Thermal inactivation and injury of Bacillus stearothermophilus spores.

Aqueous spore suspensions of Bacillus stearothermophilus ATCC 12980 were heated at different temperatures for various time intervals in a resistometer, spread plated on antibiotic assay medium supplemented with 0.1% soluble starch without (AAMS) or with (AAMS-S) 0.9% NaCl, and incubated at 55 degrees C unless otherwise indicated. Uninjured spores formed colonies on AAMS and AAMS-S; injured spores formed colonies only on AAMS. Values of D, the decimal reduction time (time required at a given temperature for destruction of 90% of the cells), when survivors were recovered on AAMS were 62.04, 18.00, 8.00, 3.33, and 1.05 min at 112.8, 115.6, 118.3, 121.1, and 123.9 degrees C, respectively. Recovery on AAMS-S resulted in reduced decimal reduction time. The computed z value (the temperature change which will alter the D value by a factor of 10) for spores recovered on AAMS was 8.3 degrees C; for spores recovered on AAMS-S, it was 7.6 degrees C. The rates of inactivation and injury were similar. Injury (judged by salt sensitivity) was a linear function of the heating temperature. At a heating temperature of less than or equal to 118.3 degrees C, spore injury was indicated by the curvilinear portion of the survival curve (judged by salt sensitivity), showing that injury occurred early in the thermal treatment as well as during logarithmic inactivation (reduced decimal reduction time). Heat-injured spores showed an increased sensitivity not only to 0.9% NaCl but also to other postprocessing environmental factors such as incubation temperatures, a pH of 6.6 for the medium, and anaerobiosis during incubation.

Factors affecting inactivation of Moraxella-Acinetobacter cells in an irradiation process.

The effect of various stages of the irradiation processing of beef on the injury and inactivation of radiation-resistant Moraxella-Acinetobactor cells was studied. Moraxella-Acinetobacter cells were more resistant to heat inactivation and injury when heated in meat with salts (0.75% NaCl and 0.375% sodium tripolyphosphate) then in meat without salts. These salts had no effect on radiation resistance. Both radiation- and heat-injured cells were unable to form colonies at 30 degrees C in plate count agar containing 0.8% NaCl. Neither unstressed nor heat-stressed cells were able to multiply in minced beef incubated at 30 degrees C for 12 h. Only after the beef was diluted 1:10 with peptone water were the heat-injured cells able to repair and eventually multiply. Heated cells were more sensitive to radiation inactivation and injury than unheated cells. After repair, the cells regained their resistance to both NaCl and irradiation. Freezing and storage at -40 degrees C for 14 days had only a slight effect on either unstressed or heat-stressed cells.

Thermal inactivation and injury of Moraxella-Acinetobacter cells in ground beef.

The thermal inactivation and injury (sensitivity to 0.8% NaCl) of a radiation-resistant culture of Moraxella-Acinetobacter mixed in minced beef were determined. Survival curves for Moraxella-Acinetobacter cells in beef had an initial shoulder preceding a logarithmic decline when the cells were heated at 65, 70, and 75 degrees C, but not at 80 degrees C. In all cases, the experimental points not included in the shoulder were linearized by means of a least-squares straight line, and the latter was used to determine D values. Shoulder values of 12.2, 4.1, and 0.6 min at temperatures of 65, 70, and 75 degrees C were added to the respective D values of 35.4, 6.6, and 1.4 min to determine the time required to destroy one log cycle. The Z value was 7.3 degrees C. Moraxella-Acinetobacter cells in meat were more rapidly injured than inactivated, on initial exposure to heat. The number of cells injured by this initial exposure increased as the temperature was increased. At 65 degrees C the percentage of injured cells increased more rapidly with exposure time than did the inactivated cells. As the temperature was increased, the rates of inactivation and injury became more and more similar.

Radiation resistance and injury of Yersinia enterocolitica.

The D values of Yersinia enterocolitica strains IP134, IP107, and WA, irradiated at 25 degrees C in Trypticase soy broth, ranged from 9.7 to 11.8 krad. When irradiated in ground beef at 25 and -30 degrees C, the D value of strain IP107 was 19.5 and 38.8 krad, respectively. Cells suspended in Trypticase soy broth were more sensitive to storage at -20 degrees C than those mixed in ground beef. The percentages of inactivation and of injury (inability to form colonies in the presence of 3.0% NaCl) of cells stored in ground beef for 10 days at -20 degrees C were 70 and 23%, respectively. Prior irradiation did not alter the cell's sensitivity to storage at -20 degrees C, nor did storage at -20 degrees C alter the cell's resistance to irradiation at 25 degrees C. Added NaCl concentrations of up to 4.0% in Trypticase soy agar (TSA) (which contains 0.5% NaCl) had little effect on colony formation at 36 degrees C of unirradiated Y. enterocolitica. With added 4.0% NaCl, 79% of the cells formed colonies at 36 degrees C; with 5.0% NaCl added, no colonies were formed. Although 2.5% NaCl added to ground beef did not sensitize Y. enterocolitica cells to irradiation, when added to TSA it reduced the number of apparent radiation survivors. Cells uninjured by irradiation formed colonies on TSA when incubated at either 36 or 5 degrees C. More survivors of an exposure to 60 krad were capable of recovery and forming colonies on TSA when incubated at 36 degrees C for 1 day than at 5 degrees C for 14 days. This difference in count was considered a manifestation of injury to certain survivors of irradiation.

