Wine Barrel Biofilm as a Source of Yeasts with Non-Conventional Properties.

This study investigated the main microbial groups characterizing the interior surface of oak barrels from different years (1890, 1895, 1920, 1975, 2008) used in the production of vino cotto. The yeasts were characterized for the following properties: γ-aminobutyric acid (GABA) production, antioxidant activity, air-liquid interfacial biofilm formation, and anthocyanin adsorption capacity. Community-level physiological profile analysis revealed that the microbial communities inside the barrels used the tested carbon sources in different manners. The following yeast species were identified: Millerozyma farinosa, Zygosaccharomyces bisporus, Wickerhamiella versatilis, Zygosaccharomyces bailii, Starmerella lactis-condensi, and Zygosaccharomyces rouxii. All the strains were able to produce GABA, and S. lactis-condensi, Z. bisporus and Z. rouxii were the highest producers (more than 600 mg/L). The Z. rouxii and Z. bailii strains showed the highest antioxidant activity. Only seven strains out of ten M. farinosa formed air-liquid interfacial biofilm. None of the M. farinosa strains adsorbed anthocyanins on their cell wall. The other strains adsorbed anthocyanins in a strain-dependent way, and the highest adsorption was observed for the W. versatilis strains. The yeasts isolated in this study could be used to increase the functional properties and the quality of fermented foods and beverages.

Contribution of Starmerella bacillaris and Oak Chips to Trebbiano d'Abruzzo Wine Volatile and Sensory Diversity.

In this study, six fermentation trials were carried out: co-inoculation and sequential inoculation of Saccharomyces cerevisiae and Starmerella bacillaris in the presence and absence of oak chips. Moreover, Starm. bacillaris strain was attached to the oak chips and co-inoculated or sequentially inoculated with S. cerevisiae. Wines fermented with Starm. bacillaris adhered to oak chips showed a higher concentration of glycerol (more than 6 g/L) than the others (about 5 g/L). These wines also showed a higher content of polyphenols (more than 300 g/L) than the others (about 200 g/L). The addition of oak chips induced an increase of yellow color (b* value of about 3). Oak-treated wines were characterized by a higher concentration of higher alcohols, esters and terpenes. Aldehydes, phenols and lactones were detected only in these wines, independently from the inoculation strategy. Significant differences (p < 0.05) were also observed in the sensory profiles. The fruity, toasty, astringency, and vanilla sensations were perceived as more intense in wines treated with oak chips. The white flower descriptor showed a higher score in wines fermented without chips. Oak surface-adhered Starm. bacillaris cells could be a good strategy to improve the volatile and sensory profile of Trebbiano d'Abruzzo wines.

Impact of Saccharomyces cerevisiae and non-Saccharomyces yeasts to improve traditional sparkling wines production.

In this study the effect of a co-inoculum of S. cerevisiae (F6789) with Torulaspora delbrueckii (TB1) or Starmerella bacillaris (SB48) on the oenological and aroma characteristics of sparkling wines obtained with the Champenoise method was investigated. The autolytic outcome and the sensory profile of sparkling wines were also evaluated. The secondary fermentations were completed by all mixed and single starter cultures with the only exception of those guided by Starm.bacillaris. Sparkling wines produced with S. cerevisiae F6789+Starm.bacillaris SB48 showed the highest amounts of glycerol (6.51 g/L). The best autolytic potential was observed in sparkling wines produced with +Starm.bacillaris (81.98 mg leucin/L) and S. cerevisiae+T. delbrueckii (79.03 mg leucin/L). The lowest value was observed for sparkling wines obtained with S. cerevisiae F6789 (53.96 mg leucin/L). Sparkling wines showed different aroma and sensory profiles. Esters were mainly present in sparkling wines obtained with S. cerevisiae F6789 (88.09 mg/L) followed by those obtained with S. cerevisiae+T. delbrueckii (87.20 mg/L), S. cerevisiae +Starm.bacillaris (81.93 mg/L). The content of esters decreased over time, and that might be related to the adsorption on lees and chemical hydrolysis. The highest concentrations of higher alcohols were found in sparkling wines produced with S. cerevisiae+T. delbrueckii (27.50 mg/L). Sparkling wines obtained with S. cerevisiae +Starm.bacillaris were well differentiated from the others due to their high score for the descriptor for spicy, bread crust, freshness and floral. Tailored strains with different autolytic potential might represent an interesting strategy to improve traditional sparkling wine production and favour their differentiation.

Impact of vineyard management on grape fungal community and Montepulciano d'Abruzzo wine quality.

