Calcium cyanamide reduces methane and other trace gases during long-term storage of dairy cattle and fattening pig slurry.

Calcium cyanamide (CaCN2) has been used in agriculture for more than a century as a nitrogen fertilizer with nitrification inhibiting and pest-controlling characteristics. However, in this study, a completely new application area was investigated, as CaCN2 was used as a slurry additive to evaluate its effect on the emission of ammonia and greenhouse gases (GHG) consisting of methane, carbon dioxide, and nitrous oxide. Efficiently reducing these emissions is a key challenge facing the agriculture sector, as stored slurry is a major contributor to global GHG and ammonia emissions. Therefore, dairy cattle and fattening pig slurry was treated with either 300 mg kg-1 or 500 mg kg-1 cyanamide formulated in a low-nitrate CaCN2 product (Eminex®). The slurry was stripped with nitrogen gas to remove dissolved gases and then stored for 26 weeks, during which gas volume and concentration were measured. Suppression of methane production by CaCN2 began within 45 min after application and persisted until the storage end in all variants, except in the fattening pig slurry treated with 300 mg kg-1, in which the effect faded after 12 weeks, indicating that the effect is reversible. Furthermore, total GHG emissions decreased by 99% for dairy cattle treated with 300 and 500 mg kg-1 and by 81% and 99% for fattening pig, respectively. The underlying mechanism is related to CaCN2-induced inhibition of microbial degradation of volatile fatty acids (VFA) and its conversion to methane during methanogenesis. This increases the VFA concentration in the slurry, lowering its pH and thereby reducing ammonia emissions.

Acidification of slurry to reduce ammonia and methane emissions: Deployment of a retrofittable system in fattening pig barns.

Livestock farming, and in particular slurry management, is a major contributor to ammonia (NH3) and methane (CH4) emissions in Europe. Furthermore, reduced NH3 and CH4 emissions are also relevant in licensing procedures and the management of livestock buildings. Therefore, the aim is to keep emissions from the barn as low as possible. Acidification of slurry in the barn can reduce these environmental and climate-relevant emissions by a pH value of 5.5. In this study, an acidification technology was retrofitted in an existing fattening pig barn equipped with a partially slatted floor. The slurry in a compartment with 32 animals was acidified. An identical compartment was used for reference investigations (case-control approach). Several times a week slurry was pumped for acidification in a process tank outside the barn compartment in a central corridor, where sulphuric acid (H2SO4) was added. Then the slurry was pumped back into the barn. In contrast to other systems, where acidified slurry was stored mainly in external storage tanks, in this study the slurry was completely stored in the slurry channels under the slatted floor, during the entire fattening period. The emission mass flow of NH3 and CH4 was measured continuously over three fattening periods, with one period in spring and two periods in summer. On average 17.1 kg H2SO4 (96%) (m³ slurry)-1 were used for acidification during the three fattening periods. NH3 and CH4 emissions were reduced by 39 and 67%, respectively. The hydrogen sulphide (H2S) concentration in the barn air of the acidification compartment was harmlessly low (0.02 ppm). Thus, despite the storage of the acidified slurry in the barn, the system leads to a lower concentration of detrimental gases, which is beneficial for the animals' as well as for the workers' health. The study shows that it is possible to retrofit acidification technology into existing pig barns. Further investigations shall identify possible measures to reduce the amount of H2SO4 used and thus minimise the sulphur input into the slurry.

Dynamics of Different Buffer Systems in Slurries Based on Time and Temperature of Storage and Their Visualization by a New Mathematical Tool.

Slurry treatments such as acidification and alkalization have proven to be promising solutions to reduce gaseous emission produced by farm animals. The optimization of these technologies requires detailed knowledge of how and to what extent the buffer capacities in slurries will change during storage under the influence of different temperatures, as this may save resources needed to adjust a targeted pH value. Fresh slurries from dairy cows, fattening pigs and sows were collected and stored for 12 weeks under either cold (4.7 ± 1.1 °C) or warm (23.6 ± 2.1 °C) conditions to perform titrations in acidic and alkaline milieu at regular intervals. Based on these results, we successfully verified a new mathematical tool that we have developed to be able to calculate and visualize the most important buffer systems found in the analyzed slurries. Our experimental results showed a strong correlation between the degradation of the volatile fatty acid (VFA) buffer and the emergence of the carbonate buffers, i.e., the HCO3- and the CO32- buffer. Furthermore, a drop in the pH value caused by enhanced microbial production of VFAs can be mitigated by the presence of the NH3 buffer. In conclusion, we demonstrated that the buffers cannot be considered individually but must be interpreted as a complex and interacting system.

