Evaluating the efficacy of peroxyacetic acid in preventing Salmonella cross-contamination on tomatoes in a model flume system.

The use of flume tanks for tomato processing has been identified as a potential source of cross-contamination, which could result in foodborne illness. This study's objective was to assess the efficacy of peroxyacetic acid (PAA) at a concentration of ≤80 mg/L in preventing Salmonella enterica cross-contamination under various organic loads in a benchtop model tomato flume tank. The stability of 80 mg/L PAA at different chemical oxygen demand (COD) levels was also tested. Tomatoes were spot inoculated with a five-serovar rifampin-resistant (rif+) Salmonella cocktail (106 or 108 colony forming unit (CFU)/tomato). Inoculated (n = 3) and uninoculated (n = 9) tomatoes were introduced into the flume system containing 0-80 mg/L PAA and 0 or 300 mg/L COD. After washing for 30, 60, or 120 s, uninoculated tomatoes were sampled and analyzed for cross-contamination. All experiments were conducted in triplicate. Increasing the organic load (measured as COD) affected the stability of PAA in water with significantly faster dissociation when exposed to 300 mg/L COD. The concentration of PAA, inoculum level, COD levels, and time intervals were all significant factors that affected cross-contamination. Cross-contamination occurred at the high inoculum level (108 CFU/tomato) even when 80 mg/L PAA was present in the model flume tank, regardless of the organic load level. When the tomatoes were contaminated at a level of 106 CFU/tomato, concentrations as low as 5 mg/L of PAA were effective in preventing cross-contamination at 0 mg/L COD; however, 100 % tomatoes (9/9) were positive when the organic load increased to 300 mg/L COD. When the PAA concentration was increased to 10 mg/L, it effectively prevented cross-contamination in the tank, regardless of the presence of organic load. These results suggest that using PAA at concentrations below the maximum limit remains effective in limiting bacterial cross-contamination and offers a more environment-friendly option for tomato packinghouse operators.

Southern Region Produce Safety Alliance Grower Training: Using Pre- and Post-Training Knowledge Assessments to Understand Training Effectiveness.

The Produce Safety Alliance (PSA) grower training was introduced in 2016 as the standardized curriculum to meet the training requirements of the Food and Drug Administration's (FDA) Food Safety Modernization Act's (FSMA) Produce Safety Rule (PSR). The PSR states that at least one supervisor or responsible party from each farm must have successfully completed this food safety training or one equivalent to the standardized curriculum, as recognized by the FDA. This study evaluated the effectiveness of PSA trainings conducted between 2017 and 2019 in the Southern United States by the Southern Regional Center for Food Safety Training, Outreach, and Technical Assistance by analyzing pre- and posttest assessments. Effectiveness was based on a 25-question knowledge assessment administered to participants before (n = 2494) and after (n = 2460) each training. The knowledge assessment indicated the overall effectiveness of the training, with average scores increasing significantly from pretest (15.9/25, 63.4%) to posttest (20.3/25, 81.3%) (P < 0.001). The greatest knowledge gains were seen in the Postharvest Handling and Sanitation, How to Develop a Farm Food Safety Plan, and Agricultural Water modules. Notably, these modules had lower posttest scores compared to the other modules, indicating that the amount of knowledge gained did not necessarily correspond with a sufficient understanding of the material. To ensure that participants understand all aspects of the PSR and best practices to minimize food safety risks, additional or advanced trainings may be needed. Additionally, the current testing instrument (pre-/posttest) used for PSA grower training, while validated, may not be optimal, thus alternative methods to assess the training effectiveness are likely needed.

Draft Genome Sequences of 110 Shiga Toxin-Producing Escherichia coli Isolates Collected from Bovine Manure Samples in the Southern United States.

