Complex network analysis of slaughterhouse waste anaerobic digestion: From failure to success of long-term operation.

The study explored slaughterhouse waste (SHW) as prime feedstock associated with and without supplement of an external slowly degradable lignocellulosic carbon source to overcome the synergistic co-inhibitions of ammonia and fatty acids. Long-term solid-state digestion (SSD) and liquid-state digestion (LSD) were investigated using a mixture of pork liver and fat. At 2.0 g volatile solids (VS) L-1 d-1 of organic loading rate (OLR), the two reactors of SSD experienced operational instability due to ammonia inhibition and volatile fatty acid (VFA) accumulation while LSD successfully produced 0.725 CH4 L CH4 g-1VS during 197 d of working days under unfavorable condition with high total ammonia nitrogen (>4.7 g/L) and VFAs concentration (>1.9 g/L). The network analysis between complex microflora and operational parameters provided an insight for sustainable biogas production using SHW. Among all, hydrogenotrophic methanogens have shown better resistance than acetoclastic methanogens.

Methane potential of fruit and vegetable waste: an evaluation of the semi-continuous anaerobic mono-digestion.

The anaerobic digestion (AD) of a high diversity blend of fruit and vegetable waste (FVW) generated in tropical conditions as a single substrate was performed. A continuously stirred tank reactor (CSTR) operated in semi-continuous regime was used for AD. The reactor performance was monitored with gradually increasing organic loading rates (OLRs) from 0.5 up to 5.0 gVS L-1 d-1. The biochemical methane potential (BMP) of FVW determined by batch bottles was 360 LN CH4 kgVS-1, with a biodegradability of 79%. A stable pH with an adequate level of buffering capacity was observed during the entire experiment. Methane yield indicated the best performance at an OLR of 3.0 gVS L-1 d-1, with 285 LN CH4 kgVS-1 added, reaching 79% of BMP. At an OLR over 3.0 gVS L-1 d-1 accumulation of volatile fatty acids (VFA) was detected; in particular, propionic acid was monitored, and a decreased methane yield was detected. Biogas production rate was 1.55 LN L-1 d-1 and showed linear increase according to increases in the OLR.

Comparison of pre- and inter-stage aerobic treatment of wastewater sludge: Effects on biogas production and COD removal.

The aim of this study was to investigate thermophilic (55°C) aerobic digestion (TAD) as pre- and inter-stage treatment of sludge anaerobic digestion and to analyse the change in organic matter accessibility and complexity. Pre-treatment decreased methane yield (up to -70%), due to oxidation losses whereas inter-stage treatment slightly improved overall methane yield (+2.6%) and total COD removal (+5%) compared to control. Anaerobic degradability and COD removal in the second anaerobic stage significantly increased, by 13-40%. Organic matter fractionation showed that TAD led to an increase in sludge organic matter accessibility in all cases. Organic matter complexity, measured by fluorimetry, increased after TAD pre-treatment whereas it remained constant after inter-stage treatment. TAD was shown to be more efficient if applied to a more recalcitrant substrate and should thus be used as inter-stage treatment to avoid decreasing methane production.

Biogas Digester Hydraulic Retention Time Affects Oxygen Consumption Patterns and Greenhouse Gas Emissions after Application of Digestate to Soil.

Knowledge about environmental impacts associated with the application of anaerobic digestion residue to agricultural land is of interest owing to the rapid proliferation of biogas plants worldwide. However, virtually no information exists concerning how soil-emitted NO is affected by the feedstock hydraulic retention time (HRT) in the biogas digester. Here, the O planar optode technique was used to visualize soil O dynamics following the surface application of digestates of the codigestion of pig slurry and agro-industrial waste. We also used NO isotopomer analysis of soil-emitted NO to determine the NO production pathways, i.e., nitrification or denitrification. Two-dimensional images of soil O indicated that anoxic and hypoxic conditions developed at 2.0- and 1.5-cm soil depth for soil amended with the digestate produced with 15-d (PO15) and 30-d (PO30) retention time, respectively. Total NO emissions were significantly lower for PO15 than PO30 due to the greater expansion of the anoxic zone, which enhanced NO reduction via complete denitrification. However, cumulative CO emissions were not significantly different between PO15 and PO30 for the entire incubation period. During incubation, NO emissions came from both nitrification and denitrification in amended soils. Increasing the HRT of the biogas digester appears to induce significant NO emissions, but it is unlikely to affect the NO production pathways after application to soil.

Co-ensiling of straw with sugar beet leaves increases the methane yield from straw.

This study examined the effect of co-ensiling of wheat straw and sugar beet leaves on the biochemical methane potential (BMP) by both lab-scale and pilot-scale co-ensiling. BMP was increased by co-ensiling, and the increase ranged from 19 to 34% after 9months of co-ensiling in lab-scale and from 18 to 32% after 6months of co-ensiling in pilot-scale. No effluent run-off was found through pilot-scale co-ensiling and there was a mass loss of only 0.1%. The study demonstrates that co-ensiling of straw and green biomass has potential as biological pretreatment and for avoiding effluent run-off from pure beet leave silage.

Estimation of Methane Emissions from Slurry Pits below Pig and Cattle Confinements.

Quantifying in-house emissions of methane (CH4) from liquid manure (slurry) is difficult due to high background emissions from enteric processes, yet of great importance for correct estimation of CH4 emissions from manure management and effects of treatment technologies such as anaerobic digestion. In this study CH4 production rates were determined in 20 pig slurry and 11 cattle slurry samples collected beneath slatted floors on six representative farms; rates were determined within 24 h at temperatures close to the temperature in slurry pits at the time of collection. Methane production rates in pig and cattle slurry differed significantly at 0.030 and 0.011 kg CH4 kg-1 VS (volatile solids). Current estimates of CH4 emissions from pig and cattle manure management correspond to 0.032 and 0.015 kg CH4 kg-1, respectively, indicating that slurry pits under animal confinements are a significant source. Fractions of degradable volatile solids (VSd, kg kg-1 VS) were estimated using an aerobic biodegradability assay and total organic C analyses. The VSd in pig and cattle slurry averaged 0.51 and 0.33 kg kg-1 VS, and it was estimated that on average 43 and 28% of VSd in fresh excreta from pigs and cattle, respectively, had been lost at the time of sampling. An empirical model of CH4 emissions from slurry was reparameterised based on experimental results. A sensitivity analysis indicated that predicted CH4 emissions were highly sensitive to uncertainties in the value of lnA of the Arrhenius equation, but much less sensitive to uncertainties in VSd or slurry temperature. A model application indicated that losses of carbon in VS as CO2 may be much greater than losses as CH4. Implications of these results for the correct estimation of CH4 emissions from manure management, and for the mitigation potential of treatments such as anaerobic digestion, are discussed.