Effects of reducing dietary crude protein levels and replacement with crystalline amino acids on growth performance, carcass composition, and fresh pork quality of finishing pigs fed ractopamine hydrochloride.

Progeny of GPK-35 females mated to PIC 380 boars were blocked by initial BW, and within the 9 blocks, pens of pigs (3 gilts and 3 barrows/pen) were randomly assigned to dietary treatments where CP of finisher-I, -II, and -III diets was 1) 16.04, 14.55, and 16.23%, respectively (Ctrl); 2) 14.76, 13.48, and 15.27%, respectively (ILE); 3) 14.26, 12.78, and 14.28%, respectively (VAL); or 4) 12.65, 12.38, and 13.32%, respectively (NoSBM). All finisher-III diets included 10 mg/kg of ractopamine hydrochloride (RAC) and a Lys:ME ratio of 2.79 g/Mcal. At slaughter, HCW and Fat-O-Meat'er data were recorded before carcasses were subjected to a rapid chilling process. A subsample of whole hams (2/pen) and whole loins (2/pen) were transported under refrigeration to the University of Arkansas. Hams were dissected with a knife into lean, fat, and bone, and 2.5-cm-thick chops from the semimembranosus (SM) and the LM were used to measure fresh pork quality characteristics. Both ADG and G:F decreased (linear, = 0.05) as CP decreased in finisher-I diets, whereas ADFI was reduced (linear, = 0.01) in response to decreasing CP in finisher-II diets. When RAC was included in the finisher-III diets, ADFI and BW decreased (linear, ≤ 0.03) with decreasing CP, and pigs fed the ILE diet had greater (cubic, < 0.01) G:F than pigs fed the Ctrl and VAL diets. Across the entire finishing period, ADG and ADFI decreased (linear, = 0.01) in response to reductions in dietary CP. Conversely, reducing CP in finisher diets did not ( ≥ 0.13) affect carcass yield, fat depth, LM depth, or calculated fat-free lean yield, and dietary CP content did not ( ≥ 0.09) alter the lean, fat, or bone composition of fresh hams. Moreover, there was no effect of dietary CP on the visual and instrumental color or firmness of the LM ( ≥ 0.06) or SM ( ≥ 0.12). However, there were linear increases in LM marbling scores ( = 0.02) and intramuscular fat content ( = 0.03) as CP was reduced in the finisher diets. Although reducing dietary CP decreased overall ADG and ADFI by approximately 6.1 and 4.9%, respectively, carcass composition was not impacted by dietary CP level. More importantly, reducing dietary CP, although meeting the standard ileal digestible requirements for Lys, Thr, Trp, Met, Ile, and Val with crystalline AA, did not impact pork color or water-holding capacity and actually increased the intramuscular fat content of the LM.

Cookery method and endpoint temperature can affect the Warner-Bratzler shear force, cooking loss, and internal cooked color of beef semimembranosus and infraspinatus steaks.

Steaks from USDA Select inside rounds (Exp. 1) and shoulder clods (Exp. 2) were used to test the interactive effect of cookery method and endpoint temperature on Warner-Bratzler shear force (WBSF) and internal cooked color. Pairs of 2.5-cm-thick semimembranosus (SM) or infraspinatus (INF) steaks ( = 360/muscle) were cut from each subprimal, labeled, vacuum packaged, and frozen at -30°C in the dark for approximately 60 d before being cooked to 65.5, 71.1, or 76.6°C using 1) a forced-air convection oven (FAC); 2) a forced-air impingement oven (IMP); 3) a gas-fired, open-hearth charbroiler (CHAR); 4) an electric countertop griddle (GRID); or 5) a clam-shell grill (CLAM). Thawed steaks were cooked to their assigned endpoint temperature × cookery method combination, and, after a 5-min cooling period, steaks were weighed to calculate cooking loss percentage and subsequently sliced perpendicular to the cut surface to measure instrumental cooked color. Then, 6 cores were removed for measurement of WBSF. Cooking losses of SM steaks increased ( < 0.05) with each increase in endpoint temperature, whereas INF steaks cooked on a CHAR had the greatest ( < 0.05) cooking losses and cooking INF steaks with the GRID and the CLAM resulted in lesser ( < 0.05) cooking losses than cooking with the FAC and the IMP. Cooking SM steaks on the CHAR resulted in greater ( < 0.05) WBSF values than all other cookery methods when cooked to 65.5 and 76.6°C and greater ( < 0.05) WBSF values than those cooked on the FAC, GRID, and CLAM when cooked to 71.1°C. Shear force values were greater ( < 0.05) for INF steaks cooked to 71.1 and 76.6°C than those cooked to 65.5°C, but INF WBSF values were similar ( = 0.55) among cookery methods. At 65.5°C, FAC-cooked SM steaks were redder ( < 0.05) than those cooked with the GRID and the IMP and, at 71.1°C, CLAM-cooked SM steaks were redder ( < 0.05) than FAC- and IMP-cooked SM steaks; however, a* values were similar ( > 0.05) among cookery methods when cooked to 76.6°C. Redness did not ( > 0.05) differ among INF steaks cooked to 65.5 and 71.1°C with the FAC and the CHAR, whereas internal color of INF steaks cooked in the IMP and the FAC was redder ( < 0.05) than that of INF steaks cooked with the CLAM and the GRID to 76.6°C. Results suggest that endpoint temperature has a greater impact on cooking properties of SM and INF steaks than cookery method, yet it is apparent that internal cooked color of INF and SM steaks react differently to some cookery method-endpoint temperature combinations.