Shiga toxin-producing Escherichia coli (STEC) bacteria continue to impact the food industry. Environmental sampling of potential sources of contamination is important to aid epidemiologic efforts in tracking foodborne illnesses throughout the United States. Here, the draft genome sequences of 110 STEC isolates from bovine manure collected in Florida and Texas are reported.

Growth Media of Escherichia coli Does Not Affect Its Survival in Soil under Static Conditions.

ABSTRACT: Many studies have examined the survival of Escherichia coli and foodborne pathogens in agricultural soils. The results of these studies can be influenced by various growth conditions and growth media used when preparing cultures for an experiment. The objectives of this study were to (i) determine the growth curves of rifampin (R)-resistant E. coli in three types of growth media containing R: tryptic soy agar (TSA-R); tryptic soy broth (TSB-R); and poultry pellet extract (PPE-R) and (ii) evaluate the influence of growth media on the survival of E. coli in agricultural soil. Poultry pellet extract (PPE) was prepared by filter sterilizing a 1:10 suspension of heat-treated poultry pellets in sterile water. Generic E. coli (TVS 353) acclimated to 80 µg/mL of R was grown in TSA-R, TSB-R, and PPE-R at 3.0 to 3.5 log CFU/mL and incubated at 37°C. Growth curves were determined by quantifying E. coli populations at 0, 4, 8, 16, 24, and 32 h. Soil microcosms were inoculated with E. coli (6.0 log CFU/g) previously cultured in one of the three media types and stored at 25°C, and soil samples were quantified for E. coli on days 0, 1, 3, 7, 14, 28, and 42. Growth curves and survival models were generated by using DMFit and GInaFiT, respectively. E. coli growth rates were 0.88, 0.77, and 0.69 log CFU/mL/h in TSA-R, TSB-R, and PPE-R, respectively. E. coli populations in the stationary phase were greater for cultures grown in TSA-R (9.4 log CFU/mL) and TSB-R (9.1 log CFU/mL) compared with PPE-R (7.9 log CFU/mL). The E. coli populations in the soil remained stable up to 3 days before declining. An approximate 2 log CFU/g decline of E. coli in soil was observed for each culture type between days 3 and 7, after which E. coli populations declined more slowly from days 7 to 42. A biphasic shoulder model was used to evaluate E. coli survival in soils on the basis of growth media. Using standardized culture growth preparation may aid in determining the complex interactions of enteric pathogen survival in soils.

Draft Genome Sequences of 278 Salmonella enterica Isolates from Poultry Litter in the Southeastern United States.

Salmonella enterica continues to be a pervasive food safety concern in the poultry industry, contributing to the annual burden of foodborne illnesses in the United States. Poultry litter is a known environmental source for the transmission of Salmonella among broiler flocks. Here, we describe the draft genome sequences of 278 S. enterica isolates collected from poultry litter in Florida.

The prevalence and concentration of Salmonella enterica in poultry litter in the southern United States.

Poultry litter is applied to crop production land in the southern United States as a waste management strategy as it is a nitrogen-rich fertilizer and plentiful throughout the region. While litter is a known reservoir for human enteric pathogens including Salmonella enterica, little is known regarding pathogen prevalence, concentration, and common serotypes within the material. Litter from thirteen farms across four southern states was examined for Salmonella. Samples (n = 490) from six of the thirteen (46.2%) farms tested positive. Thirty-three samples out of 490 (6.7%) were Salmonella positive. Salmonella was ca. 95% less likely to be collected from stacked litter piles than from the poultry house floor or pasture, and every day increase in litter age reduced the likelihood of recovering Salmonella by 5.1%. When present, concentrations of Salmonella in contaminated poultry litter were variable, ranging from <0.45 to >280,000 MPN/g. The most prevalent serotypes found were Kentucky (45.5%), Kiambu (18.2%), and Michigan (12.1%). Salmonella Kentucky also had the greatest distribution and was found on 4 of the 6 (66.7%) positive farms. Results from this survey demonstrated that Salmonella prevalence and concentration in poultry litter is highly variable, and good agricultural practices are critical to safely use poultry litter as a soil amendment on fresh produce fields.

