Phosphine-Free Aminocarbonylation Using Pd/DBU Catalyst: Carbonylative Coupling of Aryl Iodides and Amines.

An improved carbonylation method allowing amide bond formation between aryl iodides and aromatic amines is presented. In contrast to usual methods based on Pd catalysis, this method does not require a phosphine ligand. The catalyst system simply employs bis(dibenzylideneacetone)palladium (0.5 mol %) and DBU (10 mol %). The method was applied to the synthesis of various aromatic amides from aryl iodides and amines, and was scaled to gram order synthesis under as low as 1 atm of carbon monoxide.

New directions in radical carbonylation chemistry: combination with electron catalysis, photocatalysis and ring-opening.

Radical carbonylation offers potent methods for introducing carbon monoxide into organic molecules. This feature article focuses on our current efforts to develop new strategies for radical carbonylation, which include electron-transfer carbonylation, site-selective C(sp3)-H carbonylation by a photocatalyst and ring-opening carbonylation.

High-speed C-H chlorination of ethylene carbonate using a new photoflow setup.

We report the high-speed C-H chlorination of ethylene carbonate, which gives chloroethylene carbonate, a precursor to vinylene carbonate. A novel photoflow setup designed for a gas-liquid biphasic reaction turned out to be useful for the direct use of chlorine gas. The setup employed sloped channels so as to make the liquid phase thinner, ensuring a high surface-to-volume ratio. When ethylene carbonate was introduced to the reactor, the residence time was measured to be 15 or 30 s, depending on the slope of the reactor set at 15 or 5°, respectively. Such short time of exposition sufficed the photo C-H chlorination. The partial irradiation of the flow channels also sufficed for the C-H chlorination, which is consistent with the requirement of photoirradiation for the purpose of radical initiation. Near-complete selectivity for single chlorination required the low conversion of ethylene carbonate such as 9%, which was controlled by limited introduction of chlorine gas. At a higher conversion of ethylene carbonate such as 61%, the selectivity for monochlorinated ethylene carbonate over dichlorinated ethylene carbonate was 86%. We found that the substrate contamination with water negatively influenced the performance of the C-H chlorination.

Improved efficiency of photo-induced synthetic reactions enabled by advanced photo flow technologies.

In this article, we discuss how effective photo-induced organic reactions became when applied evolving photo flow technologies through our experiences over these two last decades. We started with the flow update of traditional [2 + 2] cycloaddition using Mikroglas Dwell device as a flow reactor and a compact light source, such as blacklight, instead of a high-pressure mercury lamp. Then we examined Barton nitrite reaction using a photo flow reactor consisting of stainless-steel channels and a quartz glass top provided by DNS. Again the use of blacklight was successful. However, the energy profile of these reactions was improved further by the use of LED lights. We used a photo-flow set-up, consisting of stainless steel engraved microchannels covered by a quartz top (MiChS L-1) and a sodium lamp, for the isomerization of a fulleroid to PCBM. Photo-redox-catalyzed alkene alkylation proceeded within a shortened reaction time when the same photo flow reactor and white LED were used instead of a batch reactor. Photo-induced reductive 5-exo-dig radical cyclization and reduction of alkenyl halides proceeded smoothly, thanks to the combination of a photo flow reactor and low-pressure Hg lamp. We also applied flow technologies for photo-bromination and chlorination of C-H bonds. Photocatalytic oxidation of benzyl alcohol by molecular oxygen became quick when high-power LED irradiation was employed.

Using High-Power UV-LED to Accelerate a Decatungstate-Anion-Catalyzed Reaction: A Model Study for the Quick Oxidation of Benzyl Alcohol to Benzoic Acid Using Molecular Oxygen.

High-power UV-LED irradiation (365 nm) effectively accelerated the decatungstate-anion-catalyzed oxidation of benzyl alcohol 1 to benzoic acid 3 via benzaldehyde 2. As the power of the UV-LED light increased, both the selectivity and yield of benzoic acid also increased. The reaction was finished within 1 h to give 3 in a 93% yield using 2 mol% of decatungstate anion catalyst. The combination of a flow photoreactor and high-power irradiation accelerated the oxidation reaction to an interval of only a few minutes.

Electron-Catalyzed Aminocarbonylation: Synthesis of α,ß-Unsaturated Amides from Alkenyl Iodides, CO, and Amines.

Aminocarbonylation of alkenyl iodides with CO and amines proceeded under heating to produce α,ß-unsaturated amides in good yields (23 examples, 71% average yield). This catalyst-free method exhibited good functional-group tolerance, and open a straightforward access to functionalized acrylamides, as illustrated by the synthesis of Ilepcimide. A hybrid radical/ionic mechanism involving chain electron transfer is proposed for this transformation.

Greener Synthesis of Pristane by Flow Dehydrative Hydrogenation of Allylic Alcohol Using a Packed-Bed Reactor Charged by Pd/C as a Single Catalyst.