Postrigor citric acid enhancement can alter cooked color but not fresh color of dark-cutting beef.

In 2 experiments, dark-cutting (DC) beef strip loins were used to test the effects of citric acid-enhancement pH on visual and instrumental color of fresh and cooked steaks. In Exp. 1 and 2, each DC (mean pH = 6.57 and 6.65, respectively) and normal-pH, low USDA Choice (CH; mean pH = 5.48 and 5.51, respectively) strip loin was cut into 2 equal-length sections, and DC sections were injected to 111% of raw section weight with pH 3.5 to 5.0 (Exp. 1) or pH 2.0 to 3.5 (Exp. 2) solutions made by mixing citric acid in either 0.05% orthophosphate (PO) solution or tap water (HO) base solutions (Exp. 1) and 0.5% PO or 0.5% tripolyphosphate solution base solutions (Exp. 2). After enhancement, sections were cut into steaks, which were assigned to either 5 d of simulated retail display or cooked to 71°C for cooked color measurement. Postenhancement pH of DC steaks enhanced with pH 3.5 to 5.0 solutions did not ( ≥ 0.180) differ from that of nonenhanced DC steaks (Exp. 1) but linearly decreased ( < 0.001) as solution pH decreased from 3.5 to 2.0 (Exp. 2). Even though fresh color scores were increased ( < 0.001) by citric acid enhancement over untreated DC steaks during the first 3 d of display, fresh steak color never ( < 0.001) approached that of nonenhanced CH steaks. When compared with nonenhanced DC steaks, enhancement with pH 3.5 to 5.0 solutions received lower cooked color scores, whereas enhancing DC sections with pH 2.5 solutions produced cooked color and degree-of-doneness scores similar ( ≥ 0.113) to those of nonenhanced CH steaks (Exp. 2). Results indicated that the pH of citric acid enhancement solutions, regardless of base solution, were insufficient to improve the fresh color of DC beef; however, enhancement with pH 2.5 citric acid solutions effectively eliminated the persistent red cooked color typically associated with DC beef comparable with that of normal-pH beef.

Alternating dietary fat sources for growing-finishing pigs fed dried distillers grains with solubles: I. Growth performance, pork carcass characteristics, and fatty acid composition of subcutaneous fat depots.

Crossbred pigs (n = 216) were used to test the effects of phase-feeding beef tallow (BT) and yellow grease (YGr) on live performance, carcass characteristics, and fatty acid composition of subcutaneous (s.c.) fat depots of growing-finishing swine. Pigs were blocked by initial BW (26.0 ± 5.3 kg) before allotment to pens (6 pigs/pen), and pens (6 pens/block) were assigned randomly to 1 of 6 dietary treatments: 1) corn-soybean meal-based grower and finisher diets formulated with 4.7% YGr fed during all 5 feeding phases (YG15), 2) corn-soybean meal-based diets formulated with 5.0% BT fed during all 5 phases (BT15), 3) diets containing 5.0% BT fed during the first 2 phases and diets with 4.7% YGr fed the last 3 phases (YG345), 4) diets formulated with 5.0% BT fed during first 3 phases and diets containing 4.7% YGr fed during the last 2 phases (YG45), 5) diets containing 4.7% YGr fed during the first 3 phases and diets with 5.0% BT fed during the last 2 feeding phases (BT45), or 6) diets formulated with 4.7% YGr fed during the first 2 phases and diets with 5.0% BT fed during the last 3 phases (BT345). Overall performance was similar (P ≥ 0.06) among dietary treatments; however, overall ADG and ADFI increased (quadratic, P ≤ 0.05) with increasing days fed BT, but duration of dietary YGr did not affect ADG (P ≥ 0.22) or ADFI (P ≥ 0.30). There was no (P ≥ 0.23) effect of fat inclusion on carcass characteristics, but carcass lean yield decreased (linear, P = 0.02) as duration of YGr feeding increased from 37 to 103 d. Proportions of back fat SFA (quadratic, P = 0.03) and jowl fat MUFA (linear, P = 0.02) increased as the time fed BT increased from 47 to 103 d. Conversely, PUFA content of both s.c. fat depots increased (linear, P < 0.01) with increasing durations of dietary YGr. Moreover, quadratic slopes for linolenic (18:2n-6) and linolenic (18:3n-3) acids in jowl fat differed (P ≤ 0.05) between BT and YGr durations, indicating that the percentages of 18:2n-6 and 18:3n-3 increased at a greater rate with increasing time fed YGr than the rate of decreases in 18:2n-6 and 18:3n-3 associated with increasing time fed BT. Results of this study confirm that the fatty acid composition of s.c. fat depots are similar to that of the dietary fat source fed during the last 2 or 3 feeding phases, yet deposition rates of specific fatty acids appear to be dependent on the length of time pigs are fed a specific fat source.

