Evaporation Kinetics of Sessile Water Droplets on a Smooth Stainless Steel Surface at Elevated Temperatures and Pressures.

The evaporation of water droplets on a solid surface at elevated temperatures under a pressurized condition has not yet been well understood, although this phenomenon is of both theoretical and practical significance. In this work, water droplet evaporation on smooth stainless steel surfaces in nitrogen gas atmosphere at elevated pressures and temperatures (up to 2 MPa and 202.4 °C, respectively) was investigated experimentally. It was observed that the increase in pressure diminishes the proportion of the constant contact radius stage over the entire evaporation time, whereas an opposite trend was found when raising the temperature, due to the change in the surface pinning ability with pressure (and temperature). The results also suggested that the evaporation mode transition is mainly affected by temperature rather than pressure. In addition, the evaporation rate was calculated under various degrees of subcooling, revealing that the evaporation rate increases almost linearly with pressure when keeping the degree of subcooling constant. However, when fixing the test temperature, a nonlinear decrease of the evaporation rate with pressure was observed. A power law growth of the evaporation rate with temperature was also found at a constant pressure. Last, it was uncovered by a theoretical analysis that the saturated vapor concentration is the dominant factor dictating the evaporation rate.

Understanding the Temperature Dependence of Contact Angles of Water on a Smooth Hydrophobic Surface under Pressurized Conditions: An Experimental Study.

It is of both practical and scientific significance to understand the temperature dependence of contact angles of water on various surfaces. However, the variation trend of water wettability on a smooth hydrophobic surface with increasing temperature remains unclear. In this work, in situ characterization of the contact angle of water on Teflon (polytetrafluoroethylene) surfaces and the interfacial tension of water over a temperature spectrum from ∼25 to 160 °C under pressurized conditions (2, 3, and 5 MPa) in a nitrogen atmosphere was conducted by employing the sessile drop and pendant drop methods, respectively. A nearly invariant trend of the contact angle was observed over the entire temperature and pressure range. As expected, however, it was shown that the water-N2 interfacial tension almost linearly declines with increasing temperature and that pressure has a negative effect on the interfacial tension. Based on the theory of surface thermodynamics, the effects of temperature on the contact angles were analyzed in combination with the gas adsorption effect. Estimations on the solid-gas interfacial tension, surface entropy, and the heat of immersion were made to gain more insights into the temperature dependence of the water contact angle on a smooth hydrophobic surface.