RESUMEN
With the emergence of clade 2.3.4.4b H5N1 highly pathogenic avian influenza virus (AIV) infection of dairy cattle and its subsequent detection in raw milk, coupled with recent AIV infections affecting dairy farm workers, experiments were conducted to affirm the safety of cooked ground beef related to AIV because such meat is often derived from cull dairy cows. Specifically, retail ground beef (percent lean:fat = ca. 80:20) was inoculated with a low pathogenic AIV (LPAIV) isolate to an initial level of 5.6 log10 50% egg infectious doses (EID50) per 300 g patty. The inoculated meat was pressed into patties (ca. 2.54 cm thick, ca. 300 g each) and then held at 4 °C for up to 60 min. In each of the two trials, two patties for each of the following three treatments were cooked on a commercial open-flame gas grill to internal instantaneous temperatures of 48.9 °C (120°F), 62.8 °C (145°F), or 71.1 °C (160°F), but without any dwell time. Cooking inoculated ground beef patties to 48.9 °C (ave. cooking time of ca. 15 min) resulted in a mean reduction of ≥2.5 ± 0.9 log10 EID50 per 300 g of ground beef as assessed via quantification of virus in embryonating chicken eggs (ECEs). Likewise, cooking patties on a gas grill to 62.8 °C (ave. cooking time of ca. 21 min) or to the USDA FSIS recommended minimum internal temperature for ground beef of 71.1 °C (ave. cooking time of ca. 24 min) resulted in a reduction to nondetectable levels from initial levels of ≥5.6 log10 EID50 per 300 g. These data establish that levels of infectious AIV are substantially reduced within inoculated ground beef patties (20% fat) using recommended cooking procedures.
Asunto(s)
Culinaria , Animales , Bovinos , Humanos , Gripe Aviar , Carne Roja , Subtipo H5N1 del Virus de la Influenza A , Carne , AvesRESUMEN
Thermal inactivation studies were undertaken on Listeria monocytogenes and Salmonella spp. inoculated on the surface of country ham. Hams (average = ca. 3.4 ± 0.5 kg each; average = ca. ≥18% shrinkage) were used as provided by the processor (i.e., "salted hams"), desalted in tap water (i.e., "desalted hams"), or dried for an additional period (i.e., "extra-dried hams"). Hams were surface inoculated (ca. 9.5 log CFU/ham) with a multistrain cocktail of L. monocytogenes or Salmonella spp. and cooked within a bag ina circulating water bath to an internal temperature of 130°F (54.4°C) instantaneous, 145°F (62.8°C) and held for 4 min, 153°F (67.2°C) and held for 34 s, or 160°F (71.1°C) instantaneous. Regardless of ham type, all four time and temperature combinations tested herein delivered a ≥6.7-log reduction of cells of L. monocytogenes or Salmonella spp. Differences in product pH, moisture content, or aw did not have an appreciable impact on the thermal inactivation of L. monocytogenes or Salmonella spp. on country ham. In addition, shelf-life studies were undertaken using slices of "salted" country ham that were surface inoculated (ca. 5.5 log CFU/slice) with a multistrain cocktail of L. monocytogenes or Staphylococcus aureus and then stored at 20°C. Levels of S. aureus increased by ca. ≤1.4 log CFU/slice during storage for 90 days, whereas levels of L. monocytogenes remained relatively unchanged (≤0.2 log CFU/slice increase). Our data validated that cooking parameters elaborated in the U.S. Department of Agriculture's Food Safety and Inspection Service Cooking Guideline for Meat and Poultry Products (Revised Appendix A) are sufficient to deliver significant reductions (ca. ≥6.8 log CFU/ham) in levels of L.monocytogenes and Salmonella spp. on country ham. In addition, in the event of postprocessing contamination, country ham may support the outgrowth of S. aureus or survival of L. monocytogenes during storage at 20°C for 90 days.
Asunto(s)
Listeria monocytogenes , Productos de la Carne , Manipulación de Alimentos , Staphylococcus aureus , Recuento de Colonia Microbiana , Culinaria , Temperatura , Salmonella , Agua , Microbiología de AlimentosRESUMEN
Cells of Listeria monocytogenes, Salmonella spp., or Shiga toxin-producing Escherichia coli (STEC) were inoculated (ca. 4.0 log CFU/slice) onto slices (ca. 4 g each slice) of an all-beef soppressata (ca. pH 5.05 and aw 0.85). The storage of vacuum-sealed slices of inoculated soppressata at 4 °C or 20 °C for 90 days resulted in reductions of all three pathogens by ca. 2.2 to 3.1 or ca. ≥3.3 log CFU/slice, respectively. When pathogen levels decreased to below detection (≤1.18 log CFU/slice) by direct plating, it was possible to recover each of the target pathogens by enrichment, albeit more frequently from slices stored at 4 °C (p < 0.05) compared to 20 °C. In summary, the slices of the commercially produced beef soppressata selected for this study did not provide a favorable environment for either survival or outgrowth of surface-inoculated cells of L. monocytogenes, Salmonella spp., or STEC during storage.
