Effects of nutrient levels and average culture pH on the glycosylation pattern of camelid-humanized monoclonal antibody.

The impact of operating conditions on the glycosylation pattern of humanized camelid monoclonal antibody, EG2-hFc produced by Chinese hamster ovary (CHO) cells has been evaluated by a combination of experiments and modeling. Cells were cultivated under different levels of glucose and glutamine concentrations with the goal of investigating the effect of nutrient depletion levels and ammonia build up on the cell growth and the glycoprofiles of the monoclonal antibody (Mab). The effect of average pH reduction on glycosylation level during the entire culture time or during a specific time span was also investigated. The relative abundance of glycan structures was quantified by hydrophilic interaction liquid chromatography (HILIC) and the galactosylation index (GI) and the sialylation index (SI) were determined. Lower initial concentrations of glutamine resulted in lower glucose consumption and lower cell yield but increased GI and SI levels when compared to cultures started with higher initial glutamine levels. Similarly, reducing the average pH of culture resulted in lower growth but higher SI and GI levels. These findings indicate that there is a tradeoff between cell growth, resulting Mab productivity and the achievement of desirable higher glycosylation levels. A dynamic model, based on a metabolic flux analysis (MFA), is proposed to describe the metabolism of nutrients, cell growth and Mab productivity. Finally, existing software (GLYCOVIS) that describes the glycosylation pathways was used to illustrate the impact of extracellular species on the glycoprofiles.

Proteomics analysis of chinese hamster ovary cells undergoing apoptosis during prolonged cultivation.

The degradation of environmental conditions, such as nutrient depletion and accumulation of toxic waste products over time, often lead to premature apoptotic cell death in mammalian cell cultures and suboptimal protein yield. Although apoptosis has been extensively researched, the changes in the whole cell proteome during prolonged cultivation, where apoptosis is a major mode of cell death, have not been examined. To our knowledge, the work presented here is the first whole cell proteome analysis of non-induced apoptosis in mammalian cells. Flow cytometry analyses of various activated caspases demonstrated the onset of apoptosis in Chinese hamster ovary cells during prolonged cultivation was primarily through the intrinsic pathway. Differential in gel electrophoresis proteomic study comparing protein samples collected during cultivation resulted in the identification of 40 differentially expressed proteins, including four cytoskeletal proteins, ten chaperone and folding proteins, seven metabolic enzymes and seven other proteins of varied functions. The induction of seven ER chaperones and foldases is a solid indication of the onset of the unfolded protein response, which is triggered by cellular and ER stresses, many of which occur during prolonged batch cultures. In addition, the upregulation of six glycolytic enzymes and another metabolic protein emphasizes that a change in the energy metabolism likely occurred as culture conditions degraded and apoptosis advanced. By identifying the intracellular changes during cultivation, this study provides a foundation for optimizing cell line-specific cultivation processes, prolonging longevity and maximizing protein production.

Metabolic flux-based modeling of mAb production during batch and fed-batch operations.

This paper proposes mathematical models that predict the physiology, growth behavior and productivity of hybridoma cells in both batch and fed-batch systems. Murine hybridoma 130-8F producing anti-F-glycoprotein monoclonal antibody was employed as a model system. A systematic approach based on metabolic flux analysis (MFA) was utilized to yield a dynamic model for predicting the concentration of significant metabolites over time. Correlation analysis was performed to formulate a Biomass Model for predicting cell concentration and viability as a function of the extracellular metabolite concentrations. The coefficients of the model equation were estimated by employing the Metropolis-Hastings algorithm. The Metabolites Model was combined with the Biomass Model to get an Integrated Model capable of predicting concentration values for substrates, extracellular metabolites, and viable and dead cell concentration by utilizing only starting concentrations as input. The prediction accuracy of the model was tested by using experimental data.

Heterologous expression of lipase in Escherichia coli is limited by folding and disulfide bond formation.

Functional expression of lipase B from Pseudozyma antarctica (PalB) in the cytoplasm of Escherichia coli BL21(DE3) and its mutant derivative Origami B(DE3) was explored. Coexpression of DsbA was found to be effective in enhancing PalB expression. The improvement was particularly pronounced with Origami B(DE3) as a host, suggesting that both folding and disulfide bond formation may be major factors limiting PalB expression. Fusion tag technique was also explored by constructing several PalB fusions for the evaluation of their expression performance. While the solubility was enhanced for most PalB fusions, only the DsbA tag was effective in boosting PalB activity, possibly by both enhanced solubility and correct disulfide bond formation. Our results suggest that PalB activity is closely associated with correct disulfide bond formation, and increased solubilization by PalB fusions does not necessarily result in activity enhancement.

