Evaluation of low volume sampling devices for a pharmacodynamic biomarker analysis: Challenges and solutions.

Low volume sampling technologies have gained popularity as they are minimally invasive, reduce patient burden, enhance population diversity, and have the potential to facilitate decentralized clinical trials. Herein, we validated a Gyrolab assay to measure soluble Mucosal Addressin Cell Adhesion Molecule 1 (sMAdCAM-1) in dried blood samples collected using two low volume sampling devices, Mitra and Tasso-M20. This validated assay was implemented in a proof-of-concept study to compare three low volume sampling devices (Mitra, Tasso-M20 and TassoOne Plus) with serum collected via venipuncture from healthy volunteers receiving etrolizumab. We observed significantly higher concentration of sMAdCAM-1 in dried blood samples collected using Mitra and Tasso-M20 compared to serum in some paired samples, which was attributed to interference from the dried blood extraction buffer. To mitigate this interference, samples required substantial dilution into the appropriate buffer, which negatively impacted the detectability of sMAdCAM-1 with the Gyrolab assay. By employing the Quanterix single molecule array (Simoa), known for its superior assay sensitivity, the interference was minimized in the diluted samples. Both liquid blood collected in TassoOne Plus and dried blood collected using Mitra and Tasso-M20 demonstrated great concordance with serum for sMAdCAM-1 measurement. However, a bias was observed in Mitra dried blood samples, presumably due to the different sample collection sites in comparison with venipuncture and Tasso devices. Our study highlights the potential of low volume sampling technologies for biomarker analysis, and underscores the importance of understanding the challenges and limitations of these technologies before integrating them into clinical studies.

Patient-centric microsampling for abrocitinib pharmacokinetics: multiple-analytes assay bridging using Tasso device.

Aim: The feasibility of using Tasso devices (Tasso-SST® and Tasso+) collecting capillary blood samples for measuring abrocitinib and its metabolites were evaluated, and assay concordance established between capillary and venous blood samplings.Methods: Capillary serum and venous plasma concentrations were measured using their respective qualified and validated assays. Concentration and exposure comparisons were conducted for abrocitinib and its metabolites (M1, M2 and M4) to establish assay concordance.Results: The correlation coefficient between capillary serum and venous plasma concentrations were >0.98 for all four analytes from three separate assays, and PK parameters (AUClast and Cmax) were compared and met bioequivalence criteria.Conclusion: These results demonstrate the feasibility of patient-centric microsampling device, such as Tasso, in future abrocitinib pediatric study.

[Box: see text].

Comparison of sample materials for S100b analysis.

Head injury is a potentially lethal and frequently occurring condition in the emergency department (ED). Reliable and fast diagnosis is important both for patients and flow in the ED. Circulating S100B is used to rule out the need for head computer tomography in low-risk patients with mild head injury. The flow of these patients through the ED would benefit from shorter turn-around time. Standard serum clotting tubes require 30-60 min clotting time, followed by an analysis time of 45 min. Here, we evaluated the performance of two alternative blood collection tubes; a rapid serum tube (RST) with a recommend clotting time of 5 min and a hirudin tube (HIR) for instant anticoagulation. S100B measurement was performed on paired blood samples from 221 subjects using a Roche Cobas 602 analyser. The performances of the alternative tubes were evaluated by method comparison to the standard serum clotting tube, repeatability and agreement of results obtained from alternative tubes compared with the standard clotting tube. Both alternative tubes had a minor positive bias (RST = 0.011 µg/L, HIR = 0.008 µg/L). The repeatability was 2% for RST and 10% for HIR, while being 4% for the standard clotting tube. In the agreement analysis, the positive and negative predictive values for RST were 62% and 100% while being 73% and 99% for HIR respectively. Our study suggests that RST is a feasible alternative to reduce laboratory turn-around time in S100b analysis.

Proof-of-concept study: Remote capillary blood collection for hCG analysis in early pregnancy.

