Effects of the in ovo injection of an Escherichia coli vaccine on the hatchability and quality characteristics of commercial layer hatchlings.

In the commercial egg industry, avian pathogenic Escherichia coli (APEC) can lead to significant economic loss. The Poulvac E. coli vaccine (PECV) is a commercially available attenuated live vaccine commonly applied via spray or drinking water to protect against losses associated with colibacillosis. The PECV has not been tested in layer hatching eggs using in ovo injection. Therefore, the purpose of this experiment was to determine the effects of injecting 50 µL of different doses of the PECV into Hy-Line W-36-layer hatching eggs on the hatchability and quality characteristics of hatchlings. At 18 d of incubation (DOI), treatments included 1 noninjected and 1 diluent-injected control. Furthermore, PECV treatments included a full dose (4.4 × 108E. coli CFU) or serial dilutions of the full dose to produce 4.4 × 106, 4.4 × 104, or 4.4 × 102 CFU doses of E. coli. In ovo injections targeted the amnion. Percent hatchability of live embryonated eggs (HI), percent residue eggs, hatchling mortality, and female chick whole and yolk-free BW, relative yolk sac weight, and body length were among the variables examined. Treatment significantly (P < 0.0001) affected HI, with HI being highest in the control groups (97.3% in the noninjected and 94.2% in the diluent-injected), and with HI values being 89.0, 88.9, 84.4, and 71.2% in the 4.4 × 102, 4.4 × 104, 4.4 × 106, and 4.4 × 108 CFU E. coli dose treatments, respectively. The percentage of live embryos that did not complete hatch but that pipped internally (P = 0.024) or externally (P < 0.0001) were significantly affected by treatment, with percentages being highest in the 4.4 × 108 CFU treatment. Female chick body length was significantly (P < 0.0001) affected by treatment and was longer in both control groups and in the 1 × 102 CFU E. coli treatment in comparison to all other treatments. Yolk-free female chick BW was significantly (P = 0.034) affected by treatment and was lower in the 4.4 × 106 CFU and 4.4 × 108 CFU treatments when compared to the diluent-injected control group. An increase in the E. coli concentration administered in the amnion of embryonated layer hatching eggs at 18 DOI decreased hatch success and female chick yolk-free BW and body length.

Utilizing in ovo telemetry to examine the effects of reduced incubation temperature on broiler embryo temperature and subsequent hatchability.

The current commercial broiler embryo experiences a rapid metabolism and growth rate and may produce more heat than those of the past. Consequently, it may be beneficial to lower standard incubation temperature for commercial broiler hatching eggs. The purpose of this experiment was to determine if lowering incubation temperature at 12 d of incubation (DOI) would affect embryo temperature (ET) in embryonated Ross 708 broiler hatching eggs. From 0 to 12 DOI, eggs were incubated under standard conditions (37.50°C dry bulb, 29.76°C wet bulb). At 12 DOI, temperature transponders were aseptically placed on the inner air cell membrane to measure air cell temperature (ACT) as an estimate of ET in 120 eggs. The eggs were then randomly assigned to 4 separate still-air incubators, each containing 30 eggs. Two replicate incubators were maintained at a standard (STRT; 37.5°C) or low (LTRT; 35.6°C) temperature treatment between 12 and 21 DOI. A significant positive correlation existed between incubator air temperature (IAT) and ACT across temperature treatment and in the STRT. However, IAT was not significantly correlated with ACT in the LTRT. A significantly higher ACT was observed in the STRT than in the LTRT for 88% of the readings taken between 12 and 21 DOI. Percent egg weight loss (PEWL) between 13 and 17 DOI did not significantly differ between temperature treatments. From 13 to 17 DOI, there was a significant positive correlation between PEWL and ACT in the STRT, however, no significant correlation occurred between PEWL and ACT in the LTRT. Percent hatch of fertile eggs containing live embryos at 12 DOI was 93.3% in the STRT and 100% in the LTRT. However, time of hatch occurred 14 to 19 h later and hatchling BW was lower in the LTRT than in the STRT. Although lowering IAT at 12 DOI may improve hatchability, an associated delay in hatch and a decrease in hatchling BW may not be commercially acceptable.

The role of packaging on the flavor of fluid milk.