Survival and inactivation kinetics of Salmonella enterica serovar Typhimurium in irradiated and natural poultry litter microcosms.

The use of poultry litter as a biological soil amendment presents a risk for the preharvest contamination of fresh produce by Salmonella. In order to properly assess this risk, it is important to understand the factors influencing the persistence of Salmonella in poultry litter. This research was performed to investigate the influence of indigenous microflora on the survival of Salmonella Typhimurium in poultry litter. Microcosms of irradiated (sterilized) and natural poultry litter were inoculated with S. Typhimurium, adjusted to pH 8.0, 0.92 water activity (aw), and stored at 30°C for 6 days. S. Typhimurium populations (log CFU g-1) declined in both litter treatments and there were no significant differences (P > 0.05) in recovery between litter treatments on any sampling days (0 to 6). The pH of the natural litter significantly increased (P < 0.05) from 8.42 on day 0 to 9.00 on day 6. By day 6, S. Typhimurium populations in both litter treatments fell below the limit of detection (1 log CFU g-1). The inactivation kinetics of S. Typhimurium in both litter treatments were described by the Weibull model. Under the experimental conditions (pH 8.0, 0.92 aw, 30°C), the presence or absence of poultry litter microflora did not significantly influence the survival of S. Typhimurium. This study demonstrates that the mere presence of poultry litter microflora will not inhibit Salmonella survival. Instead, inhibitory interactions between various microorganisms in litter and Salmonella are likely dependent on more favorable environmental conditions (e.g., aw, pH) for growth and competition.

Determining spoilage of whiteleg shrimp (Litopanaeus vannemei) during refrigerated storage using colorimetric strips.

A reliable spoilage assessment method is needed to ensure sufficient quality control of shrimp. Colorimetric dye-based indicators that change color in response to pH changes can monitor food quality changes in a simple, quick, and accurate way and generate easy-to-interpret results. Significant positive correlations with storage time were observed for the results of the bromophenol blue (BPB) strips (r = 0.8513, p < 0.0001) and the rose bengal strips (r = 0.8981, p < 0.0001). The results of both colorimetric methods significantly correlated with sensory and chemical quality indicators, including sensory attributes "salty water-like", "natto water-like" and "sour milk-like", and volatile compounds such as 3-methyl-3-butenol, 2-methyl-1-butanol, 3-methyl-1-butanol, hexanol, 2-methyl-1-butanal, and 3-methyl-1-butanal. The BPB strips and rose bengal strips have the potential to be used as objective, accurate, and cost-efficient methods to evaluate shrimp quality and lead to consistent and easy-to-interpret results.

Antimicrobial Efficacy of Un-Ionized Ammonia (NH3) against Salmonella Typhimurium in Buffered Solutions with Variable pH, NH3 Concentrations, and Urease-Producing Bacteria.