INTRODUCTION: Capillary blood collection, a technique traditionally used in diabetes care, shows promise for many applications including pregnancy monitoring. Serial measurement of serum human Chorionic Gonadotrophin (hCG) is frequently necessary for managing early pregnancy, including molar pregnancy, requiring multiple visits to a maternity hospital for blood collection by venepuncture. This proof-of-concept study aimed to assess the clinical performance and user acceptability of capillary blood samples collected remotely, as an alternative to venous blood for hCG measurement. METHODS: Women attending the early pregnancy unit who required serum hCG measurement, were invited to participate. Following informed written consent, participants were shown how to collect capillary blood samples using the Mini-Collect® collection device. Matched venous and capillary blood samples were collected in clinic for hCG comparison purposes. Participants were also supplied with a home collection kit in a prepaid return envelope. They were asked to perform a finger-prick blood collection at home using the instructions provided and to return the capillary blood sample by post within 24 h of collection, along with a completed user-satisfaction questionnaire. Statistical analysis was performed using Analyse-it® software. RESULTS: The study enrolled 71 participants and over a third of these women collected a capillary blood sample at home. The median age of participants was 33 years (range 29-36). Passing-Bablok linear regression (y = -0.037 + 1.04x) and Spearman correlation (r = 0.999, p < 0.0001), demonstrated good agreement and strong correlation between venous and capillary samples, over a broad range of hCG values (1.2 to 224,0000 IU/L). The majority of capillary samples collected remotely (39%, 27/69) had sufficient blood volume for analysis (74%, 20/27). Respondents (77%, 18/25) found the collection device easy to use and expressed willingness to use a future service if available (80%, 20/25) CONCLUSION: The study demonstrated excellent agreement between the hCG results obtained from both collection methods, suggesting that capillary blood can serve as a reliable alternative for venous hCG measurement, particularly in clinical settings requiring frequent hCG monitoring. Feedback from the study questionnaire indicates a preference for this type of follow-up among women, indicating potential improvements in compliance for blood based diagnostic tests.

Analysis of arterial blood gas values when discarding different volumes of blood samples in an arterial heparin blood collector during thoracoscopic surgery.

BACKGROUND: Arterial blood gas analysis (ABGA) plays a vital role in emergency and intensive care, which is affected by many factors, such as different instrumentation, temperature, and testing time. However, there are still no relevant reports on the difference in discarding different blood volumes on ABGA values. METHODS: We enrolled 54 patients who underwent thoracoscopic surgery and analysed differences in blood gas analysis results when different blood volumes were discarded from the front line of the arterial heparin blood collector. A paired t test was used to compare the results of the same patient with different volumes of blood discarded from the samples. The difference was corrected by Bonferroni correction. RESULTS: Our results demonstrated that the PaO2, PaCO2, and THbc were more stable in the 4th ml (PaO2 = 231.3600 ± 68.4878 mmHg, PaCO2 = 41.9232 ± 7.4490 mmHg) and 5th ml (PaO2 = 223.7600 ± 12.9895 mmHg, PaCO2 = 42.5679 ± 7.6410 mmHg) blood sample than in the 3rd ml (PaO2 = 234.1000 ± 99.7570 mmHg, PaCO2 = 40.6179 ± 7.2040 mmHg). CONCLUSION: It may be more appropriate to discard the first 3 ml of blood sample in the analysis of blood gas results without wasting blood samples.

Comparison of laser and traditional lancing devices for capillary blood sampling in patients with diabetes mellitus and high bleeding risk.

PURPOSE: Despite the importance of self-monitoring blood glucose (SMBG) for management of diabetes mellitus (DM), frequent blood sampling is discouraged by bleeding risk due to dual-antiplatelet agent therapy (DAPT) or thrombocytopenia. METHODS: We compared the bleeding time (BT) of sampling by using a laser-lancing-device (LMT-1000) and a conventional lancet in patients with DM and thrombocytopenia or patients undergoing DAPT. BT was measured using the Duke method, and pain and satisfaction scores were assessed using numeric rating scale (NRS) and visual analog scale (VAS). The consistency in the values of glucose and glycated-hemoglobin (HbA1c) sampled using the LMT-1000 or lancet were compared. RESULTS: The BT of sampling with the LMT-1000 was shorter than that with the lancet in patients with thrombocytopenia (60s vs. 85s, P = 0.024). The NRS was lower and the VAS was higher in laser-applied-sampling than lancet-applied sampling in the DAPT-user group (NRS: 1 vs. 2, P = 0.010; VAS: 7 vs. 6, P = 0.003), whereas the group with thrombocytopenia only showed improvement in the VAS score (8 vs. 7, P = 0.049). Glucose and HbA1c sampled by the LMT-1000 and lancet were significantly correlated in both the DAPT-user and the thrombocytopenia groups. CONCLUSION: The LMT-1000 can promote SMBG by shortening BT in subject with thrombocytopenia and by increasing satisfaction score, as well as by showing reliable glucose and HbA1c value.