RESUMEN
ABSTRACT: The primary objective of this study was to monitor viability of Shiga toxin-producing Escherichia coli (STEC), Salmonella spp., and Listeria monocytogenes during preparation and storage of fuet. Regarding methodology, coarse-ground pork (ca. 35% fat) was mixed with salt (2.5%), dextrose (0.3%), starter culture (ca. 7.0 log CFU/g), celery powder (0.5%), and ground black pepper (0.3%) and then separately inoculated with a multistrain cocktail (ca. 7.0 log CFU/g) of each pathogen. The batter was stuffed into a ca. 42-mm natural swine casing and fermented at 23 ± 2°C and ca. 95% ± 4% relative humidity to ≤pH 5.3 (≤48 h). Sausages were then dried at 12 ± 2°C and ca. 80% ± 4% relative humidity to a water activity (aw) of 0.89 (within 33 days) or aw 0.86 (within 60 days). A portion of each batch of fuet was subjected to high-pressure processing (HPP; 600 MPa for 3 min) before chubs were vacuum packaged and stored for 30 days at 20 ± 2°C. The results revealed that pathogen numbers remained relatively unchanged after fermentation (≤0.35 log CFU/g reduction), whereas reductions of ca. 0.8 to 3.2 log CFU/g were achieved after drying fuet to aw 0.89 or 0.86. Regardless of whether fuet was or was not pressure treated, additional reductions of ca. 2.2 to ≥5.3 log CFU/g after drying were achieved following 30 days of storage at 20°C. For non-HPP-treated fuet dried to aw 0.89 and stored for 30 days at 20°C, total reductions of ≥5.3 log CFU/g in levels of STEC or Salmonella spp. were achieved, whereas levels of L. monocytogenes were reduced by ca. 3.6 log CFU/g. Total reductions of ≥5.3 log CFU/g in levels of all three pathogens were achieved after drying non-HPP-treated fuet to aw 0.86. For fuet dried to aw 0.89 or 0.86, that were pressure treated and then stored for 30 days at 20°C, total reductions of >6.2 log CFU/g in levels of all three pathogens were achieved. In conclusion, the processing parameters tested herein, with or without application of HPP, validated that reductions of ≥2.0 or ≥5.0 log CFU/g in levels of STEC, Salmonella spp., and L. monocytogenes were achieved during preparation and storage of fuet.
Asunto(s)
Listeria monocytogenes , Carne de Cerdo , Carne Roja , Escherichia coli Shiga-Toxigénica , Animales , Microbiología de Alimentos , Conservación de Alimentos/métodos , Salmonella , PorcinosRESUMEN
ABSTRACT: A total of 482 veal cutlet, 555 ground veal, and 540 ground beef samples were purchased from retail establishments in the mid-Atlantic region of the United States over a noncontiguous 2-year period between 2014 and 2017. Samples (325 g each) were individually enriched and screened via real-time PCR for all seven regulated serogroups of Shiga toxin-producing Escherichia coli (STEC). Presumptive STEC-positive samples were subjected to serogroup-specific immunomagnetic separation and plated onto selective media. Up to five isolates typical for STEC from each sample were analyzed via multiplex PCR for both the virulence genes (i.e., eae, stx1 and/or stx2, and ehxA) and serogroup-specific gene(s) for the seven regulated STEC serogroups. The recovery rates of non-O157 STEC from veal cutlets (3.94%, 19 of 482 samples) and ground veal (7.03%, 39 of 555 samples) were significantly higher (P < 0.05) than that from ground beef (0.93%, 5 of 540 samples). In contrast, only a single isolate of STEC O157:H7 was recovered; this isolate originated from 1 (0.18%) of 555 samples of ground veal. Recovery rates for STEC were not associated with state, season, packaging type, or store type (P > 0.05) but were associated with brand and fat content (P < 0.05). Pulsed-field subtyping of the 270 viable and confirmed STEC isolates from the 64 total samples testing positive revealed 78 pulsotypes (50 to 80% similarity) belonging to 39 pulsogroups, with ≥90% similarity among pulsotypes within pulsogroups. Multiple isolates from 43 (67.7%) of 64 samples testing positive had an indistinguishable pulsotype. STEC serotypes O26 and O103 were the most prevalent serogroups in beef and veal, respectively. These findings support related findings from regulatory sampling studies over the past decade and confirm that recovery rates for the regulated STEC serogroups are higher for raw veal than for raw beef samples, as was observed in the present study of meat purchased at food retailers in the mid-Atlantic region of the United States.
