History repeats itself: consumption of a local traditional roast pork meat recipe leads to Salmonella ser. Give cases in Greece.

INTRODUCTION: An outbreak of gastroenteritis due to Salmonella Give, a very rarely identified serotype in human isolates in Greece, occurred in participants of a religious festival in a rural area of southern Greece, in September 2022. The objectives of this study were to describe the outbreak in terms of epidemiology, identify the vehicle of transmission of the foodborne pathogen and recommend prevention measures. METHODS: The outbreak was linked to the consumption of a local traditional recipe of roasted pork meat served by a street food vendor. In 2018, the same food item, served in a restaurant in the same region, was implicated in another S. Give outbreak. RESULTS: Outbreak investigations revealed that outbreak-associated isolates, of food and human origin, belonged to the same S. Give strain. Significant deficiencies regarding food safety practices were identified. CONCLUSION: Technical knowledge about pathogen transmission paths is important in order for both food handlers and consumers to follow hygiene and sanitary measures, mainly in cases of mass gatherings, where large quantities of food are prepared, handled, cooked and served. Efficient official supervision, mainly during summer festivals, is required in order to avoid recurrence of foodborne infections by different combinations of pathogens/food commodities.

Insights into the identification of bitter peptides from Jinhua ham and its taste mechanism by molecular docking and transcriptomics analysis.

In order to identify the peptides responsible for bitter defects and to understand the mechanism of bitterness in dry-cured ham, the peptides were identified by LC-MS/MS, and the interaction between bitter peptides and receptor proteins were evaluated by molecular docking and molecular dynamics simulation; the signal transduction mechanism of bitter peptides was investigated using the model of HEK-293T cells by calcium imaging and transcriptomics analysis. The results of LC-MS/MS showed that 11 peptides were identified from the high bitterness fraction of defective ham; peptides PKAPPAK, VTDTTR and YIIEK derived from titin showed the highest bitterness values compared with other peptides. The results of molecular docking showed that lower CDOCKER energy was observed in the interaction between these peptides and hT2R16 in comparison with these receptors of hT2R1, hT2R4, hT2R5, hT2R8 and hT2R14, and the interaction of hT2R16 and peptides was stabilized by hydrophobic interaction and hydrogen bond. The average RMSF values of VTDTTR were higher than that of YIIEK and PKAPPAK, while EC50 values of VTDTTR were lower compared with PKAPPAK and YIIEK. Transcriptomics analysis showed that 529 differentially expressed genes were identified in HEK-293T cells during the stimulating by VTDTTR and were mainly enriched into neuroactive ligand-receptor interaction, MAPK pathway, cAMP pathway and calcium signaling pathway, which were mainly responsible for the bitter signal transduction of VTDTTR. These results could provide evidence for understanding the bitter defects of dry-cured ham and the taste mechanism of bitter peptide.

Effect of dietary Eucommia ulmoides oliver polysaccharide on immune function and meat quality of Songliao Black Pigs.

Eucommia ulmoides is a traditional Chinese herbal medicine, with pharmacological effects such as lowering blood pressure and enhancing immune function. The effects of dietary Eucommia ulmoides polysaccharide (EUP) on immune function and meat quality were studied in Songliao Black Pigs. Blood lymphocyte counts and percentage, concentrations of serum total protein and of albumin increased, whereas those of urea nitrogen and triglyceride decreased. White blood cell and lymphocyte counts, and serum IgA, IgE, IgG2 a and IFN-γ increased. Average daily weight gain, slaughter weight, lean meat rate and cooked meat rate increased, whereas pH24, feed-weight ratio, fat rate, yellowness (b#) and centrifugal dehydration rate decreased. Transcriptome sequencing of longissimus dorsi muscle detected 32 differentially expressed genes (DEGs), of which 26 were up-regulated and 6 down-regulated. A total of 19 genes were differentially expressed in the four groups, 18 of which were up-regulated. The DEGs included ADAMTS4, PER1, STAC, SERPINE1, FASN, THRSP, SP7 and KRT80 and the protein interaction network showed 20 up-regulated nodes, three down-regulated nodes and 14 DEGs. GO functional annotation and enrichment analysis showed that 34 items were significantly enriched, including transferase activity, actin binding, acetyl coenzyme A, acyl coenzyme A metabolism, adipose tissue development and acyl glycerol homeostasis. KEGG pathway analysis showed that the AMPK and PPAR signaling pathways were enriched. Dietary Eucommia polysaccharide enhanced immune function in Songliao Black Pigs, improved growth and carcass performance, increased the expression of genes related to meat quality traits and improved meat quality.