Using an Innovative Method for Self-Collection of Capillary Blood for HIV and Syphilis Testing Among Men Who Have Sex With Men Who Use Pre-exposure Prophylaxis in the Netherlands; Limburg4zero.

BACKGROUND: Home-based sampling could create accessible testing opportunities for men who have sex with men (MSM) who use pre-exposure prophylaxis (PrEP). Blood collection is required for the most reliable laboratory results for HIV and syphilis testing. An innovative blood collection method (Tasso+) creates a vacuum and semi-automatically collects larger volumes of blood from the upper arm. This study aimed to assess acceptability and feasibility of this device among PrEP-using MSM and the performance of blood collection. METHODS: Between August 2022 and January 2023, 47 MSM were recruited during their routine PrEP consultations at a Dutch Centre for Sexual Health. Participants tested the method directly after consultation, and an online questionnaire determined acceptability and feasibility. Blood and residual serum volumes were measured after sampling and after HIV and syphilis testing. RESULTS: Of the participants, 87% had a positive attitude toward use of the device, and 77% would use it again for self-sampling at home. Participants rated the use of the blood collection device as easy (96%). On average, 536 µL whole blood (244 µL serum) was collected. All samples were tested for HIV and syphilis, and most samples had sufficient blood for routine HIV (91%) and syphilis testing (89%). Most samples (85%) had 220 µL residual blood, sufficient for further testing (e.g., confirmation). CONCLUSIONS: Blood self-sampling with a method that creates a vacuum from the upper arm is highly acceptable by users and performs well in blood collection for multiple tests. This method has promising potential for use in home-based sexual health care for PrEP-using MSM.

Minimally Invasive Blood Collection for an Mpox Serosurvey among People Experiencing Homelessness.

BACKGROUND: People experiencing homelessness (PEH) are underrepresented in public health and clinical research. Study methods that can improve participation by this group are needed. METHODS: In late 2022, the Centers for Disease Control and Prevention conducted an mpox serological survey using venipuncture among PEH in San Francisco, California. Blood collection by a minimally invasive device was offered if venipuncture was not possible or preferred. Participants who had a successful blood draw using the device were asked about device acceptability. RESULTS: Of the 209 successful blood collections, 137 (66%) were among participants who underwent venipuncture and 72 (34%) were among participants who used the device. Use of the device increased overall blood collection participation by 53%. Participants reported high acceptability and preference for the device over venipuncture. CONCLUSIONS: Minimally invasive blood collection devices may increase participation and representation of PEH in serosurveys.

Comparison of a two-step Tempus600 hub solution single-tube vs. container-based, one-step pneumatic transport system.

OBJECTIVES: Efficient and timely transportation of clinical samples is pivotal to ensure accurate diagnoses and effective patient care. During the transportation process, preservation of sample integrity is crucial to avoid pre-analytical aberrations on laboratory results. Here, we present a comparative analysis between a two-step Tempus600 hub solution single-tube and a one-step, container-based pneumatic transport system (PTS) from Airco, for the in-house transportation of blood samples. METHODS: Ten blood samples from healthy volunteers were split in 10 mL collection tubes filled at full or half capacity for transportation with the two PTS (about 250 m). To compare the impact of transportation, markers of hemolysis such as lactate dehydrogenase (LDH), potassium (K+), and the hemolysis index (HI), were determined. Additionally, differences in HI in routine samples and repeated transportation was investigated. To assess and compare the mechanistic impact profiles, we recorded the acceleration profiles of the two PTS using a shock data logger. RESULTS: Transportation using the Tempus600 hub solution resulted in 49 and 46 % higher HI with samples filled to total or half capacity, respectively. Routine samples transported with the Tempus600 hub solution showed a higher median HI by 23 and 33 %. Additionally, shock logger analysis showed an elevated amount of shocks (6.5 fold) and shock intensities (1.8 fold). CONCLUSIONS: The Tempus600 hub solution caused an increased number of unreportable LDH or K+ results based on the hemolysis index. However, it was only statistically significant for LDH (p<0.01 and p<0.08) - while the comparisons for K+ were not statistically significant (p<0.28 and p<0.56).