Alternating dietary fat sources for growing-finishing pigs fed dried distillers grains with solubles: II. Fresh belly and bacon quality characteristics.

Crossbred pigs (n = 216) were used to test the effects of phase-feeding beef tallow (BT) and yellow grease (YGr) on fresh belly and bacon quality characteristics of growing-finishing swine fed dried distillers grains with solubles (DDGS). Pigs were blocked by initial BW (26.0 ± 5.3 kg) before allotment to pens (6 pigs/pen), and pens (6 pens/block) were assigned randomly to 1 of 6 dietary treatments: 1) corn-soybean meal-based grower and finisher diets formulated with 4.7% YGr fed during all 5 feeding phases (YG15); 2) corn-soybean meal-based diets formulated with 5.0% BT fed during all 5 phases (BT15); 3) diets containing 5.0% BT fed during the first 2 phases and diets with 4.7% YGr fed the last 3 phases (YG345); 4) diets formulated with 5.0% BT fed during first 3 phases and diets containing 4.7% YGr fed during the last 2 phases (YG45); 5) diets containing 4.7% YGr fed during the first 3 phases and diets with 5.0% BT fed during the last 2 feeding phases (BT45); or 6) diets formulated with 4.7% YGr fed during the first 2 phases and diets with 5.0% BT fed during the last 3 phases (BT345). All dietary treatments were formulated with 30% dried distillers grains with solubles (DDGS) during the first 3 phases, 15% DDGS in the fourth phase, and no DDGS during the last phase. Fresh belly quality data were collected on the left-side bellies, whereas bacon from the right-side bellies was prepared under commercial processing conditions. Additionally, USDA-certified No. 1 slices were collected for cooking characteristics and sensory panel evaluations. Bellies from the YG15-fed pigs were softer (P ≤ 0.05) than bellies from BT15-fed pigs; however, instrumentally measured belly firmness was not (P ≥ 0.06) different among treatments. Concentrations of palmitic, stearic, and oleic acids, as well as all SFA and all MUFA, were greater (P < 0.01) in bellies from BT15- than YG15-fed pigs. In contrast, proportions of linoleic acid, all PUFA, and iodine value were greater (P < 0.01) in belly fat from YG15-fed pigs in comparison with BT15-fed pigs. Yield of commercially processed bacon (P ≥ 0.06), mechanical bacon tenderness (P ≥ 0.69), and bacon palatability attributes (P ≥ 0.55) were not affected by the dietary treatments. Thus, results of this study indicated that phase-feeding BT to pigs fed diets formulated with DDGS produced minor improvements in fresh belly firmness due to greater proportions of SFA but had no effect on yields of commercially processed bacon or bacon quality characteristics.

Comparison of hematologic and serologic profiles of broiler birds with normal and severe degrees of white striping in breast fillets.

White striping is the white striation occasionally observed parallel to the direction of muscle fibers in broiler breast fillets and thighs at the processing plant. Broiler breast fillets can be categorized as normal (NORM), moderate (MOD), or severe (SEV) based on the degree of white striping. Histologically, SEV fillets are characterized by the highest degree of degeneration of muscle fibers along with fibrosis and lipidosis when compared with NORM. The present study was undertaken to compare the hematologic and serologic profiles of broilers with NORM and SEV degrees of white striping to get more information on the systemic changes associated with the condition. Day-old male broiler chicks of a commercial strain were grown on the same diet in 6 replicate pens (n = 32 birds/pen). Blood samples (5 mL) were collected from the wing vein of each bird on the day before processing for analyzing hematologic and serologic profiles. At 63 d, the birds were weighed and processed in a commercial inline processing system. Weight of the butterfly fillets, liver, and abdominal fat pad were recorded. Left-side fillets were scored to obtain the degree of white striping for each bird. Representative samples for NORM (n = 24) and SEV (n = 17) categories were selected to compare the hematologic and serologic profiles. The SEV birds had greater (P < 0.05) live, fillet, and liver weights, as well as fillet yield, compared with the NORM birds, but the abdominal fat yield was less (P < 0.05) in SEV birds. The NORM and SEV birds did not show any differences in various hematological parameters, including the differential leukocyte count. Conversely, SEV birds had elevated (P < 0.05) serum levels of creatine kinase, alanine transaminase, aspartate aminotransferase, and lactate dehydrogenase. These results suggest that there is no systemic infectious or inflammatory condition associated with a SEV degree of white striping. The elevated serum enzyme levels confirm the muscle damage associated with the degenerative myopathy in SEV birds.

