ABSTRACT
The esterification reaction of geraniol with acetic acid catalyzed by immobilized Candida antarctica lipase B was studied in hexane using a pervaporation-assisted batch reactor. The effect of thermodynamic water activity (a(w)) on the initial reaction rate was investigated at a(w) ranging from 0.02 to 1.0. The a(w) was monitored on-line in real time. a(w) was actively controlled throughout the reaction by using highly water-selective membrane pervaporation. This novel combination of a(w) sensing and control eliminates changes in a(w) during the reaction even in the initial phase of relatively rapid water release during an esterification. No chemicals are introduced for a(w) control, and no purge gases or liquids are needed. A maximum in the initial reaction rate was found approximately at a(w)=0.1. The initial reaction rate declined quickly at higher a(w), and dropped precipitously at lower a(w).
Subject(s)
Enzymes, Immobilized/metabolism , Hexanes/pharmacology , Thermodynamics , Water/pharmacology , Bioreactors , Calibration , Candida/enzymology , Catalysis/drug effects , Chromatography, Gas , Esterification , Hexanes/chemistry , Kinetics , Lipase/metabolism , Membranes, Artificial , Time Factors , Water/chemistryABSTRACT
The esterification of geraniol with acetic acid in n-hexane was investigated. A commercial lipase preparation from Candida antarctica was used as catalyst. The equilibrium conversion (no water removal) was found to be 94% for the reaction of 0.1 M alcohol and 0.1 M acid in n-hexane at 30 degrees C. This was shown by both hydrolysis and esterification reactions. The activation energy of reaction over the temperature range 10 degrees to 50 degrees C was found to be 16 kJ/mol. The standard heat of reaction was -28 kJ/mol. Membrane pervaporation using a cellulose acetate/ceramic composite membrane was then employed for selective removal of water from the reaction mixture. The membrane was highly effective at removing water while retaining all reaction components. Negligible transport of the solvent n-hexane was observed. Water removal by pervaporation increased the reaction rate by approximately 150% and increased steady-state conversion to 100%.