Few studies have addressed the effects of package material in the absence of light on contributions to fluid milk flavor. The objective of this study was to compare the sensory and chemical properties of fluid milk packaged in paperboard cartons, low-density polyethylene, high-density polyethylene (HDPE), polyethylene terephthalate (PET), linear low-density polyethylene (LLDPE), and glass. Pasteurized (high temperature short time, 77°C for 25 s) skim and whole milk were filled (280 mL ± 10 mL) into paperboard cartons, low-density polyethylene, HDPE, PET, LLDPE, and glass (control). Milks were stored at 4°C in the dark and sampled at d 0, 5, 10, and 15. Descriptive analysis was applied to document sensory profiles at each time point, and volatile compounds were extracted and identified by solid-phase microextraction with gas chromatography mass spectrometry and gas chromatography-olfactometry. Tetrad tests with consumers were conducted at d 10. Both skim and whole milks packaged in cartons had noticeable paperboard flavor by d 5 and higher levels of hexanal than skim and whole milks in other package types at d 5. Skim milks packaged in paperboard cartons and LLDPE had distinct refrigerator/stale flavor compared with milks in the other package types, concurrent with increased levels of refrigerator/package-related compounds including styrene, acetophenone and 2-ethyl-1-hexanol. Milks packaged in glass, PET and HDPE were not distinguished by consumers at d 10 post-processing. Package type influences fluid milk flavor, and these effects are greater in skim milk compared with whole milk. Paperboard cartons do not preserve milk freshness, as well as PET, HDPE, or glass, due to flavor migration and scalping. Glass remains an ideal barrier to preserve fluid milk flavor, but in the absence of light, HDPE and PET provide additional benefits while also maintaining fluid milk flavor.

Consumer perception of dried dairy ingredients: Healthy, natural, and sustainable?

Conscious consumerism is growing, along with consumer demand for socially conscious dairy products or dairy alternatives. To successfully position dairy products (especially conventional dairy) in this changing marketplace, dairy producers and processors must understand how to strategically use both on- and off-package messaging aligned with consumer perceptions. However, consumer perception of attributes such as sustainable, natural, and healthy is complex, and varies between product categories as well as among products within a category. The objective of this study was to characterize consumer definitions of the terms "sustainable," "natural," and "healthy" as they pertain to dried dairy ingredients. To meet this objective, we conducted an online survey with 3 maximum difference scaling exercises to determine the importance of 63 label claims to consumer definitions of the terms sustainable, natural, and healthy. The role of priming with dried ingredient processing information on consumer perception of these terms was also explored. Within the dried dairy ingredients category, there is extensive cognitive overlap between the terms sustainable, natural, and healthy. Priming did not affect consumer definitions of any of these terms. Certification-related claims were considered among the least important claims for consumer definitions of sustainable, natural, and healthy, whereas claims that were simple to read and visualize were considered among the most important. Claims related to animal welfare and happiness or simple, minimal ingredients and processing were considered by consumers to be important for all 3 terms. For each of these terms, there was a cluster of consumers who defined the term primarily by simple ingredients and minimal processing, and another cluster who defined the term primarily by happy cows and conscious farming practices. The terms sustainable and healthy each had a third, unique consumer cluster. This third definition cluster defined sustainability primarily by environmental effects, whereas this cluster defined healthy primarily in fitness and nutrition terms. Age and to a lesser extent, gender, affected importance placed on these 3 terms and also affected definition of the term. Understanding these consumer definitions provides insight on how to formulate marketing and educational messaging to speak to each consumer segment.

Research Note: Effects of the in ovo injection of organic zinc, manganese, and copper and posthatch holding time before placement on broiler body temperature during grow out.

Effects of the in ovo injection of organic microminerals (OM) (zinc, manganese, and copper) and posthatch holding time (HT) on the daily body temperature (bt) of broilers during grow out were determined. The hatching eggs from a Ross 708 breeder flock at 32 wk of age were incubated under standard commercial conditions. At 17 d of incubation, eggs were randomly allocated to 3 in ovo OM injection treatment (TRT) groups, and at 21 d of incubation, male hatchlings were randomly allocated to 2 posthatch HT treatment groups. Eggs were either not injected or were in ovo injected with diluent only or diluent containing the OM mixture. A 0-hour HT group had immediate access to water and feed, and a 24-hour HT (24HT) group contained birds that were kept in transport baskets in their pens without access to feed and water for 24 h before being released. Fifteen male birds were placed in each of 36 litter floor pens in a temperature-controlled facility. Approximately 2 birds in each of 6 replicate pens belonging to each TRT-HT combination had temperature transponders inserted subcutaneous in the mid-dorsal region of the neck. All birds were brooded under standard commercial conditions and had ad libitum access to feed and water after their respective HT. The bt of the same birds were determined daily at the same time each day beginning at hatch and ending on 39 d of posthatch age (AGE). There were no significant main or interactive effects involving TRT or HT for bt. However, there was a significant (P ≤ 0.0001) main effect because of AGE. A general increase in bt occurred during the 39 d grow out period. At hatch, bt was 40.54 ± 0.056°C and at AGE 39 was 41.46 ± 0.055°C. Under standard brooding conditions, a general increase in bt occurred in the Ross 708 broilers. However, these birds did not exhibit a significant bt response to TRT or a 24HT before placement.

Consumer perception of the sustainability of dairy products and plant-based dairy alternatives.

