Laser-induced breakdown spectroscopy for 24/7 automatic liquid slag analysis at a steel works.

Laser-induced breakdown spectroscopy (LIBS) is applied for the inline analysis of liquid slag at a steel works. The slag in the ladle of a slag transporter is measured at a distance of several meters during a short stop of the transporter. The slag surface with temperatures from ≈600 to ≈1400 °C consists of liquid slag and solidified slag parts. Automatic measurements at varying filling levels of the ladle are realized, and the duration amounts to 2 min including data transmission to the host computer. Analytical results of the major components such as CaO, Fe, SiO2, MgO, Mn, and Al2O3 are compared with reference values from the steel works laboratory for solid pressed slag samples as well as for samples from the liquid slag. Stable 24/7 operation during the first three-month test run was achieved.

A new type of gradiometer for the receiving circuit of magnetic induction tomography (MIT).

Magnetic induction tomography (MIT) is a low-resolution imaging modality which aims at the three-dimensional (3D) reconstruction of the electrical conductivity in objects from alternating magnetic fields. In MIT systems the magnetic field perturbations to be detected are very small when compared to the excitation field (ppm range). The voltage which is induced by the excitation field in the receiver coils must be suppressed for providing sufficient dynamic range. In the past, two very efficient strategies were proposed: adjusted planar gradiometers (PGRAD) and the orientation of a receiver coil with respect to the excitation coil such that the net magnetic flow is zero (zero flow coil, ZFC). In contrast to the PGRAD no voltage is induced in the ZFC by the main field. This is advantageous because two comparatively high voltages in the two gradiometer coils can never be subtracted perfectly, thus leaving a residual voltage which is prone to drift. However, a disadvantage of the ZFC is the higher susceptibility to interferences from far RF sources. In contrast, in the gradiometer such interferences are cancelled to a high degree. We developed a new type of gradiometer (zero flow gradiometer, ZFGRAD) which combines the advantages of ZFC and PGRAD. All three systems were compared with respect to sensitivity and perturbation to signal ratio (PSR) defined as the ratio of the signal change due to a magnetic perturbation field at the carrier frequency and the signal change due to shifting a metallic sphere between two test points. The spatial sensitivity of the three systems was found to be very similar. The PSR of the ZFGRAD was more than 12 times lower than that of the ZFC. Finally, the feasibility of image reconstruction with two arrays of eight excitation coils and eight ZFGRAD, respectively, was shown with a single-step Gauss-Newton reconstructor and simulated measurement data generated for a cylindrical tank with a spherical perturbation. The resulting images show a clear, bright feature at the correct position of the sphere and are comparable to those with PGRAD arrays.

Sodium intake does not influence bioimpedance-derived extracellular volume loss in head-down rest.

INTRODUCTION: There is disagreement regarding the impact of dietary sodium on alterations in extracellular volume during head-down bed rest (HDBR). The primary purpose of this study was to assess the effects of salt intake on extracellular volume (ECV) during HDBR. METHODS: We performed whole-body bioimpedance spectroscopy with controlled sodium intake during 4 d of ambulation and 8 d of -6 degrees HDBR in 10 normotensive men. Each subject performed an initial 12-d familiarization run with moderate sodium (246 +/- 12 mmol x L(-1) x d(-1) excreted) during which no measurements were made. They then participated in treatment runs involving low sodium (LS: 143 +/- 10 mmol x L(-1) x d(-1) Na+ excreted) and high sodium (HS: 434 +/- 17 mmol x L(-1) x d(-1) Na+ excreted). The different treatments were separated by > or =1 mo and the order of LS and HS was balanced among the subjects. These treatments were based on controlled food and drink supplies as prepared by a dietitian. We monitored sodium output and measured aldosterone, plasma renin activity (PRA), and vasopressin. Bioimpedance was measured every second day in supine position using tetrapolar electrodes. RESULTS: Based on exponential data fitting, we calculated an ECV decrease of 0.79 +/- 0.32 L (-5.8%; p = 0.018) in LS, and 1.21 +/- 0.31 L (-4.0%; p = 0.002) in HS during HDBR. LS and HS were not different (p > 0.1); 4 d pre-HDBR sodium adjustment produced a fall in ECV in the LS group only (-3.7%, p = 0.023). Hormone levels were not changed by HDBR. Plasma aldosterone was lower in HS (69 +/- 7 pg x ml(-1)) than in LS (180 +/- 24 pg x ml(-1)). DISCUSSION: Our bioimpedance data confirm that low sodium intake decreases ECV in ambulatory conditions and indicate that 8 d of HDBR produce a loss of ECV of about 5% (p < 0.05). The loss did not seem to be influenced by sodium intake between approximately 3 and approximately 10 g x d(-1).