Microbiological Safety of Radappertized Beef 1.

To assure microbiological safety and stability of irradiated meats, inoculated pack studies are performed with each meat. These studies are designed to provide partial spoilage data for computation of that dose required to reduce the number of viable spores of a single most resistant strain of Clostridium botulinum by 12 log cycles. A beef inoculated pack had only one significant partial spoilage "point" at 22 kGy. Therefore, the binomial confidence limit method was used to compute a 12D dose of 41.2 kGy. This 12D dose, together with a prveious thermal treatment of inactivate autolytic enzymes, provides a wide margin of microbiological safety and stability to packaged meats stored without refrigeration.

Resuscitation of Stressed Fecal Coliforms and Their Subsequent Detection by Radiometric and Impedance Techniques.

Approximately 99% of cells in a heat-stressed Escherichia coli culture were injured and were able to grow on trypticase soy agar (TSA) but not on Violet Red Bile Agar (VRBA). Employing a surface-overlay or pour-overlay method, complete recovery of this thermally-stressed population required incubation of the TSA plates at 35 C for 6 h before overlaying with VRBA and incubating at 45 C. While the surface-overlay technique provides a more accurate index of injury than the pour-overlay method, there appears to be little difference in plating procedures with respect to recovery of injured cells. Heat-stressed cells were inactivated by the bile salts mixture in the conventional EC broth and by incubation temperatures of 42-45 C. Most of the heat-stressed cells were able to recover in 3 h at 35-37 C, without any evidence of replication, in EC broth minus the bile salts mixture (EC-B), adjusted to pH 6.1-6.5. Under similar conditions freeze-stressed cells recovered without multiplication within 1 h and the replication of an unstressed population of E. coli was evident in 2 h but not in 1 h of incubation. Both radiometry and impedance show promise as rapid (17-18 h) screening techniques for determining if a cooked food meets the microbial criterion of 0 fecal coliforms/g. A resuscitation period of 3 h was essential for reliable detection of thermally-stressed fecal coliforms by either radiometry or impedance. An impedance based-MPN procedure (18 h or less) compared favorably with a TSA/VRBA pour-overlay method (24 h) and a conventional 3-tube most probable number technique (48-72 h) for enumerating freeze-injured and uninjured fecal coliforms.

Occurrence of Staphylococcus aureus in and the Moisture Content of Precooked Canned Bacon.

Staphylococcus aureus was found in 9.0% of 221 cans of precooked bacon. The count in 6.9% of the cans exceeded 1000/g and ranged as high as 1.7 × 105/g. Aerobic plate counts were greater than 105/g in 24% of the cans. The maximum moisture to salt ratio (percent moisture divided by percent salt) of 9.0, permitted by Federal Specifications, was exceeded in 73.0% of the cans and ranged from 5.97 to 21.44. This bacon production was rejected for military procurement.

Cryogenic gamma irradiation of prototype pork and chicken and antagonistic effect between Clostridium botulinum types A and B.

Inoculated, irradiated pork (2,300 cans) and chicken (2,000 cans) pack studies were performed to establish the 12D dose for these foods. Each can was inoculated with a mixture of 10(6) spores of each of 10 strains of Clostridium botulinum (five type A and five type B), or a total of 10(7) spores. The cans received a series of increasing doses of gamma rays (60Co) at -30 +/- 10 degrees C; they were incubated for 6 months at 30 +/- 2 degrees C and examined for swelling, toxicity, and recoverable botulinal cells. The highest rate of swelling for both foods occurred within the first week of incubation, and maximum swelling was observed within 4 to 5 weeks. The minimal experimental sterilizing dose (ESD) based on flat, nontoxic sterile cans was 3.0 less than ESD less than or equal to 3.2 Mrad for pork and 4.0 less than ESD less than or equal to 4.2 Mrad for chicken. An analysis of the partial spoilage data by extreme-value statistics indicated with 90% confidence that the rate of spore death in the two foods was not a normal distribution, but appeared to favor a shifted exponential function. Based on the latter distribution, and assuming one most resistant strain in the mixture of 10 used, the 12D dose computed to 4.37 Mrad, with a shoulder of 0.11 Mrad, for pork and to 4.27 Mrad, with a shoulder of 0.51 Mrad, for chicken. An assumption that there were two or more most resistant strains in the inoculum progressively lowered the 12D dose. There was an apparent antagonism between the irradiated type A and B viable strains in the two foods. Cans with type B cells and toxin predominated over cans with type A cells and toxin, but cans with a mixture of type A and B toxins predominated over cans with a mixture of Type A and B cells. At the highest sublethal doses, only type A cells survived in pork, but in chicken there was a least one type B strain that was at least as resistant as type A strains.

