Properties of corn-expressed carbohydrase AC1 in swine diets and its effects on apparent ileal digestibility, performance, hematology, and serum chemistry.

Carbohydrases are often incorporated into livestock feed as digestive aids to improve animal performance. AC1 is a thermostable carbohydrase with ß-1,4-glucanase, endo-cellulase, and cellobiohydrolase activity. AC1 has been expressed in corn, where it accumulates in the grain for easy inclusion in animal diets. Incorporating the enzyme in high-fiber diets (corn-soy supplemented with distiller's dry grains with solubles) that were fed to 5-week-old pigs led to a trend of decreasing viscosity of the digesta as the dose of the enzyme increased (P = 0.092). AC1 also tended to increase the apparent ileal digestibility (AID) of neutral detergent fiber (P = 0.076). When fed diets containing 2126 U/kg AC1, pigs experienced no adverse effects in terms of performance metrics (body weights, average daily gain, average daily feed intake and gain-to-feed ratio), hematology, blood chemistry or general health when compared to pigs fed a control diet that lacked AC1.

A Novel Corn-Expressed Phytase Improves Daily Weight Gain, Protein Efficiency Ratio and Nutrients Digestibility and Alters Fecal Microbiota in Pigs Fed with Very Low Protein Diets.

The objective of this study was to assess the effect of a novel corn-expressed phytase (CEP) on growth, nutrients digestibility, bone characteristics and fecal microbiota of pigs fed with very low-protein, -calcium (Ca) and -phosphorous (P) diets. Forty-eight barrows were subjected to 6 groups for 4 weeks: positive control-adequate protein (PC), negative control-reduced protein (NC), NC + low-dose CEP, i.e., 2000 FTU/kg (LD), NC + high-dose CEP, i.e., 4000 FTU/kg (HD), LD with 0.12% unit reduced Ca and 0.15% unit reduced available P (LDR), and HD with 0.12% unit reduced Ca and 0.15% unit reduced available P (HDR). Compared to NC, LD and HDR had a higher average daily gain (ADG) and gain:protein ratio (G:P), HD and HDR had greater apparent fecal digestibility of Ca and P and bone mineral density and LDR and HDR had lower serum osteocalcin. The feces of LD was enriched in Lachnospiraceae, while the HD had a higher abundance of Succinvibrio and LDR had a higher abundance of Bifidobacterium and Actinobacteria. In conclusion, supplementation of protein-restricted diets with a CEP decreased their negative effects on ADG and G:P ratio, increased the digestibility of Ca and P regardless of the levels of these minerals in the diet, improved bone characteristics and produced differential effects on fecal bacterial population.

Effects of a novel corn-expressed E. coli phytase on digestibility of calcium and phosphorous, growth performance, and bone ash in young growing pigs1.