Natural aromatic extract of black tea improved the water retention of pork meat batter.

The effect of varying proportions (w/w) of natural aromatic extract of black tea (NAEBT) with pre-emulsification on the water-holding capacity (WHC) of pork meat batter was investigated. The addition of NAEBT significantly reduced the cooking loss (CL) of pork meat batter from 23.95 % to 18.30 % (P < 0.05). Furthermore, NAEBT with pre-emulsification significantly improved the color stability and increased the springiness (P < 0.05). The results of TBARS and carbonyls indicated that NAEBT with pre-emulsification significantly alleviated oxidative damage to proteins (P < 0.05), resulting in an increased level of ß-sheet (P < 0.05), as confirmed by FT-IR analysis. As a result, the water mobility of pork meat batter was restricted (P < 0.05), resulting in an increase in the energy storage modulus (P < 0.05) and a decrease in the pore size. In summary, the WHC of pork meat batter was improved by the antioxidant effect of the NAEBT.

Effects of slaughter weight and backfat depth on trimming, curing, and deboning losses and quality traits of Italian dry-cured ham.

This study aimed at assessing the effects of two infra-vitam traits, specifically the slaughter weight (SW) and the ultrasound backfat depth (BCKF) on several post-mortem and quality traits of typical Prosciutto Veneto protected designation of origin (PDO) dry-cured ham. The trial was conducted on a population of 423 pigs fed using different strategies to generate a high variation in SW (175 ± 15.5 kg) and BCKF (23.16 ± 4.14 mm). All the left thighs were weighed at slaughter and the ham factory during the different processing phases. The fat cover depth of green trimmed hams was measured. Data were analyzed with a linear model including SW classified in tertiles, BCKF as a covariate, SW × BCKF interaction, sex, batch, and pen nested within batch. Our results highlighted that, for each 10 kg increase in SW, trimmed and seasoned ham weights increased by 0.76 and 0.54 kg, respectively. The increase in SW significantly reduced relative curing and deboning losses but did not affect ham fat cover depth and trimming losses. A rise in BCKF increased the ham fat cover depth and trimming losses and decreased the curing and deboning losses. Increases in SW and BCKF improved quality traits of the seasoned ham including fat cover depth, visible marbling, inner lean firmness, and fat color. These findings confirm the feasibility of increasing SW and BCKF, which will result in a reduction in the relative losses associated with the dry-curing process while improving the quality of the seasoned ham.

Difference comparison of characteristic aroma compounds between braised pork cooked by traditional open-fire and induction cooker and the potential formation cause under electromagnetic cooking.

