Proposal of Simplified Standardization of the Cell-Growth-Promoting Activity of Human Adipose Tissue Mesenchymal Stromal Cell Culture Supernatants.

The conditioned medium (CM) obtained from mesenchymal stromal cell (MSC) culture has excellent cell growth-promoting activity and is used for cosmetics and healthcare products. Unlike pharmaceuticals, strict efficacy verification is not legally required for these products. However, their efficacy must be substantiated as commercial products. We attempted to simplify CM production and to standardize the evaluation of the growth-promoting activity of CM. CM was obtained through the culturing of two lines of commercially available human adipose tissue-derived MSCs using MEMα with or without 10% fetal bovine serum (FBS) for 24 h. Non-CM control media were produced by the same protocol without MSCs. Growth-promoting activities of the CM were estimated by [3H]-thymidine pulse. CM were subjected to molecular weight fractionation with ultrafiltration using 10 k-, 30 k-, 50 k-, and 100 k-membranes. The FBS-free CMs showed 1.34- to 1.85-fold increases and FBS-containing CMs showed 1.45- to 1.67-fold increases in proliferation-promoting activity compared with non-CM controls, regardless of the source of the cell. The thymidine incorporation levels were approximately three times higher in FBS-containing CMs. Aged cells also showed 1.67- to 2.48-fold increases in the activity due to FBS-containing CM, but not to FBS-free CM. The CM activities were sustained even after 1 year at 4 °C. Molecular weight fractionation showed that the activity was recovered in the fraction above 100 k. Clear and stable cell-growth-promoting activity was confirmed with CMs of commercially available adipose tissue MSCs. The activity was detected in the fraction over 100 k. We propose here the importance of standardizing the production and evaluation of CMs to indicate their specific action.

LEDitSHAKE: a lighting system to optimize the secondary metabolite content of plant cell suspension cultures.

Plant secondary metabolites are widely used in the food, cosmetic and pharmaceutical industries. They can be extracted from sterile grown plant cell suspension cultures, but yields and quality strongly depend on the cultivation environment, including optimal illumination. Current shaking incubators do not allow different light wavelengths, intensities and photoperiods to be tested in parallel. We therefore developed LEDitSHAKE, a system for multiplexed customized illumination within a single shaking incubator. We used 3D printing to integrate light-emitting diode assemblies into flask housings, allowing 12 different lighting conditions (spectrum, intensity and photoperiod) to be tested simultaneously. We did a proof of principle of LEDitSHAKE using the system to optimize anthocyanin production in grapevine cell suspension cultures. The effect of 24 different light compositions on the total anthocyanin content of grapevine cell suspension cultures was determined using a Design of Experiments approach. We predicted the optimal lighting conditions for the upregulation and downregulation of 30 anthocyanins and found that short-wavelength light (blue, UV) maximized the concentration of most anthocyanins, whereas long-wavelength light (red) had the opposite effect. Therefore our results demonstrate proof of principle that the LEDitSHAKE system is suitable for the optimization of processes based on plant cell suspension cultures.

EBiSC best practice: How to ensure optimal generation, qualification, and distribution of iPSC lines.

Disease-relevant human induced pluripotent stem cells (iPSCs) are generated worldwide for research purposes; however, without robust and practical ethical, legal, and quality standards, there is a high risk that their true potential will not be realized. Best practices for tissue procurement, iPSC reprogramming, day-to-day cultivation, quality control, and data management aligned with an ethical and legal framework must be included into daily operations to ensure their promise is maximized. Here we discuss key learning experiences from 7 years of operating the European Bank for induced Pluripotent Stem Cells (EBiSC) and recommend how to incorporate solutions into a daily management framework.

Human Platelet Lysate for Good Manufacturing Practice-Compliant Cell Production.