Our previous work established a continuous-flow synthesis of pristane, which is a saturated branched alkane obtained from a Basking Shark. The dehydration of an allylic alcohol that is the key to a tetraene was carried out using a packed-bed reactor charged by an acid-silica catalyst (HO-SAS) and flow hydrogenation using molecular hydrogen via a Pd/C catalyst followed. The present work relies on the additional propensity of Pd/C to serve as an acid catalyst, which allows us to perform a flow synthesis of pristane from the aforementioned key allylic alcohol in the presence of molecular hydrogen using Pd/C as a single catalyst, which is applied to both dehydration and hydrogenation. The present one-column-two-reaction-flow system could eliminate the use of an acid catalyst such as HO-SAS and lead to a significant simplification of the production process.

Site-Selective Alkenylation of Unactivated C(sp3 )-H Bonds Mediated by Compact Sulfate Radical.

A broad variety of unactivated acyclic and alicyclic substrates cleanly undergo site-selective alkenylation of unactivated C(sp3 )-H bonds with 1,2-bis(phenylsulfonyl)ethene in the presence of persulfate. This simple transformation furnishes (E)-2-alkylvinylphenylsulfones in up to 88 % yield. In contrast with the previously reported decatungstate protocol, the current method is applicable to alkenylation of sterically hindered C-H bonds. This important advantage significantly broadens the substrate scope, and is attributed to the compact size of the sulfate radical employed in the C-H activation and cleavage.

Vicinal difunctionalization of alkenes by four-component radical cascade reaction of xanthogenates, alkenes, CO, and sulfonyl oxime ethers.

Four-component coupling reactions between xanthogenates, alkenes, CO, and sulfonyl oxime ethers were studied. In the presence of hexabutylditin, working as a propagating radical reagent, the chain reaction proceeds, as expected, taking into account reagents polarities, affording the corresponding functionalized α-keto oximes. Although yields are modest, this rare one-pot four-component process is easy to carry out and the resulting compounds, bearing multiple functionalities, have the potential for further elaboration.

Synthesis of 4,4-Difluoroalkenes by Coupling of α-Substituted α,α-Difluoromethyl Halides with Allyl Sulfones under Photoredox Catalyzed Conditions.

Photoredox-catalyzed allylation of α-gem-difluorinated organohalides with allyl sulfones proceeded smoothly under visible light irradiation to give 4,4-difluoroalkenes in good yields. In the presence of catalytic Ru(bpy)3Cl2, Hantzsch ester, and diisopropylethylamine, the reaction was complete within 2 h. Using the same methodology, three-component cascade reactions to give 6,6-difluoroalkenes were carried out successfully.

Carbonylation of Alkyl Radicals Derived from Organosilicates through Visible-Light Photoredox Catalysis.

Primary, secondary, and tertiary alkyl radicals formed by the photocatalyzed oxidation of organosilicates underwent efficient carbonylation with carbon monoxide (CO) to give a variety of unsymmetrical ketones. This study introduces the possibility of radical carbonylation under a photooxidative regime.

Synthesis of perinaphthenones through rhodium-catalyzed dehydrative annulation of 1-naphthoic acids with alkynes.

An efficient approach to the synthesis of perinaphthenones via the rhodium-catalyzed dehydrative annulation of 1-naphthoic acids with internal alkynes was developed. Norbornadiene can act as an acetylene equivalent to give unsubstituted perinaphthenones at the 2- and 3-positions via dehydrative annulation followed by a retro Diels-Alder reaction.

Applications of Radical Carbonylation and Amine Addition Chemistry: 1,4-Hydrogen Transfer of 1-Hydroxylallyl Radicals.

1,4-Hydrogen transfer from the 1-hydroxyallyl radical to give the enoxyl (α-keto) radical is an exothermic process with a high activation energy based on DFT calculations. The lack of experimental examples of such 1,4-H shift reactions lies in the difficulty of generating the 1-hydroxyallyl radical. We have shown that radical carbonylation of alkenyl radicals with CO followed by nucleophilic trapping of the carbonyl portion of the resulting radical by amines gives rise to 1-amino-substituted 1-hydroxyallyl radicals in situ. At the outset of this chemistry, we examined intramolecular trapping reactions via radical carbonylation of alkynylamines mediated by tributyltin hydride. Consequently, α-methylene lactams were obtained, for which the initially formed 1-amino-substituted 1-hydroxyallyl radical underwent a 1,4-H shift followed by subsequent ß-scission, which led to the expulsion of a tributyltin radical. A competing pathway of the 1,4-H shift of 1-amino-substituted 1-hydroxyallyl radicals involving hydrogen abstraction was observed, which led to the formation of α-stannylmethylene lactams as a major byproduct. However, in contrast, when intermolecular trapping of α-ketenyl radicals by amines was carried out, the 1,4-H shift from the 1-amino-substituted 1-hydroxyallyl radical became the major pathway, which gave good yields of α,ß-unsaturated amides. Thus, we were able to develop three-component reactions comprising terminal alkynes, CO, and amines that led to α,ß-unsaturated amides via the 1,4-H shift reaction. DFT calculations support the observation that the 1,4-H shift is more facile when 1-hydroxyallyl radicals have both 1-amino and 3-tin substituents. The choice of substituents on the amine nitrogen is also important, since N-C bond cleavage via an SH2-type reaction can become a competing pathway. Such an unusual SH2-type reaction at the amine nitrogen is favored when the leaving alkyl radicals are stable, such as PhC(•)H(CH3) and t-Bu•. Interestingly, even nucleophilic attack of tertiary amines onto α-ketenyl radicals causes cleavage of the C-N bond. For this reaction, DFT calculations predict an indirect homolytic substitution mechanism involving expulsion of alkyl radicals through the zwitterionic radical intermediate arising from nucleophilic amine addition onto the α-ketenyl radical. In contrast, the carbonylation of aryl radicals, generated from aryl iodides, in the presence of amines gave aromatic carboxylic amides in good yields. It is proposed that radical anions originating from acyl radicals and amines undergo electron transfer to aryl iodides to give aminocarbonylation products.