Plant-based dairy alternative beverage sales have increased in recent years. Plant-based dairy alternatives often advertise on a platform of sustainability and environmental commitment. To successfully position and market dairy products in this competitive environment, dairy companies must understand the consumer definition of and importance placed on sustainability, as well as communicate sustainability information effectively. The objective of this study was to characterize consumer perception of the sustainability of milk and dried dairy ingredients and their respective plant-based alternatives. Focus groups and 2 online surveys were conducted. In the first survey, maximum difference scaling was used to rank the importance of specific dairy product attributes to sustainability, along with an exercise in which respondents selected whether a fluid milk or protein powder product was sustainable. A follow-up survey included 2 exercises in which respondents selected whether generic dairy products or dried dairy ingredients were sustainable, natural, healthy, trustworthy, or ethical. Over half of dairy product consumers reported that they looked for sustainability-related information. Consumers who purchased both plant-based dairy alternative and dairy products placed a higher self-reported importance on sustainability than those who purchased dairy products only. Focus group and survey maximum difference scaling results identified 5 key attributes for sustainability: minimal carbon footprint/greenhouse gas emissions, few/no preservatives, animal happiness and welfare, and simple/minimal ingredients. Plant-based dairy alternatives followed by fluid milk and protein powders were considered more sustainable than dairy products, but package type and organic status also played a role in consumer sustainability perception. Product labels were the most common source of sustainability information, although consumers also sought information on websites affiliated and unaffiliated with dairy companies. There was cognitive overlap among the terms sustainable, natural, healthy, ethical, and trustworthy as they relate to dairy products, but consumers used the terms distinctly. Consumers perceived differences in these terms between general categories of dairy as well as among products in a specific dairy category. Dairy companies may be able to differentiate themselves by helping consumers make these choices by simplifying sustainability-related messaging and by maintaining open, transparent communication regarding sustainability.

Effects of dietary Original XPC on selected blood variables in layer pullets challenged with Mycoplasma gallisepticum,.

Effects of dietary Original XPC (XPC) on 17 selected blood variables in commercial layer pullets challenged with the virulent, low-passage R strain of Mycoplasma gallisepticum (RlowMG) were investigated. Hy-Line W-36 pullets sourced from M. gallisepticum-clean layer breeders were fed a basal diet with XPC (1.25 kg/metric ton) or without from hatch until 12 wk of age (woa). At 8 and 10 woa, half of the birds in each dietary treatment were challenged with RlowMG. Blood samples were taken immediately before the initial RlowMG challenge at 8 woa and again at 12 woa (4 wk after challenge). At 8 woa, blood pH was lower and glucose concentration was higher in the preassigned challenge treatment groups. At 12 woa, the concentration of oxygen dissolved in the blood was significantly lower in the RlowMG-challenged group than the unchallenged group of birds regardless of dietary treatment. The RlowMG challenge significantly increased blood carbon dioxide partial pressure, calcium, sodium, anion gap, osmolality, glucose, and corticosterone levels but significantly decreased blood oxygen partial pressure, oxyhemoglobin concentration, concentration of oxygen dissolved in the blood, chloride, and pH levels. Because blood pH and glucose concentration at 8 woa were examined before challenge, their baseline values were biased with respect to challenge treatment before treatment was applied. However, the lack of a significant main effect due to diet at 8 woa for blood pH and glucose concentration, along with the other 15 blood variables, indicate that the baseline data with respect to dietary treatment were unbiased, allowing for real dietary effects to be accurately assessed. In conclusion, layer pullets challenged with RlowMG undergo a stress response associated with changes in various physiological blood variables, and a decrease in pH and increase in carbon dioxide partial pressure, in association with a lack of change in bicarbonate, indicates that the stress response caused by the RlowMG challenge was associated with respiratory acidosis. Nevertheless, feeding XPC did not influence the effects of challenge treatment on these postchallenge physiological blood values.

Growth and humoral immune effects of dietary Original XPC in layer pullets challenged with Mycoplasma gallisepticum.