Influence of growth rate on the occurrence of white striping in broiler breast fillets.

White striping refers to the occurrence of different degrees of white striations on broiler breast fillets and thighs of larger broilers, yet little is known about its causes. Thus, the objective of the study was to estimate the occurrence of normal (NORM), moderate (MOD), and severe (SEV) degrees of white striping with respect to the growth rate of broilers and to compare their proximate composition without the confounding effect of diet. Straight-run 1-d-old chicks (n = 280) were randomly assigned to either a low- (LED) or high-energy (HED) diet (5 replicates of 28 birds/dietary treatment). Birds were processed at 54 d of age, and live weight, deboned fillet weight, and occurrence of white striping were recorded. As expected, birds fed the HED had lower (P < 0.05) feed conversion ratios than birds fed LED (2.08 vs. 2.28). Also, HED-fed birds had heavier P < 0.05) live and fillet weights when compared with the LED-fed birds. A greater (P < 0.05) percentage of breast fillets from LED-fed birds were scored NORM, whereas HED-fed birds produced a greater (P < 0.05) percentage of SEV fillets. Fillet weight and yield (percent of live weight) increased (P < 0.05) as the degree of white striping increased from NORM to SEV. Additionally, NORM fillets had greater (P < 0.05) lipid and lower (P < 0.05) protein content when compared with SEV fillets. Also, NORM fillets had greater (P < 0.05) percentages of SFA than SEV fillets; however, proportions of all monounsaturated fatty acids, as well as linoleic and linolenic acids, were greater (P < 0.05) in SEV than NORM fillets. These results suggest that an increased growth rate results in increased occurrence of higher degrees of white striping in broiler breast fillets, and the various degrees of white striping are associated with differences in chemical composition of breast fillets.

Lactic acid enhancement can improve the fresh and cooked color of dark-cutting beef.

Two experiments were conducted to compare the effects of enhancing dark-cutting (DC) strip loins with lactic acid (LAC) on fresh and cooked beef color, as well as sensory attributes, with nonenhanced, normal pH strip loins (CH). Strip loins, with an average ultimate pH of 6.70 ± 0.11 (Exp. 1) and 6.78 ± 0.11 (Exp. 2), were cut into 2 equal-length sections, and DC sections were randomly assigned as either nonenhanced DC or DC enhanced with 0.15 (Exp. 1), 0.35 (Exp. 1 and 2), or 0.50% (Exp. 2) LAC at a target of either 105 (Exp. 1) or 112% (Exp. 2) of the raw product weight. Enhancement with 0.15 and 0.35% LAC did not (P > 0.05) affect postenhancement pH of DC strip loins when enhanced at a target of 105% (Exp. 1); however, postenhancement pH was reduced (P < 0.05) substantially by LAC enhancement at 115% of raw product weight, with pH values of DC sections enhanced with 0.50% LAC being similar (P > 0.05) to those of CH strip loin sections (Exp. 2). In Exp. 1, raw steaks from CH strip loins had greater (P < 0.05) a* and b* values as well as Japanese beef color scores compared with steaks from nonenhanced and LAC-enhanced DC strip loins across the first 3 d of simulated retail display (LAC enhancement × retail display duration; P < 0.01). Again in Exp. 2, raw steaks from CH sections had greater (P < 0.05) L*, a*, and b* values and Japanese color scores than did steaks from DC sections, regardless of LAC enhancement; however, mean Japanese color scores of CH steaks were only 0.7 and 0.4 units greater (P < 0.05) than the color scores of DC steaks enhanced with 0.35 and 0.50% LAC, respectively. In Exp. 1, CH steaks received the highest (P < 0.05) cooked color and degree of doneness scores, yet scores for CH steaks and steaks from DC sections enhanced with 0.50% LAC did not (P > 0.05) differ when cooked to 71°C in Exp. 2. Fresh and cooked color of DC beef was only minimally altered when enhanced with 0.35% LAC at 105% of the fresh product weight; however, when DC beef was enhanced with 0.35 and 0.50% LAC at a target of 112%, fresh and cooked color were improved close to that of CH beef. Because the persistent red or pink cooked color of DC was virtually eliminated by 0.50% LAC enhancement, LAC-enhanced DC beef may be suitable for food-service markets; however, the raw or fresh color results of Exp. 2 suggested that the fresh color of DC beef can be improved to the color of normal pH beef by postmortem acidification, leading to the possible recoupment of most, if not all, of the lost value associated with DC beef.

How is the instrumental color of meat measured?