Numerous cell-based therapeutics are currently being tested in clinical trials. Human platelet lysate (HPL) is a valuable alternative to fetal bovine serum as a cell culture medium supplement for a variety of different cell types. HPL as a raw material permits animal serum-free cell propagation with highly efficient stimulation of cell proliferation, enabling humanized manufacturing of cell therapeutics within a reasonable timeframe. Providers of HPL have to consider dedicated quality issues regarding identity, purity, potency, traceability and safety. Release criteria have to be defined, characterizing the suitability of HPL batches for the support of a specific cell culture. Fresh or expired platelet concentrates from healthy blood donors are the starting material for HPL preparation, according to regulatory requirements. Pooling of individual platelet lysate units into one HPL batch can balance donor variation with regard to essential platelet-derived growth factors and cytokines. The increasingly applied pathogen reduction technologies will further increase HPL safety. In this review article, aspects and regulatory requirements of whole blood donation and details of human platelet lysate manufacturing are presented. International guidelines for raw materials are discussed, and defined quality controls, as well as release criteria for safe and GMP-compliant HPL production, are summarized.

Messenger RNA Expression of Albumin, Transferrin, Transthyretin, Asialoglycoprotein Receptor, Cytochrome P450 Isoform, Uptake Transporter, and Efflux Transporter Genes as a Function of Culture Duration in Prolonged Cultured Cryopreserved Human Hepatocytes as Collagen-Matrigel Sandwich Cultures: Evidence for Redifferentiation upon Prolonged Culturing.

Hepatic gene expression as a function of culture duration was evaluated in prolonged cultured human hepatocytes. Human hepatocytes from seven donors were maintained as near-confluent collagen-Matrigelsandwich cultures, with messenger RNA expression for genes responsible for key hepatic functions quantified by real-time polymerase chain reaction at culture durations of 0 (day of plating), 2, 7, 9, 16, 23, 26, 29, 36, and 43 days. Key hepatocyte genes were evaluated, including the differentiation markers albumin, transferrin, and transthyretin; the hepatocyte-specific asialoglycoprotein receptor 1 cytochrome P450 isoforms CYP1A2, CYP2B6, CYP2C8, CYP2C9, CYP2C19, CYP2D6, CYP3A4, and CYP3A7; uptake transporter isoforms SLC10A1, SLC22A1, SLC22A7, SLCO1B1, SLCO1B3, and SLCO2B1; efflux transporter isoforms ATP binding cassette (ABC)B1, ABCB11, ABCC2, ABCC3, ABCC4, and ABCG2; and the nonspecific housekeeping gene hypoxanthine ribosyl transferase 1 (HPRT1). The well established dedifferentiation phenomenon was observed on day 2, with substantial (>80%) decreases in gene expression in day 2 cultures observed for all genes evaluated except HPRT1 and efflux transporters ABCB1, ABCC2, ABCC3 (<50% decrease in expression), ABCC4 (>400% increase in expression), and ABCG2 (no decrease in expression). All genes with a >80% decrease in expression were found to have increased levels of expression on day 7, with peak expression observed on either day 7 or day 9, followed by a gradual decrease in expression up to the longest duration evaluated of 43 days. Our results provide evidence that cultured human hepatocytes undergo redifferentiation upon prolonged culturing. SIGNIFICANCE STATEMENT: This study reports that although human hepatocytes underwent dedifferentiation upon 2 days of culture, prolonged culturing resulted in redifferentiation based on gene expression of differentiation markers, uptake and efflux transporters, and cytochrome P450 isoforms. The observed redifferentiation suggests that prolonged (>7 days) culturing of human hepatocyte cultures may represent an experimental approach to overcome the initial dedifferentiation process, resulting in "stabilized" hepatocytes that can be applied toward the evaluation of drug properties requiring an extended period of treatment and evaluation.

Cell culture techniques in gastrointestinal research: Methods, possibilities and challenges.

Cell culture is one of the most valuable tools which is being applied in both fundamental and applied gastrointestinal research. The cells are isolated from their natural location (in vivo) and further propagated in vitro or artificial environment and studied. Over the years, several methods have been devised to isolate animal cells derived from the gut and culture them in vitro to study the functions and biology in the context of complex gastrointestinal diseases. This mini-review briefly describes the types and methods of cell culture covering the simplest monoculture models to more recent 3D organoid models, highlighting its importance in personalized precession medicine and other aspects of translational research. It also throws light upon the major challenges and outlines the future directions for using cell culture as a model system.

Surface expression of the immunotherapeutic target GD2 in osteosarcoma depends on cell confluency.

