RESUMEN
In Drug Discovery, pharmacology studies often require benign formulation compositions for safe administration in animal models. Here, we applied Adaptive Focused Acoustics™ (AFA) to a molecular scaffold with challenging physicochemical properties for intraperitoneal administration. Nanosuspensions can be prepared at small scales and provide broad applicability. Our results show that nanosuspension formulations prepared by AFA have improved PK performance relative to a DMSO solution formulation that is prone to precipitation in-vivo.
Asunto(s)
Nanopartículas , Animales , Tamaño de la Partícula , Solubilidad , SuspensionesRESUMEN
This article describes the discovery and characterization of nanocolloidal structures formed between VX-985 (an orally administered inhibitor of hepatitis C virus protease) and the bile salt, sodium taurocholate at concentrations of the latter >4 mM. These complexes (1) distribute narrowly in size around a mean diameter of 260 nm, (2) separate from solution only with ultracentrifugation, and (3) appear to influence the absorption of VX-985 from the intestinal tract in vivo, in rodents and humans. Although the oral bioavailability of suspensions of its solid forms is poor, addition of vitamin E D-alpha-tocopherol polyethylene glycol 1000 succinate to dosing vehicles improves the fraction absorbed of the compound in vivo. In vitro characterization is compatible with the hypothesis that surfactants like D-alpha-tocopherol polyethylene glycol 1000 succinate preclude nanocolloidal structures and increase the bioavailability by increasing the rate of absorption of VX-985. This study, while specific to VX-985, provides a route to circumvent the poor oral bioavailability caused by formation of kinetically stable complexes between bile salts and drug molecules. This study also underscores the importance of characterizing aggregation phenomenon that may be observed in solubility measurements during preclinical formulation development.
Asunto(s)
Antivirales/administración & dosificación , Portadores de Fármacos/química , Compuestos de Espiro/administración & dosificación , Ácido Taurocólico/química , Vitamina E/química , Administración Oral , Animales , Antivirales/farmacocinética , Disponibilidad Biológica , Coloides/química , Hepacivirus/enzimología , Hepatitis C/tratamiento farmacológico , Humanos , Absorción Intestinal , Inhibidores de Proteasas/administración & dosificación , Inhibidores de Proteasas/farmacocinética , Ratas , Solubilidad , Compuestos de Espiro/farmacocinéticaRESUMEN
Three anhydrous polymorphs, a monohydrate and a dihydrate of an active pharmaceutical ingredient, N-{[(5S)-3-(4-{6-[(1R,5S)-6-cyano-3-oxabicyclo[3.1.0]hex-6-yl]pyridin-3-yl}phenyl)-2-oxo-1,3-oxazolidin-5-yl]methyl}acetamide (Compound 1), have been crystallized and characterized. Slurry experiments and thermal data have been used to determine their relative thermodynamic stability. The hydrates of Compound 1 were found to be less stable than the most stable anhydrous Form I and converted into Form I in water within 15 min. The rate of conversion in a dry state was found to depend on the relative humidity (RH) and was highest at the two RH extremes examined, 5% and 97.5% RH.
Asunto(s)
Acetamidas/química , Preparaciones Farmacéuticas/química , Rastreo Diferencial de Calorimetría , Química Farmacéutica , Cristalización , Estabilidad de Medicamentos , Almacenaje de Medicamentos , Humedad , Cinética , Estructura Molecular , Transición de Fase , Solubilidad , Solventes/química , Temperatura , Termodinámica , Termogravimetría , Factores de Tiempo , Agua/química , Difracción de Rayos XRESUMEN
We report formation and characterization of the first pharmaceutically acceptable and stable molecular complex of a mono-HCl salt of Compound 1 with HCl. The novelty of this discovery is due to the fact that there is only one major basic site in the molecule. Thus this complex is reminiscent of other noncovalent crystalline forms including solvates, hydrates, cocrystals and others. To the best of our knowledge, the observed bis-HCl salt appears to be the first example of an active pharmaceutical ingredient in a form of a stable HCl complex. The paucity of stable complexes of APIs with HCl is likely due to the fact that HCl is a gas at ambient conditions and can easily evaporate compromising physical (and chemical) stability of a drug. The bis-HCl salt was chemically/physically stable at low humidity and the molecular HCl stays in the lattice until heated above 140 degrees C under nitrogen flow. Structure solution from powder diffraction using the Monte Carlo simulated annealing method as well as variable temperature ATR-FTIR suggest the possibility of weak hydrogen bonding between the molecular HCl and the nitrogen atom of the amide group. Two years later after the search for a suitable pharmaceutical salt began, the elusive conventional mono-HCl salt was obtained serendipitously concluding the lengthy quest for a regular salt. This work emphasizes the necessity to be open-minded during the salt selection process. It also highlights the difficult, lengthy and often serendipitous path of finding the most appropriate form of an API for pharmaceutical development.