In this study the effect of farming practices on the diversity of grape fungal community of Vitis vinifera L. cultivar Montepulciano and the microbial metabolic activity was investigated. Small-scale vinifications were performed and wines were characterized. Agronomic management system affected the fungal community composition. Hanseniaspora, Areobasidium and Botrytis genera represented 30%, 20% and 10% of the total reads in all samples. A. pullulans, and Cladosprium cladosporioides mainly occurred on organic and biodynamic grapes. Saccharomyces and Pseudopithomyces genera were present only on organic or biodynamic grapes, respectively. The agronomic managements also influenced the potential functionality of microbial community. In fact, the metabolic function was increased in organic and biodynamic grapes. Polymers were used only by organic and biodynamic microbial communities, which also showed the highest values of Shannon's diversity index, and substrate richness. However, no significative differences were observed for the oenological parameters analyzed, with the only exception of the content of sugars which were higher on conventional grapes. The fermentation profiles showed that conventional wines had a lower residual sugars content, and a higher amount of alcohol. The differences observed in the volatile composition of the wines were both quantitative and qualitative. Conventional wines showed a lower content of esters, and a higher concentration of alcohols than organic and biodynamic ones. Biodynamic wines were characterized by the highest content of organic acids. The obtained results revealed that farming practices shape the fungal community influencing wine traits linking the wine with the viti-vinicultural area of origin.

Promoting Candida zemplinina adhesion on oak chips: A strategy to enhance esters and glycerol content of Montepulciano d'Abruzzo organic wines.

In this study cell surface hydrophobicity and the ability to adhere on abiotic surfaces (polystyrene plates, stainless steel and oak chips) of 10 Candida zemplinina strains were assessed. Moreover, the impact of C. zemplinina cells adhered on oak surface on fermentation kinetics and volatile profile of Montepulciano d'Abruzzo organic wines was evaluated. All strains showed a hydrophobic nature with a certain affinity for the apolar solvents tested (hexadecane and decane). In agreement with this data strains were able to adhere on abiotic surfaces in a strain dependent way. On polystyrene plates all strains mainly grew as planktonic cells. On stainless steel surfaces sessile cells ranged from 2.6 Log CFU/mL (SB2) to 4.1 Log CFU/mL (SB8), while on oak chips were about 2 log higher ranging from 4.3 Log CFU/mL (SB8) to 6.1 Log CFU/mL (SB10). Candida zemplinina sessile state resulted in an increase of glycerol (from 6.98 g/L to 11.92 g/L) and esters amount (from 55.47 g/L to 91.5 mg/L), and a reduction of ethanol content (from 14.13% to 9.12% v/v). As for esters, methyl vanillate, ethyl isobutyrate, and ethyl isovalerate were present only when C. zemplinina was adhered on oak chips. This study revealed that changes of concentrations in esters and glycerol content reflected the fermentation bioactivity of yeast cells attached on oak chips. Surface-adhered behaviours should be considered in the improvement of strategies for the development of high-quality organic wines and eventually obtain novel wine styles.

Oenococcus oeni Lifestyle Modulates Wine Volatilome and Malolactic Fermentation Outcome.

In this study, nine Oenococcus oeni strains were tested for their ability to adhere to polystyrene using mMRS and wine as culture media. Moreover, planktonic and biofilm-detached cells were investigated for their influence on malic acid degradation kinetics and aroma compound production. Three strains were able to adhere on polystyrene plates in a strain-dependent way. In particular, MALOBACT-T1 and ISO359 strains mainly grew as planktonic cells, while the ISO360 strain was found prevalent in sessile state. The strain-dependent adhesion ability was confirmed by confocal laser scanning microscopy. Planktonic and biofilm detached cells showed a different metabolism. In fact, biofilm-detached cells had a better malic acid degradation kinetic and influenced the aroma composition of resulting wines, acting on the final concentration of esters, higher alcohols, and organic acids. Oenococcus oeni in biofilm lifestyle seems to be a suitable tool to improve malolactic fermentation outcome, and to contribute to wine aroma. The industrial-scale application of this strategy should be implemented to develop novel wine styles.

Adhesion Properties, Biofilm Forming Potential, and Susceptibility to Disinfectants of Contaminant Wine Yeasts.

In this study, yeasts isolated from filter membranes used for the quality control of bottled wines were identified and tested for their resistance to some cleaning agents and potassium metabisulphite, adhesion to polystyrene and stainless-steel surfaces, and formation of a thin round biofilm, referred to as a MAT. A total of 40 strains were identified by rRNA internal transcribed spacer (ITS) restriction analysis and sequence analysis of D1/D2 domain of 26S rRNA gene. Strains belong to Pichia manshurica (12), Pichia kudriavzevii (9), Pichia membranifaciens (1), Candida sojae (6), Candida parapsilosis (3), Candida sonorensis (1), Lodderomyces elongisporus (2), Sporopachydermia lactativora (3), and Clavispora lusitaniae (3) species. Regarding the adhesion properties, differences were observed among species. Yeasts preferred planktonic state when tested on polystyrene plates. On stainless-steel supports, adhered cells reached values of about 6 log CFU/mL. MAT structures were formed only by yeasts belonging to the Pichia genus. Yeast species showed different resistance to sanitizers, with peracetic acid being the most effective and active at low concentrations, with minimum inhibitory concentration (MIC) values ranging from 0.08% (v/v) to 1% (v/v). C. parapsilosis was the most sensible species. Data could be exploited to develop sustainable strategies to reduce wine contamination and establish tailored sanitizing procedures.