Peer-reviewed journal articles (n=1068) were used to gather instrumental color measurement information in meat science research. The majority of articles, published in 10 peer-reviewed journals, originated from European countries (44.8%) and North America (38.5%). The predominant species was pork (44.2%), and most researchers used Minolta (60.0%) over Hunter (31.6%) colorimeters. Much of the research was done using illuminant D65 (32.3%); nevertheless, almost half (48.9%) of the articles did not report the illuminant. Moreover, a majority of the articles did not report aperture size (73.6%) or the number of readings per sample (52.4%). Many factors influence meat color, and a considerable proportion of the peer-reviewed, published research articles failed to include information necessary to replicate and/or interpret instrumental color results; therefore, a standardized set of minimum reportable parameters for meat color evaluation should be identified.

Effects of L-carnitine supplementation on quality characteristics of fresh pork bellies from pigs fed 3 levels of corn oil.

Crossbred pigs (n = 216) were used to test the effect of supplemental L-carnitine (CARN) on the fatty acid composition and quality characteristics of fresh pork bellies from pigs fed diets formulated with different inclusion levels of corn oil. Pigs were blocked by BW (43.6 ± 1.0 kg) and allotted randomly to pens of 6 pigs within blocks. Then, within blocks, pens were assigned randomly to 1 of 6 dietary treatments in a 2 × 3 factorial arrangement, with either 0 or 100 mg/kg of supplemental CARN and 3 dietary inclusion levels (0, 2, or 4%) of corn oil (CO). When the lightest block weighed 125.0 kg, all pigs were slaughtered, and left-side bellies were captured during carcass fabrication for quality data collection. Fresh pork bellies were evaluated for length, width, thickness, and firmness (bar-suspension and Instron-compression methods) before a 2.5-cm-wide strip of belly was removed and subsequently dissected into subcutaneous fat, primary lean (latissimus dorsi), secondary lean (cutaneous trunci), and intermuscular fat for fatty acid composition determination. Although belly length, width, and thickness of fresh pork bellies were not affected by CARN (P ≥ 0.128) or CO (P ≥ 0.073), belly firmness decreased linearly (P < 0.001) with increasing dietary CO, but there was no (P ≥ 0.137) effect of CARN on any belly firmness measure. Dietary CARN increased (P < 0.05) the proportion of total SFA in the intermuscular fat layer, increased (P < 0.05) the proportion of total MUFA in the primary and secondary lean layers, and decreased (P < 0.05) the proportion of total PUFA in the intermuscular fat and secondary lean layers of pork bellies. Moreover, the SFA and MUFA compositions decreased linearly (P < 0.001) with increasing dietary CO, and the rate of the decrease in SFA composition was greater (P < 0.001) in the fat layers than the lean layers. Conversely, the PUFA content increased linearly (P < 0.001) with increasing dietary CO, and the rate of the increase in PUFA was greater (P < 0.001) in the fat than the lean layers, and greater (P = 0.022) in the primary than secondary lean layer. Results from this study would indicate that differences in the amount and rate of fatty acid deposition associated with feeding increased amounts of CO, along with moisture differences among the belly layers, combine to negatively affect fresh pork belly firmness.

Cookery method and end-point temperature can affect the Warner-Bratzler shear force, cooking loss, and internal cooked color of beef longissimus steaks.

Steaks from 60 beef ribeye rolls were used to test the interactive effects of cookery method and end-point temperature on Warner-Bratzler shear force (WBSF) and internal cooked color. Pairs of longissimus thoracis (LT) steaks were assigned to combinations of 3 different end-point temperatures and 5 cookery methods. The forced-air convection oven (FAC) required the longest time and produced the reddest internal color, regardless of end-point temperature. The clam-shell grill (CLAM) required the least cooking time and resulted in the lowest cooking losses, but CLAM-cooked steaks also had the greatest WBSF values and least red internal color. Repeatability values for WBSF were acceptable (>0.60) for all degrees of doneness when steaks were cooked in the FAC and impingement oven, but steaks cooked on the CLAM were not repeatable. The relationship of myofibrillar toughening, moisture loss and cooked color changes in beef LT steaks also differed due to cookery methods.

Characterization of particulate matter size distributions and indoor concentrations from kerosene and diesel lamps.

UNLABELLED: Over one-quarter of the world's population relies on fuel-based lighting. Kerosene lamps are often located in close proximity to users, potentially increasing the risk for respiratory illnesses and lung cancer. Particulate matter concentrations resulting from cook stoves have been extensively studied in the literature. However, characterization of particulate concentrations from fuel-based lighting has received minimal attention. This research demonstrates that vendors who use a single simple wick lamp in high-air-exchange market kiosks will likely be exposed to PM(2.5) concentrations that are an order of magnitude greater than ambient health guidelines. Using a hurricane lamp will reduce exposure to PM(2.5) and PM(10) concentrations by an order of magnitude compared to using a simple wick lamp. Vendors using a single hurricane or pressure lamp may not exceed health standards or guidelines for PM(2.5) and PM(10), but will be exposed to elevated 0.02-0.3 µm particle concentrations. Vendors who change from fuel-based lighting to electric lighting technology for enhanced illumination will likely gain the ancillary health benefit of reduced particulate matter exposure. Vendors exposed only to ambient and fuel-based lighting particulate matter would see over an 80% reduction in inhaled PM(2.5) mass if they switched from a simple wick lamp to an electric lighting technology. PRACTICAL IMPLICATIONS: Changing lighting technologies to achieve increased efficiency and energy service levels can provide ancillary health benefits. The cheapest, crudest kerosene lamps emit the largest amounts of PM(2.5). Improving affordability and access to better lighting options (hurricane or pressure lamps and lighting using grid or off-grid electricity) can deliver health benefits for a large fraction of the world's population, while reducing the economic and environmental burden of the current fuel-based lighting technologies.