Influence of postirradiation incubation temperature on recovery of radiation-injured Clostridium botulinum 62A spores.

The number of colonies formed by unirradiated Clostridium botulinum 62A spores was independent of temperature, in the range from 20 to 45 degrees C (in 5 degrees C increments); no colonies developed at 50 degrees C. Spores irradiated at 1.2 or 1.4 Mrads produced more macrocolonies at 40 degrees C than at higher or lower temperatures. Apparently, radiation-injured spores were capable of repair of 40 degrees C than at the other temperatures studied. More than 99% of the radiation (1.2 Mrads) survivors were injured and were unable to form macrocolonies in the presence of 5% NaCl. The germinated radiation-injured spores were also sensitive to dilution, resulting in the loss of viability of 77 to 79% of the radiation survivors. At 30 and 40 degrees C, the irradiated spores did not differ significantly in the extent of germination (greater than 99% at both 30 and 40 degrees C), emergence (64% at 30 degrees C and 67% at 40 degrees C), and the maximum number of emerged cells that started to elongate (69% at 30 degrees C and 79% at 40 degrees C). However, elongation was remarkably more extensive at 40 degrees C than at 30 degrees C. Many elongated cells lysed within 48 h at 30 degrees C, indicating an impaired repair mechanism. If the radiation-injured spores were incubated at 40 degrees C in the recovery (repair) medium for 8 to 10 h, they germinated, emerged, and elongated extensively and were capable of repair. If, after 8 to 10 h at 40 degrees C, these cultures were shifted to 30 degrees C, the recovery at 30 increased by more than eightfold, resulting in similar colony counts at 30 and 40 degrees C. Thus, repair appeared to be associated with outgrowth. Repair did not occur in the presence of chloramphenicol at 40 degrees C, whereas penicillin had no effect, suggesting that the repair involved protein synthesis but did not require multiplication.

Low-temperature irradiation of beef and methods of evaluation of radappertization process.

An inoculated, irradiated beef pack (1,240 cans) was conducted for the determination of microbiological safety for unrestricted human consumption. Each can contained a mixture of 10(6) spores of each of 10 strains of Clostridium botulinum (5 type A and 5 type B), or a total of 10(7) spores/can. The cans were irradiated to various doses (100 cans/dose) with 60Co gamma rays at -30 +/- 10 C, incubated at 30 +/- 2 C for 6 months, and examined for swelling, toxicity, and recoverable botulinal cells. The minimal experimental sterilizing dose based on nonswollen, nontoxic sterile cans were 2.2 less than experimental sterilizing dose based on nonswollen, nontoxic sterile cans was 2.2 less than experimental sterilizing dose less than or equal to 2.6 Mrad. Using recoverable cells as the most stringent criterion of spoilage, and assuming the conventional simple exponential (without an initial shoulder) rate of spore kill, the "12D" dose was 3.7 Mrad when estimated on the basis of mixture of 10 strains totaling 10(7) spores/can, and 4.3 Mrad if it is assumed that each can of beef contained 10(6) spores of a single most resistant strain and all of these spores were of identical resistances. However, an analysis of the data by extreme value statistics indicated with 90% confidence that the spore death rate was not a simple exponential but might be a shifted exponential (with an initial shoulder), Weibull, lognormal, or normal, with a "12D" equivalent of about 3.0 Mrad regardless of the initial spore density per can. There was an apparent antagonism between the irradiated type A and B strains in the cans. Some of the cans contained type B toxin but did not include type B viable cells. Other cans had a mixture of type A and B toxins, but a large number of these cans did not yield recoverable type B cells. However, type A viable cells could always be demonstrated in those cans containing type A toxin.

Improvements in a non-proprietary radiometric medium to allow the detection of some Pseudomonas species and Alcaligenes faecalis.

The addition of [5-14C]glutamate and [14C]formate to a non-proprietary medium containing [14C]glucose, Trypticase, yeast extract, thiotone, and salts enabled the radiometric detection of the presence of nonfermenters of glucose. It did not interfere with the rapid detection of the presence of aerobic and anaerobic sporeforemers and nonsporeformers.

Microbiological testing of Skylab foods.

