Multi-layered structure and physicochemical properties of reconstituted meat-based products from minced fish by physical extrusion: Impact of extrusion strength.

Multi-layered structure of reconstituted meat-based products from minced fish was formed by physical extrusion, followed by an investigation into the impact of extrusion strength on structural and physicochemical properties before and after frying. Under an appropriate pressure (3-9 kPa), the air within minced fish underwent enrichment and rearrangement to form a stratified phase, promoting the formation of multi-layered structure during frying. Conversely, the lower pressure (≤1.5 kPa) was insufficient for phase separation and directional rearrangement, while the higher pressure (≥15 kPa) would cause the stratified phase to flow out of food system. Moreover, by directly increasing water mobility and meat compactness, physical extrusion indirectly caused more water loss and stronger ionic bonds during frying, which was positively correlated with multi-layered structure. However, an excessive pressure caused an increase in random coil and hydrophobic interactions during frying, which was negatively correlated with multi-layered structure. In conclusion, appropriate physical extrusion strength promoted the formation of multi-layered structure.

The effect of ohmic heating conditions and heating modes on gel properties of unwashed pre-rigor common carp (Cyprinus carpio) surimi.

Ohmic heating (OH) at different conditions (voltage: 15, 20, 25 V; frequency: 1, 5, 10 kHz) and one-step water bath (WB) were used to heat wash and unwash surimi prepared from fresh pre-rigor common carp. The optimal heating conditions were established through assessments of gel strength, Texture Profile Analysis (TPA), water-holding capacity (WHC), whiteness, and sensory evaluation. Then, the impact of heating modes on gelation properties of unwashed surimi based on the optimal heating conditions was investigated. The study findings indicated a significant enhancement in gel properties compared to WB. Unwashed surimi gel properties showed improvement when derived from freshly caught raw fish and subjected to OH treatment. Moreover, variations in frequencies and voltages were observed to influence the heating rate. Optimal gel quality was achieved at 10 kHz 20 V (10 V/cm), facilitating swift progression through the gel deterioration stage, inhibition of protein hydrolyzing enzymes activity, and establishment of a stable gel network. Continuing to increase the heating rate would disrupt its network structure, resulting in diminished gel strength and WHC. The best quality of unwashed surimi gel was achieved by heating to 40°C for 30 min, followed by heating to 90°C for another 30 min (40°C 30 min + 90°C 30 min) under 10 kHz 20 V. The gel strength increased when held for 1 h at 40°C. For optimal heating efficiency, the heating mode of 40°C 30 min + 90°C 30 min is recommended to prepare unwashed surimi gel. PRACTICAL APPLICATION: Ohmic heating, as a rapid food heat treatment method, can both increase the heating rate and improve the gelation properties of freshwater surimi. There is a wide range of potential applications for the heat treatment of the surimi.

Metaproteomic Analysis of Microbial Communities Affecting Fishery Products.

Fishery products are one of the main human nutritional sources, and due to the consumption increase, the quality of the derived products may be modified, during catching, technological processing, and storage. Detection and identification of pathogenic and spoilage microorganisms in fishery products is needed because the first may be involved in human diseases, while the second is responsible of significant economic losses. In this sense, liquid chromatography-electrospray ionization-tandem mass spectrometry (LC-ESI-MS/MS) method and computational analysis of MS data are useful tools for characterizing and identifying different microorganisms and to develop promising strategies for food science investigations. Moreover, in the past decade, metaproteomic methodologies have progressed for the study of microorganisms isolated from their natural samples and independently of the culture restrictions. Metaproteomics enables assessment of proteins and pathways from individual members of the consortium. Metaproteomics can provide a detailed understanding of which organisms occupy specific metabolic niches, how they interact, and how they utilize nutrients, and these insights can be obtained directly from environmental samples.According to that, the sample preparation of the fishery product, the LC-ESI-MS/MS dedicated method, and the MS data analysis were described in the present chapter to obtain the metaproteomic analysis of the respective microbiomes or microbial communities.