End-user verification results of two serum separator tubes for clinical chemistry analytes according to CLSI GP34-A and CLSI GP41-A6.

Tube manufacturers use different composition of gels and blood clot activator formulations in serum tube production. Our aim was to investigate the within-tube (repeatability) and between-tube variation, concordance between comparison results of BD and VacuSEL tubes. Blood samples were collected from control subjects (n = 20) and patients (n = 30) in accordance with the CLSI GP41-A6 and CLSI GP34-A guidelines. Twenty-three clinical chemistry parameters were analysed via Roche Cobas C702 Chemistry Analyzer on T0 (0 hour) and T24 (24 hour). Mean differences % were compared with Wilcoxon matched pair test. Clinical significance was evaluated based on desirable bias according to total allowable error (TEa). VacuSEL tubes demonstrated acceptable performance for the results of 20 parameters with regards to desirable bias % limits. Lactate dehydrogenase (LD) [mean difference % (%95 confidence intervals (CI) values of BD and VacuSEL tubes at T0 [6.41% (4.80-8.01%)]; sodium (Na) and total protein (TP) at T24 [-0.27% (-0.46 to -0.07%) and -1.39% (-1.87 to -0.91), respectively] were over the desirable bias limits (LD: 4.3%, Na: 0.23% and TP: 1.36%, respectively) but not exceeding total biological variation CV % [Na: 0.5 (0.0-1.0) % and TP: 2.6 (2.3-2.7) %). %95 confidence intervals (CI) of T0 LD values overlap with within-subject biological variation % (CI) limits (LD: 5.2 (4.9-5.4) %). The differences between two tubes were not medically significant and necessarily conclusive. VacuSEL serum tubes presented comparable performance with BD serum tubes.

Feasibility, acceptability, and safety of a novel device for self-collecting capillary blood samples in clinical trials in the context of the pandemic and beyond.

BACKGROUND: Home blood self-collection devices can enable remote monitoring, but their implementation requires validation. Our objectives were to explore (i) the impact of sampling sites and topical analgesia on capillary blood volume and pain perception and (ii) the safety, acceptability, and failure of capillary self-collection among adults and children using the Tasso-SST device. METHODS: We conducted a two-phase study. The investigational phase consisted of two on-site cross-sectional studies in healthy adult participants (≥ 12 years) and children (1-17 years) with their accompanying parent. Adults received 4 capillary samplings, where puncture sites and topical analgesia were randomized in a factorial design, and a venipuncture; children (and one parent) had one capillary sampling. The two co-primary outcomes were blood volume and pain. The implementation phase was conducted in two multicentre trials in participants choosing remote visits; blood volume, collection failure, adverse events, and satisfaction were documented. RESULTS: In the investigational phase, 90 participants and 9 children with 7 parents were enrolled; 15 adults and 2 preschoolers participated in the implementation phase. In the adult investigational study, the device collected a median (25%, 75%) of 450 (250, 550) µl of blood with no significant difference between the puncture site, topical analgesia, and its interaction. Using topical analgesia reduced pain perception by 0.61 (95% CI: 0.97, 0.24; P <0.01) points on the 11-point scale; the pain reduction varied by puncture site, with the lower back showing the most significant decrease. Overall, combining all studies and phases, the median volume collected was 425 (250, 500) µl, and the device failure rate was 4.4%; minor adverse effects were reported in 8.9% of the participants, all were willing to use the device again. CONCLUSION: Capillary blood self-collection, yielding slightly less than 500 µl, proves to be a safe and relatively painless method for adults and children, with high satisfaction and low failure rates. The puncture site and topical analgesia do not affect blood volume, but topical analgesia on the lower back could reduce pain.

Effects of automatic heel lancet on invasiveness in neonates: A systematic review and meta-analysis.