The characteristic aroma compounds of braised pork were identified through molecular sensory science and PLSR analysis, and the difference between two cooking methods, traditional open-fire (BPF) and induction cooker (BPC), was compared. Seventeen aroma compounds with odor activity values (OAVs) > 1 were identified in both samples. BPF revealed higher OAVs for most of the aroma compounds compared to BPC, and the higher aroma quality. Aroma recombination and omission experiments confirmed that twelve aroma compounds significantly contributed to the characteristic aroma of braised pork, and eight compounds such as hexanal, (E)-2-octenal, and methanethiol were further confirmed as important contributors by PLSR analysis. Furthermore, PLSR analysis clarified the role of aldehydes such as hexanal, (E)-2-octenal, and (E,E)-2,4-decadienal in contributing to fatty attribute, whereas methanethiol was responsible for the meaty aroma. These characteristic aroma compounds mainly derived from lean meat due to its high content of phospholipids, and the exogenous seasonings contributed to the balanced characteristic aroma profile of braised pork by altering the distribution of these characteristic aroma compounds. Variations in heating parameters affected the formation of lipid oxidation and Strecker degradation products, which might explain aroma discrepancy between braised pork cooked by two methods with different heat transfer efficiencies.

In Silico Detection of Integrons and Their Relationship with Resistance Phenotype of Salmonella Isolates from a Brazilian Pork Production Chain.

The pork production chain is an important reservoir of antimicrobial resistant bacteria. This study identified and characterized integrons in Salmonella isolates from a Brazilian pork production chain and associate them with their antibiotic resistance pattern. A total of 41 whole-genome sequencing data of nontyphoidal Salmonella were analyzed using PlasmidSPAdes and IntegronFinder software. Nine isolates (21.9%) had some integrons identified (complete and/or incomplete). Six complete class 1 integrons were found, with streptomycin resistance genes (aadA1, aadA2) alone or downstream of a trimethoprim resistance gene (dfrA1, dfrA12), and some also containing resistance genes for sulfonamides (sul1, sul3) and chloramphenicol (cmlA1). Class 2 integron was detected in only one isolate, containing dfrA1-sat2-aadA1 gene cassettes. Five isolates harbored CALINs-clusters attC but lacking integrases-with antimicrobial resistance genes typically found in integron structures. In all, integrons were observed among four serotypes: Derby, Bredeney, Panama, and monophasic var. Typhimurium I 4,[5],12:i:-. The association of integrons with antibiotic resistance phenotype showed that these elements were predominantly identified in multidrug resistance isolates, and six of the seven gentamicin-resistant isolates had integrons. So, surveillance of integrons in Salmonella should be performed to identify the potential for the spread of antimicrobial resistance genes among bacteria.

Revealing the intrinsic relationship between microbial communities and physicochemical properties during ripening of Xuanwei ham.

To clarify the relationship between microorganisms and physicochemical indicators of Xuanwei ham. Six ham samples for the first, second and third year were selected, respectively. The changes of physicochemical properties, the free fatty acids and microbial communities of Xuanwei ham were investigated by GC-MS and high-throughput sequencing technology. Results showed that scores of colour, overall acceptability, texture, taste and aroma were the highest in the third year sample. With increasing ripening time, moisture content, water activity (Aw), lightness (L*), springiness, and resilience decreased continuously, and yellowness (b*) was the highest in the second year sample. 31 free fatty acids were detected, and unsaturated fatty acids such as palmitoleic acid, oleic acid, and linoleic acid were the major fatty acids. The content of palmitoleic acid, oleic acid and eicosenoic acid increased significantly during processing. At the phylum level, the dominant bacteria were Proteobacteria and Firmicutes, and fungi were Ascomycota. At the genus level, the dominant bacteria were Staphylococcus and Psychrobacter, and fungi were Aspergillus. Correlation analysis showed that water content and Aw were closely related to microorganisms, and most unsaturated fatty acids were significantly correlated with microorganisms. These findings showed that microorganisms played an important role in the quality of Xuanwei ham, and provided a scientific basis for the quality control of Xuanwei ham.

Identification of a novel QTL for lean meat percentage using imputed genotypes.

Lean meat percentage is a critical production trait in pig breeding systems with direct implications for the sustainability of the industry. In this study, we conducted a genome-wide association study for lean meat percentage using a cohort of 850 Duroc × (Landrace × Yorkshire) crossbred pigs and we identified QTL on SSC3 and SSC18. Based on the predicted effect of imputed variants and using the PigGTEx database of molecular QTL, we prioritized candidate genes and SNPs located within the QTL regions, which may be involved in the regulation of porcine leanness. Our results indicate that a nonsense mutation in ZC3HAV1L on SSC18 has a direct effect on lean meat percentage.