Various factors affecting the gel properties of surimi: A review.

As an important aquatic prepared food, surimi products are favored by consumers due to their unique viscoelastic properties and high nutritional value. Gel properties are the main indicators to measure the quality of surimi products. The gelation of surimi mainly involves intramolecular (conformational change) and intermolecular (chemical force) changes. Factors such as processing treatments, raw fish species and exogenous additives affect surimi protein structure, chemical forces and endogenous enzyme activities, which further affect the gel properties of surimi products. This review focuses on the mechanism of surimi heat-induced gel, mainly including protein chain expansion and aggregation through various chemical forces to form a three-dimensional network structure. In addition, the mechanism and application of different factors on the gel properties of surimi were also discussed, providing a reference for the selection of fish species, the control of heating conditions in the gel process of surimi products, the selection of additives and other measures to improve the gel performance.

Modification of myofibrillar protein structural characteristics: Effect of ultrasound-assisted first-stage thermal treatment on unwashed Silver Carp surimi gel.

The hardness properties of unwashed surimi gel are considered as the qualities of gelation defect. This research investigated the effect of ultrasound-assisted first-stage thermal treatment (UATT) on the physicochemical properties of unwashed Silver Carp surimi gel, and the enhancement mechanism. UATT could reduce protein particle size, which significantly reduced from 142.22 µm to 106.70 µm after 30 min of UATT compared with the nature protein. This phenomenon can promote the protein crosslinking, resulting in the hardness of surimi gel increased by 15.08 %. Partially unfolded structure of myofibrillar protein and exposures of tryptophan to water, lead to the increase in the zeta potential absolute value, driven by UATT. The reduced SH group level and the conformational conversion of proteins from random coiling to α-helix and ß-sheet, which was in support of intermolecular interaction and gel network construction. The results are valuable for processing protein gels and other food products.

The impacts of cold plasma on the taste and odor formation of dried silver carp products.

This study investigated non-thermal pretreatment (cold plasma, CP) on the flavor (taste and odor) profiles of dried fish products. CP treatment of 5 min contributed to accumulation of umami nucleotides adenosine 5'-monophosphate (AMP) from 30.96 to 40.82 µg/g and inosine 5'-monophosphate (IMP) from 2009.29 to 2132.23 µg/g, and significant reduction of bitter hypoxanthine ribonucleoside (HxR) and hypoxanthine (Hx), respectively (P < 0.05) in the dried fish products. A noticeable enhancement in sweet glycine (from 429.41 to 490.03 mg/100 g) and umami glutamic acid (from 55.68 to 67.76 mg/100 g) accompanied with the CP treatment (P < 0.05) based on taste activity value (TAV > 1). And the characteristic odor volatiles (nonanal, hexanal and 1-octen-3-ol) were strengthened 2.13-, 2.16- and 2.17- folds, respectively (P < 0.05). The results of equivalent umami concentration and Gibbs free energy calculation, combining with the correlation analysis, indicate that nucleotides and free amino acids synergically enhanced the taste improvement of dried fish products. Moderate lipids oxidation favored the formation of characteristic volatiles. The CP pretreatment offered new strategies for enhancing flavor of dried fish products.

Perilla juice and ginger juice reduced warmed-over flavor (WOF) in surimi gels: Due to the inhibition of the formation of the WOF compounds and the masking of the WOF.

The effects and reasons of perilla juice (PJ) and ginger juice (GJ) on the reduction of "warmed-over flavor" (WOF) in surimi gels were revealed by detecting odor profiles and protein and lipid oxidation degrees of surimi gels, concentrations and odor activity values (OAVs) of WOF compounds. Adding PJ and GJ to surimi gels significantly reduced the WOF and improved the fish fragrance odor, but sodium ascorbate (SA) only weakened the WOF. The (E,E)-2,4-heptadienal's OAVs in the PJ and GJ groups were decreased by >50% compared with the control check (CK) and SA groups. Meanwhile, surimi gels added with PJ and GJ presented lower lipid and protein oxidation degrees. The verification test indicated that PJ and GJ's aroma had a masking effect on the WOF. In conclusion, PJ and GJ reduced the WOF in surimi gels by preventing WOF compounds' production and masking the WOF with their distinct aroma.