Development of a minimal defined medium for recombinant human interleukin-3 production by Streptomyces lividans 66.

A systematic approach was developed to identify and optimize the essential amino acids in defined minimal medium for the production of recombinant human interleukin 3 (rHuIL-3) by Streptomyces lividans. Starvation trials were carried out initially to narrow down the number of probable essential amino acids from an initial number of 20 to 8. Then a screening mixture experiment was designed and performed with the eight identified amino acids and distance-based multivariate analysis was employed to rank the probable essential amino acids regarding both growth and product formation. Following this procedure, the search was narrowed to four amino acids (Asp, Leu, Met, and Phe). Finally, a mixture design experiment known as the simplex lattice design was carried out and the composition of the optimum minimal medium was found (Asp 53%, Met 5%, and Phe 42%).

Dynamic metabolic modeling for a MAB bioprocess.

Production of monoclonal antibodies (MAb) for diagnostic or therapeutic applications has become an important task in the pharmaceutical industry. The efficiency of high-density reactor systems can be potentially increased by model-based design and control strategies. Therefore, a reliable kinetic model for cell metabolism is required. A systematic procedure based on metabolic modeling is used to model nutrient uptake and key product formation in a MAb bioprocess during both the growth and post-growth phases. The approach combines the key advantages of stoichiometric and kinetic models into a complete metabolic network while integrating the regulation and control of cellular activity. This modeling procedure can be easily applied to any cell line during both the cell growth and post-growth phases. Quadratic programming (QP) has been identified as a suitable method to solve the underdetermined constrained problem related to model parameter identification. The approach is illustrated for the case of murine hybridoma cells cultivated in stirred spinners.

Biodegradation kinetics of 2,4,6-trichlorophenol by an acclimated mixed microbial culture under aerobic conditions.

The objective of this study was to achieve a better quantitative understanding of the kinetics of 2,4,6-trichlorophenol (TCP) biodegradation by an acclimated mixed microbial culture. An aerobic mixed microbial culture, obtained from the aeration basin of the wastewater treatment plant, was acclimated in shake flasks utilizing various combinations of 2,4,6-TCP (25-100 mg l(-1)), phenol (300 mg l(-1)) and glycerol (2.5 mg l(-1)) as substrates. Complete primary TCP degradation and a corresponding stoichiometric release of chloride ion were observed by HPLC and IEC analytical techniques, respectively. The acclimated cultures were then used as an inoculum for bench scale experiments in a 4 l stirred-tank reactor (STR) with 2,4,6-TCP as the sole carbon/energy (C/E) source. The phenol acclimated mixed microbial culture consisted of primarily Gram positive and negative rods and was capable of degrading 2,4,6-TCP completely. None of the predicted intermediate compounds were detected by gas chromatography in the cell cytoplasm or supernatant. Based on the disappearance of 2,4,6-TCP, degradation was well modelled by zero-order kinetics which was also consistent with the observed oxygen consumption. Biodegradation rates were compared for four operating conditions including two different initial 2,4,6-TCP concentrations and two different initial biomass concentrations. While the specific rate constant was not dependent on the initial 2,4,6-TCP concentration, it did depend on the initial biomass concentration (X (init)). A lower biomass concentration gave a much higher zero-order specific degradation rate. This behaviour was attributed to a lower average biomass age or cell retention time (theta(x)) for these cultures. The implications of this investigation are important for determining and predicting the potential risks associated with TCP, its degradation in the natural environment or the engineering implications for ex situ treatment of contaminated ground water or soil.

Characterization of the T7 promoter system for expressing penicillin acylase in Escherichia coli.

The pac gene encoding penicillin acylase (PAC) was overexpressed under the regulation of the T7 promoter in Escherichia coli. PAC, with its complex formation mechanism, serves as a unique target protein for demonstration of several key strategies for enhancing recombinant protein production. The current T7 system for pac overexpression was fraught with various technical hurdles. Upon the induction with a conventional inducer of isopropyl-beta-D-thiogalactopyranoside (IPTG), the production of PAC was limited by the accumulation of PAC precursors (proPAC) as inclusion bodies and various negative cellular responses such as growth inhibition and cell lysis. The expression performance could be improved by the coexpression of degP encoding a periplasmic protein with protease and chaperone activities. In addition to IPTG, arabinose was shown to be another effective inducer. Interestingly, arabinose not only induced the current T7 promoter system for pac expression but also facilitated the posttranslational processing of proPAC for maturation, resulting in significant enhancement for the production of PAC. Glycerol appeared to have an effect similar to, but not as significant as, arabinose for enhancing the production of PAC. The study highlights the importance of developing suitable genetically engineered strains with culture conditions for enhancing recombinant protein production in E. coli.