BACKGROUND: Chimeric antigen receptor (CAR) T-cell therapy of pediatric sarcomas is challenged by the paucity of targetable cell surface antigens. A candidate target in osteosarcoma (OS) is the ganglioside GD2 , but heterogeneous expression of GD2 limits its value. AIM: We aimed to identify mechanisms that upregulate GD2 target expression in OS. METHODS AND RESULTS: GD2 surface expression in OS cells, studied by flow cytometry, was found to vary both among and within individual OS cell lines. Pharmacological approaches, including inhibition of the histone methyltransferase Enhancer of Zeste Homolog 2 (EZH2) and modulation of the protein kinase C, failed to increase GD2 expression. Instead, cell confluency was found to be associated with higher GD2 expression levels both in monolayer cultures and in tumor spheroids. The sensitivity of OS cells to targeting by GD2 -specific CAR T cells was compared in an in vitro cytotoxicity assay. Higher cell confluencies enhanced the sensitivity of OS cells to GD2 -antigen specific, CAR T-cell-mediated in vitro cytolysis. Mechanistic studies revealed that confluency-dependent upregulation of GD2 expression in OS cells is mediated by increased de novo biosynthesis, through a yet unknown mechanism. CONCLUSION: Expression of GD2 in OS cell lines is highly variable and associated with increasing cell confluency in vitro. Strategies for selective upregulation of GD2 are needed to enable effective therapeutic targeting of this antigen in OS.

An optimised GAS-pharyngeal cell biofilm model.

Group A Streptococcus (GAS) causes 700 million infections and accounts for half a million deaths per year. Biofilm formation has been implicated in both pharyngeal and dermal GAS infections. In vitro, plate-based assays have shown that several GAS M-types form biofilms, and multiple GAS virulence factors have been linked to biofilm formation. Although the contributions of these plate-based studies have been valuable, most have failed to mimic the host environment, with many studies utilising abiotic surfaces. GAS is a human specific pathogen, and colonisation and subsequent biofilm formation is likely facilitated by distinct interactions with host tissue surfaces. As such, a host cell-GAS model has been optimised to support and grow GAS biofilms of a variety of GAS M-types. Improvements and adjustments to the crystal violet biofilm biomass assay have also been tailored to reproducibly detect delicate GAS biofilms. We propose 72 h as an optimal growth period for yielding detectable biofilm biomass. GAS biofilms formed are robust and durable, and can be reproducibly assessed via staining/washing intensive assays such as crystal violet with the aid of methanol fixation prior to staining. Lastly, SEM imaging of GAS biofilms formed by this model revealed GAS cocci chains arranged into three-dimensional aggregated structures with EPS matrix material. Taken together, we outline an efficacious GAS biofilm pharyngeal cell model that can support long-term GAS biofilm formation, with biofilms formed closely resembling those seen in vivo.

Using the Microwell-mesh to culture microtissues in vitro and as a carrier to implant microtissues in vivo into mice.

Prostate cancer (PCa) patient-derived xenografts (PDXs) are commonly propagated by serial transplantation of "pieces" of tumour in mice, but the cellular composition of pieces is not standardised. Herein, we optimised a microwell platform, the Microwell-mesh, to aggregate precise numbers of cells into arrays of microtissues, and then implanted the Microwell-mesh into NOD-scid IL2γ-/- (NSG) mice to study microtissue growth. First, mesh pore size was optimised using microtissues assembled from bone marrow-derived stromal cells, with mesh opening dimensions of 100×100 µm achieving superior microtissue vascularisation relative to mesh with 36×36 µm mesh openings. The optimised Microwell-mesh was used to assemble and implant PCa cell microtissue arrays (hereafter microtissues formed from cancer cells are referred to as microtumours) into mice. PCa cells were enriched from three different PDX lines, LuCaP35, LuCaP141, and BM18. 3D microtumours showed greater in vitro viability than 2D cultures, but neither proliferated. Microtumours were successfully established in mice 81% (57 of 70), 67% (4 of 6), 76% (19 of 25) for LuCaP35, LuCaP141, and BM18 PCa cells, respectively. Microtumour growth was tracked using live animal imaging for size or bioluminescence signal. If augmented with further imaging advances and cell bar coding, this microtumour model could enable greater resolution of PCa PDX drug response, and lead to the more efficient use of animals. The concept of microtissue assembly in the Microwell-mesh, and implantation in vivo may also have utility in implantation of islets, hair follicles or other organ-specific cells that self-assemble into 3D structures, providing an important bridge between in vitro assembly of mini-organs and in vivo implantation.

