Development of thiolated poly(acrylic acid) microparticles for the nasal administration of exenatide.

The purpose of this study was to develop a microparticulate formulation for nasal delivery of exenatide utilizing a thiolated polymer. Poly(acrylic acid)-cysteine (PAA-cys) and unmodified PAA microparticles loaded with exenatide were prepared via coprecipitation of the drug and the polymer followed by micronization. Particle size, drug load and release of incorporated exenatide were evaluated. Permeation enhancing properties of the formulations were investigated on excised porcine respiratory mucosa. The viability of the mucosa was investigated by histological studies. Furthermore, ciliary beat frequency (CBF) studies were performed. Microparticles displayed a mean size of 70-80 µm. Drug encapsulation was ∼80% for both thiolated and non-thiolated microparticles. Exenatide was released from both thiolated and non-thiolated particles in comparison to exenatide in buffer only within 40 min. As compared to exenatide dissolved in buffer only, non-thiolated and thiolated microparticles resulted in a 2.6- and 4.7-fold uptake, respectively. Histological studies performed before and after permeation studies showed that the mucosa is not damaged during permeation studies. CBF studies showed that the formulations were cilio-friendly. Based on these results, poly(acrylic acid)-cysteine-based microparticles seem to be a promising approach starting point for the nasal delivery of exenatide.

Efficient MRI labeling of endothelial progenitor cells: design of thiolated surface stabilized superparamagnetic iron oxide nanoparticles.

The aim of this study was to design thiolated surface stabilized superparamagnetic iron oxide nanoparticles (TSS-SPIONs) for efficient internalization with high MRI sensitivity. TSS-SPIONs were developed by chelation between thiolated chitosan-thioglycolic acid (chitosan-TGA) hydrogel and iron ions (Fe(2+)/Fe(3+)). Likely, unmodified chitosan hydrogel SPIONs (UC-SPIONs) and uncoated SPIONs were used as control. Moreover, TSS-SPIONs were investigated regarding to their iron core size, hydrodynamic diameter, zeta potential, iron contents, molar relaxivities (r1 and r2), and cellular internalization. TSS-SPIONs demonstrated an iron oxide core diameter (crystallite size by XRD) of 3.1 ± 0.02 nm, a hydrodynamic diameter of 94 ± 20 nm, a zeta potential of +21 ± 5 mV, and an iron content of 3.6 ± 0.9 mg/mL. In addition, internalization of TSS-SPIONs into human endothelial progenitor cells (EPC) from umbilical cord blood was more than threefold and 17-fold higher in contrast to UC-SPIONs and SPIONs, respectively. With twofold lower incubation iron concentration of TSS-SPIONs, more than threefold higher internalization was achieved as compared to Resovist®. Also, cell viability of more than 90% was observed in the presence of TSS-SPIONs after 24h. The molar MR relaxivities (r2) value at 1.5 T was threefold higher than that of Resovist® and demonstrated that TSS-SPIONs have the potential as very effective T2 contrast-enhancement agent. According to these findings, TSS-SPIONs with efficient internalization, lower cytotoxicity, and high MRI sensitivity seem to be promising for cell tracking.

Thiolated chitosan nanoparticles for the nasal administration of leuprolide: bioavailability and pharmacokinetic characterization.

The purpose of this study was to develop thiolated nanoparticles to enhance the bioavailability for the nasal application of leuprolide. Thiolated chitosan-thioglycolic acid (chitosan-TGA) and unmodified chitosan nanoparticles (NPs) were developed via ionic gelation with tripolyphosphate (TPP). Leuprolide was incorporated during the formulation process of NPs. The thiolated (chitosan-TGA) NPs had a mean size of 252 ± 82 nm, a zeta potential of +10.9 ± 4 mV, and payload of leuprolide was 12 ± 2.8. Sustained release of leuprolide from thiolated NPs was demonstrated over 6h, which might be attributed to inter- and/or intramolecular disulfide formation within the NPs network. Ciliary beat frequency (CBF) study demonstrated that thiolated NPs can be considered as suitable additives for nasal drug delivery systems. Compared to leuprolide solution, unmodified NPs and thiolated NPs provoked increased leuprolide transport through porcine nasal mucosa by 2.0 and 5.2 folds, respectively. The results of a pharmacokinetic study in male Sprague-Dawley rats showed improved transport of leuprolide from thiolated NPs as compared to leuprolide solution. Thiolated NPs had a 6.9-fold increase in area under the curve, more than 4-fold increase in elimination half-life, and a ∼3.8-fold increase in maximum plasma concentration compared to nasal solution alone. The relative nasal bioavailability (versus s.c. injection) of leuprolide thiolated NPs calculated on the basis of AUC((0-6)) was about 19.6% as compared to leuprolide solution 2.8%. The enhanced bioavailability of leuprolide is likely due to facilitated transport by thiolated NPs rather than improved release.

In vitro evaluation of mucoadhesive vaginal tablets of antifungal drugs prepared with thiolated polymer and development of a new dissolution technique for vaginal formulations.

