RESUMEN
The sustainability of direct land application of dairy manure is challenged by significant nutrient losses. Bioelectrochemical systems for ammonia recovery offer a manure management strategy that can recover both ammoniacal and organic nitrogen as a stable ammonia fertilizer. In this research, a microbial fuel cell (MFC) was used to treat two types of dairy manure under a variety of imposed anode compartment conditions. The system achieved a maximum coulombic efficiency of 20 ± 18 % and exhibited both COD and total nitrogen removals of approximately 60 %. Furthermore, the MFC showed a maximum organic nitrogen removal of 73.8 ± 12.1 %, and no differences in organic nitrogen (orgN) removal were detected among different conditions tested. Decreasing concentrations of anolyte ammonia nitrogen coupled with the observed orgN removal from the anolyte indicate that the MFC is effective at recovering orgN in dairy manure as ammoniacal nitrogen in the catholyte. Additionally, ion competition between NH4+ and other relevant cations (Na+, K+, and Mg2+) for transport across the CEM was investigated, with only K+ showing minor competitive effects. Based on the results of this research, we propose three key processes and two sub-processes that contribute to the successful operation of the MFC for nitrogen recovery from dairy manure. Bioelectrochemical systems for nitrogen recovery from dairy manure offer a novel, robust technology for producing a valuable ammonia nitrogen fertilizer, a thus far untapped resource in dairy manure streams.
Asunto(s)
Amoníaco , Fuentes de Energía Bioeléctrica , Amoníaco/metabolismo , Estiércol , Fertilizantes , Nitrógeno/análisisRESUMEN
Almost 60% of all ammonia (NH3) emissions are from livestock manure. Understanding the sources and magnitude of NH3 emissions from manure systems is critical to implement mitigation strategies. This study models 13 archetypical conventional (5 farms), organic (5 farms), and grazing (3 farms) dairy farms to estimate NH3 emissions from manure at the barn, storage, and after land application. Mitigation practices related to management of the herd, crop production, and manure are subsequently modeled to quantify the change in NH3 emissions from manure by comparing archetypical practices with these alternative practices. A mass balance of nutrients is also conducted. Emissions per tonne of excreted manure for the manure system (barn, storage, and land application) range from 3.0 to 4.4 g of NH3 for conventional farms, 3.5 to 4.4 g of NH3 for organic farms, and 3.4 to 3.9 g of NH3 for grazing farms. For all farm types, storage and land application are the main sources of NH3 emissions from manure. In general, solid manures have higher emission intensities due to higher pH during storage (pH = 7.4 for liquid, 7.8 for slurry, and 8.5 for solid manure) and lower infiltration rates after land application when compared with slurry and liquid manures. The most effective management practices to reduce NH3 emissions from manure systems are combining solid-liquid separation with manure injection (up to 49% reduction in NH3 emissions), followed by injection alone, and reducing crude protein in the dairy ration, especially in organic and grazing farms that have grazing and forages as the main component of the dairy ration. This study also shows that the intensity of NH3 emissions from manure depends significantly on the functional unit and presents results per manure excreted, total solids in excreted manure, animal units, and fat- and protein-corrected milk.
Asunto(s)
Amoníaco , Gases de Efecto Invernadero , Animales , Amoníaco/análisis , Estiércol/análisis , Metano/análisis , Gases de Efecto Invernadero/análisis , GranjasRESUMEN
Growing concerns about environmental impacts of dairy farms have driven producers to address greenhouse gas (GHG) emissions and nitrogen (N) losses from soil following land application of dairy manure. Tannin dietary additives have proved to be a successful intervention for mitigating GHG and ammonia (NH3 ) emissions at the barn scale. However, it is unknown how land application of dairy manure from cows fed tannin diets affects crop-soil nitrogen dynamics and soil GHG flux. To test this, cows were fed diets at three levels of tannins (0.0%, 0.4%, and 1.8% of dry matter intake) and their manure was field applied at two N rates (240 and 360 kg N ha-1 ). Soil NH4 + -N, NO3 - -N, corn silage yield, and soil GHG flux were then measured over a full growing season. Soils amended with tannin manure had lower initial NH4 + -N concentrations and lower total mineral N (NH4 + -N + NO3 - -N) concentrations 19 days after application, compared to soils amended with no tannin manures. Despite lower early season N availability in tannin-fertilized plots, there were no differences in corn silage yield. No differences in soil GHG and NH3 emissions were observed between manure-amended treatments. These results demonstrate that while tannin addition to dairy cow feed does not offer short-term GHG or NH3 emissions reductions after field manure application, it can promote slower soil N mineralization that may reduce reactive N loss after initial application.