Kinetics evaluation of a semi-continuously fed anaerobic digester treating pig manure at two mesophilic temperatures.

Anaerobic digestion of animal waste at a low range of mesophilic conditions has not been well described to date. In this study, laboratory-scale semi-continuously fed anaerobic digesters treating pig manure were operated at 28 and 38 °C with organic loading rates ranging from 1.3 to 4.3 g ODM L(-1) d(-1). The estimated biomass yield was higher at 28 °C (0.065 g VSS g(-1) COD(removed)) than at 38 °C (0.016 g VSS g(-1) COD(removed)). The resulting calculated biomass concentration range at 28 and 38 °C was 1.2-2.4 and 0.3-0.6g VSS L(-1), respectively, which fitted well with a Michaelis-Menten type function. These VSS results are one or two orders of magnitude lower than previously reported for manure-fed digesters. Although maximum specific substrate utilisation rate at 38 °C is five-fold that at 28 °C, higher biomass yield in the digester at 28 °C seemed to compensate for the adverse effects of lower temperature on digester performance.

Performance evaluation of a completely stirred anaerobic reactor treating pig manure at a low range of mesophilic conditions.

Many Chinese biogas plants run in the lower range of mesophilic conditions. This study evaluated the performance of a completely stirred anaerobic reactor treating pig manure at different temperatures (20, 28 and 38°C). The start-up phase of the reactor at 20°C was very long and extremely poor performance was observed with increasing organic loading rate (OLR). At an OLR of 4.3g ODML(-1)d(-1), methane production at 28°C was comparable (3% less) with that at 38°C, but the risk of acidification was high at 28°C. At low OLR (1.3g ODML(-1)d(-1)), the biogas process appeared stable at 28°C and gave same methane yields as compared to the reactor operating at 38°C. The estimated sludge yield at 28°C was 0.065g VSSg(-1) CODremoved, which was higher than that at 38°C (0.016g VSSg(-1) CODremoved).

Thermal modelling of the completely stirred anaerobic reactor treating pig manure at low range of mesophilic conditions.

Most of Chinese middle size agricultural biogas plants run at the lower range of mesophilic conditions and low organic loading rates (OLRs) which result in the low biogas production. How to obtain an economically viable operation mode is a challenge for Chinese farm biogas plants. In this study, the performance of completely stirred anaerobic reactors treating pig manure was studied at 20, 28 and 38 °C. A thermal mathematic model was accordingly developed to decide the optimum digesting temperature and OLRs considering ambient temperature of 20, 10 and 0 °C. The regression surface model can fit well on the experimental data when the ambient temperature was around 10-20 °C, at which maximum net energy production (Np,max) can be achieved when the digesters run at OLR of 4.6-5.4 kgODM/m(3) d with temperature of above 26 °C. Co-digestion on the pig farm was suggested in winter in order to increase the Np.

Performance of different composting techniques in reducing oestrogens content in manure from livestock in a Vietnamese setting.

Steroid oestrogens (SE) are released by humans and animals into the environment. In the Mekong Delta animal excrement is directly discharged into surface water and can pollute the water. Only a few animal production sites are currently treating the excrement in either biogas plants or vermicomposting systems. The concentration of SE in manures from pigs and cattle was monitored in the Mekong Delta, Vietnam. Fresh cow faeces had an oestrogen concentration of 3.3 ng E2 eq/g dry weight. The SE concentration in effluent from biogas plants fed with animal manures was 341 ng E2 eq/L. Most of the SE were in the solid phase (77.9-98.7%). Vermicomposting reduced SE to 95% of the original input.

Greenhouse evaluation and environmental impact assessment of different urine-derived struvite fertilizers as phosphorus sources for plants.