AIM: We conducted a meta-analysis comparing the invasiveness of automatic lancet devices, which can collect adequate amount of blood at shallow puncture depths, with conventional manual lance devices (lancet or needle) to statistically identify less invasive instruments for neonatal heel lance. METHODS: We searched PubMed, Cochrane Central Register of Controlled Trials (CENTRAL), CINAHL, and Ichushi databases for studies comparing the invasiveness between automatic lancet and manual lancet or needle in term and preterm neonates in neonatal intensive care unit. RESULTS: This review included 9 out of 449 searched articles, with 673 neonates. Automatic lancet had significantly lower pain scores (standardised mean difference: -2.0, 95% confidence interval: -3.3 to -0.7), heart rate (mean difference: -8.0, 95% confidence interval: -13.8 to -2.1), cry duration (mean difference: -21.5, 95% confidence interval: -32.5 to -10.4), number of punctures (mean difference: -0.6, 95% confidence interval: -1.1 to -0.2), and duration of procedures (mean difference: -37.7, 95% confidence interval: -75.2 to -0.2) than manual lancet or needle. Furthermore, peripheral oxygen saturation was significantly higher in automatic lancet than in manual lancet or needle (mean difference: 4.5, 95% confidence interval: 0.5-8.5). CONCLUSION: Automatic heel lancet devices were less invasive than manual heel lance devices (lancet or needle).

Evaluation of the Tasso+ blood self-collection device for quantitation of plasma cytomegalovirus (CMV) DNAemia in adult solid organ transplant recipients (SOTr).

Quantitative monitoring of cytomegalovirus (CMV) DNAemia in venous blood is standard in solid organ transplant recipients (SOTr) but is limited by the need for phlebotomy facilities and personnel. The aim of the study was to evaluate the Tasso+ capillary blood (CB) self-collection device for quantitation of plasma CMV DNAemia. Thirty adult SOTr with suspected CMV DNAemia were enrolled to have a supervised Tasso+ CB sample collection within 24 h of a venous sample. CMV DNA was quantitated in paired samples by using the Abbott M2000 Real-Time qPCR instrument. The participants were provided with a study-specific survey that measured patient acceptability of the Tasso+ device compared with venipuncture. A Tasso + CB sample was successfully collected in 28/30 (93%) patients, and 44 paired samples were analyzed. Concordance for detection of CMV DNAemia above the limit of detection (LOD) was 91% (42/44), and the Tasso + CB sample was estimated to be 95% sensitive at a viral load (VL) of 308 IU/mL. Among samples with a quantifiable DNAemia result with both methods (N = 31), there was excellent correlation between methods (Spearman R2 = 0.99). The difference in CMV VL between venous and Tasso+ CB samples was not dependent on time (P > 0.1). Of 12 who completed the survey, 11 (92%) expressed a preference for Tasso+ CB collection over venipuncture. Collection of CB with the Tasso+ device is feasible, patient-acceptable, and yields generally comparable CMV DNAemia load to standard venous samples, but with lower sensitivity. Future studies to optimize and evaluate this methodology for patient self-collected samples are warranted. IMPORTANCE: We evaluate an FDA-cleared blood self-collection device (Tasso+) and demonstrate that it is patient-acceptable and yields a liquid blood sample with quantitative CMV DNAemia results comparable to those of standard venipuncture samples. This opens up possibilities for self-blood collection to monitor for CMV and potentially other viruses in transplant and other at-risk populations.

A Bioinspired and Cost-Effective Device for Minimally Invasive Blood Sampling.

Conventional venipuncture is invasive and challenging in low and middle-income countries. Conversely, point-of-care devices paired with fingersticks, although less invasive, suffer from high variability and low blood volume collection. Recently approved microsampling devices address some of these issues but remain cost-prohibitive for resource-limited settings. In this work, a cost-effective microsampling device is described for the collection of liquid blood with minimal invasiveness and sufficient volume retrieval for laboratory analyses or immediate point-of-care testing. Inspired by the anatomy of sanguivorous leeches, the single-use device features a storage compartment for blood collection and a microneedle patch hidden within a suction cup. Finite Element Method simulations, corroborated by mechanical analyses, guide the material selection for device fabrication and design optimization. In piglets, the device successfully collects ≈195 µL of blood with minimal invasiveness. Additionally, a tailor-made lid and adapter enable safe fluid transportation and integration with commercially available point-of-care systems for on-site analyses, respectively. Taken together, the proposed platform holds significant promise for enhancing healthcare in the pediatric population by improving patient compliance and reducing the risk of needlestick injuries through concealed microneedles. Most importantly, given its cost-effective fabrication, the open-source microsampling device may have a meaningful impact in resource-limited healthcare settings.