Asunto(s)
Gases de Efecto Invernadero , Suelo , Femenino , Bovinos , Animales , Estiércol , Taninos , Nitrógeno , Amoníaco/análisisRESUMEN
Livestock manure is typically applied to fertilize crops, however the accurate determination of manure nutrient composition through a reliable method is important to optimize manure application rates that maximize crop yields and prevent environmental contamination. Existing laboratory methods can be time consuming, expensive, and generally the results are not provided prior to manure application. In this study, the evaluation of a low-field nuclear magnetic resonance (NMR) sensor designated for manure nutrient prediction was assessed. Twenty dairy manure samples were analyzed for total solid (TS), total nitrogen (TN), ammoniacal nitrogen (NH4-N), and total phosphorus (TP) in a certified laboratory and in parallel using the NMR analyzer. The linear regression of NMR prediction versus lab measurements for TS had an R2 value of 0.86 for samples with TS < 8%, and values of 0.94 and 0.98 for TN and NH4-N, respectively, indicating good correlations between NMR prediction and lab measurements. The TP prediction of NMR for all samples agreed with the lab analysis with R2 greater than 0.87. The intra- and inter-sample variations of TP measured by NMR were significantly larger than other parameters suggesting less robustness in TP prediction. The results of this study indicate low-field NMR is a rapid method that has a potential to be utilized as an alternative to laboratory analysis of manure nutrients, however, further investigation is needed before wide application for on farm analysis.
Asunto(s)
Estiércol , Fósforo , Estudios de Factibilidad , Espectroscopía de Resonancia Magnética , Estiércol/análisis , Nitrógeno/análisis , Nutrientes/análisis , Fósforo/análisisRESUMEN
Anaerobic digestion has been suggested as an intervention to attenuate antibiotic resistance genes (ARGs) in livestock manure but supporting data have typically been collected at laboratory scale. Few studies have quantified ARG fate during full-scale digestion of livestock manure. We sampled untreated manure and digestate from seven full-scale mesophilic dairy manure digesters to assess ARG fate through each system. Samples were collected biweekly from December through August (i.e., winter, spring, and summer; n = 235 total) and analyzed by quantitative polymerase chain reaction for intI1, erm(B), sul1, tet(A), and tet(W). Concentrations of intI1, sul1, and tet(A) decreased during anaerobic digestion, but their removal was less extensive than expected based on previous laboratory studies. Removal for intI1 during anaerobic digestion equaled 0.28 ± 0.03 log10 units (mean ± SE), equivalent to only 48% removal and notable given intI1's role in horizontal gene transfer and multiple resistance. Furthermore, tet(W) concentrations were unchanged during anaerobic digestion (p > 0.05), and erm(B) concentrations increased by 0.52 ± 0.03 log10 units (3.3-fold), which is important given erythromycin's status as a critically important antibiotic for human medicine. Seasonal log10 changes in intI1, sul1, and tet(A) concentrations were ≥50% of corresponding log10 removals by anaerobic digestion, and variation in ARG and intI1 concentrations among digesters was quantitatively comparable to anaerobic digestion effects. These results suggest that mesophilic anaerobic digestion may be limited as an intervention for ARGs in livestock manure and emphasize the need for multiple farm-level interventions to attenuate antibiotic resistance.