A selection of six urine-derived struvite fertilizers generated by innovative precipitation technologies was assessed for their quality and their effectiveness as phosphorus sources for crops. Struvite purity was influenced by drying techniques and magnesium dosage. In a greenhouse experiment, the urine fertilizers led to biomass yields and phosphorus uptakes comparable to or higher than those induced by a commercial mineral fertilizer. Heavy metal concentrations of the different struvite fertilizers were below the threshold limits specified by the German Fertilizer and Sewage Sludge Regulations. The computed loading rates of heavy metals to agricultural land were also below the threshold limits decreed by the Federal Soil Protection Act. Urine-derived struvite contributed less to heavy metal inputs to farmland than other recycling products or commercial mineral and organic fertilizers. When combined with other soil conditioners, urine-derived struvite is an efficient fertilizer which covers the magnesium and more than half of the phosphorus demand of crops.

Solar thermal evaporation of human urine for nitrogen and phosphorus recovery in Vietnam.

A No Mix sanitation system was installed in a dormitory at the University of Can Tho in Vietnam, with the objective of recycling nutrients from source separated urine. This paper presents a pilot scale evaporation technology, and investigates the feasibility of recovering nitrogen and phosphorus from human urine by solar still for use as fertilizer. After 26 days of sun exposure, 360 g of solid fertilizer material was recovered from 50 L undiluted urine. This urine-derived fertilizer was mainly composed of sodium chloride, and had phosphorus and nitrogen contents of almost 2%. When tested with maize and ryegrass, the urine fertilizer led to biomass yields and phosphorus and nitrogen uptakes comparable to those induced by a commercial mineral fertilizer. Urine acidification with sulfuric or phosphoric acid prior treatment reduced nitrogen losses, improved the nutrient content of the generated fertilizers, and induced higher biomass yields and nitrogen and phosphorus uptakes than the commercial mineral fertilizer. However, acidification is not recommended in developing countries due to additional costs and handling risks. The fate of micropollutants and the possibility of separating sodium chloride from other beneficial nutrients require further investigation.

Short term effects of copper, sulfadiazine and difloxacin on the anaerobic digestion of pig manure at low organic loading rates.

Antibiotics of inorganic and organic origin in pig manure can inhibit the anaerobic process in biogas plants. The influence of three frequently used antibiotics, copper dosed as CuSO(4), sulfadiazine (SDZ), and difloxacin (DIF), on the anaerobic digestion process of pig manure was studied in semi-continuous experiments. Biogas production recovered after every Cu dosage up to a sum of 12.94g Cukg(-1) organic dry matter (ODM), probably due to Cu precipitation following the formation of sulphide from sulphate. Complete inhibition was found at the very high Cu concentration of 19.40g Cukg(-1) ODM. Inhibitory effect of SDZ and DIF was observed at concentrations as high as 2.70gkg(-1) ODM and 0.54gkg(-1) ODM, respectively. It seems very unlikely that the antibiotics tested would inhibit the anaerobic process in a full-scale biogas plant.

PCDD/F and dioxin-like PCB profiles in soils amended with sewage sludge, compost, farmyard manure, and mineral fertilizer since 1962.