Head down tilt at -6 degrees to -24 degrees can neutralize the cardiovascular effects of LBNP at -15 or -35 mmHg.

INTRODUCTION: The purpose of this study was to identify the combinations of head down tilt (HDT) and lower body negative pressure (LBNP) that would counterbalance each other's effects on cardiovascular and endocrine variables to produce a "neutral point" (NP). METHODS: We conducted 8 30-min experiments in 14 normotensive subjects (2 male, 12 female). Conditions included four levels of HDT (-6 degrees to -24 degrees) and two of LBNP (-15 and -35 mmHg). We determined blood plasma mass density, hematocrit, plasma aldosterone concentration, and plasma renin activity (PRA) before and at the end of stimulation. The effect of stimulus duration was tested using continuous measurements of heart rate (HR), blood pressure (BP), and thoracic electrical impedance (Z0). RESULTS: NPs were found for all variables except BP, which remained unchanged. NPs were similar for all variables. The 15 mmHg LBNP was compensated by 20 degrees HDT and 35 mmHg LBNP by 27.5 degrees HDT. Longer stimulus duration required increasing HDT angles to balance HR at 35 mmHg LBNP but had no influence on Z0 NP. DISCUSSION: Antiorthostatic positioning can compensate cardiovascular effects of LBNP in a similar fashion for all variables that are significantly influenced by LBNP and body angle, commensurate with stimulus magnitude. Arterial BP remained stable with stimulation and seems to be the primarily defended variable. Why stimulus duration seems to influence the NP for HR remains to be elucidated.

Bed rest immobilization with various oral sodium supply: plasma hormones and body fluids.

OBJECTIVE: To answer the question if plasma hormone concentrations (plasma renin activity--PRA, vasopressin--pAVP, and aldosterone concentration) due to antiorthostatic immobilization (8 days -6 degree head-down tilt bed rest--HDBR) are altered by oral salt load, we provided constant sodium supply during 4 days ambulatory conditions followed by 8 days HDBR in 10 normotensive men. METHODS: A low' (LS: 143 10 mM) and high' (HS: 434+/-17 mM Na+/d excreted) sodium treatment were provided in randomized order, separated > or = 1 mo. Before and at the end of HDBR, hemodynamic variables and thoracic impedance were determined, and blood was taken for aldosterone and PRA, venous hematocrit, and plasma mass density. Extracellular fluid volume and pAVP were determined every second day. Whole body electrical impedance spectroscopy was employed to assess changes in extracellular volume, hormone determinations were done with radioimmunoassay, mass density measurements with the mechanical oscillator technique. RESULTS: Extracellular volume decreased with HDBR (LS: -4.0%, p=0.002; HS: -5.8%, p=0.018) without significant difference between salt treatments. Resting hormone levels were not altered by HDBR, but pAVP was lower (5.5+/-0.1 pg/ml) in HS than in LS (7.2+/-0.3 pg/ml) as was plasma aldosterone (HS: 69+/-7 pg/ml, LS: 180+/-24 pg/ml). On the other hand, HDBR reduced extracellular volume by ?5% irrespective of dietary sodium supply. CONCLUSIONS: Our data support the hypothesis that hormonal activities are more affected by oral salt load than by simulated short-term space flight, and suggest that the reduction of extracellular fluid volume due to head down bed rest is not influenced by moderate changes of dietary sodium supply.