Electron transfer-induced reduction of organic halides with amines.

Reduction of a variety of organo halides was examined by using amines as a sacrificial hydrogen source. UV light-induced reduction of vinyl and aryl halides with triethylamine proceeded smoothly to give the corresponding reduced products. High temperature heating also caused the reduction and DABCO (1,4-diazabicyclo[2.2.2]octane) also served as a good reducing reagent.

Photocatalyzed Site-Selective C(sp3)-H Functionalization of Alkylpyridines at Non-Benzylic Positions.

Tetrabutylammonium decatungstate (TBADT)-photocatalyzed C-H functionalization of alkylpyridines was investigated. Unlike alkylbenzene counterparts, alkylation of α-C-H bonds did not proceed for the reaction of 2- and 4-alkylpyridines and reluctantly proceeded for 3-alkylpyridines, which allow site-selective C(sp3)-H functionalization at nonbenzylic positions. The observed nonbenzylic site selectivities are rationalized by the polar inductive effects of pyridyl groups in the SH2 transition states. Consecutive γ-functionalization and α-bromofunctionalization were successfully carried out in selected cases.

Bromoallylation of Alkenes Leading to 4-Alkenyl Bromides Based on Trapping of ß-Bromoalkyl Radicals.

A radical-chain addition of allyl bromides to aryl alkenes, vinyl ester, and vinyl phthalimide was studied in which elusive ß-bromoalkyl radicals were trapped efficiently to give 5-bromo-1-pentenes in good to high yields (16 examples). A subsequent carbonylative radical cyclization with AIBN/Bu3SnH/CO was successful in giving the corresponding 3,5-disubstituted cyclohexanone derivatives in moderate yields. Synthesis of a piperidine ring was also successful by subsequent reaction with primary amine.

Cooperative Polar/Steric Strategy in Achieving Site-Selective Photocatalyzed C(sp3 )-H Functionalization.

Synergistic control over the SH 2 transition states of hydrogen abstraction exploiting polar and steric effects provides a promising cooperative strategy for site-selective C(sp3 )-H functionalization using decatungstate anion photocatalysis. By using this photocatalytic approach, the C-H bonds of substituted lactones and cyclic ketones were functionalized selectively. In the remarkable case of 2-isoamyl 4-tert-butyl cyclohexanone (1 t) bearing five methyl, five methylene, and three methine C-H bonds, one methine C-H bond in the isoamyl tether was selectively functionalized.

Photoredox-Catalyzed Hydrodifluoroalkylation of Alkenes Using Difluorohaloalkyl Compounds and a Hantzsch Ester.

Photoredox-catalyzed hydrodifluoroalkylation of alkenes proceeded smoothly in the presence of a Hantzsch ester as a hydrogen source under visible light irradiation. The reaction was also applicable to the hydrodifluoroalkylation of alkynes, and a continuous photo flow reaction was also successful.

Versatile cross-dehydrogenative coupling of heteroaromatics and hydrogen donors via decatungstate photocatalysis.

A facile sunlight-induced derivatization of heteroaromatics via photocatalyzed C-H functionalization in amides, ethers, alkanes and aldehydes is described. Tetrabutylammonium decatungstate (TBADT) was used as the photocatalyst and allowed to carry out the process under mild conditions.

Formal Total Synthesis of l-Ossamine via Decarboxylative Functionalization Using Visible-Light-Mediated Photoredox Catalysis in a Flow System.

A formal total synthesis of l-ossamine was achieved. The key feature of the synthesis was the decarboxylative functionalization of a threonine derivative using visible-light-mediated photoredox catalysis. This reaction was implemented in a flow reactor, allowing for the efficient conversion to the desired product.