Review: High temperature short time treatment of cell culture media and feed solutions to mitigate adventitious viral contamination in the biopharmaceutical industry.

Events of viral contaminations occurring during the production of biopharmaceuticals have been publicly reported by the biopharmaceutical industry. Upstream raw materials were often identified as the potential source of contamination. Viral contamination risk can be mitigated by inactivating or eliminating potential viruses of cell culture media and feed solutions. Different methods can be used alone or in combination on raw materials, cell culture media, or feed solutions such as viral inactivation technologies consisting mainly of high temperature short time, ultraviolet irradiation, and gamma radiation technologies or such as viral removal technology for instance nanofiltration. The aim of this review is to present the principle, the advantages, and the challenges of high temperature short time (HTST) technology. Here, we reviewed effectiveness of HTST treatment and its impact on media (filterability of media, degradation of components), on process performance (cell growth, cell metabolism, productivity), and product quality based on knowledge shared in the literature.

High-Sensitivity Assessment of Phagocytosis by Persistent Association-Based Normalization.

Phagocytosis is measured as a functional outcome in many research fields, but accurate quantification can be challenging, with no robust method available for cross-laboratory reproducibility. In this study, we identified a simple, measurable parameter, persistent prey-phagocyte association, to use for normalization and dose-response analysis. We apply this in a straightforward analytical method, persistent association-based normalization, in which the multiplicity of prey (MOP) ratio needed to elicit half of the phagocytes to associate persistently (MOP50) is determined first. MOP50 is then applied to normalize for experimental factors, separately analyzing association and internalization. We use reference human phagocyte THP-1 cells with different prey and opsonization conditions to compare the persistent association-based normalization method to standard ways of assessing phagocytosis and find it to perform better, exhibiting increased robustness, sensitivity, and reproducibility. The approach is easily incorporated into most existing phagocytosis assays and allows for reproducible results with high sensitivity.

Acquired genetic changes in human pluripotent stem cells: origins and consequences.

In the 20 years since human embryonic stem cells, and subsequently induced pluripotent stem cells, were first described, it has become apparent that during long-term culture these cells (collectively referred to as 'pluripotent stem cells' (PSCs)) can acquire genetic changes, which commonly include gains or losses of particular chromosomal regions, or mutations in certain cancer-associated genes, especially TP53. Such changes raise concerns for the safety of PSC-derived cellular therapies for regenerative medicine. Although acquired genetic changes may not be present in a cell line at the start of a research programme, the low sensitivity of current detection methods means that mutations may be difficult to detect if they arise but are present in only a small proportion of the cells. In this Review, we discuss the types of mutations acquired by human PSCs and the mechanisms that lead to their accumulation. Recent work suggests that the underlying mutation rate in PSCs is low, although they also seem to be particularly susceptible to genomic damage. This apparent contradiction can be reconciled by the observations that, in contrast to somatic cells, PSCs are programmed to die in response to genomic damage, which may reflect the requirements of early embryogenesis. Thus, the common genetic variants that are observed are probably rare events that give the cells with a selective growth advantage.

Immortalized equivalent human epidermis as a platform to evaluation hair dyes toxicity: Efficiency comparison between 3D and monolayer culture.

The use of 3D models in various scientific applications is becoming more popular to replace traditional monolayers models. In this work, we used a three-dimensional in-house model of epidermis using HaCaT immortalized cells to evaluate the dermal toxicity induced by Basic Blue 99 and Basic Red 51, both present in commercial hair dye formulations. Our data show that cells cultured in the 3D model respond differently to those cultured in monolayer. Basic Red 51 dye induces apoptosis an DNA breaks in both models, however, these effects is more pronounced in cells cultured in monolayer. The toxic mode of action of Basic Blue 99 seems to be the induction of cell death, without genotoxic effects, but while the necrotic pathway is observed in HaCaT monolayer cell culture, was apoptosis seen in the Equivalent Human Epidermis (EHE) model. We could also confirm that cells in EHE model, an environment that could better mimic human effects, react differently to chemical stressors than the cells cultivated in 2D.