BACKGROUND, AIM, AND SCOPE: Biowaste contains compounds of agricultural value such as organic carbon, nutrients, and trace elements and can partially replace mineral fertilizer (MIN) and improve the physical properties of the soil. However, the obvious benefits of land spreading need to be carefully evaluated against potential adverse effects on the environment and human health. Environmental contamination resulting from biowaste application is one of the key variables when assessing cost/benefits. This study provides data on the resulting concentration of polychlorinated dibenzodioxins and dibenzofurans (PCDD/Fs) and dioxin-like polychlorinated biphenyls (DL-PCBs) in the soil column as a result of the different types of fertilizers. MATERIALS AND METHODS: In a long-term field experiment established in 1962, we investigated the influence of the application of biowaste-derived fertilizers such as sewage sludge (SSL), compost (COM), and farmyard manure (FYM) to a luvisol derived from loess on the contents of PCDD/Fs and DL-PCBs. Control plots amended only with MIN served as a basis to compare the biowaste-amended soils with soils affected only by atmospheric deposition, thus experimentally separating the two pathways of soil contamination. Samples of the soil column down to a depth of 90 cm were taken in 2001 and analyzed for PCDD/Fs and dioxin-like PCBs according to US-EPA methods 1613 and 1668, respectively. RESULTS: Thirty-nine years of experimental SSL and COM applications exceeding four times the maximal amount as laid down in German legislation resulted in a doubling of the international toxicity equivalent (I-TEQ) budget for PCDD/Fs and a threefold increase for DL-PCBs as compared to test plots amended with MIN only. As compared to MIN, the application of FYM had no effect on the PCDD/F and PCB content in soil. The average contribution of the DL-PCBs to the WHO-TEQ was 19% in the MIN and FYM plots and somewhat higher in the COM (23%) and in the SSL (27%) plots. DISCUSSION: Although the test plots received four times the maximum application of SSL as laid down in the German SSL ordinance and the investigated region represents the upper end of the topsoil concentrations typically found in Germany, the soils treated with SSL and COM were still a factor of 4 below the German guideline value of PCDD/Fs for arable land. No enhancement of translocation of PCDD/Fs and PCBs into the corresponding subsoils due to the presence of dissolved humic matter or other surfactants potentially present in the biowaste was observed. The similarity of congener patterns in all soils, irrespective of the type of fertilizer applied, points towards atmospheric deposition of PCDD/Fs and DL-PCBs as the main intake route in the soils. The higher levels in the SSL- and COM-amended soils can be explained by the fact that both biowastes are subject to atmospheric deposition occurring at their origin. In the case of COM, it is accumulation in the foliage, while in the case of SSL, atmospheric particulate from wet and dry deposition is collected in the wastewater treatment system via urban runoff. CONCLUSIONS: It appears that the common practice of SSL applications in Germany does not pose a current threat to the agro-environment with regard to PCDD/Fs and DL-PCBs. However, time trend data on PCDD/Fs in SSL-amended soils will be needed to obtain a prognosis about the long-term effect of biowaste applications on soil quality.

Urine--a valuable fertilizer with low risk after storage in the tropics.

Urine contains a considerable amount of nutrients and potentially could be used as supplement commercial mineral fertilizer; however, it carries risk of contamination. The effect of urine storage as a simple treatment method was examined under tropical conditions. Initial concentrations of total coliforms (2.3 x 10(5) CFU/100 mL), E. coli (<1.0 x 10(4) CFU/100 mL), and Salmonella sp. were less than detection limit after four weeks. Open storage led to nitrogen losses of 90%, whereas closed storage containers retained 93% of total nitrogen. Under storage, the N:P ratio of 8:1 in fresh urine changed to 14:1 in the supernatant and to 1:12 in the precipitate, and 100% of magnesium and 96% of calcium was precipitated. A model showed that, depending on plant requirements, using the mixture of supernatant and precipitate as fertilizer for crops such as cassava was reasonable. To fertilize crops such as rice, however, additional P and K was needed. The nutrient-based flux of heavy metals to soils was negligible.

Transport of pharmaceuticals in columns of a wastewater-irrigated Mexican clay soil.

The irrigation or agricultural land with wastewater is increasingly practiced in many parts of the world as a consequence of growing populations and urbanization. The risks emerging from pharmaceuticals that are contained in wastewater for soils and groundwater have hardly been investigated. We studied leaching and effects of naproxen, ibuprofen, bezafibrate, diclofenac, gemfibrocil, clarithromycin, trimethoprim, clindamycin, erythromycin, and metoprolol in a soil column experiment simulating an irrigation event with 8.6 cm of wastewater containing 20 microg L(-1) or 2000 microg L(-1) of each compound or of erythromycin alone. The leached fraction of applied pharmaceuticals ranged from 0.1 +/- 0.1% (clarithromycin, 2000 microg L(-1)) to 130 +/- 41% (naproxen, 20 microg L(-1)) and tended to increase with decreasing K(d) or K(oc). Naproxen transport was similar to that of the tracer chloride. Ibuprofen was also hardly retarded (R = 1.20 +/- 0.18), but showed a higher degradation rate of 0.02 +/- 0.004 h(-1) (2000 microg L(-1)) than naproxen. The transport of a pulse of 2000 microg L(-1) of bezafibrate could be described with a retardation factor of 1.5 and a degradation rate of 0.033 h(-1). The application of erythromycin alone or of a cocktail of all pharmaceuticals significantly increased soil CO2 emissions by 50% 1 d after the application. There is a considerable risk that pharmaceuticals are leached to groundwater during wastewater irrigation.