Asunto(s)
Proteínas de Escherichia coli , Carne Roja , Escherichia coli Shiga-Toxigénica , Animales , Bovinos , Proteínas de Escherichia coli/genética , Carne , Mid-Atlantic Region , Serogrupo , Estados UnidosRESUMEN
ABSTRACT: Foodborne pathogens continue to pose a public health risk and can cause serious illness and significant outbreaks of disease in consumers. Toxoplasmosis is a zoonotic disease that occurs worldwide and is caused by the protozoan parasite, Toxoplasma gondii. The consumption of raw or undercooked infected meat, including pork, that contains infectious stages of T. gondii has been regarded as a major route of T. gondii transmission to humans. Given the occasional presence of T. gondii in pork meat, the frequent use of pork for products not intended to be cooked, such as dry-cured ham, presents a potential risk for its transmission to consumers. In this study, we investigated the viability of T. gondii in dry-cured whole hams processed using methods that were previously required for treatment of hams to inactivate Trichinella spiralis in the U.S. Code of Federal Regulations (9 CFR 318.10) and are now described in guidance documents from the U.S. Food Safety and Inspection Service. Infected pork hams were salted and cured for 33 days at 3°C and 85% ± 5% relative humidity (RH) and then were dried for up to 12 months at 12°C and 67.5% ± 2.5% RH. Inactivation of T. gondii was assessed in mouse bioassays and, serologically, by the modified agglutination test (MAT). Results showed that T. gondii bradyzoites were inactivated during the salting and curing step (33 days); no viable T. gondii was detected in the mouse bioassay and no evidence of serological conversion was detected by MAT in any of the mice inoculated with any of the samples tested during the drying step over the 12 months of the experiment. These results demonstrated that the approved protocols for production of dry-cured hams validated herein can inactivate T. gondii and lower the risk to consumers of this product.
Asunto(s)
Productos de la Carne , Toxoplasma , Toxoplasmosis Animal , Toxoplasmosis , Animales , Carne , Ratones , Carne de CerdoRESUMEN
Whole genome sequencing (WGS) was performed on 201 Listeria monocytogenes isolates recovered from 102 of 27,389 refrigerated ready-to-eat (RTE) food samples purchased at retail in U.S. FoodNet sites as part of the 2010-2013 interagency L. monocytogenes Market Basket Survey (Lm MBS). Core genome multi-locus sequence typing (cgMLST) and in-silico analyses were conducted, and these data were analyzed with metadata for isolates from five food groups: produce, seafood, dairy, meat, and combination foods. Six of 201 isolates, from 3 samples, were subsequently confirmed as L. welshimeri. Three samples contained one isolate per sample; mmong the 96 samples that contained two isolates per sample, 3 samples each contained two different strains and 93 samples each contained duplicate isolates. After 93 duplicate isolates were removed, the remaining 102 isolates were delineated into 29 clonal complexes (CCs) or singletons based on their sequence type. The five most prevalent CCs were CC155, CC1, CC5, CC87, and CC321. The Shannon's diversity index for clones per food group ranged from 1.49 for dairy to 2.32 for produce isolates, which were not significantly different in pairwise comparisons. The most common molecular serogroup as determined by in-silico analysis was IIa (45.6%), followed by IIb (27.2%), IVb (20.4%), and IIc (4.9%). The proportions of isolates within lineages I, II, and III were 48.0%, 50.0% and 2.0%, respectively. Full-length inlA was present in 89.3% of isolates. Listeria pathogenicity island 3 (LIPI-3) and LIPI-4 were found in 51% and 30.6% of lineage I isolates, respectively. Stress survival islet 1 (SSI-1) was present in 34.7% of lineage I isolates, 80.4% of lineage II isolates and the 2 lineage III isolates; SSI-2 was present only in the CC121 isolate. Plasmids were found in 48% of isolates, including 24.5% of lineage I isolates and 72.5% of lineage II isolates. Among the plasmid-carrying isolates, 100% contained at least one cadmium resistance cassette and 89.8% contained bcrABC, involved in quaternary ammonium compound tolerance. Multiple clusters of isolates from different food samples were identified by cgMLST which, along with available metadata, could aid in the investigation of possible cross-contamination and persistence events.