The presence of Salmonella in poultry litter, when used as a biological soil amendment, presents a risk for the preharvest contamination of fresh produce. Poultry litter is rich in organic nitrogen, and previous studies have suggested that ammonia (NH3) in poultry litter may affect the survival of Salmonella. Salmonella enterica serovar Typhimurium was inoculated into buffer solutions to characterize the pH dependency, minimum antimicrobial concentration, and efficacy of NH3 production. In solutions with 0.4 M total ammonia nitrogen (TAN) at various pH levels (5, 7, 8, and 9), significant inactivation of Salmonella only occurred at pH 9. Salmonella was reduced by ∼8 log CFU/mL within 12 to 18 h at 0.09, 0.18, 0.26, and 0.35 M NH3. The minimum antimicrobial concentration tested was 0.04 M NH3, resulting in an ∼7 log CFU/mL reduction after 24 h. Solutions with urea (1% and 2%) and urease enzymes rapidly produced NH3, which significantly reduced Salmonella within 12 h. The urease-producing bacterium Corynebacterium urealyticum showed no antagonistic effects against Salmonella in solution. Conversely, with 1% urea added, C. urealyticum rapidly produced NH3 in solution and significantly reduced Salmonella within 12 h. Salmonella inactivation data were nonlinear and fitted to Weibull models (Weibull, Weibull with tailing effects, and double Weibull) to describe their inactivation kinetics. These results suggest that high NH3 levels in poultry litter may reduce the risk of contamination in this biological soil amendment. This study will guide future research on the influence of ammonia on the survival and persistence of Salmonella in poultry litter. IMPORTANCE Poultry litter is a widely used biological soil amendment in the production of fresh produce. However, poultry litter may contain human pathogens, such as Salmonella, which introduces the risk of preharvest produce contamination in agricultural fields. Ammonia in poultry litter, produced through bacterial degradation of urea, may be detrimental to the survival of Salmonella; however, these effects are not fully understood. This study utilized aqueous buffer solutions to demonstrate that the antimicrobial efficacy of ammonia against Salmonella is dependent on alkaline pH levels, where increasing concentrations of ammonia led to more rapid inactivation. Inactivation was also demonstrated in the presence of urea and urease or urease-producing Corynebacterium urealyticum. These findings suggest that high levels of ammonia in poultry litter may reduce the risk of contamination in biological soil amendments and will guide further studies on the survival and persistence of Salmonella in poultry litter.

Influence of Free Chlorine and Contact Time on the Reduction of Salmonella Cross-Contamination of Tomatoes in a Model Flume System.

ABSTRACT: The process of washing tomatoes in dump (flume) tanks has been identified as a potential source of cross-contamination. This study's objective was to assess the potential for Salmonella enterica cross-contamination at various inoculation levels in the presence of free chlorine (HOCl) and organic matter. Uninoculated tomatoes were introduced into a laboratory-based model flume containing tomatoes inoculated with a cocktail of five rifampin-resistant S. enterica serovars at 104, 106, or 108 CFU per tomato in water containing 0 or 25 mg/L HOCl and 0 or 300 mg/L chemical oxygen demand (COD). Uninoculated tomatoes exposed to the inoculated tomatoes were removed from the water after 5, 30, 60, and 120 s and placed in bags containing tryptic soy broth supplemented with rifampin and 0.1% sodium thiosulfate. Following incubation, enrichment cultures were plated on tryptic soy agar supplemented with rifampin and xylose lysine deoxycholate agar to determine the presence of Salmonella. HOCl and pH were measured before and after each trial. The HOCl in water containing 300 mg/L COD significantly declined (P ≤ 0.05) by the end of each 120-s trial, most likely due to the increased demand for the oxidant. Higher inoculum levels and lower HOCl concentrations were significant factors (P ≤ 0.05) that contributed to increased cross-contamination. At 25 mg/L HOCl, no Salmonella was recovered under all conditions from uninoculated tomatoes exposed to tomatoes inoculated at 104 CFU per tomato. When the inoculum was increased to 106 and 108 CFU per tomato, cross-contamination was observed, independent of COD levels. The results from this study indicate that the currently required sanitizer concentration (e.g., 100 or 150 mg/L) for flume water may be higher than necessary and warrants reevaluation.

Effects of water activity, ammonia and Corynebacterium urealyticum on the survival of Salmonella Typhimurium in sterile poultry litter.

