Application of gamma radiation in the beef texture development during accelerated aging.

This study aimed to evaluate the effects of gamma radiation (3 kGy) on the quality of post-rigor beef (M. longissimus lumborum) aged for up to 21 days at different temperatures (1, 7, and 15°C). Irradiation reduced the mesophilic and lactic acid bacteria counts, which were higher in the non-irradiated samples aged at 7 and 15°C. The water retention capacity was lower in the irradiated beef, resulting in higher values of exudation and cooking losses. High aging temperatures increased the exudation loss and myofibrillar proteolysis (lower fragmentation index; FI) and reduced the total and insoluble collagen contents and the beef Warner-Bratzler square Shear Force (WBsSF). However, irradiated beef had higher FI and SF than non-irradiated ones, increasing the time required for the beef tenderizing. Gamma irradiation (3 kGy) can be used to ensure the microbiological safety during short storage at high temperatures (up to 15°C) in order to accelerate the process of beef tenderizing.

Assessment of Japanese radish derivatives as nitrite substitute on the physicochemical properties, sensorial profile, and consumer acceptability of restructured cooked hams.

This study aimed to evaluate the technological and sensory properties of restructured cooked hams prepared with natural curing agents (0.5% radish powder, HRP; 3% radish juice, HRJ; and 0.5% radish pulp powder, HRPP) and with 40 and 150 mg/kg sodium nitrite (HN40 and HN150, respectively). No difference was observed for pH, proximate composition, or cooking loss. Higher residual nitrite contents were observed in the HN150, followed by the radish derivatives hams and HN40. All radish derivatives hams had a similar hue (h) color to HN40, but the h values of HRJ also did not differ from the HN150 ones. The stability of the cured color was not affected. Consumers perceived a non-characteristic aroma and flavor in the radish derivatives hams, but the HRJ had the best acceptance scores. The HRJ appearance was similar to the HN150, and the other sensory attributes were like the HN40. The potential use of radish derivatives, especially radish juice, as natural curing agents was confirmed.

Effect of freezing/irradiation/thawing processes and subsequent aging on tenderness, color, and oxidative properties of beef.

This study evaluated the use of gamma irradiation (3, 6 and 9 kGy) in frozen vacuum-packed beef and subsequent thawing and aging for up to 14 days. The effects on tenderness, color, and oxidative properties were determined and compared to non-irradiated controls for frozen/thawed and chilled vacuum-packed beef. The combined irradiation and freezing/thawing processes increased total exudate loss and reduced the meat water-holding capacity, regardless of the dose used. Myofibrillar fragmentation was favored by the freezing/thawing processes and negatively affected by irradiation. Lower shear force values were observed in the non-irradiated frozen/thawed samples. Frozen samples irradiated at 9 kGy had a higher percentage of soluble collagen, lipid peroxidation, and a more reddish color tone. The meat reducing capacity and oxygen consumption were reduced by freezing and further by irradiation, which also included accumulation of metmyoglobin. It was concluded that irradiation of frozen meat and its subsequent thawing and aging does not confer any additional advantages for beef technological quality.

Combined effects of gamma irradiation and aging on tenderness and quality of beef from Nellore cattle.

Combined effects of gamma irradiation (0, 3, 6 and 9 kGy) and aging (1 and 14 days) on quality attributes of vacuum-packaged beef from Nellore cattle were evaluated. The meat water holding capacity was affected by irradiation, increasing (p < 0.05) purge and cooking loss regardless of the dose used. Irradiation negatively affected myofibrillar fragmentation, but samples irradiated at 9 kGy had (p < 0.05) higher soluble collagen and lower shear force values. The meat metmyoglobin reducing activity was reduced (p < 0.05) by the irradiation process, inducing the metmyoglobin accumulation with increasing dose applied. Samples irradiated at 9 kGy presented (p < 0.05) higher lipid oxidation and lower oxymyoglobin proportion and color redness and chroma values. It was concluded that irradiation at 9 kGy combined with aging can be used as an effective tool for improving the tenderness of Nellore beef, but resulted in a discoloration of the beef.

Sensory profile and technological characterization of boneless dry-cured ham with lactulose added as a prebiotic.

OBJECTIVE: This study investigates the technological and sensory profile of boneless dry-cured ham added with different contents of lactulose as a prebiotic ingredient. METHODS: In addition to the control samples (without the addition of lactulose), three treatments were formulated to contain 2, 4 or 6% lactulose. Technological (lactulose content, CIE color and texture profile analysis) and sensory (acceptance and check-all-that-applies tests) analyses were performed on the final product. RESULTS: The lactulose content in the finished product (1.86±0.23%, 3.16±0.18% and 2.51±1.35%) was lower than the lactulose originally added (2, 4 and 6% respectively). The addition of 4% and 6% lactulose made (P &lt; 0.05) the products darker (lower L*) and redder (lower h) with higher hardness and chewiness values, when compared to control samples. The additions of 2% and 4% lactulose reduce the appearance acceptability of the products, but overall the treatments were well accepted. CONCLUSION: The use of up to 4% lactulose as a prebiotic in the production of boneless dry-cured hams provides an alternative to improving its nutritional value with little alteration in the technological characteristics and still meeting the sensory characteristics desired by consumers.