Asunto(s)
Microbiología de Alimentos , Variación Genética , Listeria monocytogenes/genética , Virulencia/genética , Proteínas Bacterianas/genética , ADN Bacteriano/química , ADN Bacteriano/metabolismo , Humanos , Listeria monocytogenes/clasificación , Listeria monocytogenes/aislamiento & purificación , Listeria monocytogenes/patogenicidad , Listeriosis/patología , Listeriosis/transmisión , Tipificación de Secuencias Multilocus , Filogenia , Plásmidos/genética , Plásmidos/metabolismo , Serogrupo , Secuenciación Completa del GenomaRESUMEN
High pressure processing (HPP) was evaluated to inactivate Shiga toxin-producing Escherichia coli (STEC) in raw meatballs. Ground meat (>90% lean) was inoculated (ca. 7.0 log CFU/g) with a rifampicin-resistant cocktail of eight STEC strains (O26:H11, O45:H2, O103:H2, O104:H4, O111:H-, O121:H19, O145:NM, and O157:H7). Inoculated ground beef, ground veal, or a mixture of ground beef, pork, and veal were separately mixed with liquid whole eggs and seasonings, shaped by hand into meatballs (40 g each), and stored at -20 or at 4 °C for at least 18 h. Samples were then exposed to 400 or 600 MPa for 0 to 18 min. There were no differences (p > 0.05) in pathogen reduction related to the species of meat used or for meatballs that were refrigerated (0.9 to 2.9 log CFU/g) compared to otherwise similar meatballs that were stored frozen (1.0 to 3.0 log CFU/g) prior to HPP treatment. However, less time was needed to achieve a ≥ 2.0 log CFU/g reduction at 600 MPa (1 to 3 min) compared to 400 MPa (at least 9 min). This work provides new and practically useful information on the use of HPP to inactivate STEC in raw meatballs.
RESUMEN
ABSTRACT: We evaluated high pressure processing to lower levels of Shiga toxin-producing Escherichia coli (STEC) and Listeria monocytogenes inoculated into samples of plant or beef burgers. Multistrain cocktails of STEC and L. monocytogenes were separately inoculated (â¼7.0 log CFU/g) into plant burgers or ground beef. Refrigerated (i.e., 4°C) or frozen (i.e., -20°C) samples (25 g each) were subsequently exposed to 350 MPa for up to 9 or 18 min or 600 MPa for up to 4.5 or 12 min. When refrigerated plant or beef burger samples were treated at 350 MPa for up to 9 min, levels of STEC were reduced by ca. 0.7 to 1.3 log CFU/g. However, when refrigerated plant or beef burger samples were treated at 350 MPa for up to 9 min, levels of L. monocytogenes remained relatively unchanged (ca. ≤0.3-log CFU/g decrease) in plant burger samples but were reduced by ca. 0.3 to 2.0 log CFU/g in ground beef. When refrigerated plant or beef burger samples were treated at 600 MPa for up to 4.5 min, levels of STEC and L. monocytogenes were reduced by ca. 0.7 to 4.1 and ca. 0.3 to 5.6 log CFU/g, respectively. Similarly, when frozen plant and beef burger samples were treated at 350 MPa up to 18 min, reductions of ca. 1.7 to 3.6 and ca. 0.6 to 3.6 log CFU/g in STEC and L. monocytogenes numbers, respectively, were observed. Exposure of frozen plant or beef burger samples to 600 MPa for up to 12 min resulted in reductions of ca. 2.4 to 4.4 and ca. 1.8 to 3.4 log CFU/g in levels of STEC and L. monocytogenes, respectively. Via empirical observation, pressurization did not adversely affect the color of plant burger samples, whereas appreciable changes in color were observed in pressurized ground beef. These data confirm that time and pressure levels already validated for control of STEC and L. monocytogenes in ground beef will likely be equally effective toward these same pathogens in plant burgers without causing untoward effects on product color.
Asunto(s)
Manipulación de Alimentos/métodos , Microbiología de Alimentos , Listeria monocytogenes , Productos de la Carne/microbiología , Escherichia coli Shiga-Toxigénica , Recuento de Colonia Microbiana , Inocuidad de los Alimentos , Humanos , Listeria monocytogenes/crecimiento & desarrollo , Escherichia coli Shiga-Toxigénica/crecimiento & desarrolloRESUMEN
ABSTRACT: The viability of Shiga toxin-producing Escherichia coli (STEC), Salmonella, and Listeria monocytogenes within plant- and beef-based burgers was monitored during storage and cooking. When inoculated (ca. 3.5 log CFU/g) into 15-g portions of plant- or beef-based burgers, levels of STEC and Salmonella decreased slightly (≤0.5-log decrease) in both types of burgers when stored at 4°C, but increased ca. 2.4 and 0.8 log CFU/g, respectively, in plant-based burgers but not beef-based burgers (≤1.2-log decrease), after 21 days at 10°C. For L. monocytogenes, levels increased by ca. 1.3 and 2.6 log CFU/g in plant burgers after 21 days at 4 and 10°C, respectively, whereas pathogen levels decreased slightly (≤0.9-log decrease) in beef burgers during storage at 4 and 10°C. Regarding cooking, burgers (ca. 114 g each) were inoculated with ca. 7.0 log CFU/g STEC, Salmonella, or L. monocytogenes and cooked in a sauté pan. Cooking plant- or beef-based burgers to 62.8°C (145°F), 68.3°C (155°F), or 73.9°C (165°F) delivered reductions ranging from ca. 4.7 to 6.8 log CFU/g for STEC, ca. 4.4 to 7.0 log CFU/g for L. monocytogenes, and ca. 3.5 to 6.7 log CFU/g for Salmonella. In summary, the observation that levels of all three pathogens increased by ca. 1.0 to ca. 2.5 log CFU/g in plant-based burgers when stored at an abusive temperature (10°C) highlights the importance of proper storage (4°C) to lessen risk. However, because all three pathogens responded similarly to heat in plant-based as in beef-based burgers, well-established cooking parameters required to eliminate STEC, Salmonella, or L. monocytogenes from ground beef should be as effective for controlling cells of these same pathogens in a burger made with plant-sourced protein.