Impact of Saccharomyces cerevisiae strains on traditional sparkling wines production.

Sparkling wine fermentation is a challenge for yeasts due to the hostile conditions. A phenotype sought in starters is flocculation, because it reduces riddling time. For this reason, six flocculent Saccharomyces cerevisiae wine strains with different flocculation degree and autolytic activity and two commercial strains were tested for traditional sparkling wine production in a winery. Yeast viability, free aminoacids and high molecular weight nitrogen release and physico-chemical composition of sparkling wines were evaluated. Moreover, strains were tested for their aromatic potential. Obtained data revealed that flocculent yeasts presented oenological performances (in terms of fermentation rate, maximum pressure reached, free aminoacids - AAN and high molecular weight nitrogen - HMWN release) similar to the commercial strains. All considered strains were able to complete fermentation and viable cells of all strains were detected in all sparkling wines produced even after 6 months. F6789 and F10471 strains showed slow fermentation kinetics reaching the maximum of pressure at 180 days. Regarding nitrogen compounds release, FI strain was characterized by the highest amount of AAN and HMWN released, followed by F6789. Strains showed a considerable diversification in terms of number and amount of aroma molecules produced and sparkling wines obtained with autochthonous flocculent strains presented a higher amount of alcohols and esters already after 3 months. Further studies are necessary to select starter strains to improve traditional sparkling wines production.

Aroma Profile of Montepulciano d'Abruzzo Wine Fermented by Single and Co-culture Starters of Autochthonous Saccharomyces and Non-saccharomyces Yeasts.

Montepulciano d'Abruzzo is a native grape variety of Vitis vinifera L., grown in central Italy and used for production of high quality red wines. Limited studies have been carried out to improve its enological characteristics through the use of indigenous strains of Saccharomyces cerevisiae. The main objective of the present work was to test two indigenous strains of S. cerevisiae (SRS1, RT73), a strain of Starmerella bacillaris (STS12), one of Hanseniaspora uvarum (STS45) and a co-culture of S. cerevisiae (SRS1) and S. bacillaris (STS12), in an experimental cellar to evaluate their role in the sensory characteristic of Montepulciano d'Abruzzo wine. A S. cerevisiae commercial strain was used. Fermentations were conducted under routine Montepulciano d'Abruzzo wine production, in which the main variables were the yeast strains used for fermentation. Basic winemaking parameters, some key chemical analysis and aroma compounds were considered. S. cerevisiae strain dynamics during fermentation were determined by molecular methods. The musts inoculated with the co-culture were characterized by a faster fermentation start and a higher content of glycerol after 3 days of fermentation, as well as the musts added with strains S. bacillaris (STS12) and H. uvarum (STS45). At the end of fermentation the parameters studied were quite similar in all the wines. Total biogenic amines (BA) content of all the wines was low. Ethanolamine was the predominant BA, with a concentration ranging from 21 to 24 mg/l. Wines were characterized by esters and alcohols. In particular, 2-phenylethanol, 3-methylbut-1-yl methanoate, and ethyl ethanoate were the major aroma volatile compounds in all wines. Statistical analysis highlighted the different role played by aroma compounds in the differentiation of wines, even if it was impossible to select a single class of compounds as the most important for a specific yeast. The present study represents a further step toward the use of tailored autochthonous strains to impart the specific characteristics of a given wine which are an expression of a specific terroir.

Biodiversity of autolytic ability in flocculent Saccharomyces cerevisiae strains suitable for traditional sparkling wine fermentation.

Yeasts involved in secondary fermentation of traditional sparkling wines should show specific characteristics, such as flocculation capacity and autolysis. Recently it has been postulated that autophagy may contribute to the outcome of autolysis. In this study, 28 flocculent wine Saccahromyces cerevisiae strains characterized by different flocculation degrees were studied for their autolytic and autophagic activities. Autolysis was monitored in synthetic medium through the determination of amino acid nitrogen and total proteins released. At the same time, novel primer sets were developed to determine the expression of the genes ATG1, ATG17 and ATG29. Twelve strains were selected on the basis of their autolytic rate and ATG gene expressions in synthetic medium and were inoculated in a base wine. After 30, 60 and 180 days the autolytic process and ATG gene expressions were evaluated. The obtained data showed that autolysis and ATG gene expressions differed among strains and were independent of the degree of flocculation. This biodiversity could be exploited to select new starter stains to improve sparkling wine production. Copyright © 2016 John Wiley & Sons, Ltd.