Asunto(s)
Antibacterianos , Estiércol , Anaerobiosis , Animales , Antibacterianos/farmacología , Bovinos , Farmacorresistencia Bacteriana/genética , Genes Bacterianos , Ganado/genéticaRESUMEN
Mixing has been shown to have effect on biogas production in anaerobic digestion systems. To further examine this impact, a study was designed to evaluate nearly continuous mixing (mixing for 15â min followed by no mixing for 15â min, CON), intermediate mixing (mixing for 15â min followed by no mixing for 45â min, INT) and no mixing (unmixed, NO) on biogas production in three 208â L pilot-scale tank reactors. The experiments were conducted in triplicates at a controlled temperature of 37 ± 1°C, with a total solids percentage of 5%, a hydraulic retention time (HRT) of 21 days, and an organic loading rate (OLR) of 2â kgâ VSâ m-3â d- 1. Digesters with NO mixing had greater solids build up in the bottom quarter of the digester after four weeks' retention time. The methane percentage in biogas produced from digesters with INT and CON mixing were 63% and 62%, respectively, which were 4% and 5% higher than that from digesters with NO mixing (58%). The specific methane yield for digesters with NO, INT and CON mixing was 1.15, 1.15, and 1.49 m3-methane per kg-VS destroyed, however, those differences were not statistically significant (p > 0.05). Digesters had the least amount of Methanosarcinales of the methanogens measured under all treatments. However, the Methanosarcinales, Methanosarcinaceae, Methanomicrobiales, and the total amount of methanogens were less in digesters with INT mixing compared to NO and CON mixing treatments.
Asunto(s)
Biocombustibles , Reactores Biológicos , Anaerobiosis , Estiércol , MetanoRESUMEN
We propose a coordination framework for managing urban and rural organic waste in a scalable manner by orchestrating waste exchange, transportation, and transformation into value-added products. The framework is inspired by coordinated management systems that are currently used to operate power grids across the world and that have been instrumental in achieving high levels of efficiency and technological innovation. In the proposed framework, suppliers and consumers of waste and derived products as well as transportation and technology providers bid into a coordination system that is operated by an independent system operator. Allocations and prices for waste and derived products are obtained by the operator by solving a dispatch problem that maximizes the social welfare and that balances supply and demand across a given geographical region. Coordination enables handling of complex constraints and interdependencies that arise from transportation and bio-physico-chemical transformations of waste into products. We prove that the coordination system delivers prices and product allocations that satisfy economic and efficiency properties of a competitive market. The framework is scalable in that it can provide open access that fosters transactions between small and large players in urban and rural areas and over wide geographical regions. Moreover, the framework provides a systematic approach to enable coordinated responses to externalities such as droughts and extreme weather events, to monetize environmental impacts and remediation, to achieve complex social goals such as geographical nutrient balancing, and to justify technology investment and development efforts. Furthermore, the framework can facilitate coordination with electrical, natural gas, water, and transportation, and food distribution infrastructures.
RESUMEN
Anaerobic digestion can inactivate zoonotic pathogens present in cattle manure, which reduces transmission of these pathogens from farms to humans through the environment. However, the variability of inactivation across farms and over time is unknown because most studies have examined pathogen inactivation under ideal laboratory conditions or have focused on only one or two full-scale digesters at a time. In contrast, we sampled seven full-scale digesters treating cattle manure in Wisconsin for 9 mo on a biweekly basis ( = 118 pairs of influent and effluent samples) and used real-time quantitative polymerase chain reaction to analyze these samples for 19 different microbial genetic markers. Overall, inactivation of pathogens and fecal indicators was highly variable. When aggregated across digester and season, log-removal values for several representative microorganisms-bovine , -like CowM3, and bovine polyomavirus-were 0.78 ± 0.34, 0.70 ± 0.50, and 0.53 ± 0.58, respectively (mean ± SD). These log-removal values were up to two times lower than expected based on the scientific literature. Thus, our study indicates that full-scale anaerobic digestion of cattle manure requires optimization with regard to pathogen inactivation. Future studies should focus on identifying the potential causes of this suboptimal performance (e.g., overloading, poor mixing, poor temperature control). Our study also examined the fate of pathogens during manure separation and found that the majority of microbes we detected ended up in the liquid fraction of separated manure. This finding has important implications for the transmission of zoonotic pathogens through the environment to humans.