Asunto(s)
Manipulación de Alimentos/métodos , Microbiología de Alimentos , Listeria monocytogenes , Salmonella , Escherichia coli Shiga-Toxigénica , Animales , Bovinos , Recuento de Colonia Microbiana , Listeria monocytogenes/crecimiento & desarrollo , Productos de la Carne/microbiología , Salmonella/crecimiento & desarrollo , Escherichia coli Shiga-Toxigénica/crecimiento & desarrolloRESUMEN
A total of 514 raw pork samples (395 ground or nonintact and 119 intact samples) were purchased at retail stores in Pennsylvania, Delaware, and New Jersey between July and December 2017. All raw pork samples were screened for serogroup O26, O45, O103, O111, O121, O145, or O157:H7 cells of Shiga toxin-producing Escherichia coli (STEC-7) using standard microbiological and molecular methods. In short, 21 (5.3%) of the 395 ground or nonintact pork samples and 3 (3.4%) of the 119 intact pork samples tested positive via the BAX system real-time PCR assay for the stx and eae virulence genes and for the somatic O antigens for at least one of the STEC-7 serogroups. However, none of these 24 presumptive-positive pork samples subsequently yielded a viable isolate of STEC displaying a STEC-7 serogroup-specific surface antigen in combination with the stx and eae genes. These data suggest that cells of STEC serogroups O26, O45, O103, O111, O121, O145, or O157:H7 are not common in retail raw pork samples in the mid-Atlantic region of the United States.
Asunto(s)
Microbiología de Alimentos , Carne de Cerdo , Serogrupo , Escherichia coli Shiga-Toxigénica , Animales , Mid-Atlantic Region , Carne de Cerdo/microbiología , Escherichia coli Shiga-Toxigénica/clasificación , Escherichia coli Shiga-Toxigénica/aislamiento & purificaciónRESUMEN
Meat bars are dried snacks containing a mixture of meat, berries, and nuts. To explore consumer awareness of meat bars, we conducted two online, nationally representative surveys and established that 70.8% (743 of 1,050) of U.S. citizens were unfamiliar with this product. When asked to check all answers that applied, most of the 545 respondents (who were recruited based on their familiarity with meat bars) preferred beef (n = 385) as the protein source, followed by chicken (n = 293), pork (n = 183), and turkey (n = 179). Most meat bars were purchased from grocery stores (n = 447), followed by online orders (n = 130) and outdoor stores (n = 120). When asked specifically whether they made their own meat bars, 17.8% of respondents (97 of 545) replied "yes," the majority (52 of 97, 54%) of which obtained recipes online. Some 69.1% (67 of 97) measured the internal temperature of the meat during dehydration, but only 10.3% (10 of 97) confirmed the internal temperature by using a thermometer. Given the paucity of information available on the fate of pathogenic or spoilage bacteria associated with meat bars, as another component of this study, batter was prepared with or without encapsulated citric acid (ECA; 0.74%) added to a formulation of ground beef (65%; 90% lean, 10% fat), chopped pecans (15%), golden flaxseed flour (9.7%), chopped cranberries (5.0%), chopped sunflower seeds (3.1%), sea salt (1.1%), black pepper (0.8%), and celery powder (0.35%). Batter was inoculated (ca. 6.5 log CFU/g) with Shiga toxin-producing Escherichia coli (STEC), portioned by hand (40 ± 0.1 g each), and then dried in a commercial dehydrator. Regardless of the drying treatment, inclusion of ECA in the batter resulted in a pH decrease from ca. 5.5 to ca. 4.7 to 5.0 in the finished product. Without ECA, when meat bars were dried at 62.8°C for 6 h, 71.1°C for 4 h, or 62.8°C for 2 h and then 71.1°C for 2 h, levels of STEC decreased by ca. 6.2, 6.3, or 5.2 log CFU/g, respectively. With ECA, STEC decreased by ca. 6.0, 6.6, or 6.0 log CFU/g in meat bars dried at 62.8°C for 6 h, 71.1°C for 4 h, or 62.8°C for 2 h and then 71.1°C for 2 h, respectively. Our results confirmed that a ≥5.0-log reduction in STEC could be achieved in meat bars formulated with or without ECA under all dehydration conditions tested.