Consumer responses for tenderness and overall impression can be predicted by visible and near-infrared spectroscopy, Meullenet-Owens razor shear, and Warner-Bratzler shear force.

Beef ribeye rolls (n=40) from Select, low Choice, top (upper 2/3) Choice, and Prime quality grade carcasses were used to determine the relationship of visible and near-infrared spectroscopy (VNIR) reflectance, Warner-Bratzler shear force (WBSF), and Meullenet-Owens razor shear (MORS) with consumer responses for tenderness and overall impression. Steaks (2.54 cm) were cut and assigned to either 14 or 28d aging (n=4/aging period). Reflectance in the VNIR spectrum was measured 1d from the box-date no less than 30 min after cutting, and prior to aging. The steak used for VNIR measurement was designated for WBSF and MORS measurement, whereas three adjacent steaks were cooked for evaluation by a consumer panel (n=240 members). Steaks from the Select-grade ribeye rolls had the greatest (P=0.06) WBSF values and lower (P<0.05) overall impression scores than those from top Choice and Prime quality grades. Consumer panelists evaluated steaks aged 28 d as more tender (P<0.05) than those aged 14 d. The relationship of mechanical tenderness measurements were higher with consumer panel responses for tenderness than with overall impression, and those relationships were stronger for the Select grade than for quality grades with higher degrees of marbling. The 2nd derivatives of VNIR measurements were more successful at predicting consumer panel responses of tenderness and overall impression than WBSF and MORS; thus, VNIR methodology was less invasive and more predictive than other, more traditional tenderness measurements.

Interactive effects of dietary fat source and slaughter weight in growing-finishing swine: I. Growth performance and longissimus muscle fatty acid composition.

Crossbred pigs (n=288) were used to test the interactive effects of dietary fat source and slaughter weight on live performance, carcass traits, and fatty acid composition of the LM. Pigs were blocked by initial BW, and, within each of 9 blocks, pens (8 pigs/pen) were randomly assigned to either control corn-soybean meal grower and finisher diets devoid of added fat (Ctrl) or diets formulated with 5% beef tallow (BT), poultry fat (PF), or soybean oil (SBO). Immediately after treatment allotment, as well as at mean block BW of 45.5, 68.1, 90.9, and 113.6 kg, 1 pig was randomly selected from each pen, slaughtered, and allowed to chill for 48 h at 1 degrees C. Backfat was measured on the right sides, and a sample of the LM was removed for fatty acid composition analysis. Regardless of source, inclusion of fat in swine diets did not (P >or= 0.349) affect ADG, ADFI, or G:F. Furthermore, carcasses from pigs fed diets formulated with 5% fat had greater (P=0.013) average backfat depths than those from pigs fed the Ctrl diet. Body weight, carcass weight, and backfat depths increased (P<0.001) as slaughter weight increased from 28.1 to 113.6 kg. The proportion of SFA in the LM increased (P<0.001) with increasing slaughter weight from 28.1 to 68.1 kg, but SFA percentages were similar between 68.1 and 113.6 kg, and pigs fed the Ctrl diet had greater (P=0.032) proportions of SFA than pigs fed the SBO and PF diets. Moreover, the proportion of all MUFA increased (P<0.001) by 9.4 percentage units from 28.1 to 113.6 kg; however, only pigs fed the SBO diet had reduced (P=0.004) MUFA percentages than those fed the Ctrl, BT, and PF diets. Even though the proportion of PUFA in the LM decreased with increasing slaughter weight, pigs fed SBO had greater PUFA percentages, a greater PUFA-to-SFA ratio, and greater iodine values than pigs fed all other dietary treatments when slaughtered at BW of 45.5 kg or greater (fat source x slaughter weight, P < 0.001). Results of this study indicate that fat source had little to no impact on live pig performance, but feeding a polyunsaturated fat source altered the fatty acid profile of the LM within the first 17.4 kg of BW gain; more specifically, including 5% SBO in swine diets could lead to economical ramifications associated with soft pork or fat.

Interactive effects of dietary fat source and slaughter weight in growing-finishing swine: II. Fatty acid composition of subcutaneous fat.