Inhibitive effect of trehalose and sodium pyrophosphate on oxidation and structural changes of myofibrillar proteins in silver carp surimi during frozen storage.

This work investigated the cryoprotective effect of trehalose (TH) and sodium pyrophosphate (SPP) alone and in combination on myofibrillar protein (MP) oxidation and structural changes in silver carp surimi during 90 days of frozen storage (-20 °C). TH combined with SPP was significantly more effective than single TH or SPP in preventing MP oxidation (P < 0.05), showing a higher SH content (6.05 nmol/mg protein), and a lower carbonyl (4.24 nmol/mg protein) and dityrosine content (1280 A.U.). SDS-PAGE results indicated that TH combined with SPP did not differ significantly from TH and SPP in inhibiting protein degradation but was more effective in inhibiting protein crosslinking. Moreover, all cryoprotectants could stabilise the secondary and tertiary structures and inhibit unfolded and aggregation of MP, with the combination of TH and SPP being the best. It's worth noting that TH combined with SPP had a synergistic effect on inhibiting the decrease in α-helix content and gel-forming ability, and the increase in surface hydrophobicity. Overall, TH combined with SPP could significantly inhibited MP oxidation and structural changes in surimi during frozen storage and improve the gel-forming ability, which was significantly better than single TH or SPP.

Green fractionation and hydrolysis of fish meal to improve their techno-functional properties.

A green strategy employing water as solvent has been adopted to obtain protein hydrolysates from fish meal (FM), its water-soluble fraction (WSP), and its non-water-soluble fraction (NSP). The techno-functional properties of the hydrolysates have been investigated and compared to hydrolysates obtained with Alcalase®. In general, SWH hydrolysates presented higher content of free amino acids and higher degree of hydrolysis, which reflected on the molecular size distribution. However, Alcalase® hydrolysates presented better solubility (from 74 ± 4% for NSP at pH = 2 up to 99 ± 1% for WSP at pH = 4-7). According to fluorescence experiments, FM and NSP hydrolysates showed the highest surface hydrophobicity, which has been related to better emulsifying properties and higher emulsion stability. The emulsions stabilized with 2%wt. of SWH-treated NSP showed the smallest particle sizes, with D[4,3] = 155 nm at day 0, and good stability, with D[4,3] = 220 nm at day 7, proving that water fractionation followed by SWH treatment is a good method to improve the techno-functional properties of the hydrolysates.

Metabolomics, volatolomics, and bioinformatics analyses of the effects of ultra-high pressure pretreatment on taste and flavour parameters of cured Culter alburnus.

The effects of ultra-high pressure (UHP) pretreatment (50-250 MPa) on the fish curing were studied. UHP increased the overall volatile compound concentration of cured fish. Among 50-250 MPa five treatment groups, 150 MPa UHP group exhibited the highest total free amino acid content (294.34 mg/100 g) with that of the control group being 92.39 mg/100 g. The activity of cathepsin L was increased under 50-200 MPa UHP treatment (62.28-58.15 U/L), compared with that in the control group (53.80 U/L). UHP treatment resulted in a significant increase in small molecule compounds, especially the amino acid dipeptides and ATP metabolic products. Under UHP treatments, the bacterial phyla Actinobacteriota (1.04-5.25 %), Bacteroidota (0.20-4.47 %), and Deinococcota (0.00-0.05 %) exhibited an increased abundance, and they promoted taste and flavor formation. Our results indicated that UHP is a promising pretreatment method to improve taste and flavour in cured fish by affecting the microorganisms, cathepsin, and proteins.

Exploring the Relationships Between Bacterial Community, Taste-Enhancing Peptides and Aroma in Thai Fermented Fish (Pla-ra).