AIMS: This study examined the effects of water activity (aw ), ammonia and Corynebacterium urealyticum on the survival of Salmonella Typhimurium in sterile poultry litter. METHODS AND RESULTS: Sterile poultry litter inoculated with S. Typhimurium was adjusted to pH 9.0, various aw levels (0.84, 0.92 and 0.96), and total ammonia nitrogen levels were increased either by the addition of ammonium sulphate or C. urealyticum inoculation with 1% urea added. All litter treatments were incubated at 30°C and sampled daily for five days. Similar results were observed at each aw level in both experiments. At 0.84 and 0.92 aw , S. Typhimurium populations in litter fell below 1 log CFU g-1 within 5 days, with no significant differences between the controls and increased ammonia treatments. At 0.96 aw , Salmonella populations treated with increased ammonia levels were significantly lower than control treatments on days 1-5. CONCLUSIONS: This study showed that C. urealyticum can produce ammonia in litter at higher aw levels with sufficient available urea and that the antimicrobial efficacy of ammonia is dependent on high aw (~0.96) in litter. SIGNIFICANCE AND IMPACT OF THE STUDY: These results provide insights into the production of ammonia in litter, its antimicrobial efficacy in litter and the importance of aw in this interaction.

Application of Chitosan Microparticles against Human Norovirus.

ABSTRACT: Human norovirus (HuNoV) is the leading cause of foodborne illness outbreaks and the second most common cause of waterborne infections in the United States. The goal of this research was to investigate the antiviral activity of chitosan microparticles (CMs) against HuNoV GII.4 Sydney and its cultivable surrogate Tulane virus (TuV) in suspensions mimicking fecally contaminated water. CMs were prepared by cross-linking chitosan molecules with sodium sulfate, and the antiviral activity of CMs was assessed with an infectivity assay on TuV and by quantitative reverse transcription PCR on TuV and HuNoV. A 3% CM suspension in phosphate-buffered saline (pH 7.2) bound to TuV particles but had a negligible impact on virus infectivity (P > 0.05). A 10-min contact time resulted in a 1.5-log reduction in genomic copies per mL of TuV and HuNoV in fecal suspensions (P < 0.05). Despite the negligible impact on viral infectivity, CMs can moderately bind to infectious virus particles and help purify environmental water by removing these particles. In this study, TuV was a suitable surrogate for HuNoV with similar log reductions in fecal suspension. These findings highlight the potential application of CM as a novel treatment to minimize the spread of waterborne viral pathogens.

Determining Bacterial Load and Water Quality Parameters of Chlorinated Tomato Flume Tanks in Florida Packinghouses.

ABSTRACT: Monitoring and maintenance of water quality in dump tanks or flume systems is crucial to maintaining proper sanitizer levels to prevent pathogen cross-contamination during postharvest washing of tomatoes, but there is limited information on how organic matter influences sanitizer efficacy in the water. The main objective of this study was to monitor water quality in flume tanks and evaluate the efficacy of postharvest washing of tomatoes in commercial packinghouses. Flume tank water samples (n = 3) were collected on an hourly basis from three packinghouses in Florida and analyzed for pH, total dissolved solids (TDS), free chlorine, chemical oxygen demand (COD), oxidation-reduction potential, and turbidity. Additionally, three flume-water samples were collected and tested for total aerobic plate count (APC), total coliforms (TC), and Escherichia coli. Fresh tomatoes (n = 3), both before and after washing, were collected and analyzed for the same bacterial counts. Turbidity, COD, and TDS levels in flume water increased over time in all packinghouses. Correlations observed include COD and turbidity (r = 0.631), turbidity and TDS (r = 0.810), and oxidation-reduction potential and chlorine (r = 0.660). APC for water samples had an average range of 0.0 to 4.7 log CFU/mL and TC average range of 0.0 to 4.7 log CFU/mL. All water samples were negative for E. coli. The average APC for pre- and postflume tomatoes from the three packinghouses was 6.0 log CFU per tomato and ranged from 2.2 to 7.4 log CFU per tomato. The average TC count was <1.5 and 7.0 log CFU per tomato for pre- and postwash tomatoes, respectively. There was no significant effect (P > 0.05) of postharvest washing on the microbiological qualities of tomatoes. Water quality in flume tanks deteriorated over time in all packinghouses during a typical operational day of 4 to 8 h.