Plasma Glucose Concentrations in Different Sampling Tubes Measured on Different Glucose Analysers.

INTRODUCTION: The German Diabetes Association recommends using sampling tubes with citrate and fluoride additives to diagnose diabetes by oral glucose tolerance test to inhibit glycolysis. The effect of different tubes on measurement results was assessed. MATERIALS AND METHODS: In a first study, an oral glucose tolerance test was performed on 41 participants without anamnestically known diabetes. Venous blood was sampled in two different tubes with citrate/fluoride additives from different manufacturers and one with only lithium-heparin additive. A second study with 42 participants was performed to verify the initial results with an adapted design, in which a third tube with citrate buffer was used, and glucose measurements were performed on two additional devices of another analyser model. Samples were centrifuged either immediately (<5 min incubation time) or after 20 min or 4 h. All glucose measurements were performed in plasma. Glucose concentrations in lithium-heparin tubes with<5 min incubation time served as baseline concentrations. RESULTS: In the first study, glucose concentrations in one of the citrate/fluoride tubes were similar to the baseline. In the other citrate/fluoride tube, markedly lower concentrations (approximately - 5 mg/dL (- 0.28 mmol/L)) were measured. This was reproduced in the verification study for the same analyser, but not with the other analyser model. Lithium-heparin tubes centrifuged after 20 and 240 min showed systematically lower glucose concentrations. CONCLUSIONS: The results confirm that glycolysis can be effectively inhibited in citrate/fluoride-containing sampling tubes. However, glucose measurement results of one analyser showed a relevant negative bias in tubes containing liquid citrate buffer.

Measuring the performance of an artificial intelligence-based robot that classifies blood tubes and performs quality control in terms of preanalytical errors: A preliminary study.

OBJECTIVES: Artificial intelligence-based robotic systems are increasingly used in medical laboratories. This study aimed to test the performance of KANKA (Labenko), a stand-alone, artificial intelligence-based robot that performs sorting and preanalytical quality control of blood tubes. METHODS: KANKA is designed to perform preanalytical quality control with respect to error control and preanalytical sorting of blood tubes. To detect sorting errors and preanalytical inappropriateness within the routine work of the laboratory, a total of 1000 blood tubes were presented to the KANKA robot in 7 scenarios. These scenarios encompassed various days and runs, with 5 repetitions each, resulting in a total of 5000 instances of sorting and detection of preanalytical errors. As the gold standard, 2 experts working in the same laboratory identified and recorded the correct sorting and preanalytical errors. The success rate of KANKA was calculated for both the accurate tubes and those tubes with inappropriate identification. RESULTS: KANKA achieved an overall accuracy rate of 99.98% and 100% in detecting tubes with preanalytical errors. It was found that KANKA can perform the control and sorting of 311 blood tubes per hour in terms of preanalytical errors. CONCLUSIONS: KANKA categorizes and records problem-free tubes according to laboratory subunits while identifying and classifying tubes with preanalytical inappropriateness into the correct error sections. As a blood acceptance and tube sorting system, KANKA has the potential to save labor and enhance the quality of the preanalytical process.

Novel method for determining when a field-collected donor unit is sufficiently full.

BACKGROUND: Whole blood (WB) collections can occur downrange for immediate administration. An important aspect of these collections is determining when the unit is sufficiently full. This project tested a novel method for determining when a field collection is complete. METHODS: The amount of empty space at the top of WB units, destined to become LTOWB or separated into components, that were collected at blood centers or hospitals was measured by holding a WB unit off the ground and placing the top of a piece of string where the donor tubing entered the bag. The string was marked where it intersected the top of the column of blood in the bag and measured from the top. The WB units were also weighed. RESULTS: A total of 15 different bags, two of which were measured in two different filling volumes, from 15 hospitals or blood centers were measured and weighed. The most commonly used blood bag, Terumo Imuflex SP, had a median string length of 9 mm (range: 2-24 mm) and weighed a median of 565.1 g (range: 524.8-636.7 g). CONCLUSION: Pieces of string can be precut to the appropriate length depending on the type of bag before a mission where field WB collections might be required and a mark placed on the bag before the collection commences to indicate when the unit is full.