Two experiments were conducted to test the hypothesis that a corn-expressed phytase increases growth performance, bone measurements, and nutrient digestibility by young growing pigs, if added to diets that are deficient in Ca and P. In Exp. 1, 60 pigs (initial BW: 10.78 ± 0.67 kg) were randomly allotted to 6 dietary treatments that included a positive control diet (PC; 0.70% total Ca and 0.60% total P) and a negative control diet (NC; 0.50% total Ca and 0.42% total P). Four additional diets were formulated by supplementing the NC diet with 250, 500, 1,000, or 1,500 phytase units (FTU)/kg. Diets were fed for 28 d and the individual BW of pigs on days 1 and 28 were recorded. Fecal samples were collected from days 25 to 27 to calculate apparent total tract digestibility (ATTD) of Ca and P. On the last day of the experiment, all pigs were euthanized, and the left femur was removed and analyzed for ash, Ca, and P. Results indicated that growth performance, ATTD of Ca and P, and bone ash measurements were reduced (P < 0.05) in NC fed pigs compared with PC fed pigs. However, growth performance, ATTD of Ca and P, and bone ash measurements were improved (linear and quadratic, P < 0.05) by including increasing concentrations of phytase to the NC diet. In Exp. 2, experimental procedures were similar to those used in Exp. 1. Forty-eight pigs (initial BW: 11.15 ± 0.85 kg) were randomly allotted to 6 dietary treatments in a 28-d experiment. Treatments included a PC diet, an NC diet, and 4 diets in which 500 or 1,000 FTU/kg of either the corn-expressed phytase or a commercial microbial phytase were added to the NC diet. Pigs fed the NC diet had reduced (P < 0.01) final BW, ADG, G:F, and bone ash concentrations compared with pigs fed the PC diet. When 500 FTU/kg phytase was fed, no differences were observed in growth performance or bone ash measurements between phytase sources, and there were no differences in growth performance among pigs fed 1,000 FTU/kg of either phytase source or the PC diet. However, regardless of concentration or source of phytase, pigs fed the PC diet had greater (P < 0.001) amount of bone ash, bone Ca, and bone P compared with pigs fed phytase diets. In conclusion, the corn-expressed phytase is effective in improving growth performance, Ca and P digestibility, and bone measurements in pigs fed diets that are deficient in Ca and P.

Effects of feeding corn-expressed phytase on the live performance, bone characteristics, and phosphorus digestibility of nursery pigs.

A 41-d feeding trial was conducted to determine the efficacy of a corn-expressed phytase (GZ; GraINzyme, Agrivida Inc., Woburn, MA) on the live performance, bone characteristics, and P digestibility of nursery pigs fed a reduced P diet. Weaned piglets (21 ± 3 d; n = 324) were acclimated on a common diet for 7 d (phase 1) before randomization into 54 single-sex pens (5 gilt and 4 barrow pens per treatment) containing 6 pigs (6.6 ± 1.2 kg) per pen. Six treatments were fed: positive control (PC; 0.4% or 0.32% aP for phase 2 or 3 and 4, respectively), negative control (NC; 0.15% reduction in aP), and 500, 1,000, 2,000, or 4,000 FTU per kg phytase from GZ added to NC in a 3-phase feeding program. Pigs were weighed on day 1, 14, 28, and 41, and feed disappearance recorded per phase. Apparent total tract digestibility (ATTD) of P was determined by feeding chromic oxide marker (day 28 to 35) and collecting fecal samples on day 35. On day 41, 4 pigs per pen were euthanized and metacarpal bones were collected to evaluate bone breaking strength (BBS) and ash. Data were analyzed using PROC GLM of SAS (block, sex, and treatment). Treatment least squares means were separated and linear and quadratic treatment effects evaluated. Other than feed efficiency (G:F) and day 15 to 28 ADFI, the pigs fed PC were superior (P < 0.05) to NC-fed pigs in all other variables. Pigs fed ≥500 FTU per kg phytase had increased (P < 0.05) ADG and ADFI compared to NC pigs and equivalent (P > 0.05) ADG and ADFI as PC pigs from day 0 to 41. Feeding ≥500 FTU per kg phytase resulted in higher (P < 0.05) ATTD of P than both NC and PC pigs and higher (P < 0.05) BBS and bone ash weight than NC. Pigs fed 1,000 or 2,000 FTU per kg phytase had equivalent (P > 0.05) BBS and bone ash weight compared to pigs fed PC diets. Feeding 4,000 FTU per kg phytase resulted in higher (P < 0.05) day 1 to 41 ADG, ATTD of P, and bone ash weight compared to feeding ≤1,000 FTU per kg phytase or PC diets. There were linear (P < 0.05) increases in ADG, ADFI, ATTD of P, BBS, and bone ash characteristics as GZ inclusion increased. In conclusion, ≥500 FTU per kg phytase from GZ improved growth, ATTD of P, BBS, and bone ash when added to a reduced P diet and 4,000 FTU per kg phytase increased growth greater than the PC treatment.