Quantification of human intravenous immunoglobulin from plasma and in process samples by affinity chromatography.

Advances in affinity chromatography now make it possible to analyze immunoglobulin G from plasma and its fractions with a simple chromatographic method. Ligands derived from camelid antibodies have been developed which have affinity to all 4 subclasses of human IgG without a cross reactivity to other immunoglobulins. The commercially available Capture Select FcXL is the basis for a simple method for direct quantification of immunoglobulin G from plasma or from fractions from cold ethanol precipitation. After direct injection of the sample into the column the unbound proteins are washed out with equilibration buffer and eluted with a pH-step. The elution the peak is integrated, and quantity is derived form a standard curve. The limit of detection with 40 µg/mL, and a linearity up to 250 µg/mL allows an analysis of samples ranging from 0.04 to 50 mg/mL using varying injection volume without further dilution and the two-wavelength detection. A full cycle is completed within five minutes. This method can serve as orthogonal method for in-process control but also for process development.

L-Arginine sulfate reduces irreversible protein binding in immobilized metal affinity chromatography.

Immobilized metal affinity chromatography (IMAC) is a powerful technique for capture and purification of relevant biopharmaceuticals in complex biological matrices. However, protein recovery can be drastically compromised due to surface induced spreading and unfolding of the analyte, leading to fouling of the stationary phase. Here, we report on the kinetics of irreversible adsorption of a protease on an IMAC resin in a time span ranging from minutes to several hours. This trend correlated with the thermal data measured by nano differential scanning calorimetry, and showed a time-dependent change in protein unfolding temperature. Our results highlight that 'soft' proteins show a strong time dependent increase in irreversible adsorption. Furthermore, commonly used co-solvents for preservation of the native protein conformation are tested for their ability to reduce fouling. Thermal data suggests that the amino acid l-arginine is beneficial in preventing unfolding, which was confirmed in batch adsorption experiments. The choice of counter-ions has to be considered when using this amino acid. These results show that l-arginine sulfate decelerates the irreversible adsorption kinetics of proteins on the IMAC stationary phase to a greater extent than l-arginine chloride.

Proteomics analysis of host cell proteins after immobilized metal affinity chromatography: Influence of ligand and metal ions.

Different degrees of protein purity have been observed in immobilized metal affinity chromatography ranging from extremely high purity to moderate and low purity. It has been hypothesized that the host cell protein composition and the metal ligands are factors governing the purity of a protein obtained after immobilized metal affinity chromatography (IMAC). Ni nitrilotriacetic acid (NTA) has become the first choice for facile His-tagged protein purification, but alternative ligands such as iminodiacetic acid (IDA) with other immobilized metal ions such as Zn, Cu and Co are valuable options when the expected purity or binding capacity is not reached. Especially Cu and Zn are very attractive, due to their reduced environmental and safety concerns compared to Ni. Co and Zn are more selective than Ni and Cu. This increased selectivity comes at the cost of weaker binding. In this work, the influence of ligand choice on protein purity after IMAC was evaluated by several methods, including peptide mapping. His-tagged GFP was used as model protein. We found that host cell protein (HCP) content varies drastically between ligands, as IDA eluates generally showing higher HCP concentrations than NTA. The relative content of the key amino acids His, Cys and Trp in the sequence of the co-eluted protein does not suffice to explain co-eluting propensity. The co-elution of HCPs is mostly influenced by metal binding clusters on the protein surface and not by total content or surface concentration of metal interacting amino acids. Prediction of co-elution is not dependent on these clusters alone, due to protein-protein interactions, indicted by a relative low metal binding cluster score but high co-elution propensity and in a lot of cases these proteins are often part of complex such as ribosome and chaperones. The different co-eluting proteins were presented by a heatmap with a dendrogram. Ward's linkage method was used to calculate the distance between groups of co-eluting proteins. Clustering of co-eluting HCPs was observed according to ligand and by metal ions, with Zn and Co forming one cluster and Ni and Cu another. The co-elution of host cell proteins can be explained by clusters of metal interacting amino acids on the protein surface and by protein-protein interactions. While Ni NTA still appears to be highly advantageous, it might not be the cure-all for all applications.