Effect of ultrasound-assisted L-lysine treatment on pork meat quality and myofibrillar protein properties during postmortem aging.

This paper aimed to investigate the effects of ultrasound-assisted L-lysine treatment on meat quality and myofibrillar proteins (MPs) properties of pork longissimus dorsi during postmortem aging. The results revealed that the L-lysine (Lys) and/or ultrasound treatment significantly increased (p < 0.05) the water-holding capacity and tenderness of the pork during postmortem aging, while the ultrasound-assisted Lys treatment had the lowest cooking loss, pressurization loss, Warner-Bratzler shear force, and hardness. In addition, L-lysine and/or ultrasound treatment increased (p < 0.05) pH value, T21, and myofibrillar fragmentation index, while the ultrasound-assisted Lys treatment had the highest value. Meanwhile, the protein solubility was increased with Lys and/or ultrasound treatment during postmortem aging, and ultrasound-assisted Lys treatment had the highest solubility, reaching 88.19%, 92.98%, and 91.73% at 0, 1, and 3 days, respectively. The result of protein conformational characteristics showed that Lys and/or ultrasound treatment caused the unfolding of the α-helix structure, resulting in the exposure of more hydrophobic amino acids and buried sulfhydryl groups, ultimately enhancing MPs solubility. In summary, ultrasound-assisted Lys treatment altered the structure of MPs, resulting in the enhancement of the water-holding capacity and tenderness of the pork. PRACTICAL APPLICATION: This study showed that ultrasound-assisted L-lysine (Lys) treatment could enhance the water-holding capacity and tenderness of pork during postmortem aging. The results might provide a reference for the application of ultrasound-assisted Lys treatment on the improvement of pork meat quality. To facilitate practical applications in production, the development of medium and large-sized ultrasound equipment for conducting small-scale and pilot experiments is crucial for future research.

Investigating the mechanistic impact of pork soft tissue preparation techniques on the classification precision of laser-induced breakdown spectroscopy.

The investigation of the mechanism underlying the impact of biological soft tissue sample preparation methods on laser-induced breakdown spectroscopy (LIBS) signals can enhance the stability of LIBS signals. Our study focused on four specific preparation methods applied to pork samples: rapid freezing, fresh slicing, drying, and pressing. The influence of various preparation techniques on the signal-to-noise ratio and fluctuation of Ca, Na, Mg, and CN bands within the sample spectra was assessed. The signal-to-noise ratios for samples that were dried and pressed notably improved. And the pressing method effectively mitigated the uneven distribution of pork tissue components, displaying superior spectral line stability. To explain this phenomenon, we used the Saha-Boltzmann diagram to estimate the plasma temperature. Remarkably, there was a significant reduction in plasma temperature fluctuations across four pressed samples, with a standard deviation of 108.53. Furthermore, we undertook a classification analysis employing support vector machine models to corroborate the generalization efficacy of the sample preparation technique. Dried and pressed samples demonstrated notably higher classification accuracy, precision, and recall (all >93%) compared to frozen and fresh samples, where these metrics remained below 86%. The performance of the SVM model was ultimately evaluated using Receiver Operating Characteristic (ROC) curves and the Area Under the Curve (AUC). The AUC for the frozen, fresh, dried, and pressed samples was 0.854, 0.907, 0.989, and 0.996, respectively. The findings revealed that the pressing method exhibited superior performance, followed by drying, fresh slicing, and freezing, in descending order of effectiveness.

Salmonella in Chicken and Pork Meat as a Likely Major Contributor to Foodborne Illness in Peru.