The main objective of this work was to develop antifungal matrix tablet for vaginal applications using mucoadhesive thiolated polymer. Econazole nitrate (EN) and miconazole nitrate (MN) were used as antifungal drugs to prepare the vaginal tablet formulations. Thiolated poly(acrylic acid)-cysteine (PAA-Cys) conjugate was synthesized by the covalent attachment of L-cysteine to PAA with the formation of amide bonds between the primary amino group of L-cysteine and the carboxylic acid group of the polymer. Vaginal mucoadhesive matrix tablets were prepared by direct compression technique. The investigation focused on the influence of modified polymer on water uptake behavior, mucoadhesive property and release rate of drug. Thiolated polymer increased the water uptake ratio and mucoadhesive property of the formulations. A new simple dissolution technique was developed to simulate the vaginal environment for the evaluation of release behavior of vaginal tablets. In this technique, daily production amount and rate of the vaginal fluid was used without any rotational movement. The drug release was found to be slower from PAA-Cys compared to that from PAA formulations. The similarity study results confirmed that the difference in particle size of EN and MN did not affect their release profile. The release process was described by plotting the fraction released drug versus time and n fitting data to the simple exponential model: M(t)/M(∞)=kt(n). The release kinetics were determined as Super Case II for all the formulations prepared with PAA or PAA-Cys. According to these results the mucoadhesive vaginal tablet formulations prepared with PAA-Cys represent good example for delivery systems which prolong the residence time of drugs at the vaginal mucosal surface.

Safety assessment of thiolated polymers: effect on ciliary beat frequency in human nasal epithelial cells.

OBJECTIVE: The aim of this study was to investigate the nasal safety of gel formulations of thiolated polymers (thiomers) by assessing their effect on ciliary beat frequency (CBF) in human nasal epithelial cells. METHODS: Poly(acrylic acid) 450 kDa-cysteine (PAA-cys) and alginate-cysteine (alg-cys) were synthesized by covalent attachment of L-cysteine to the polymeric backbone. The cationic polymer chitosan-thiobutylamidine (chito-TBA) was synthesized by attaching iminothiolane to chitosan. CBF using was measured by a photometric system. CBF was measured before incubating the cells with test gels, during incubation and after washing out the polymeric test gels to evaluate reversibility of cilio-inhibition. The influence of viscosity on CBF was determined by using hydroxyethylcellulose (HEC)-gels of various concentrations. RESULTS: Ciliary beating was observed to be affected by viscosity, but cilia were still beating in the presence of a HEC-gel displaying an apparent viscosity of 25 Pa.s. In case of thiolated polymers and their unmodified control, a concentration-dependent decrease in CBF could be observed. PAA-cys, alg-cys, chito-TBA and their corresponding unmodified controls exhibited a moderate cilio-inhibitory effect, followed by a partial recovery of CBF when used at a concentration of 1%. Alg-cys 2% and chito-TBA 2% (m/v) gels exhibited severe cilio-inhibition, which was partially reversible. L-cysteine and reduced glutathione led to mild cilio-inhibition at concentrations of 3% (m/v). CONCLUSIONS: Taking into account that dilution after application and cilio-modifying effects is usually more pronounced under in vitro conditions, thiomers can be considered as suitable excipients for nasal drug delivery systems.

Thiolated chitosans: influence of various sulfhydryl ligands on permeation-enhancing and P-gp inhibitory properties.

PURPOSE: The influence of various sulfhydryl ligands on permeation-enhancing and P-glycoprotein (P-gp) inhibitory properties of the six established thiolated chitosan conjugates was investigated using Rhodamine-123 (Rho-123) and fluorescein isothiocyanate-dextran 4 (FD4) as model compounds. METHODS: Permeation of these compounds was tested on freshly excised rat intestine in Ussing-type chambers. Apparent permeability coefficients (Papp) were calculated and compared to values obtained from the buffer only control. RESULTS: The lyophilized polymers had a thiol group content in the range of 230-520 µmol/g. Results of this study led to the following rank order in permeation enhancement: chitosan-6-mercaptonicotinic acid (chitosan-6MNA) > chitosan-cysteine (chitosan-Cys) > chitosan-glutathione (chitosan-GSH) > chitosan-4-thiobutylamidine (chitosan-TBA) > chitosan-thioglycolic acid (chitosan-TGA) > chitosan-N-acetyl cysteine (chitosan-NAC). In P-gp inhibition studies, 0.5% (m/v) chitosan-NAC showed the highest inhibitory effect on P-gp, where the Papp was determined to be 3.78-fold increased compared with the buffer control. Among these thiolated chitosans, chitosan-NAC and chitosan-6MNA are the most effective polymers being responsible for P-gp inhibition and permeation enhancement, respectively. CONCLUSION: These thiolated chitosans would therefore be advantageous tools for enhancing the noninvasive bioavailability of active pharmaceutical ingredients.