Asunto(s)
Manipulación de Alimentos , Microbiología de Alimentos , Alimentos en Conserva , Carne , Viabilidad Microbiana , Escherichia coli Shiga-Toxigénica , Encuestas y Cuestionarios , Animales , Bovinos , Recuento de Colonia Microbiana , Manipulación de Alimentos/estadística & datos numéricos , Microbiología de Alimentos/estadística & datos numéricos , Alimentos en Conserva/microbiología , Carne/microbiología , Escherichia coli Shiga-Toxigénica/fisiologíaRESUMEN
HIGHLIGHTS: Cooking may reduce the potential risk of salmonellosis associated with liver pâté. A 5-log reduction was achieved when inoculated pâté was cooked to an internal temperature of ≥73.8°C. A 5-log reduction was achieved when pâté was made with inoculated liver fried for >8 min at 140°C. Findings of this study may be useful for establishing cooking guidelines for liver and pâté.
Asunto(s)
Pollos , Microbiología de Alimentos , Calor , Hígado , Viabilidad Microbiana , Salmonella , Animales , Recuento de Colonia Microbiana , Microbiología de Alimentos/métodos , Hígado/microbiología , Salmonella/fisiologíaRESUMEN
We surveyed chicken livers from various sources for the presence and levels of Salmonella. The pathogen was recovered from 148 (59.4%) of 249 chicken livers purchased at retail stores in Delaware, New Jersey, and Pennsylvania over about a 9-month period. Positive samples harbored Salmonella at levels of 6.4 most probable number (MPN)/g to 2.4 log CFU/g. The percentage of Salmonella-positive livers purchased at retail outlets in New Jersey (72%, 59 of 82 livers) was significantly higher (P < 0.05) than the percentage for livers purchased in Delaware (48%, 36 of 75 livers); however, this percentage was not significantly different (P > 0.05) from that for livers purchased in Pennsylvania (57.6%, 53 of 92 livers). The pathogen was also recovered more often (P = 0.019) from livers that were packaged by retailers (81 of 121 livers, 66.9%) than from livers packaged directly by processors (67 of 128 livers, 52.3%). In related studies, 12 (5.8%) of 207 chicken livers harvested from birds on a research farm tested positive for Salmonella at levels of 0.4 to 2.2 MPN/g. The recovery rate of Salmonella was 4.4% (6 of 135 livers) from livers with the gall bladder attached and 8.3% (6 of 72 livers) from livers when the gall bladder was removed at harvest on the research farm. We also quantified the levels of a nine-strain cocktail (ca. 6.5 log CFU/g) of Salmonella strains inoculated externally onto or internally into livers both before and after extended cold storage. Storage for at least 2 days at 4°C or 15 days at -20°C resulted in a decrease of about 1.0 log CFU/g in pathogen levels. Given the relatively high recovery rate (ca. 6.0 to 60.0%) and high (possibly illness causing) levels (0.4 MPN/g to 2.4 CFU/g) of Salmonella associated with chicken livers in the present study, further interventions for processors are needed to lower the prevalence and levels of this pathogen on poultry liver.
Asunto(s)
Pollos , Recuento de Colonia Microbiana , Microbiología de Alimentos , Hígado , Salmonella , Animales , Microbiología de Alimentos/estadística & datos numéricos , Hígado/microbiología , Prevalencia , Salmonella/aislamiento & purificación , Salmonella/fisiologíaRESUMEN
Coarse ground meat was mixed with non-meat ingredients and starter culture (Pediococcus acidilactici) and then inoculated with an 8-strain cocktail of Shiga toxin-producing Escherichia coli (ca. 7.0 log CFU/g). Batter was fine ground, stuffed into fibrous casings, and fermented at 35.6°C and ca. 85% RH to a final target pH of ca. pH 4.6 or ca. pH 5.0. After fermentation, the pepperoni-like sausage were heated to target internal temperatures of 37.8°, 43.3°, 48.9°, and 54.4°C and held for 0.5 to 12.5 h. Regardless of the heating temperature, the endpoint pH in products fermented to a target pH of pH 4.6 and pH 5.0 was pH 4.56±0.13 (range of pH 4.20 to pH 4.86) and pH 4.96±0.12 (range of pH 4.70 to pH 5.21), respectively. Fermentation alone delivered ca. a 0.3- to 1.2-log CFU/g reduction in pathogen numbers. Fermentation to ca. pH 4.6 or ca. pH 5.0 followed by post-fermentation heating to 37.8° to 54.4°C and holding for 0.5 to 12.5 h generated total reductions of ca. 2.0 to 6.7 log CFU/g.
