracted a second time, the observed concentrations did not change dramatically (<5%), and the recovery yields of heavier D-PAHs (i.e., MW≥264) were approximately half of those of the first extract, including D-IcdP (3.4%). These results suggest that both partitioning and isotopic equilibria of PAHs and D-PAHs between sample and solvent were achieved for extractable heavier PAHs under the condition. Thus, the observed concentrations of PAHs obtained by MAE-IDMS were reasonable, even though recovery yields of D-PAHs were <50%. From the results of carbon analyses and extractable contents, lower recovery yields of D-PAHs from the tunnel dust were due to a large content of char with low extractable contents.
RESUMEN
Fish certified reference material (CRM), NMIJ CRM 7404-a, for the analysis of polychlorinated biphenyls (PCBs) and organochlorine pesticides (OCPs) was developed by the National Metrology Institute of Japan, part of the National Institute of Advanced Industrial Science and Technology. Fish samples (Japanese seabass) used for the preparation of the CRM were collected from Tokyo Bay, and the edible part was freeze-dried, pulverized, sieved, homogenized, and sterilized by gamma-irradiation. This sample is in the form of a powder comprising approximately 10 g stored in a brown glass bottle. The certification was carried out using multiple analytical methods such as pressurized liquid extraction, Soxhlet extraction, saponification, and homogenization to ensure the reliability of analytical results; the certified values of target PCBs (PCB 28, PCB 70, PCB 105, PCB 153, and PCB 170) and OCPs (trans-nonachlor, dieldrin, p,p'-DDE, p,p'-DDT, and p,p'-DDD) were 1.05-14.0 microg kg(-1) and 1.57-18.0 microg kg(-1) for PCBs and OCPs, respectively. This is the first fish powder CRM in which PCBs and OCPs were determined by isotope dilution mass spectrometry.
Asunto(s)
Hidrocarburos Clorados/normas , Plaguicidas/normas , Bifenilos Policlorados/normas , Estándares de Referencia , Animales , Peces , Hidrocarburos Clorados/análisis , Japón , Métodos , Plaguicidas/análisis , Bifenilos Policlorados/análisisRESUMEN
Brown rice powder certified reference material, NMIJ CRM 7504-a, for the analysis of pesticide residues was developed by the National Metrology Institute of Japan, part of the National Institute of Advanced Industrial Science and Technology. Brown rice sample was harvested to contain the pesticides such as etofenprox and fenitrothion, and that was collected from a field in Ibaraki Prefecture in Japan. The certification was carried out using multiple analytical methods such as pressurized liquid extraction, homogenization, and solid-liquid extraction (shaking); the values of target pesticides were obtained by isotope dilution mass spectrometry. Certified values were 0.19 +/- 0.05 mg/kg and 0.109 +/- 0.017 mg/kg for etofenprox and fenitrothion, respectively.
Asunto(s)
Análisis de los Alimentos/normas , Insecticidas/análisis , Oryza/química , Estabilidad de Medicamentos , Fenitrotión/análisis , Cromatografía de Gases y Espectrometría de Masas , Japón , Espectrometría de Masas , Piretrinas/análisis , Control de Calidad , Estándares de Referencia , Extracción en Fase SólidaRESUMEN
The National Metrology Institute of Japan has issued a certified reference material (CRM) of freshwater lake sediment for polycyclic aromatic hydrocarbon (PAHs) analyses. The certification used three extraction techniques: pressurized liquid extraction (PLE) with toluene, PLE with dichloromethane/ethyl acetate (1:1 by volume), and alkaline extraction (1 M KOH in methanol) in combination with microwave-assisted extraction. Both gas chromatography/mass spectrometry (GC/MS) and liquid chromatography/dopant-assisted atmospheric pressure photoionization/MS (LC/DA-APPI/MS) analyses were used. Certified values are provided for 18 PAHs at 1-25 microg kg(-1) except for perylene (2.08 x 10(3) microg kg(-1)), and information values are provided for two. Since the values of PAHs in the CRM are much lower than those in other CRMs and are comparable to those found at sites with little human influence, the CRM is suitable for PAH monitoring in sediment and soil samples.
Asunto(s)
Academias e Institutos , Técnicas de Química Analítica/normas , Sedimentos Geológicos/química , Hidrocarburos Policíclicos Aromáticos/análisis , Agencias Gubernamentales , Japón , Estándares de Referencia , Reproducibilidad de los ResultadosRESUMEN
The aim of this study was to assess the performance of a method of analyzing pesticides in rice by using pressurized liquid extraction (PLE) and to perform a preliminary monitoring by using that method. The instrumental quantification limit, instrumental detection limit, method quantification limit, and method detection limit were determined. PLE temperature was also optimized for 6 target pesticides. Mean recoveries of spiked rice with target pesticides (4 ng/g and 40 ng/g) were 83%-109% with the repeatability of the analysis, represented as relative standard deviations, ranged from 1.3% to 11% (n = 5) for PLE at 130 degrees C. These results were satisfactory according to the method of positive list in Japan. In a preliminary analysis of 10 target pesticides in 54 commercial rice samples, ferimzone was detected in only one unpolished rice sample.