As a traditional Thai condiment, Pla-ra is used to add flavor and richness to dishes. Nine treatment combinations of Pla-ra formulations created from 3 types of fish (Mor fish, Kradee fish, and Mor + Kradee fish) and 4 different carbohydrate sources (none, rice bran, roasted rice, and rice bran─roasted rice mixture) were studied through a 12 month fermentation period (1, 3, 5, 7, 8, 9, 10, 11, and 12 months). 16S rRNA Next Generation Sequencing (NGS) and LC-MS/MS techniques were used to analyze the microbial diversity and identify taste-enhancing peptides. Descriptive sensory analysis was performed on the extracts of the 108 Pla-ra samples mixed in a model broth. Koku perception and saltiness-enhancing attributes were clearly perceived and dominant in all samples, even though glutamyl peptides, including γ-Glu-Val-Gly, were found at subthreshold levels. The samples from mixed fish and Mor fish fermented with roasted ground rice and rice bran for 12 months had the most typical Pla-ra odors and tastes and had high taste-enhancing activities. NGS analysis revealed the presence of bacteria containing a large number of protease and aminopeptidase genes in the samples. Bacillus spp., Gallicola spp., and Proteiniclasticum spp. correlated well with the generation of glutamyl and arginyl peptides and typical odors in the samples. These results confirmed the typical sensory quality of Pla-ra depended on protein sources, carbohydrate sources, and bacteria communities. Further optimization of the microbial composition found could lead to the development of starter cultures to control and promote flavor development in fermented fish products.

The gelling properties of fish gelatin as improved by ultrasound-assisted phosphorylation.

This study investigated the effects of ultrasound-assisted phosphorylation on gelling properties of fish gelatin (FG). Ultrasound-assisted phosphorylation (UP) for 60, 90, and 120 min resulted in >6.54% increase of phosphorylation degree and decreased zeta potential of FG. Atomic force microscopy revealed that UP-FGs showed larger aggregates than P-FGs (normal phosphorylation FGs). Low frequent-NMR and microstructure analysis revealed that phosphorylation enhanced water-binding capability of FG and improved the gel networks. However, UP60 had the highest gel strength (340 g), gelling (17.96 °C) and melting (26.54 °C) temperature while UP90 and UP120 showed slightly lower of them. FTIR analysis indicated thatß-sheet and triple helix content increased but random coil content decreased in phosphorylated FGs. Mass spectrometry demonstrated phosphate groups mainly bound to serine, threonine and tyrosine residues of FG and UP-FG exhibited more phosphorylation sites. The study showed that mild phosphorylation (UP60) could be applied to improve FG gel properties.

Improvement mechanism of volatile flavor in fermented tilapia surimi by cooperative fermentation of Pediococcus acidilactici and Latilactobacillus sakei: Quantization of microbial contribution through influence of genus.

Single starter can hardly improve the volatile flavor of fermented fish surimi. In this study, the changes of volatile compounds (VCs) and microbial composition during cooperative fermentation of Latilactobacillus sakei and Pediococcus acidilactici were studied by headspace solid-phase microextraction gas chromatography-mass spectrometry and 16S rRNA gene high-throughput sequencing. During cooperative fermentation, most VCs and the abundance of Latilactobacillus and Lactococcus significantly increased, while Pediococcus, Acinetobacter, and Macrococcus obviously decreased. After evaluation of correlation and abundance of each genus, Latilactobacillus and Lactococcus possessed the highest influence on the formation of volatile flavor during cooperative fermentation. Compared with the natural fermentation, cooperative fermentation with starters significantly enhanced most of pleasant core VCs (odor activity value≥1), but inhibited the production of trimethylamine and methanethiol, mainly resulting from the absolutely highest influence of Latilactobacillus. Cooperative fermentation of starters is an effective method to improve the volatile flavor in the fermented tilapia surimi.

Identification and quantification of flavor compounds in smoked tuna fish based on GC-Orbitrap volatolomics approach.