Determination of aquacultured whiteleg shrimp (Litopanaeus vannemei) quality using a sensory method with chemical standard references.

BACKGROUND: Fresh shrimp are highly perishable seafood and a reliable spoilage assessment method is necessary to ensure sufficient quality control. The current quality evaluation method employed by the US Food and Drug Administration (FDA)/National Oceanic and Atmospheric Administration (NOAA) uses subjective terms 'odor of decomposition' to reject shrimp shipments, which lacks reference standards to anchor the concept and can cause ambiguity. The present study aimed to develop chemical reference standards to assist in a more objective and consistent sensory evaluation of shrimp quality. RESULTS: Chemical references were developed and used by the descriptive panel to demonstrate the aroma quality indicators of shrimp. The most important aroma attributes describing shrimp quality changes were 'salty water-like', 'natto water-like' and 'sour milk-like' based on the results of multiple linear regression analysis. The overall rating consistency of the key quality indicators was confirmed by trained a descriptive panel such that the intensity scores in two separated evaluation sessions (30 days apart) were not significant different (P > 0.05). The sensory ratings also corresponded well with presumed FDA/NOAA grades of shrimp. An untrained panel also confirmed 'salty water-like' as the main indicator of freshness and 'natto water-like' as the main indicator of spoilage, whereas the discriminative capacity was lower compared to the trained panel. CONCLUSION: The developed chemical references of key aroma quality indicators allowed the trained and untrained panels to distinguish shrimp of different freshness levels. The results indicate the potential of using chemical references as a new evaluation tool for on-site quality inspection or industrial quality assurance/quality control of shrimp with improved objectivity and consistency. © 2021 Society of Chemical Industry.

Prevalence, Concentration, and Antimicrobial Resistance Profiles of Salmonella Isolated from Florida Poultry Litter.

ABSTRACT: For over a decade, Salmonella contamination has increasingly led to outbreaks of foodborne illness associated with fresh produce. The use of untreated animal manures, or biological soil amendments of animal origin, to amend agricultural soils holds a risk of contamination from foodborne pathogens, such as Salmonella. This study was conducted to determine the prevalence, concentration, serotypes, and antimicrobial resistance profiles of Salmonella in poultry litter from Florida farms. Litter pH, total Kjeldahl nitrogen, total ammonia nitrogen, total phosphorus (P2O5), total potassium (K2O), moisture content, total solids, total ash, organic matter, and aerobic plate count (APC) were also measured. Litter samples (n = 54) were collected from 18 broiler farms across three seasons (spring, summer, and winter). Salmonella concentrations were enumerated using a most-probable-number (MPN) method, and antimicrobial susceptibility testing was performed. The prevalence of Salmonella in litter samples was 61.1%, with a geometric mean of 0.21 ± 20.7 MPN/g. Across all seasons, Salmonella concentrations were not influenced by the chemical, physical, or microbial properties measured. Recovered Salmonella isolates (n = 290) were grouped into serogroups O:4 (43.1%), O:7 (26.9%), O:8 (11.0%), O:1,3,10,19 (7.9%), and O:9,46 (7.2%). Serotyping Salmonella isolates (n = 47) resulted in 12 serotypes, with the most common being Typhimurium (27.7%), Kentucky (17.0%), Enteritidis (14.9%), and Mbandaka (14.9%). Antimicrobial resistance to tetracycline (29.8%), sulfisoxazole (23.4%), and streptomycin (14.9%) was observed. No isolates were resistant to more than two antimicrobial agents. This study provides valuable information for future risk assessments for the use of poultry litter as an untreated biological soil amendment of animal origin.

Survival of Escherichia coli O157 in autoclaved and natural sandy soil mesocosms.