Caracterização de carne mecanicamente separada de coelho / Characterization of mechanically deboned rabbit meat

Objetivou-se elaborar e caracterizar carne mecanicamente separada (CMS) de coelho (CMSC), comparando-a à CMS de frango (CMSF). As amostras foram analisadas quanto ao pH, composição centesimal, teor de cálcio, índice de peróxido (IP), índice de TBARS, pigmentos heme totais (PHT) e cor CIELAB. Com exceção para os valores de IP, a CMSC atendou aos critérios legais brasileiros para CMS, apresentando um maior teor proteico (19,08 x 12,66%) e menor teor de gordura (9,44 x 17,47%) do que a CMSF. A CMSC apresentou maior PHT (35,36 x 137,90 mg/g), o que justifica sua tonalidade menos avermelhada (h = 51,98 x 43,27) e menos intensa (C* = 23,91 x 30,26) do que a CMSF. Concluiu-se que a CMS de coelho possui um grande potencial para uso como ingrediente cárneo.

Avaliação de diferentes métodos de cozimento e de cisalhamento na determinação da maciez de lombos suínos de diferentes qualidades / Evaluation of different cooking and shear methods to assess tenderness of pork loins from different qualities

Objetivou-se avaliar a maciez de lombos suínos (M. Longissimus thoracis) de diferentes classes de qualidade (RFN, PSE e RSE) por dois métodos de cozimento (micro-ondas e grelha) e dois protocolos (SSF e WBsSF) de determinação de força de cisalhamento (FC). As classes de qualidade de carne suína não difeririam (P>0,05) quanto a FC, independentemente do método de cozimento ou protocolo de cisalhamento usado. Maior repetibilidade da FC foi observada quando do cozimento em micro-ondas (SSF = 0,77; WBsSF = 0,75), tendo alta correlação (r = 0,72) entre os dois protocolos. Concluiu-se que que as classes de qualidade da carne suína não diferem quanto à maciez instrumental e que o cozimento em micro-ondas associado ao protocolo SSF é altamente promissor para avaliação da maciez instrumental da carne suína.

Comparação dos colorímetros Nix Color Sensor Pro e MINOLTA CM-5 na avaliação da cor da carne bovina descongelada e maturada / Comparison of Nix Color Sensor Pro and MINOLTA CM-5 colorimeters in the evaluation of thawed and aged beef color

O objetivo deste trabalho foi comparar a capacidade dos colorímetros Nix Color Sensor Pro (NIX) e CM-5 (MINOLTA) para detectar a variação de cor em amostras de carne bovina submetidas a diferentes taxas de congelamento (lento x rápido) e diferentes tempos de maturação (0 e 14 dias). Todos os índices de cor mensurados foram maiores (P<0,05) no colorímetro MINOLTA do que no colorímetro NIX, que registra a cor das amostras cárneas como sendo mais escuras, com menor intensidade e com tonalidade menos vermelha. A variação nos índices de cor medida pelos aparelhos não foi compatível, indicando efeitos diferentes pelos tratamentos avaliados. Conclui-se que o NIX não pode ser considerado comparável ao MINOLTA ao medir a cor da carne bovina.

Efeito da radiação gama sobre a oxidação lipídica da carne bovina / Effect of gamma radiation on lipid oxidation of beef

Objetivou-se avaliar o efeito de diferentes doses de radiação (1, 2, 3, 6 e 9 kGy) sobre a oxidação lipídica de contrafilés bovinos pela determinação das substâncias reativas ao ácido 2-tiobarbitúrico (TBARS) e por cromatografia gasosa utilizando a técnica de microextração em fase sólida (SPME). As amostras irradiadas apresentaram maior concentração de aldeídos, com maior incidência de nonanal, independentemente da dose aplicada. Maiores concentrações de hexanal foram observadas nas amostras irradiadas por maiores doses (6 e 9 kGy), mas os maiores valores de TBARS foram observados nas amostras irradiadas por 3 e 6 kGy. Uma redução nos valores de aldeídos, especialmente nonanal e octanal, foi observada para amostras irradiadas por 2 kGy quando comparadas às demais amostras irradiadas. Conclui-se que o processo de irradiação aumentou o grau de oxidação das amostras, que consequentemente, aumentou a concentração dos aldeídos presentes.