Asunto(s)
Bacterias/aislamiento & purificación , Reactores Biológicos , Estiércol/microbiología , Anaerobiosis , Animales , Bovinos , Temperatura , Virus , WisconsinRESUMEN
BACKGROUND: Spray irrigation for land-applying livestock manure is increasing in the United States as farms become larger and economies of scale make manure irrigation affordable. Human health risks from exposure to zoonotic pathogens aerosolized during manure irrigation are not well understood. OBJECTIVES: We aimed to a) estimate human health risks due to aerosolized zoonotic pathogens downwind of spray-irrigated dairy manure; and b) determine which factors (e.g., distance, weather conditions) have the greatest influence on risk estimates. METHODS: We sampled downwind air concentrations of manure-borne fecal indicators and zoonotic pathogens during 21 full-scale dairy manure irrigation events at three farms. We fit these data to hierarchical empirical models and used model outputs in a quantitative microbial risk assessment (QMRA) to estimate risk [probability of acute gastrointestinal illness (AGI)] for individuals exposed to spray-irrigated dairy manure containing Campylobacter jejuni, enterohemorrhagic Escherichia coli (EHEC), or Salmonella spp. RESULTS: Median risk estimates from Monte Carlo simulations ranged from 10-5 to 10-2 and decreased with distance from the source. Risk estimates for Salmonella or EHEC-related AGI were most sensitive to the assumed level of pathogen prevalence in dairy manure, while risk estimates for C. jejuni were not sensitive to any single variable. Airborne microbe concentrations were negatively associated with distance and positively associated with wind speed, both of which were retained in models as a significant predictor more often than relative humidity, solar irradiation, or temperature. CONCLUSIONS: Our model-based estimates suggest that reducing pathogen prevalence and concentration in source manure would reduce the risk of AGI from exposure to manure irrigation, and that increasing the distance from irrigated manure (i.e., setbacks) and limiting irrigation to times of low wind speed may also reduce risk. https://doi.org/10.1289/EHP283.
Asunto(s)
Riego Agrícola/métodos , Industria Lechera , Estiércol/microbiología , Modelos Teóricos , Medición de RiesgoRESUMEN
Subsurface drainage from agricultural land has been identified as a contributor of both N and P into surface waters, leading to water quality degradation and eutrophication. This study evaluates the ability of P sorption media (PSM; expanded shale, expanded clay, furnace slag, and natural soil) to sorb P in both batch and column tests. Batch sorption tests estimated sorption of 3.4, 1.2, and 0.5 g P kg for expanded shale, expanded clay, and natural soil, respectively. Furnace slag sorption was evaluated for fine (FS), small (FS), and large (FS) particle sizes, with estimated sorption of 6.8, 5.1, and 3.8 g P kg, respectively. Phosphorus removal for the three furnace slag particle sizes and natural soil were tested in flow-through columns operated at residence times of 50, 17, and 7 s. A decrease in residence time reduced P removal in all columns evaluated. Following all trials, the average P removal from influent was 50% for FS, followed by 27% for FS (furnace slag-coated pea gravel), 22% for FS, and 6% for sandy loam-coated pea gravel. The data from this study provides crucial information for developing and sizing an inline tile drainage treatment system to remove P from tile drainage outlets before reaching surface waters.
Asunto(s)
Eutrofización , Fósforo/análisis , Agricultura , Filtración , Tamaño de la Partícula , SueloRESUMEN
Farmstead runoff poses significant environmental impacts to ground and surface waters. Three vegetated filter strips were assessed for the treatment of dairy farmstead runoff at the soil surface and subsurface at 0.3- or 0. 46-m and 0. 76-m depths for numerous storm events. A medium-sized Michigan dairy was retrofitted with two filter strips on sandy loam soil and a third filter strip was implemented on a small Michigan dairy with sandy soil to collect and treat runoff from feed storage, manure storage, and other impervious farmstead areas. All filter strips were able to eliminate surface runoff via infiltration for all storm events over the duration of the study, eliminating pollutant contributions to surface water. Subsurface effluent was monitored to determine the contributing groundwater concentrations of numerous pollutants including chemical oxygen demand (COD), metals, and nitrates. Subsurface samples have an average reduction of COD concentrations of 20, 11, and 85% for the medium dairy Filter Strip 1 (FS1), medium dairy Filter Strip 2 (FS2), and the small Michigan dairy respectively, resulting in average subsurface concentrations of 355, 3960, and 718 mg L COD. Similar reductions were noted for ammonia and total Kjeldahl nitrogen (TKN) in the subsurface effluent. The small Michigan dairy was able to reduce the pollutant leachate concentrations of COD, TKN, and ammonia over a range of influent concentrations. Increased influent concentrations in the medium Michigan dairy filter strips resulted in an increase in COD, TKN, and ammonia concentrations in the leachate. Manganese was leached from the native soils at all filter strips as evidenced by the increase in manganese concentrations in the leachate. Nitrate concentrations were above standard drinking water limits (10 mg L), averaging subsurface concentrations of 11, 45, and 25 mg L NO-N for FS1, FS2, and the small Michigan dairy, respectively.