Cold smoking enhances the appeal of fish products, offering consumers a smooth texture and a delicate smoky flavor. This study aims to explore variations in the volatile profile from different exposure times during cold smoking processing (light, moderate, and full-cure) in tune samples. An innovative untargeted analytical approach, headspace solid-phase microextraction combined with gas chromatography and a hybrid quadrupole-orbitrap mass analyzer, was employed to identify 86 volatiles associated with the cold smoking process. Most of these compounds, including phenols, furan derivates, aldehydes, cyclic ketones, and different aromatic species, were found to contribute to the smoke odor. The development of a QuEChERS-based extraction and clean-up method facilitated the quantification of 25 relevant smoky markers across all smoking degrees, revealing significant concentration differences after 15 h of smoking. This research sheds light on the dynamics of cold smoking impact and its on the flavor profile and safety quality of processed fish products.

Effects of different curing concentrations and drying times on the microbial community structure and metabolites of dried Spanish mackerel.

Cured Spanish mackerel has a promising market owing to its nutritious nature as well as ease of transportation and preservation. However, the nutritional and flavor formation mechanism of Spanish mackerel after curing and drying is unclear. To overcome this problem, the effects of different processing conditions on the free amino acid, microbial community, and flavor of Spanish mackerel were explored. Staphylococcus and Cobetia are the main microorganisms in cured mackerel and are closely associated with the formation of their quality. Compared with fresh mackerel, cured mackerel contains increased levels of protein, fat, and chloride, contributing to its distinctive flavor. The contents of free amino acids in the BA64 group were substantially higher than those in other groups, particularly the contents of threonine, glycine, and tyrosine. These findings will contribute to the development of high-quality cured Spanish mackerel products and cured aquatic products.

Pre-rigor salting improves gel strength and water-holding of surimi gel made from snakehead fish (Channa argus): The role of protein oxidation.

The purpose of this study was to determine the effect of pre-rigor salting on the quality characteristics of surimi gels prepared from snakehead fish muscle. Pre-rigor and post-rigor muscle were mixed with 0.3% or 3% NaCl (w/w) and made into surimi gels, respectively. Results showed that pre-rigor muscle had a higher content of ATP, longer sarcomere, higher pH and greater protein solubility. Metabolic profile suggested that pre-rigor muscle had higher content (a 28-fold increase) of antioxidants such as butyryl-l-carnitine. Transmission electron microscopy showed more damage of mitochondria in post-rigor muscle. Surimi paste from pre-rigor meat chopped with 3% NaCl generally showed greater radical scavenging ability and had higher content of free sulfhydryl. Surimi gel made from pre-rigor muscle salted with 3% NaCl showed a larger gel strength (3.18 kg*mm vs. 2.22 kg*mm) and better water-holding (86% vs. 80%) than that of post-rigor group. Based on these findings, we hypothesized that: In addition to other factors such as pH, degree of denaturation, etc., less protein oxidation in pre-rigor salted surimi also contributes to the improved gel properties.

Shotgun proteomic analyses of Pseudomonas species isolated from fish products.

Numerous Pseudomonas species can infect aquatic animals, such as farmed rainbow trout, sea trout, sea bass, and sea bream, by causing disease or stress reactions. In aquaculture facilities, a number of Pseudomonas species have been isolated and identified as the main pathogens. The present study describes the characterization of 18 Pseudomonas strains, isolated from fish products using shotgun proteomics. The bacterial proteomes obtained were further analyzed to identify the main functional pathway proteins involved. In addition, this study revealed the presence of 1015 non-redundant peptides related to virulence factors. An additional 25 species-specific peptides were identified as putative Pseudomonas spp. biomarkers. The results constitute the largest dataset, described thus far for the rapid identification and characterization of Pseudomonas species present in edible fish; furthermore, these data can provide the basis for further research into the development of new therapies against these harmful pathogens.

Adenosine monophosphate boosts the cryoprotection of ultrasound-assisted freezing to frozen surimi: Insights into protein structures and gelling behaviors.