Fungal glucoamylases.

Fungi are employed to produce industrially important glucoamylases. Most glucoamylases are glycosylated. Glycosylation enhances the enzyme stability. Glucoamylases contain both starch binding and catalytic binding domains, the former being responsible for activity on raw (insoluble) starch. Proteases may act on this domain causing the enzyme to lose its activity on insoluble starch. Optimal activity is observed at pH 4.5 to 6.5 and 50 to 70 degrees C. Glucoamylases contain up to 7 sub-sites with highly varying affinity. They can be produced by different methods including submerged, solid state and semi-solid state fermentation processes.

Cytoplasmic overexpression, folding, and processing of penicillin acylase precursor in Escherichia coli.

Penicillin acylase (PAC) precursor, proPAC, was overproduced in a soluble or insoluble form in the cytoplasm of Escherichia coli through the expression of the leader-less pac gene (ll-pac) devoid of the coding region for the signal peptide of PAC. Also, a portion of the overexpressed proPAC was further processed to form mature PAC, indicating that the posttranslational processing steps for PAC maturation can occur in both the periplasm and the cytoplasm of E. coli. The cultivation performance for ll-pac expression was limited by several factors, including (1) misfolding of proPAC, resulting in the aggregation of insoluble proPAC as inclusion bodies, (2) intracellular proteolysis, leading to the degradation of the overexpressed gene products, and (3) inefficient PAC maturation, limiting the formation of active PAC. The effect of coexpression of various cytoplasmic chaperones, including trigger factor, GroEL/ES, DnaK/J-GrpE, and their combinations, on ll-pac expression was investigated. Intracellular proteolysis of the overexpressed gene products could be prevented by coexpression of GroEL/ES. On the other hand, coexpression of trigger factor appeared to be able to facilitate the folding of soluble proPAC and to improve PAC maturation. The roles of trigger factor and GroEL/ES could be coordinated to significantly improve ll-pac expression performance. DnaK/J-GrpE had an effect for solublization of proPAC and perhaps, similar to trigger factor, for improving PAC maturation. The ll-pac expression performance was also significantly improved through the simultaneous coexpression of DnaK/J-GrpE and GroEL/ES. The results of the study suggest that the folding and/or processing of proPAC could be a major issue limiting the overproduction of PAC in E. coli and the bottleneck could be eliminated through the coexpression of appropriate chaperone(s).

Chaperone-mediated folding and maturation of the penicillin acylase precursor in the cytoplasm of Escherichia coli.

Expression of the leaderless pac gene (LL pac), which lacks the coding region for the signal peptide of penicillin acylase (PAC), in Escherichia coli was conducted. It was demonstrated that the PAC precursor, proPAC, can be produced and even processed to form mature PAC in the cytoplasm, indicating that the posttranslational processing steps for PAC maturation can occur in both the periplasm and the cytoplasm of E. coli. The outcome of proPAC folding and PAC maturation could be affected by several factors, such as inducer type, proPAC formation rate, and chaperone availability. Misfolding of proPAC in the cytoplasm could be partially resolved through the coexpression of cytoplasmic chaperones, such as trigger factor, GroEL/ES, or DnaK/J-GrpE. The three chaperones tested showed different extents of the effect on proPAC solublization and PAC maturation, and trigger factor had the most prominent one. However, the chaperone-mediated solublization of proPAC did not guarantee its maturation, which is usually limited by the first autoproteolytic step. It was observed that arabinose could act as an effective inducer for the induction of LL pac expression regulated by the lac-derived promoter system of trc. In addition, PAC maturation could be highly facilitated by arabinose supplementation and coexpression of trigger factor, suggesting that the coordination of chaperone systems with proper culture conditions could dramatically impact recombinant protein production. This study suggests that folding/misfolding of proPAC could be a major step limiting the overproduction of PAC in E. coli and that the problem could be resolved through the search for appropriate chaperones for coexpression. It also demonstrates the analogy in the issues of proPAC misfolding as well as the expression bottleneck occurring in the cytoplasm (i.e., LL pac expression) and those occurring in the periplasm (i.e., wild-type pac expression).