While the soil microbiome may influence pathogen survival, determining the major contributors that reduce pathogen survival is inconclusive. This research was performed to determine the survival of E. coli O157 in autoclaved and natural (unautoclaved) sandy soils. Soils were inoculated with three different E. coli O157 strains (stx1+/stx2+, stx1-/stx2-, and stx1-/stx2+), and enumerated until extinction at 30°C. There was a significant difference in the survival of E. coli O157 based on soil treatment (autoclaved versus natural) at 30°C on days 1 (P = 0.00022), 3, (P = 2.53e-14), 7 (P = 5.59e-16), 14 (P = 1.072e-12), 30 (P = 7.18e-9), and 56 (P = 0.00029), with greater survival in autoclaved soils. The time to extinction (two consecutive negative enrichments) for all three strains was 169 and 84 days for autoclaved and natural soils, respectively. A separate E. coli O157 trial supplemented with 16S rRNA gene sequencing of the soil microbiome was performed at 15°C and 30°C on days 0, 7, 14, and 28 for each soil treatment. Greater species richness (Chao1, P = 2.2e-16) and diversity (Shannon, P = 2.2e-16) was observed in natural soils in comparison with autoclaved soils. Weighted UniFrac (beta-diversity) showed a clear distinction between soil treatments (P = 0.001). The greatest reduction of E. coli O157 was observed in natural soils at 30°C, and several bacterial taxa positively correlated (relative abundance) with time (day 0 to 28) in these soils (P < 0.05), suggesting that the presence of those bacteria might cause the reduction of E. coli O157. Taken together, a clear distinction in E. coli O157 survival, was observed between autoclaved and natural soils along with corresponding differences in microbial diversity in soil treatments. This research provides further insights into the bacterial taxa that may influence E. coli O157 in soils.

Prevalence and concentration of stx+ E. coli and E. coli O157 in bovine manure from Florida farms.

Fresh produce outbreaks due to Shiga toxin-producing Escherichia coli (STEC) continue to occur in the United States (US). Manure-amended soils can pose a public health risk when used for growing raw agricultural commodities. Knowing the prevalence and concentration of STEC in untreated biological soil amendments of animal origin (BSAAO) is important to help guide the most appropriate pre-harvest interval(s) following application to limit risks from these soil amendments. Bovine manure samples were collected from 12 farms in Florida, including samples from piles, lagoons, barns, and screened solids. Two methods were used to detect stx1/2 and rfbE genes in samples. A prevalence rate of 9% for stx1 and/or stx2 and 19% for rfbE was observed from the 518 bovine manure samples evaluated. A most probable number (MPN) assay was performed on stx+ samples when applicable. The geometric mean for stx+ samples (n = 20) was 3.37 MPN g-1 (0.53 log MPN g-1) with a maximum value of 6,800 MPN g-1 (3.83 log MPN g-1). This research was part of a larger nationwide geographical study on the prevalence and concentration of STEC in bovine manure to help guide regulations on feasible pre-harvest intervals for the application of untreated BSAAO.

Salmonella enterica Contamination of Market Fresh Tomatoes: A Review.

Salmonella contamination associated with market fresh tomatoes has been problematic for the industry and consumers. A number of outbreaks have occurred, and dollar losses for the industry, including indirect collateral impact to agriculturally connected communities, have run into the hundreds of millions of dollars. This review covers these issues and an array of problems and potential solutions surrounding Salmonella contamination in tomatoes. Some other areas discussed include (i) the use of case-control studies and DNA fingerprinting to identify sources of contamination, (ii) the predilection for contamination based on Salmonella serovar and tomato cultivar, (iii) internalization, survival, and growth of Salmonella in or on tomatoes and the tomato plant, in biofilms, and in niches ancillary to tomato production and processing, (iv) the prevalence of Salmonella in tomatoes, especially in endogenous regions, and potential sources of contamination, and (v) effective and experimental means of decontaminating Salmonella from the surface and stem scar regions of the tomato. Future research should be directed in many of the areas discussed in this review, including determining and eliminating sources of contamination and targeting regions of the country where Salmonella is endemic and contamination is most likely to occur. Agriculturalists, horticulturalists, microbiologists, and epidemiologists may make the largest impact by working together to solve other unanswered questions regarding tomatoes and Salmonella contamination.