Thiolated polycarbophil/glutathione: defining its potential as a permeation enhancer for oral drug administration in comparison to sodium caprate.

Thiolated polyacrylates were shown to be permeation enhancers with notable potential. The aim of this study was to evaluate the permeation enhancing properties of a thiolated polycarbophil/glutathione (PCP-Cys/GSH) system for oral drug application in comparison to a well-established permeation enhancer, namely sodium caprate. In vitro permeation studies were conducted in Ussing-type chambers with sodium fluoresceine (NaFlu) and fluoresceine isothiocyanate labeled dextran (molecular mass 4 kDa; FD4) as model compounds. Bioavailability studies were carried out in Sprague Dawley rats with various formulations. Moreover, cytotoxic effects of both permeation enhancers were compared. Permeation enhancement ratios of 1% sodium caprate were found to be 3.0 (FD4) and 2.3 (NaFlu), whereas 1% PCP-Cys/0.5% GSH displayed enhancement ratios of 2.4 and 2.2. Both excipients performed at a similar level in vivo. Sodium caprate solutions increased oral bioavailability 2.2-fold (FD4) and 2.3-fold (NaFlu), while PCP-Cys hydrogels led to a 3.2-fold and 2.2-fold enhancement. Cell viability experiments revealed a significantly higher tolerance of Caco-2 cells towards 0.5% PCP-Cys (81% survival) compared to 0.5% sodium caprate (5%). As PCP-Cys is not absorbed from mucosal membranes due to its comparatively high molecular mass, systemic side-effects can be excluded. In conclusion, both systems displayed a similar potency for permeation enhancement of hydrophilic compounds. However, PCP-Cys seems to be less harmful to cultured cells.

A comprehensive in vitro and in vivo evaluation of thiolated matrix tablets as a gastroretentive delivery system.

The aim of this study was to investigate the potential of thiolated matrix tablets for gastroretentive delivery systems. Poly(acrylic acid)-cysteine (PAA-Cys) and chitosan-4-thiobuthylamidine (chitosan-TBA) were evaluated as anionic and cationic thiolated polymers and riboflavin was used as a model drug. Tablets were prepared by direct compression and each formulation was characterized in terms of disintegration, swelling, mucoadhesion, and drug release properties. Thereafter, the gastric residence times of tablets were determined with in vivo study in rats. The resulting PAA-Cys and chitosan-TBA conjugates displayed 172.80 ± 30.33 and 371.11 ± 72.74 µmol free thiol groups, respectively. Disintegration studies demonstrated the stability of thiolated tablets up to 24 h, whereas tablets prepared with unmodified PAA and chitosan disintegrated within a time period of 1 h. Mucoadhesion studies showed that mucoadhesion work of PAA-Cys and chitosan-TBA tablets were 1.341- and 2.139-times higher than unmodified ones. The mucoadhesion times of PAA, PAA-Cys, chitosan, and chitosan-TBA tablets were 1.5 ± 0.5, 21 ± 1, 1 ± 0.5, 17 ± 1 h, respectively. These results confirm the theory that thiol groups react with mucin glycoproteins and form covalent bonds to the mucus layer. Release studies indicated that a controlled release was provided with thiolated tablets up to 24 h. These promising in vitro results of thiolated tablets were proved with in vivo studies. The thiolated tablets showed a gastroretention time up to 6 h, whereas unmodified tablets completely disintegrated within 1 h in rat stomach. Consequently, the study suggests that thiolated matrix tablets might be promising formulations for gastroretentive delivery systems.

Gastroretentive particles formulated with thiomers: development and in vitro evaluation.

The objective of this study is to develop and evaluate gastroretentive particulate delivery systems using Riboflavin-5'-monophosphate sodium salt dihydrate (RF5'PNa) as model drug. Poly(acrylic acid)-cysteine and chitosan-4-thiobuthylamidine were evaluated and compared as anionic and cationic polymers for gastroretentive particles. Permeation studies were performed with freshly excised stomach mucosa from rats. Polymers and combination with glutathione were evaluated for permeation enhancing properties. Furthermore, particles were prepared by air jet milling and characterized. Permeation studies showed that the apparent permeability coefficients for RF5'PNa with thiomers and glutathione are 1.511-fold and 2.354-fold higher than control, respectively. It can be seen from the results glutathione in combination with thiomers has a significant influence for increasing permeation. Poly(acrylic acid)-cysteine and chitosan-4-thiobuthylamidine particles demonstrated a mean diameter of 336.5 +/- 16.5 and 396.3 +/- 17.0 nm and zeta potential of -19.98 +/- 1.015 and 27.15 +/- 0.500 mV, respectively. The drug loading of Poly(acrylic acid) particles was significantly higher than chitosan particles. The release rate of RF5'PNa from the thiolated particles was slower compared with unmodified particles. Moreover, thiolated particles showed higher mucoadhesive properties compared to unmodified particles. Overall, thiolated particles of both anionic and cationic polymers had improved mucoadhesive and controlled release properties. Therefore, they could be promising for gastroretentive delivery systems.