Asunto(s)
Ácido Clorhídrico/química , Preparaciones Farmacéuticas , Sales (Química)/química , Cristalización , Enlace de Hidrógeno , Estructura Molecular , Método de Montecarlo , Espectroscopía Infrarroja por Transformada de FourierRESUMEN
We report the formation of aqueous gels at low concentrations (less than 1 wt%) of an amphiphilic drug, a derivative of a chromane-2-carboxylic acid, at pH values 6.2-6.4. Formation of gels in the vicinity of the apparent pK(a) of the drug suggests that on the molecular level, the gels are composed of the aggregates of the ionized and protonated forms of the drug, which are stabilized by hydrogen bonding and hydrophobic interactions. In contrast, its identical analog, which differs by one methylene group, did not form gels or viscous solutions. We believe that additional steric hindrance, brought by the presence of the bulkier ethyl group (as compared to methyl group), prevents efficient interaction between the carboxylic acid groups thus hindering the gelation process.
Asunto(s)
Cromanos/química , Portadores de Fármacos/química , Geles/química , Tensoactivos/química , Agua/química , Concentración de Iones de Hidrógeno , Estructura Molecular , Soluciones , Relación Estructura-ActividadRESUMEN
We report the first case of a pharmaceutical cocrystal formed between an inorganic acid and an active pharmaceutical ingredient (API), which enabled us to develop a stable crystalline and bioavailable solid dosage form for pharmaceutical development where otherwise only unstable amorphous free form or salts could have been used.
Asunto(s)
Fosfatos/química , Ácidos Fosfóricos/química , Cristalización , Espectroscopía de Resonancia Magnética , Modelos Moleculares , Estructura Molecular , Fosfatos/farmacologíaRESUMEN
A method to detect and quantify a small amount crystalline material within a liquid solution of solubilized material is described. 19F CP-MAS ssNMR was investigated as a technique to detect low levels (0.2 mg/g) of crystalline sodium (2R)-7-{3-[2-chloro-4-(2,2,2-trifluoroethoxy)phenoxy]propoxy}-2-methyl-3,4-dihydro-2H-chromane-2-carboxylate (I) within a solid mixture (with microcrystalline cellulose) and a slurry with a liquid vehicle (capric and caprylic acid triglycerides). The results demonstrate that the area of the 19F CP/MAS signal obtained in 25 min at 25 degrees C is linearly dependent (R2=0.997) on the mass of I within the ssNMR rotor. Slopes of CP-MAS peak area versus mass of I in the rotor were nearly identical for the solid mixture and slurry suspension. Signal-to-noise ratio for the low potency slurry suggest detection and quantitation of 0.1 mg of crystalline I in the rotor, corresponding to 2 mg/g of crystalline material within the slurry suspension.
Asunto(s)
Benzopiranos/análisis , Celulosa/química , Espectroscopía de Resonancia Magnética/métodos , Éteres Fenílicos/análisis , Polietilenglicoles/química , Triglicéridos/química , Benzopiranos/química , Cromatografía Líquida de Alta Presión , Cristalización , Vehículos Farmacéuticos , Éteres Fenílicos/química , SolubilidadRESUMEN
PURPOSE: This study was conducted to evaluate the aggregation properties of an amphiphilic drug. METHODS: Aggregation of the drug was studied by various methods including phase-contrast and polarized microscopy, spectrophotometry, surface tensiometry, atomic force microscopy, and dynamic light scattering. Lymph-cannulated rats were used to assess fractions of drug that were absorbed into lymphatics. RESULTS: During the pharmaceutical development of an alpha/gamma dual PPAR agonist, a derivative of a chromane-2-carboxylic acid (compound 1), it was discovered that the compound was able to form various aggregates in aqueous media from pH 6.5 to 7.1, whereas aggregating predominantly into micelles at higher pH values. Critical micelle concentrations seemed to be quite low, about 0.25 mM (0.17 mg/mL) in deionized water as determined by spectrophotometric (dye) and surface tensiometry (du Nuoy) methods. Aggregation of compound 1 into large supramolecular aggregates was visualized via phase-contrast microscopy and atomic force microscopy. The observed aggregates ranged from 250 nm to greater than 10 microm in size. Formation of liquid crystalline phases was observed by polarized microscopy as the material was gradually hydrated with water. Lymph studies in rats indicated that up to 6.9% of the orally administered dose of compound 1 in pH 6.5 buffer appeared in lymph, suggesting that supramolecular aggregation may also occur in vivo leading to partitioning between the portal and the lymph routes. CONCLUSIONS: The aforementioned supramolecular aggregation was found to have a profound effect on the pharmaceutical development of the drug and potentially on in vivo absorption of the drug.