The Skylab manned space flight program presented unique food microbiology problems. This challenge was successfully met by careful evaluation of the total Skylab food system by considering the nature of Skylab foods, their processing and handling, and Skylab food safety requirements. Some of the unique problems encountered with the Skylab foods involved: extended storage times, variations in storage temperatures, no opportunity to resupply or charge foods after launch of the Skylab Workshop, first use of frozen foods in space, first use of a food-warming device in weightlessness, relatively small size of production lots requiring statistically valid sampling plans, and use of the food as an accurately controlled segment of sophisticated life science experiments. Consideration of all of these situations generated the need for definitive microbiological tests and test limits. These tests are described in this paper along with the rationale for their selection. Test results are reported which show successful compliance with the test limits.

Production of types A and B spores of Clostridium botulinum by the biphasic method: effect on spore population, radiation resistance, and toxigenicity.

Spores of three strains each of type A and type B Clostridium botulinum were produced both by a biphasic (solid medium overlaid with an aqueous phase) and by a "conventional" (deep broth culture) procedure. Sporogenesis by the biphasic system was more rapid, convenient, and economical, and yielded as many or more heat-resistant (80 C, 10 min) spores per milliliter as by the conventional technique. Of several aqueous phases [thiamine-hydrochloride, yeast extract, (NH(4))(2)SO(4)] tested with strain 62A, the highest spore colony counts were obtained with 2.0% (NH(4))(2)SO(4). The six strains formed maximum spore numbers in 5 to 6 days of incubation. Spores produced by the two methods had essentially equal radiation resistances (D and lag values), and their subcultures gave similar toxin titers (LD(50) values).

Bacteriology of dehydrated space foods.

The initial bacteriological requirement established in 1964 for space foods by the U.S. Army Natick Laboratories are: a total aerobic plate count ( 300,000), chocolate ice cream cubes (20,000), and each of four samples of chocolate candy (12,000 to 61,000); (ii) coliforms: two out of three vanilla milk drinks (16 and 127) and one beef hash bar (14); (iii) fecal coliforms: one sample of chicken soup and gravy base positive; (iv) fecal streptococci: two samples of peanut cubes (40 and 108), coconut cubes (75), chicken soup and gravy base (2,650), beef soup and gravy base (33), and five out of six flavored milk drinks (23 to 300); (v) salmonellae: one each of chicken and beef soup and gravy base were positive.

Modification of the American Public Health Association procedure for counting yeast and mold in cottage cheese.

The American Public Health Association method for counting low numbers of yeast and mold in cottage cheese was unsatisfactory due to altered pH of the culture medium. A modification of this method is presented.

Conditions Affecting Germination of Clostridium botulinum 62A Spores in a Chemically Defined Medium.

Spores of Clostridium botulinum type 62A were germinated in a chemically defined medium (8 mm l-cysteine, 11.9 mm sodium bicarbonate, 4.4 mm sodium thioglycolate; buffered with 100 mm TES, pH 7.0). The rate and extent of germination were increased when an aqueous spore suspension was heated sublethally (80 C, 60 min) before addition to the germination medium. Neither sublethal nor lethal doses of gamma radiation had any marked effect on subsequent germination. Maximum germination (>90% in 2 hr) in the defined medium occurred in the pH range of 6.5 to 7.5, at 30 to 37 C, with an l-cysteine level of 8 mm. Increasing l-cysteine to 32 mm increased the rate (over that with 8 mm l-cysteine) but not the extent of germination. The rate and extent of germination increased with NaHCO(3) addition to 8.3 mm, but increasing levels to 11.9 mm had no further effect. For maximum germination, 2.2 mm sodium thioglycolate was required and higher levels (to 8.8 mm) had no further enhancing or inhibitory effect. Under optimal conditions for germination, 97% of the spores had become heat sensitive; 98% had become sensitive to radiation; 88 and 91% had become phase dark and stainable, respectively, and the spore suspension had lost 46% of its initial optical density by 2 hr. Loss of heat resistance preceded loss of radiation resistance, acquisition of stainability, and phase darkening by about 12 min.

Changes in spores of Bacillus megaterium treated with thioglycolate at a low pH and restoration of germinability and heat resistance by cations.

Spores of Bacillus megaterium QM B1551 treated with thioglycolate (0.4 m, pH 2.6) at 50 C for 30 min remained refractile, but they became stainable, lysozymesensitive, and nonviable, and they lost dipicolinic acid (DPA). The loss of DPA and of viability were functions of the time and temperature of exposure to thioglycolate. Spores treated with thioglycolate at a lower temperature and for a shorter time (30 C, 5 min) retained DPA, viability, and nonstainability. Although these spores also retained their resistance to gamma radiation and to lysozyme, they lost thermo-resistance. Their percentage of germination over a 2-hr period in glucose was markedly reduced. Germinability and heat resistance were restored by exogenous cations, suggesting that the thioglycolate treatment (30 C, 5 min) resulted in the loss of spore ions essential for normal germination in glucose and for heat resistance.