Efeitos do congelamento lento e rápido prévios à maturação na maciez da carne bovina / Effects of slow and fast freezing prior to aging on beef tenderness

Na presente pesquisa foi analisada a influência do congelamento lento (-20 °C, ar estático) e rápido (-25 °C, ar forçado) seguido da maturação (0 e 14 dias) na maciez de contrafilé de bovinos da raça Nelore. Apenas as amostras não-congeladas e maturadas por 14 dias apresentaram maiores (P < 0,05) valores de pH do que as demais. Não foi verificado efeito significativo para a PPC (média de 23,34%), enquanto que as purgas foram maiores nas amostras congeladas do que nas não-congeladas (2,52 x 11,06%), independentemente da taxa de congelamento. Amostras congeladas rapidamente apresentaram menores força de cisalhamento do que as congeladas lentamente, mas ambas não diferiram das amostras não-congeladas. Concluiu-se que o congelamento, mesmo em diferentes taxas, associado à maturação não influenciou a maciez da carne bovina.

Efeitos do congelamento prévio à maturação na aceitação sensorial da cor da carne bovina / Effects of freezing/thawing and aging on sensorial beef color

Objetivou-se avaliar o efeito do congelamento prévio a maturação (0 e 14 dias) sobre a aceitação sensorial da cor da carne bovina, comparando com amostras não-congeladas. O congelamento reduziu os valores de pH das amostras (de 5,58 para 5,48) e aumentou a proporção de oximioglobina (de 69 para 73%) nas amostras não-maturadas. Todos os índices de cor foram afetados pelo tempo de maturação, ficando mais claras (maior L*), com tonalidade vermelha mais alaranjada (maior h) e mais intensa (maior C*). O congelamento reduziu os valores de L*, sendo que as amostras congeladas e maturadas por 14 dias foram percebidas como mais claras e reduziu a intenção de compra dos avaliadores. Conclui-se que o congelamento tem pouco efeito sob a coloração da carne, mas a maturação subsequente reduziu a sua aceitação.

Percepção sensorial do off-odor em carnes bovinas irradiadas em embalagens á vácuo contendo carvão ativado / Off-odor perception in irradiated beef vacuum packaged with charcoal

Objetivou-se avaliar a utilização de carvão ativo na redução de compostos voláteis responsáveis pelo off-odor de carnes bovinas irradiadas. Para tal, contrafilés bovinos, embalados a vácuo, com e sem carvão ativo, e irradiados (1, 2 e 3 kGy), foram analisados quanto a formação de compostos de enxofre e quanto a percepção sensorial de off-odor. O único composto de enxofre identificado nas amostras foi o dimetil sulfeto (DMS), sendo encontrado em menor concentração nas amostras irradiadas com carvão ativo na embalagem. Independentemente da utilização do carvão, os painelistas perceberam o off-odor das carnes irradiadas em qualquer dose quando comparado à carne não-irradiada. Quando foi comparado as carnes irradiadas com carvão em relação àquelas irradiadas sem carvão, os painelistas foram capazes de identificar o off-odor apenas nas amostras irradiadas com 1 kGy. Conclui-se que o carvão ativo reduziu a concentração de DMS na embalagem de carnes irradiadas.

Effects of PSE meat and salt concentration on the technological and sensory characteristics of restructured cooked hams.

The effects of the use of normal and pale, soft, and exudative (PSE) meat on the technological and sensorial quality of restructured cooked hams elaborated with different salt contents (0.8, 1.2, 1.6, 2.0, and 2.4%) were investigated. A low salt content implied (P < .05) high cooking loss (6.27 vs 3.25%), expressive moisture and C* values and low hardness. Products elaborated with PSE meat had (P < .05) lower cohesiveness, energy to fracture and hue tone colour and higher springiness than did samples elaborated with normal meat. Salty taste perception was slightly higher for the PSE meat-based products, which were also preferred by the assessors when salt contents lower than 1.6% were used. It was concluded that when PSE meat was used, the addition of 1.2% salt was sufficient to maintain the technological and sensory characteristics of the restructured cooked hams.

Retail display of beef steaks coated with monolayer and bilayer chitosan-gelatin composites.

The effects of edible monolayer and bilayer chitosan-gelatin coatings on the weight loss, lipid oxidation, color preservation (display-life), and shelf-life of beef steaks during 10 days of retail display (at 4 °C; 12 h light/day) were evaluated. The edible coatings had a homogeneous crack-free surface, with the bilayer films being two times thicker than the monolayer coatings. During storage, the control samples had higher pH values and more weight loss (P < .05) than the coated ones. The coatings effectively retarded (P < .05) lipid oxidation and microbial growth (psychrotrophic bacteria, molds, and yeast), extending the shelf-life from 6 to 10 days. The coatings also significantly prevented metmyoglobin accumulation on the beef surface, as reflected in the maintenance of the CIE color indices and sensorial redness perception throughout storage. These effects were similar for both the monolayer and bilayer films, suggesting that chitosan-gelatin coatings could improve the shelf-life and display-life of beef during retail storage.