The Ex Vivo Skin Model as an Alternative Tool for the Efficacy and Safety Evaluation of Topical Products.

The development of alternative approaches for safety and efficacy testing that avoid the use of animals is a worldwide trend, which relies on the improvement of current models and tools so that they better reproduce human biology. Human skin from elective plastic surgery is a promising experimental model to test the effects of topically applied products. As the structure of native skin is maintained, including cell population (keratinocytes, melanocytes, Langerhans cells and fibroblasts) and dermal matrix (containing collagen, elastin, glycosaminoglycans, etc.), it most closely matches the effects of substances on in vivo human skin. In this review, we present a collection of results that our group has generated over the last years, involving the use of human skin and scalp explants, demonstrating the feasibility of this model. The development of a test system with ex vivo skin explants, of standard size and thickness, and cultured at the air-liquid interface, can provide an important tool for understanding the mechanisms involved in several cutaneous disorders.

Evaluation of Cell Harvesting Techniques to Optimize Lipidomic Analysis from Human Meibomian Gland Epithelial Cells in Culture.

The lipidomic analysis of immortalized human meibomian gland epithelial cells (HMGECs) has been proposed as a preclinical model to study meibomian gland dysfunction. An in vitro study was conducted to evaluate neutral lipid recovery following three harvesting techniques and to identify candidate lipid biomarkers of HMGECs. HMGECs were cultured in serum-containing media for two days to promote lipid production. Cells were either harvested by 0.25% trypsin-ethylenediaminetetraacetic acid (EDTA), harvested by 10 mM EDTA, or simultaneously harvested and extracted by 2:1 chloroform-methanol (CM). After extraction by a modified Folch technique, the nonpolar phase was processed and infused into a TripleTOF 5600 mass spectrometer (Sciex, Framingham, MA, USA) with electrospray ionization. MS and MS/MSall spectra were acquired. Nonpolar cholesteryl esters (CEs) were consistently detected in all samples, while wax esters were not. Only small differences in two out of twenty CEs were detected between harvesting methods. CM yielded less CE18:1 than the other methods but greater CE20:4 than the trypsin-EDTA method (p < 0.05 for all). Similar to human meibum, very long-chain CEs with carbon number (nc) ≥ 24 were detected in all samples and may serve as HMGEC lipid biomarkers. Further work is needed to address the absence of wax esters. Overall, the three harvesting methods are reasonably equivalent, though CM promotes much better efficiency and is recommended for higher throughput.

Impacts on product quality attributes of monoclonal antibodies produced in CHO cell bioreactor cultures during intentional mycoplasma contamination events.

A mycoplasma contamination event in a biomanufacturing facility can result in costly cleanups and potential drug shortages. Mycoplasma may survive in mammalian cell cultures with only subtle changes to the culture and penetrate the standard 0.2-µm filters used in the clarification of harvested cell culture fluid. Previously, we reported a study regarding the ability of Mycoplasma arginini to persist in a single-use, perfusion rocking bioreactor system containing a Chinese hamster ovary (CHO) DG44 cell line expressing a model monoclonal immunoglobulin G 1 (IgG1) antibody. Our previous work showed that M. arginini affects CHO cell growth profile, viability, nutrient consumption, oxygen use, and waste production at varying timepoints after M. arginini introduction to the culture. Careful evaluation of certain identified process parameters over time may be used to indicate mycoplasma contamination in CHO cell cultures in a bioreactor before detection from a traditional method. In this report, we studied the changes in the IgG1 product quality produced by CHO cells considered to be induced by the M. arginini contamination events. We observed changes in critical quality attributes correlated with the duration of contamination, including increased acidic charge variants and high mannose species, which were further modeled using principal component analysis to explore the relationships among M. arginini contamination, CHO cell growth and metabolites, and IgG1 product quality attributes. Finally, partial least square models using NIR spectral data were used to establish predictions of high levels (≥104 colony-forming unit [CFU/ml]) of M. arginini contamination, but prediction of levels below 104 CFU/ml were not reliable. Contamination of CHO cells with M. arginini resulted in significant reduction of antibody product quality, highlighting the importance of rapid microbiological testing and mycoplasma testing during particularly long upstream bioprocesses to ensure product safety and quality.