Nontyphoidal Salmonella is one of the major causes of self-limiting diarrheal disease and the most common foodborne pathogen worldwide. It is an important contributor to the burden of foodborne illness in South America, including Peru, where chicken and pork are important vehicles for Salmonella infection. Salmonella infections are underreported, particularly in low- and middle-income countries where concerted action tackling Salmonella along the chicken and pork chains, from primary production to retail, is urgently needed. To support and inform the implementation of new strategies to reduce Salmonella contamination of chicken and pork, this study describes the frequency and distribution of foodborne outbreaks attributed to Salmonella in Peru and evaluates the level of Salmonella in chicken and pork meat sold in markets of three regions of Peru. To that end, we analyzed historical reports of foodborne outbreaks, levels of Salmonella in chicken and pork sold in markets, and the number of mesophiles in the collected meat samples. As a result, the microbiological analysis reveals a widespread contamination of chicken (77.1%) and pork (26.8%) with Salmonella. It also pinpoints Salmonella as the causative agent in nearly half of the outbreaks (47.0%) where the potential origin is identified over a 11-year period with chicken, mayonnaise, and pork being the most likely food vehicles. These results suggest that Salmonella is a major contributor to foodborne illness in Peru and that the monitoring of mesophiles could be a good strategy for surveillance, generating data to support source attribution studies and ultimately evidence-informed policies.

Centralized industrialization of pork in Europe and America contributes to the global spread of Salmonella enterica.

Salmonella enterica causes severe food-borne infections through contamination of the food supply chain. Its evolution has been associated with human activities, especially animal husbandry. Advances in intensive farming and global transportation have substantially reshaped the pig industry, but their impact on the evolution of associated zoonotic pathogens such as S. enterica remains unresolved. Here we investigated the population fluctuation, accumulation of antimicrobial resistance genes and international serovar Choleraesuis transmission of nine pig-enriched S. enterica populations comprising more than 9,000 genomes. Most changes were found to be attributable to the developments of the modern pig industry. All pig-enriched salmonellae experienced host transfers in pigs and/or population expansions over the past century, with pigs and pork having become the main sources of S. enterica transmissions to other hosts. Overall, our analysis revealed strong associations between the transmission of pig-enriched salmonellae and the global pork trade.

In vitro digestion mimicking conditions in adults and elderly reveals digestive characteristics of pork from different cooking ways.

This study aimed to investigate the impact of three cooking ways (sous vide (SV), frying (FR) and roasting (RO)) on pork protein digestion characteristics under conditions simulating healthy adult (control, C) and elderly individuals with achlorhydria (EA). Changes in degree of hydrolysis (DH), SDS-PAGE profiles, zeta potential, particle size and secondary structure during digestion were evaluated. Our results revealed the EA condition markedly affected the protein digestion process of pork with different cooking ways. The DH values of SV (25.62%), FR (21.38%) and RO (19.40%) under the EA condition were significantly lower than those of under the control condition (38.32%, 33.00% and 30.86%, respectively). Moreover, differences were also observed among three cooking ways under the EA condition. For a given cooking way, the differences between control and EA conditions gradually diminished from the gastric to the intestinal phase. Under a certain digestion condition, SV maintained the highest degree of digestion throughout the process, particularly under the EA condition. Therefore, we conclude that pork cooked by sous vide is more recommendable for the elderly considering protein digestibility.

Two Debaryomyces hansenii strains as starter cultures for improving the nutritional and sensory quality of dry-cured pork belly.