RESUMEN
All-pork mortadella, an Italian-style deli meat, was produced by a local artisanal meat producer with or without 1.0 or 1.5% liquid buffered vinegar (LBV), 0.4, 0.6, or 1.0% dry buffered vinegar (DBV), or a 2.5% blend of potassium lactate and sodium diacetate (KLac). In each of three trials, mortadella was sliced (ca. 1.5 cm thick, ca. 30 g) and surface inoculated with 250 µL per side of a five-strain mixture of Listeria monocytogenes (ca. 3.8 log CFU per slice). The packages were vacuum sealed and then stored at 4 or 12°C. In the absence of antimicrobials, L. monocytogenes levels increased by ca. 2.6 and 6.0 log CFU per slice after up to 120 or 28 days at 4 or 12°C, respectively. With inclusion of 1.0 or 1.5% LBV, 1.0% DBV, or 2.5% KLac as ingredients, pathogen levels decreased by ca. 0.3 to 0.7 log CFU per slice after 120 days at 4°C, whereas with inclusion of 0.4 or 0.6% DBV, L. monocytogenes levels increased by ca. 1.2 and 0.8 log CFU per slice, respectively. After 28 days at 12°C, inclusion of 2.5% KLac, 1.0 or 1.5% LBV, or 0.4 or 0.6% DBV resulted in a ca. 1.4- to 5.7-log increase in L. monocytogenes levels. When 1.0% DBV was included in the formulation, pathogen levels remained unchanged after 28 days at 12°C. However, product quality was lessened at this abusive storage temperature (12°C) for all treatments by the end of storage. Thus, inclusion of LBV or DBV, as clean-label ingredients, in mortadella is equally effective as KLac for controlling L. monocytogenes during storage at 4°C without adversely affecting product quality.
Asunto(s)
Antiinfecciosos , Almacenamiento de Alimentos/instrumentación , Listeria monocytogenes , Productos de la Carne , Antiinfecciosos/farmacología , Recuento de Colonia Microbiana , Conservación de Alimentos , Lactatos , Listeria monocytogenes/efectos de los fármacos , Listeria monocytogenes/crecimiento & desarrollo , Productos de la Carne/microbiología , TemperaturaRESUMEN
Scalding of hide-on bob veal carcasses with or without standard scalding chemical agents typically used for hogs, followed by an 82.2°C hot water wash and lactic acid spray (applied at ambient temperature) before chilling, was evaluated to determine its effectiveness in reducing Shiga toxin-producing Escherichia coli surrogate populations. A five-strain cocktail of rifampin-resistant, nonpathogenic E. coli surrogates was used to inoculate hides of veal carcasses immediately after exsanguination (target inoculation level of 7.0 log CFU/100 cm2). For carcasses receiving no scalding treatments, spraying with 82.2°C water as a final wash resulted in a 4.5-log CFU/100 cm2 surrogate reduction, and an additional 1.2-log CFU/100 cm2 reduction was achieved by spraying with 4.5% lactic acid before chilling. Scalding hide-on carcasses in 60°C water (no chemicals added) for 4 min in a traditional hog scalding tank resulted in a 2.1-log CFU/100 cm2 reduction in surrogate levels, and a subsequent preevisceration 82.2°C water wash provided an additional 2.9-log CFU/100 cm2 reduction. Spraying a 4.5% solution of lactic acid onto scalded, hide-on carcasses (after the 82.2°C water wash) resulted in a minimal additional reduction of 0.4 log CFU/100 cm2. Incorporation of scalding chemicals into the scald water resulted in a 4.1-log CFU/100 cm2 reduction (1.9 log CFU/100 cm2 greater than scalding without chemicals) in the surrogate population, and the first 82.2°C wash provided an additional 2.5-log CFU/100 cm2 reduction. Application of antimicrobial interventions did not affect the carcass temperature decline during chilling, the pH decline, or the color characteristics of the ribeye or the flank of the bob veal carcasses.
Asunto(s)
Antiinfecciosos , Bovinos/microbiología , Contaminación de Alimentos/prevención & control , Ácido Láctico/farmacología , Escherichia coli Shiga-Toxigénica , Animales , Antibacterianos , Antiinfecciosos/farmacología , Calor , Carne , Escherichia coli Shiga-Toxigénica/efectos de los fármacos , Escherichia coli Shiga-Toxigénica/aislamiento & purificación , AguaRESUMEN
In total, 115 marinade samples (58 fresh marinades and 57 spent marinades) were collected over 12 months from specialty retailers (four individual stores) near Raleigh, NC. These marinades were screened for total mesophilic aerobic plate count (M-APC), total psychrotrophic aerobic plate count (P-APC), and Enterobacteriaceae. These marinades were also screened for the seven regulated serogroups of Shiga toxin-producing Escherichia coli. Stores A and B used immersion to marinade raw beef cuts, whereas stores C-1 and C-2 used vacuum tumbling. In general, marinade temperatures at the stores ranged from 1.8 to 6.6°C, and beef cuts were marinated from a few minutes to up to 3 days. Regardless of the process used to marinade meat, levels of M-APC and P-APC in fresh marinades ranged from 3.4 to 4.7 and 1.4 to 1.8 log CFU/mL, respectively, whereas Enterobacteriaceae were not detected in any fresh marinades, even after enrichment. However, levels of M-APC, P-APC, and Enterobacteriaceae in spent marinades collected from stores C-1 and C-2 (ca. 3.6 to 7.1 log CFU/mL) were significantly higher (P < 0.05) compared with levels of these same types of bacteria enumerated from spent marinades collected at stores A and B (ca. ≤0.7 to 4.9 log CFU/mL). None of the 115 marinade samples tested positive for Shiga toxin-producing E. coli by using a BAX system real-time PCR assay. No significant (P > 0.05) association was observed between microbial levels (i.e., M-APC, P-APC, and Enterobacteriaceae) and the temperature or duration of the marination process. Levels of M-APC, P-APC, and Enterobacteriaceae in spent marinades were significantly affected by the marination method (P < 0.05), with levels, in general, being higher in marinades used for tumbling. Thus, retailers must continue to keep marinade solutions and meat at a safe temperature (i.e., ≤4°C) and to properly and frequently sanitize the equipment and environment in both the processing area and deli case.