Crossbred pigs (n=288) were used to test the interactive effects of dietary fat source and slaughter weight on the fatty acid composition of subcutaneous fat. Pigs were blocked by initial BW (28.1 kg), and, within blocks, pens (8 pigs/pen) were randomly assigned to either grower and finisher diets devoid of added fat (Ctrl) or diets formulated with 5% beef tallow (BT), poultry fat (PF), or soybean oil (SBO). Immediately after treatment allotment, as well as at mean block BW of 45.5, 68.1, 90.9, and 113.6 kg, 1 pig was randomly selected from each pen, slaughtered, and, within 1 h postmortem, samples of backfat were removed from each carcass between the 4th and 8th thoracic vertebra and separated into the inner, middle, and outer layers for fatty acid composition analysis. During the first 17.4 kg of BW gain, percentages of all SFA increased by more than 4% in subcutaneous fat of pigs fed the Ctrl and BT diets, but decreased by 4.4 and 7.7% in pigs fed the PF and SBO diets, respectively (fat source x slaughter weight, P<0.001). Proportions of all MUFA in subcutaneous fat from BT-fed pigs increased by 6.1% during the first 17.4 kg of BW gain, but MUFA percentages in SBO-fed pigs decreased by 9.1% between 28.1 and 45.5 kg (fat source x slaughter weight, P<0.001). Conversely, percentages of all PUFA from SBO-fed pigs increased by 39.9%, whereas PUFA concentrations in BT-fed pigs decreased by 12.6% as slaughter weight increased from 28.1 to 45.5 kg (fat source x slaughter weight, P<0.001). Resultant iodine values (IV) of subcutaneous fat from SBO-fed pigs increased (P<0.05) from 73.5 to 85.2 within the first 17.4 kg of BW gain, and remained elevated above those of their contemporaries fed the Ctrl, BT, or PF diets at each subsequent slaughter weight (fat source x slaughter weight, P<0.001). The inner backfat layer had the greatest (P<0.05) proportions of all SFA and the least (P<0.05) proportions of all PUFA, whereas the outer layer had the least (P<0.05) percentages of all SFA but the greatest (P<0.05) percentages of all MUFA. Even though the middle and outer subcutaneous fat layers had similar (P>0.05) PUFA percentages, the greatest (P<0.05) and least (P<0.05) IV were in the outer and middle layers, respectively. As expected, the fat source included in swine diets was responsible for the fatty acid compositional changes in subcutaneous fat, yet the results of this study indicate that feeding 5% SBO dramatically increased the polyunsaturation of subcutaneous fat within the first 17.4 kg of BW gain, with backfat IV exceeding 80 thereafter.

Interactive effects of dietary fat source and slaughter weight in growing-finishing swine: III. Carcass and fatty acid compositions.

Crossbred pigs (n=288) were used to test the interactive effects of dietary fat source and slaughter weight on dissected carcass composition and fatty acid composition of composite carcass samples. Pigs were blocked by initial BW, and within each of 9 blocks, pens (8 pigs/pen) were randomly assigned to either control corn-soybean meal grower and finisher diets (Ctrl) or diets formulated with 5% beef tallow (BT), poultry fat (PF), or soybean oil (SBO). Immediately after treatment allotment, as well as at mean block BW of 45.5, 68.1, 90.9, and 113.6 kg, 1 pig was randomly selected from each pen and slaughtered, and primal cuts from right carcass sides were dissected into muscle, fat, bone, and skin components. Muscle and fat tissues were then ground, and random composite samples were collected from each carcass for fatty acid composition analysis. Fat source did not alter pork primal cut yields (P >or= 0.294), nor were the percentages of carcass muscle (P=0.213), fat (P=0.502), and bone (P=0.551) affected by dietary fat source. Conversely, percentages of the whole shoulder and ham decreased linearly (P<0.001), and the percentages of loin and belly increased (P<0.001) linearly with increasing slaughter weight. Moreover, linear decreases (P<0.001) in carcass muscle, bone, and skin, as well as a linear increase (P<0.05) in carcass fat, were observed as slaughter weight increased from 28.1 to 113.6 kg. Composite samples from pigs fed the BT or Ctrl diets had greater (P<0.05) proportions of SFA, particularly oleic and stearic acids, than those from pigs fed the PF and SBO diets when slaughtered at 45.5, 68.1, and 90.9 kg (fat source x slaughter weight, P<0.001). Percentages of MUFA (including palmitoleic, oleic, and cis-vaccenic acids) decreased (P<0.05), and percentages of all PUFA, especially linoleic and linolenic acids, and iodine values increased (P<0.05) in samples from SBO-fed pigs as slaughter weight increased from 28.1 to 113.6 kg (fat source x slaughter weight, P<0.001). Dietary fat source did not affect carcass composition; however, including 5% SBO in swine diets increased the polyunsaturation of pork, which could lead to economic ramifications associated with soft pork and pork fat.

Fresh and cooked color of dark-cutting beef can be altered by post-rigor enhancement with lactic acid.