Dry-cured meat products are gaining attention owing to their distinctive sensory characteristics and health benefits. In this study, two Debaryomyces hansenii strains were investigated for their potential as starter cultures for dry-cured pork belly products. After preliminary screening, these D. hansenii strains, namely, S20 and S26, both exhibiting with excellent aroma-producing capacity in a dry-cured meat model, were selected as single-strain starter cultures. For comparison, a non-inoculated control was also evaluated. In S20- and S26-inoculated pork belly, yeast dominated the microbiota and improved microbiological safety by suppressing Enterobacteriaceae growth. Compared with the non-inoculated control, the inoculated pork belly yielded higher hardness and redness (a*) values. Starter culture inoculation accelerated proteolysis in pork belly, improving the content of total free amino acids (TFFAs) and several essential free amino acids (Thr, Val, Met, Ile, Leu, and Phe) at the end of processing. Moreover, the inoculated samples exhibited higher levels of fat oxidation-derived aldehydes as well as esters, acids, alcohols and other compounds than the non-inoculated control at the end of the 95-day ripening period. Overall, these findings provide new insights into the application of D. hansenii isolated from dry-cured ham to dry-cured pork belly.

Occurrence of ochratoxin A in Sichuan bacon from different geographical regions and characterization and biocontrol of ochratoxigenic Aspergillus westerdijkiae strain 21G2-1A.

Sichuan bacon represents the most prevalent dry-cured meat product across Southwest China, but it is vulnerable to fungal spoilage. In the present study, a total of 47 Sichuan bacons were obtained from different regions of the Sichuan Province and analyzed for the presence of ochratoxin A (OTA), yielding a positive rate of 23.4 % (11/47). All the observed OTA concentrations exceeded the maximum admissible dose in meat products (1 µg/kg) established by some EU countries, with the highest OTA concentration being 250.75 µg/kg, which raises a food safety concern and reveals the need for a standardized scientific processing protocol. Then, an OTA-producing fungus named 21G2-1A was isolated from positive samples and found to be Aspergillus westerdijkiae. Further characterization suggested a positive correlation between fungal growth and OTA production. The optimal temperature for the former was 25 °C, while it was 20 °C for the latter. Although the A. westerdijkiae strain 21G2-1A demonstrated greater mycelium growth in the presence of NaCl, OTA production was significantly dismissed when the salinity was greater than 5 %. Four lactic acid bacteria (LAB) were screened out as antagonists against the ochratoxigenic fungus. In vitro evaluation of the antagonists revealed that live cells inhibited fungal growth, and adsorption also contributed to OTA removal at different levels. This study sheds some light on OTA control in Sichuan bacon through a biological approach.

Characterization of Flavor Profile of Sauced Pork from Different Regions of China Based on E-Nose, E-Tongue and Gas Chromatography-Ion Mobility Spectroscopy.

This study aimed to investigate the volatile flavor compounds and tastes of six kinds of sauced pork from the southwest and eastern coastal areas of China using gas chromatography-ion mobility spectroscopy (GC-IMS) combined with an electronic nose (E-nose) and electronic tongue (E-tongue). The results showed that the combined use of the E-nose and E-tongue could effectively identify different kinds of sauced pork. A total of 52 volatile flavor compounds were identified, with aldehydes being the main flavor compounds in sauced pork. The relative odor activity value (ROAV) showed that seven key volatile compounds, including 2-methylbutanal, 2-ethyl-3, 5-dimethylpyrazine, 3-octanone, ethyl 3-methylbutanoate, dimethyl disulfide, 2,3-butanedione, and heptane, contributed the most to the flavor of sauced pork (ROAV ≥1). Multivariate data analysis showed that 13 volatile compounds with the variable importance in projection (VIP) values > 1 could be used as flavor markers to distinguish six kinds of sauced pork. Pearson correlation analysis revealed a significant link between the E-nose sensor and alcohols, aldehydes, terpenes, esters, and hetero-cycle compounds. The results of the current study provide insights into the volatile flavor compounds and tastes of sauced pork. Additionally, intelligent sensory technologies can be a promising tool for discriminating different types of sauced pork.

A novel QTL region for pH and meat color in Duroc pigs.