Asunto(s)
Benzopiranos/química , PPAR alfa/agonistas , PPAR gamma/agonistas , Éteres Fenílicos/química , Animales , Benzopiranos/farmacocinética , Benzopiranos/farmacología , Concentración de Iones de Hidrógeno , Sistema Linfático/efectos de los fármacos , Sistema Linfático/metabolismo , Masculino , Microscopía de Fuerza Atómica , Éteres Fenílicos/farmacocinética , Éteres Fenílicos/farmacología , Ratas , Ratas Sprague-DawleyRESUMEN
PURPOSE: The purpose of this study was to evaluate the physical form of 2-tert-butyl-4-methoxy-phenol (BHA) following wet granulation onto common pharmaceutical excipients. METHODS: A 13C label was incorporated into the methoxy group of BHA, the major isomer in synthetic butylated hydroxyanisole. Solutions of the labeled BHA were used to load the labeled BHA onto common pharmaceutical excipients. After air drying under ambient conditions, the mixtures were examined by 13C MAS and CP/MAS nuclear magnetic resonance (NMR) spectroscopy to evaluate the physical form of the BHA. RESULTS: The data suggested that BHA could exist as either a crystalline or an amorphous component and that amorphous material was either bound to excipients or relatively mobile during the time of the NMR experiment. At 0.1% loading, BHA appeared to be amorphous and mobile in the freshly prepared blends. At 0.5% loading, BHA was shown to be amorphous on microcrystalline cellulose (MCC) and hydroxypropylmethylcellulose (HPMC) while remaining crystalline on lactose, mannitol, calcium phosphate dihydrate, and croscarmellose sodium. CONCLUSIONS: Solid-state NMR spectroscopy has been used to probe the physical forms of 13C-labeled BHA granulated onto common pharmaceutical excipients. The techniques described in this paper may be applied to help explain stability changes in formulations containing BHA.
Asunto(s)
Hidroxianisol Butilado/química , Excipientes/química , Resonancia Magnética Nuclear Biomolecular/métodos , Cristalización , Transición de FaseRESUMEN
This is a study of 10 asymmetric gemini surfactants that self-assemble into vesicles which, in turn, self-assemble into gels. The geminis have the following general structure: long-chain/phosphate/2-carbon spacer/quaternary nitrogen/short-chain. Dynamic light scattering and transmission electron microscopy (TEM) demonstrate that in dilute aqueous systems these compounds self-assemble into vesicles. The vesicles are cohesive as proven by cryo-high resolution electron microscopy (cryo-HRSEM) images that reveal a "pearls on a string" morphology. These strings of vesicles create a complex network that rigidifies the water. The one gemini in the study that does not form a gel is also the only vesicle system that, according to cryo-HRSEM and TEM, assembles into clumps rather than chains. It is proposed that the vesicles are cohesive owing to protrusion of short chains from the vesicle surfaces, thereby creating hydrophobic "patches" whose intervesicular overlap supersedes the normal membrane/membrane repulsive forces. Analogous geminis having two long chains, neither of which are thought capable of departing from their bilayers, also form vesicles, but they are noncohesive (as expected from the model). Rheological experiments carried out on the gels show that gelation is mechanically reversible. Thus, if an applied torque breaks a string, the string can rapidly mend itself as long as the temperature exceeds its calorimetrically determined T(m) value. Gel strength, as manifested by the yield stress of the soft material, was shown to be particularly sensitive to the structure of the gemini. All three individual components of the systems (geminis, vesicles, and gels) have widespread practical applications.
Asunto(s)
Geles/química , Tensoactivos/química , Preparaciones de Acción Retardada/química , Elasticidad , ReologíaRESUMEN
PURPOSE: Diffusion coefficients of various retinoids have not been measured previously. It is important to know the diffusion coefficients of the retinoids because this property might be rate-limiting in dark adaptation. Also, retinoid diffusion is important to explore given that rhodopsin regeneration is not impaired in IRBP knockout mice. METHODS: Measurements of lateral diffusion coefficients (D) of 9-cis-retinal, all-trans-retinal, and all-trans-retinol were made by Fourier transform pulsed-gradient spin-echo NMR measurements (FT-PGSE NMR) in several solvents. Also,(3)H-all-trans-retinoic acid was used to measure diffusion from an aqueous agarose matrix and absorption into a toluene based scintillation fluid in a biphase assay. RESULTS: In a 1:1 mixture of CD(3)OD:D(2)O the D's of the retinoids were, 2.4 to 3.0 x 10(-6)cm( 2)/s. In the biphase assay,(3)H-all trans-retinoic acid exhibited a diffusion coefficient of 2.3 x 10(-6)cm(2)/s. CONCLUSIONS: The lower than expected D for retinoids and our calculations suggest that mechanisms in addition to pure aqueous diffusion may be needed to account for normal rhodopsin regeneration rates in the mammalian retina.