Characterisation of brewpub beer carbohydrates using high performance anion exchange chromatography coupled with pulsed amperometric detection.

High performance anion exchange chromatography (HPAEC) coupled with pulsed amperometric detection (PAD) was optimised in order to quantify mannose, maltose, maltotriose, maltotetraose, maltopentaose, maltohexaose and maltoheptaose content of beer. The method allows the determination of above mentioned oligosaccharides, in a single chromatographic run, without any pre-treatment. Limit of detection and limit of quantification were suitable for beer. Accuracy and repeatability were good for the entire amount considered. Once optimised HPAEC PAD for the specific matrix, the second goal of this research was to verify the possibility to discriminate beers, depending on their style. The carbohydrates content of brewpub commercial beers was very variable, ranging from 19.3 to 1469mg/L (mannose), 34.5 to 2882mg/L (maltose), 141.9 to 20731mg/L (maltotriose), 168.5 to 7650mg/L (maltotetraose), 20.1 to 2537mg/L (maltopentaose), 22.9 to 3295mg/L (maltohexaose), 8.5 to 2492mg/L (maltoeptaose), even in the same style of beer. However, the carbohydrates content was useful, jointed with other compounds amount, to discriminate different styles of beer. As a matter of fact, principal component analysis put in evidence beer differences considering some fermentation conditions and colour.

Correlation between different clean-up methods and analytical techniques performances to detect Ochratoxin A in wine.

Three different clean-up methods and two analytical techniques were compared to determine Ochratoxin A (OTA) in wines. The first clean-up used a MycoSep column, the second an immunoaffinity column (IAC) and the third consisted in a liquid-liquid extraction (LLE) using dichloromethane in acid conditions. Meanwhile, two different OTA determination techniques were also evaluated: a HPLC analysis using a fluorescence detector and an enzyme-linked immunosorbent assays (ELISA) method. Correlations between clean-up methods and analytical techniques to determine OTA in wine were made evaluating linearity, accuracy and precision. Both the two first clean-up methods (solid-phase extraction, SPE) showed a good linear fit (r(2)=about 0.9999), followed by LLE. The use of immunoaffinity columns showed the best recoveries, even if also the SPE with MycoSep showed good recoveries while the LLE recoveries were the worst ones. The HPLC analysis showed good precision and accuracy, while ELISA method, even with a sufficient linearity, generally underestimated OTA content in wines.

Evaluation of the combined effects of enzymatic treatment and aging on lees on the aroma of wine from Bombino bianco grapes.

In this study, two different doses of commercial beta-glucanase enzyme preparation were tested to verify their effect on wines aged on lees. These wines were compared with two samples with no enzymatic treatment. The former was aged on lees (control), and the latter was readily filtered off from the yeast cell biomass (standard). Analysis of variance (one-way ANOVA), the Tukey test, and principal component analysis (PCA) were applied to all of the samples, which were analyzed for aroma composition, along with galacturonic acid, total acidity, pH, and color. Results showed a large number of statistically significant differences among samples. In general, wines treated with beta-glucanase were characterized by higher concentration of many volatile compounds. The presence of lees and even more the exogenous enzymatic action enhanced almost all volatile compounds. Besides the high presence of ethyl esters, it is worth mentioning the behavior of hexanol and trans-3-hexenol, which are strongly enhanced by the presence of lees and by enzymatic treatments.

Chemiluminescent determination of total antioxidant capacity during winemaking.

The total antioxidant capacity (TAC) of five different wines (four red and one white) was determined in five different steps of winemaking carried out in a commercial wine cellar by a chemiluminescence (CL) assay. The CL method is suitable to determine the antioxidant capacity of beverages, and preliminary trials showed that the TAC immediately after the bottle was opened was greater than the day after (about 25% decrease). Immediate analysis or a correct sample storage is therefore necessary. The wines were characterized by different levels of total phenolics and TAC: these differences were related to grape composition and winemaking technologies. The TAC values were the highest immediately after devatting. The TAC suffered the highest decrease (30-50%) after the clarification procedure, which may be due to the fining agents used and to oxygen contact, then remained more or less constant in the subsequent steps.

Analysis of wine phenolics by high-performance liquid chromatography using a monolithic type column.

A HPLC method involving direct injection was developed to determine phenolic compounds in wine. The separation was carried out on an RP C18 monolithic column using a binary gradient elution and diode array detection. In this way 17 monomeric compounds of different phenolic groups (hydroxybenzoic acids, hydroxycinnamic acids, hydroxycinnamyltartaric acids, flavanol, flavonol and stilbenes) could be separated and quantified in a single run and in a very short time.