RESUMEN
To better understand how consumers perceive food safety risks in retail food store settings, a survey was administered to 1,041 nationally representative participants who evaluated possible food safety risks depicted in selected photographs and self-reported their perceptions, attitudes, and behaviors. Participants were shown 12 photographs taken at retail stores portraying either commonly perceived or actual food safety contributing factors, such as cross-contamination, product and equipment temperatures, worker hygiene, and/or store sanitation practices. Participants were then asked to specifically identify what they saw, comment as to whether what they saw was safe or unsafe, and articulate what actions they would take in response to these situations. In addition to the survey, focus groups were employed to supplement survey findings with qualitative data. Survey respondents identified risk factors for six of nine actual contributing factor photographs >50% of the time: poor produce storage sanitation (86%, n = 899), cross-contamination during meat slicing (72%, n = 750), bare-hand contact of ready-to-eat food in the deli area (67%, n = 698), separation of raw and ready-to-eat food in the seafood case (63%, n = 660), cross-contamination from serving utensils in the deli case (62%, n = 644), and incorrect product storage temperature (51%, n = 528). On a scale of 1 to 5, where 1 was very unsafe and 5 was very safe, a significant difference was found between average risk perception scores for photographs of actual contributing factors (score of ca. 2.5) and scores for photographs of perceived contributing factors (score of ca. 2.0). Themes from the focus groups supported the results of the survey and provided additional insight into consumer food safety risk perceptions. The results of this study inform communication interventions for consumers and retail food safety professionals aimed at improving hazard identification.
Asunto(s)
Seguridad de Productos para el Consumidor , Comida Rápida/normas , Inocuidad de los Alimentos , Contaminación de Alimentos , Manipulación de Alimentos , Microbiología de Alimentos , Humanos , Productos de la Carne , Alimentos MarinosRESUMEN
The efficacy of an electrostatic spraying system (ESS) and/or the sprayed lethality in container (SLIC) method to deliver antimicrobial agents onto the surface of beef subprimals to reduce levels of Shiga toxin-producing Escherichia coli (STEC) was evaluated. Beef subprimals were surface inoculated (lean side; ca. 5.8 log CFU per subprimal) with 2 mL of an eight-strain cocktail comprising single strains of rifampin-resistant (100 µg/mL) STEC (O26:H11, O45:H2, O103:H2, O104:H4, O111:H-, O121:H19, O145:NM, and O157:H7). Next, inoculated subprimals were surface treated with lauric arginate (LAE; 1%), peroxyacetic acid (PAA; 0.025%), or cetylpyridinium chloride (CPC; 0.4%) by passing each subprimal, with the inoculated lean side facing upward, through an ESS cabinet or via SLIC. Subprimals were then vacuum packaged and stored at 4°C. One set of subprimals was sampled after an additional 2 h, 3 days, or 7 days of refrigerated storage, whereas another set was retreated via SLIC after 3 days of storage with a different one of the three antimicrobial agents (e.g., a subprimal treated with LAE on day 0 was then treated with PAA or CPE on day 3). Retreated subprimals were sampled after 2 h or 4 days of additional storage at 4°C. A single initial application of LAE, PAA, or CPC via ESS or SLIC resulted in STEC reductions of ca. 0.3 to 1.3 log CFU per subprimal after 7 days of storage. However, when subprimals were initially treated with LAE, PAA, or CPC via ESS or SLIC and then separately retreated with a different one of these antimicrobial agents via SLIC on day 3, additional STEC reductions of 0.4 to 1.0 log CFU per subprimal were observed after an additional 4 days of storage. Application of LAE, PAA, or CPC, either alone or in combination, via ESS or SLIC is effective for reducing low levels (ca. 0.3 to 1.6 log CFU) of STEC that may be naturally present on the surface of beef subprimals.