Elemental metal variance in cell culture raw materials for process risk profiling.

Elemental metals are critical raw material attributes which can impact cell culture performance and associated therapeutic protein product quality profiles. Metals such as copper and manganese act as cofactors and reagents for numerous metabolic pathways which govern cell growth, protein expression, and glycosylation, thus mandating elemental monitoring. The growing complexity of modern cell culture media formulations adds additional opportunities for elemental variance and its associated impact risks. This article describes an analytical technique applying inductively coupled plasma mass spectrometry to characterize a list of common raw materials and media powders used in mammalian cell culture and therapeutic protein production. We aim to describe a method qualification approach suitable for biopharmaceutical raw materials. Furthermore, we present detailed profiles of many common raw materials and discuss trends in raw material subtypes. Finally, a case study demonstrating the impact of an unexpected source of raw material variation is presented along with recommendations for raw material elemental risk profiling and control.

Standardized protocols for differentiation of THP-1 cells to macrophages with distinct M(IFNγ+LPS), M(IL-4) and M(IL-10) phenotypes.

In vitro models of differing macrophage functions are useful since human monocyte-derived macrophages are short-lived, finite and vary from donor to donor. Published protocols using the promonocytic cell line THP-1 have tended to result in cells that closely resemble classically-activated macrophages, differentiated in IFNγ and LPS. However, no protocol, to date, has fully recapitulated polarization of THP-1 to the M(IL-4) or M(IL-10) macrophage phenotypes seen when human monocyte-derived macrophages are exposed to each cytokine. Here we present protocols that can be used to prepare M(IL-4) polarized THP-1 that transcribe CCL17, CCL26, CD200R and MRC1 and M(IL-10) cells which transcribe CD163, C1QA and SEPP1. We show that the inhibitory Fcγ Receptor IIb is preferentially expressed on the surface of M(IL-4) cells, altering the balance of activating to inhibitory Fcγ Receptors. Adoption of standardized experimental conditions for macrophage polarization will make it easier to compare downstream effector functions of different macrophage polarization states, where the impact of PMA exposure is minimized and rest periods and cytokine exposure have been optimized.

Standardization of organoid culture for evaluation of melanogenesis induced by UVB, UVA and visible light

Abstract Background: Organoid cultures are primary cultures that maintain architectural characteristics and the relationships between cells, as well as the extracellular matrix. They are alternatives for pathophysiological or therapeutic investigation rather than animal and in vitro tests. Objective: Development of a cutaneous organoid culture model, aiming at the study of radiation-induced melanogenesis. Method: A validation study, which involved biopsies of the skin of the back of the adult ear. One sample was irradiated with different doses of UVB, UVA, or visible light (VL); the other was maintained in the dark for 72 h. The viability of the tissues was evaluated from the morphological and architectural parameters of the histology, and the expression of the glyceraldehyde-3-phosphate dehydrogenase (GAPDH) gene, by real-time polymerase chain reaction (PCR). The radiation-induced melanin pigmentation was standardized according to the doses of each radiation and evaluated by digital image analysis (Fontana-Masson). Results: The primary skin culture was standardized at room temperature using DMEM medium. The doses of UVB, UVA, and VL (blue light) that induced differential melanogenesis were: 166 mJ/cm2, 1.524 J/cm2, and 40 J/cm2. The expression of the GAPHD constitutional gene did not differ between the sample of skin processed immediately after tissue collection and the sample cultured for 72 h in the standardized protocol. Study limitations: This was a preliminary study that evaluated only the viability and integrity of the melanogenic system, and the effect of the radiation alone. Conclusions: The standardized model maintained viable melanocytic function for 72 h at room temperature, allowing the investigation of melanogenesis induced by different forms of radiation.