One of the most important processes that occur during the transformation of muscle to meat is the pH decline as a consequence of the post-mortem metabolism of muscle tissue. Abnormal pH declines lead to pork defects such as pale, soft, and exudative meat. There is genetic variance for ultimate pH and the role of some genes on this phenotype is well established. After conducting a genome-wide association study on ultimate pH using 526 purebred Duroc pigs, we identified associated regions on Sus scrofa chromosomes (SSC) 3, 8, and 15. Functional candidate genes in these regions included PRKAG3 and PHKG1. The SSC8 region, at 71.6 Mb, was novel and, although no candidate causative gene could be identified, it may have regulatory effects. Subsequent analysis on 828 pigs from the same population confirmed the impact of the three associated regions on pH and meat color. We detected no interaction between the three regions. Further investigations are necessary to unravel the functional significance of the novel genomic region at SSC8. These variants could be used as markers in marker-assisted selection for improving meat quality.

Rapid and non-destructive microbial quality prediction of fresh pork stored under modified atmospheres by using selected-ion flow-tube mass spectrometry and machine learning.

Volatile organic compounds (VOCs) indicative of pork microbial spoilage can be quantified rapidly at trace levels using selected-ion flow-tube mass spectrometry (SIFT-MS). Packaging atmosphere is one of the factors influencing VOC production patterns during storage. On this basis, machine learning would help to process complex volatolomic data and predict pork microbial quality efficiently. This study focused on (1) investigating model generalizability based on different nested cross-validation settings, and (2) comparing the predictive power and feature importance of nine algorithms, including Artificial Neural Network (ANN), k-Nearest Neighbors, Support Vector Regression, Decision Tree, Partial Least Squares Regression, and four ensemble learning models. The datasets used contain 37 VOCs' concentrations (input) and total plate counts (TPC, output) of 350 pork samples with different storage times, including 225 pork loin samples stored under three high-O2 and three low-O2 conditions, and 125 commercially packaged products. An appropriate choice of cross-validation strategies resulted in trustworthy and relevant predictions. When trained on all possible selections of two high-O2 and two low-O2 conditions, ANNs produced satisfactory TPC predictions of unseen test scenarios (one high-O2 condition, one low-O2 condition, and the commercial products). ANN-based bagging outperformed other employed models, when TPC exceeded ca. 6 log CFU/g. VOCs including benzaldehyde, 3-methyl-1-butanol, ethanol and methyl mercaptan were identified with high feature importance. This elaborated case study illustrates great prospects of real-time detection techniques and machine learning in meat quality prediction. Further investigations on handling low VOC levels would enhance the model performance and decision making in commercial meat quality control.

Synergistic stabilization of garlic essential oil nanoemulsions by carboxymethyl chitosan/Tween 80 and application for coating preservation of chilled fresh pork.

Garlic essential oil (GEO) is a potential natural antioxidant and antimicrobial agent for food preservation, but its intrinsic low water-solubility, high volatility and poor stability severely limit its application and promotion. In this work, we investigated the synergistic stabilization of the GEO-in-water nanoemulsion using carboxymethyl chitosan (CCS) and Tween 80 (TW 80). Additionally, the nanoemulsion was fabricated through high-pressure microfluidization and utilized for the coating-mediated preservation of chilled pork. The garlic essential oil nanoemulsion (GEON) with 3.0 % CCS and 3.0 % TW 80 exhibited more homogeneous droplet size (around 150 nm) and narrower size distribution, while maintained long-term stability with no significant change in size during 30 d storage. Compared with free GEO, the GEONs exhibited a higher scavenging capacity to DPPH and ABTS free radicals as well as higher inhibitory effects against Escherichia coli and Staphylococcus aureus, suggesting that the encapsulation of GEO in nanoemulsion considerably improved its antioxidant and antibacterial activities. Furthermore, the results of coating preservation experiments showed that the GEON coating effectively expanded the shelf-life of chilled fresh pork for approximately one week. Altogether, this study would guide the development of GEO-loaded nanoemulsions, and promote GEON as a promising alternative for coating preservation of chilled fresh meat.