Ultrasound-assisted freezing (UAF) is a clean technique for meat cryoprotections; however, its effectiveness is still limited compared to conventional cryoprotectants, e.g., sugars, polyols, especially at high dosages. To resolve this problem, a synergistic cryoprotection strategy was developed in this study. Adenosine monophosphate (AMP), an adenosine-type food additive, was introduced into frozen surimi at a considerably reduced content (0.08%), yet substantially enhanced the efficiency of UAF to comparable levels of commercial cryoprotectant (4% sucrose with 4% sorbitol). Specifically, UAF/AMP treatment retarded denaturation of surimi myofibrillar protein (MP) during 60-day frozen storage, as evidenced by its increased solubility, Ca2+-ATPase activity, sulfhydryl content, declined surface hydrophobicity, particle size, and stabilized protein conformation. Gels of UAF/AMP-treated surimi also demonstrated more stabilized microstructures, uniform water distributions, enhanced mechanical properties and water-holding capacities. This study provided a feasible approach to boost the cryoprotective performance of UAF, thus expanding its potential applications in frozen food industry.

Uncovering quality changes of surimi-sol based products subjected to freeze-thaw process: The potential role of oxidative modification on salt-dissolved myofibrillar protein aggregation and gelling properties.

Frozen surimi quality generally correlates with oxidation, but impacts of protein oxidation on salt-dissolved myofibrillar protein (MP) sol in surimi remain unclear. Hence, physicochemical and gelling properties of MP sol with different oxidation degrees were investigated subjected to freeze-thaw cycles. Results showed that mild oxidation (≤1 mmol/L) improved unfrozen MP gel quality with lowest cooking loss (3.29 %) and highest hardness (829.76 N). Whereas, oxidized sol suffering freeze-thawing degenerated severely, showing reduction of 23.85 % of salt soluble protein contents with H2O2 concentrations of 10 mmol/L. Shearing before heating influenced gelling properties of freeze-thawed sol, depending on oxidation levels. Oxidized gel with shearing displayed disorganized network structures, whereas gel without shearing displayed relatively complete appearances without holes under high oxidation condition (10 mmol/L). Overall, freeze-thaw process aggravated denaturation extents of MP sol subjected to oxidation, further causing high water loss and yellow color of heat-induced gel, especially to gel with shearing.

Risk assessment of some toxic metals in canned fish products retailed in Mansoura, Egypt.

Background: Canned fish products are widely consumed in Egypt, particularly for protein-rich meals that are quick to prepare and low in calories. Canned fish products are contaminated with toxic metals from the fish itself or from canning materials during processing. Aim: To determine the residual levels of cadmium (Cd), lead (Pb), arsenic (As), mercury (Hg), aluminum (Al), and Tin (Sn) in some canned fish products obtained from retail shops in Mansoura, Egypt. Furthermore, noncarcinogenic health risks evaluation for the Egyptian population due to hazardous metal oral intake. Methods: One hundred canned fish products (20 each of herring, mackerel, salmon, sardine, and tuna) were collected from May to September 2023, and canned fish products were obtained from Mansoura city markets in Egypt. Samples were digested in a solution composed of 60% nitric acid and 40% perchloric acid, and then an atomic absorption spectrophotometer was used for the detection of selected toxic metals. Results: It was found that the residual level of hazardous metals exceeded the acceptability level established in the European Union for Pb, Cd, and Hg by 20%, 10%, and 10%, 15%, 5%, and 20%, 35%, 30%, and 45%, 25%, 25%, and 40%, in examined herring, mackerel, sardine, and tuna, respectively. In contrast, all salmon samples were accepted for Pb and Hg, and only 5% were not accepted due to a higher Cd level than the maximum permissible limit. The average estimated daily intake of (EDI) is below the tolerable daily intakes (TDIs) for all metals. Comparatively, the EDI of Hg was 0.265 µg/kg body weight (B.W) exceeded TDIs 0.228 µg/kg B.W. The hazard index for canned tuna and sardines is more than one. Conclusion: Canned fish products are contaminated with a variety of toxic metals, especially sardine and tuna. Therefore, it is advised to decrease the consumption rate of such fish products.