Fresh and cooked color of dark-cutting (DC) beef strip loins (mean pH=6.56) enhanced with 0.25, 0.50, 0.75 or 1.00% lactic acid (LA) were compared to non-enhanced DC and normal pH (NpH; mean pH=5.43) strip loins. Even though NpH steaks received the most (P<0.05) desirable fresh color scores, color scores for steaks from DC sections enhanced with 0.25% LA approached those of NpH steaks after the first day of retail display. Discoloration scores were also similar (P>0.05) among NpH and 0.25% LA-enhanced DC steaks throughout the 5 d of display. Fresh steaks from NpH strip loins were redder, as evidenced by greater (P<0.05) a(∗) values and lower (P<0.05) hue angles, than DC steaks and DC steaks enhanced with LA, regardless of concentration. However, cooked color scores and proportions of denatured myoglobin were similar (P>0.05) between untreated NpH steaks and DC steaks enhanced with 0.25% LA. Results from this study indicate that enhancing DC beef with LA may lead to the brightening of the fresh color and prevention of the persistent red cooked color, approaching that of NpH beef.

Interactive effect of ractopamine and dietary fat source on pork quality characteristics of fresh pork chops during simulated retail display.

Crossbred pigs (n = 216) were used to test the interactive effect, if any, of ractopamine (RAC) and dietary fat source on the performance of finishing pigs, pork carcass characteristics, and quality of LM chops during 5 d of simulated retail display (2.6 degrees C and 1,600 lx warm-white fluorescent lighting). Pigs were blocked by BW and allotted randomly to pens (6 pigs/pen), and, after receiving a common diet devoid of RAC for 2 wk, pens within blocks were assigned randomly to 1 of 4 diets in a 2 x 2 factorial arrangement, with 5% fat [beef tallow (BT) vs. soybean oil (SBO)] and RAC (0 vs. 10 mg/kg). Diets were formulated to contain 3.1 g of lysine/Mcal of ME and 3.48 Mcal/kg of ME. Across the entire 35-d trial, pigs fed RAC had greater (P < 0.01) ADG and G:F, but RAC did not affect (P = 0.09) ADFI; however, performance was not affected (P >or= 0.07) by dietary fat source. Carcass weight, LM depth, and lean muscle yield were increased (P < 0.01), whereas fat depth was decreased (P = 0.01), in carcasses from RAC-fed pigs; however, carcass composition measures were similar (P >or= 0.27) between fat sources. Feeding 10 mg/kg of RAC reduced (P

The impact of lactic acid concentration and sodium chloride on pH, water-holding capacity, and cooked color of injection-enhanced dark-cutting beef.

The objectives of this study were to evaluate the effect of enhancement with 0.5%, 1.0%, 1.5%, or 2.0% lactic acid (LA), with or without 0.5% salt (NaCl), on pH, water-holding capacity, and resultant cooked color of dark-cutting (DC) beef. The pH of DC sections treated with LA decreased (P<0.05), whereas water-holding capacity (WHC) increased (P<0.05) with increasing concentrations of LA. Sensory panelists noted an increase (P<0.05) in the degree of doneness (less pink internal color), whereas, a(∗) and chroma values were lower (P<0.05), and hue angles were greater (P<0.05), indicating the internal color of LA-treated DC sections was less red and appeared more well-done. Also, 630:580nm reflectance ratios were similar (P>0.05) among DC steaks treated with 0.5% and 1.0% LA and normal pH (NDC) steaks, likely caused by an increase (P<0.05) in myoglobin denaturation in LA-enhanced DC steaks. These results indicate that the use of LA can reduce postmortem muscle pH and alter the cooked color of DC beef, ultimately resulting in a deletion of the persistent pinking condition.

Influence of vacuum-aging period on bloom development of the beef gluteus medius from top sirloin butts.

The gluteus medius (GM) from USDA Select beef carcasses was used to test the effect of aging period on bloom development. Top sirloin butts (IMPS #184) were randomly allocated to 0, 7, 14, 21, 28, and 35d vacuum-aging at 2°C (n=10/aging period). Each week, aged top sirloin butts were faced before two 2.5-cm-thick, non-adjacent steaks were cut and instrumental color (L(∗), a(∗), and b(∗)) of the GM was measured at 10-min intervals for 2h after cutting. Steaks aged for 7 and 14d were a more vivid (greater chroma values; P<0.05), redder (greater a(∗) values; P<0.05), and more yellow (greater b(∗) values; P<0.05) color than steaks from the other aging periods. Change in total color (ΔE) was greater (P<0.05) for steaks from top sirloin butts aged 7, 14, and 21d than steaks from top butts aged 28 and 35d, whereas oxymyoglobin percentages for steaks from top butts aged 7 and 14 days were greater (P<0.05) than those from top sirloin butts aged 28 and 35d. As much as 90% of the total increase (P<0.05) in a(∗), b(∗), and chroma values, as well as hue angles and oxymyoglobin percentages, was achieved during the first 60min after cutting.