Pathogens in septage in Vietnam.

Septage is widely acknowledged as a major source of infectious pathogens while disposal of septage, and the operation and maintenance of septic tanks, is not regulated in many developing countries. Twenty untreated septage and septage sludge samples were taken from Can Tho City, Vietnam to examine their pathogen content, and indicator micro-organisms. Escherichia coli and Enterococcus spp. were detected in all samples, regardless of sludge storage time. Phages were detected in 80% of samples. Salmonella spp. were detected in 70% of the untreated septage and 60% of septage sludge samples. Concentrations of phages and bacteria tested in septage sludge after many years of tank storage were much higher than the expected levels. Helminth ova were present in 95% of untreated septage samples with an average of 450 oval(-1), and were detected in all septage sludge samples with an average of 16,000 oval(-1). Twelve varieties of helminth ova were identified. More helminth ova varieties in higher concentrations were found in septage than those reported from stool samples. The varieties' frequency ranged from 10% to 50% and Ascaris lumbricoides predominated. Results show that pathogens and indicator micro-organisms, especially helminth ova, accumulate in sludge. Thus helminth ova should be considered when septage sludge is treated and used for agriculture. Proper health protection measures must be applied for people handling septage.

Ryegrass uptake of carbamazepine and ibuprofen applied by urine fertilization.

Human urine is a potential alternative fertilizer for agriculture. However, its usage is associated with a risk of spreading pharmaceutical residues to fields. The individual and combined behavior of carbamazepine and ibuprofen was investigated by GC/MS analysis in a greenhouse experiment using ryegrass fertilized with pharmaceutical-spiked urine. Only carbamazepine could be detected in soil, roots, and aerial plant parts. Fifty-three per cent of carbamazepine originally present in the urine was recovered in soil samples taken after three months. Additionally, 34% of carbamazepine was found in aerial plant parts and 0.3% in roots. Model calculations showed that neither roots nor Casparian strip posed a considerable barrier to uptake. Carbamazepine transport was clearly driven by transpiration. Ibuprofen was not detected in the soil or in any plant parts after three months. This was assumed to be due to biodegradation of ibuprofen. Carbamazepine and ibuprofen, singly or in combination, did not adversely affect the growth of ryegrass.

Hygienic effects and gas production of plastic bio-digesters under tropical conditions.

Plastic plug-flow bio-digesters have been promoted as a good option for improved treatment of manure and wastewater in developing countries although minimal information has been published on their hygienic status. This bench-scale study replicates bio-digester conditions to evaluate the reduction of pathogen and indicator microorganisms at three different hydraulic retention times (HRT) in the anaerobic treatment of pig manures at 30 degrees C for 50 days. Results showed that physicochemical values differed between HRTs. Gas production efficiency was better for longer HRTS. The accumulated sludge at the reactor's base increased with longer HRT. Phages and bacteria examined were reduced, but none was completely eliminated. Log10 reduction of bacteria ranged from 0.54 to 2.47. Phages ranged from 1.60 to 3.42. The reduction of organisms at HRT = 30 days was about one log10 unit higher than HRT = 15 days and about two log10 units higher than HRT = 3 days. The results indicate that the reduction of tested organisms increases with HRT. However the hygienic quality of the liquid effluent does not meet required quality values for surface and irrigation water. Longer HRTs are recommended to increase gas yield and achieve higher pathogen reduction. More barriers should be applied while handling bio-digester outputs to minimise risks to environmental and human health.

Fertiliser products from new sanitation systems: their potential values and risks.

The plant nutrients consumed in human society today are lost through the established wastewater treatment systems in industrialised countries as well as via insufficient or non-existent handling of sewage in the developing world. New sanitation systems have been designated to overcome this failure. The source separated wastewater streams collected within these systems contain a high nutrient content, and can be used as fertiliser as well as soil conditioner after appropriate storage and/or treatment. Application in agriculture with existing techniques is feasible. However, pathogens and pharmaceuticals contained in these fertiliser types are a potential hazard. Nevertheless, storage and appropriate treatment can minimise the risks. The products deriving from these systems have a high potential to preserve available plant nutrient resources and deficiencies in agriculture as well as being able to substitute synthetic plant nutrients and at the same time prevent unwanted environmental nutrient over-enrichment.