Survival of Salmonella and Escherichia coli in Two Different Soil Types at Various Moisture Levels and Temperatures.

With the increased consumption of fresh produce, a proportional increase in numbers of produce-related foodborne illness has been observed. An estimate of foodborne illness during 1998 to 2008 attributed ∼46% of the incidences to produce. Any foodborne illness associated with produce can have devastating consequences to the industry. The most recent data from the Centers for Disease Control and Prevention implicate leafy vegetables, vine-stalk vegetables, root vegetables, and sprouts as the most common cause of produce-related foodborne outbreaks. Excess rainfall or flooding, mainly by altering levels of soil moisture and oxygen content, affects the microbial community in soil. The goal of this research was to determine the survivability of a three-serovar Escherichia coli and a five-serovar Salmonella enterica cocktail in microcosms prepared with Candler sand (CS) and Orangeburg sandy loam (OSL) soils. Microcosms were prepared with low, medium, and high volumetric water contents and were incubated at 20 and 30°C. Serotyping was used to determine which E. coli or Salmonella serovar(s) from each cocktail persisted. Microcosm inoculation levels were ∼7.0 log CFU/g. Sampling for CS and OSL microcosms incubated at 20°C ended on day 364 and 357, respectively. The reduction of Salmonella and E. coli to below the limit of detection (extinction) in CS microcosms (incubated at 30°C at all volumetric water content [VWC] levels) was reached on day 168 and 56, respectively. Extinction of Salmonella and E. coli in OSL microcosms (incubated at 30°C at all VWCs) was reached on day 168 and 224, respectively. Of the Salmonella and E. coli serovars analyzed, Salmonella Javiana persisted the longest in both soil types, whereas E. coli O104:H4 and E. coli O145 persisted the longest in CS and OSL microcosms, respectively. Results from the current study suggest that soil type and temperature influenced pathogen persistence in CS and OSL soils more than moisture level and pathogen type.

Determination of Optimum Sanitizer Levels for Prevention of Salmonella Cross-Contamination of Mature Round Tomatoes in a Laboratory Model Flume System.

Salmonella has been reported to be involved in several foodborne illness outbreaks, many of which resulted from consumption of raw tomatoes. This research aimed to optimize and evaluate the concentration of free chlorine (hypochlorous acid [HOCl]) used as a sanitizer to prevent cross-contamination of tomatoes inoculated with a cocktail of five rifampin-resistant Salmonella enterica serovars in a laboratory-based model flume system. Organic load, prepared using sterilized Scotts Premium Topsoil, was added in different quantities to the flume wash water to simulate real-world packinghouse conditions. In a typical packinghouse operation utilizing a recirculating flume system, the organic matter washed from tomato surfaces accumulates over time. In this study, different concentrations (0, 25, 50, 75, and 100 ppm) of HOCl were used as sanitizers under three organic load conditions (0, 650, and 1,000 mg/L chemical oxygen demand). Results showed that 100 ppm of HOCl was necessary to prevent Salmonella cross-contamination of uninoculated tomatoes in the model flume system in the presence of organic loading. Also, when treated with 100 ppm of HOCl, Salmonella levels were reduced by >4.5 log CFU per tomato from inoculated tomatoes in the presence of organic load. At 75 ppm of HOCl, Salmonella cross-contamination was prevented, but only in the absence of organic loading. In studies in which plate counts were negative, whole tomato enrichment studies were performed. No cross-contamination of uninoculated tomatoes was recorded when 100 ppm of HOCl was used, even in the presence of high organic load (1,000 mg/L chemical oxygen demand). Although sanitizer application reduces contamination on tomato surfaces, the primary function of sanitizers in the wash water is to prevent cross-contamination.