Effects of dietary Original XPC (XPC) in commercial layer pullets challenged with the virulent, low passage R strain of Mycoplasma gallisepticum (Rlow MG) were investigated. Hy-Line W-36 pullets sourced from MG-clean breeders were fed a basal diet with or without (CON) XPC (1.25 kg/metric ton) from hatch until 12 wk of age (woa). At 8 and 10 woa, half of the birds in each dietary treatment were challenged with Rlow MG. Body weight was recorded at 3, 8, and 12 woa, and ovary, ceca, and bursa weights were recorded at 3 and 12 woa. Blood samples were taken immediately before the initial Rlow MG challenge at 8 woa and again at 12 woa to test for IgM and IgG antibody production against MG. All birds were evaluated for MG lesion scores at 12 woa. Regardless of challenge, inclusion of XPC in the diet did not significantly alter BW at 3 or 8 woa or relative organ weights at 3 or 12 woa. However, at 12 woa, BW of XPC-fed birds, regardless of challenge was significantly (P = 0.0038) heavier than CON by 25.7 g. All birds tested negative for MG antibodies before the 8 woa challenge. Respective percentage serum plate agglutination and ELISA positive birds at 12 woa were 0 and 0% (CON, nonchallenged), 1.4 and 0% (XPC, nonchallenged), 100 and 47.2% (CON, challenged), and 100 and 50.0% (XPC, challenged). Diet did not significantly affect ELISA titers, but they were significantly (P < 0.0001) increased due to challenge. Furthermore, lesion scores were significantly higher for Rlow MG-challenged birds (P = 0.0012), and dietary treatment with XPC in challenged birds numerically reduced MG lesion scores from 0.278 to 0.194. In conclusion, although dietary XPC did not significantly alter the humoral immune response, antibody titer levels, or severity of MG lesions in layer pullets that were or were not challenged with Rlow MG, it led to an increase in their rate of growth through 12 woa.

Role of sweeteners on temporality and bar hardening of protein bars.

Protein bars are one product that meet consumer demands for a low-carbohydrate, high-protein food. With such a large market for protein bars, producers need to find the correct texture and sweetness levels to satisfy consumers while still delivering a high-protein, low-carbohydrate bar. In the bar industry, bar hardening is a major concern, and currently the effects of non-nutritive sweeteners on bar hardening is unknown. Due to the negative implications of bar hardening, it is important to investigate the sweetener-protein relationship with bar hardening. The objective of this study was to characterize the effects of sweetener and protein source on flavor, texture, and shelf life of high-protein, low-carbohydrate bars. The iso-sweet concentration of sweeteners (sucralose, sucrose, monk fruit, stevia, and fructose) in pea protein (PP), milk protein (MP) and whey protein isolate (WPI) bars were established using magnitude estimation scaling and 2-alternative forced-choice testing. Descriptive analysis and temporal check-all-that-apply methods were then applied to determine flavor and temporal differences between the protein bars. Finally, an accelerated shelf life study was completed to understand how sweetener and protein types affect the shelf life of protein bars. The 15 protein bars formulated at iso-sweet concentration were all stored at 35°C and 55% humidity for 35 d, and measurements were taken every 7 d, beginning at d 1 (d 1, 7, 14, 21, 28, and 35). Bars made with MP required significantly less sweetener, compared with PP and WPI, to reach equal sweetness. Bars sweetened with stevia or monk fruit had distinct bitter and metallic tastes, and sucralose had a low metallic taste. Bars made with WPI were the most cohesive, and PP and WPI bars were more bitter and metallic compared with MP bars. Bars made with WPI and fructose were initially the hardest, but after d 14 they scored at parity with PP sucrose. There were no significant differences among bars in terms of hardness by d 21. Bars made with WPI were consistently denser at all time points than bars made with PP or MP. Bars made with PP were the driest and least cohesive and had the fastest rate of breakdown in the study. Non-nutritive sweeteners did not have a negative effect on bar hardness in low-carbohydrate, high-protein bars. Findings from this study can be applied to commercially produced protein bars for naturally sweetened bars with different protein types without negative effects on protein bar texture.

Comparative effects of in ovo versus subcutaneous administration of the Marek's disease vaccine and pre-placement holding time on the intestinal villus to crypt ratios of Ross 708 broilers during early post-hatch development1,2,3.

Villus to crypt ratio (VCR) is used to quantify the microanatomical response of the intestine to various treatments. In early age chickens, comparative effects of the in ovo (i.o.) and s.c. methods of administration (moa) of the Marek's disease (MD) vaccine on 2 types of measurement of small intestinal VCR at 0 and 4 h post-hatch (poh) were investigated. The effects of moa and 4 and 18 h pre-placement holding times (pht) on the VCR measurements at 168 h (7 d) poh were also investigated. In the jejunum of the small intestine, a standard method for VCR determination, based on 10 villus and crypt length measurements, was utilized for the calculation of villus to crypt length ratio (VCLR). In that same region, a single histomorphometric determination of the crypt and total mucosa areas using image analysis software was also used. Subtraction of the crypt area from the total mucosa area provided the villus area, allowing for calculation of the villus to crypt area ratio (VCAR). Across 0, 4, and 18 h of poh bird age, the VCLR of birds that received an s.c. vaccination was higher in comparison to that of those that received an i.o. vaccination. The highest and lowest VCAR values were observed in the s.c. treatment at 0 h poh and in the i.o. treatment at 4 h poh, respectively. Furthermore, at 168 h poh, VCLR values in the 18 h pht and s.c. vaccination group were higher than those in the 4 h pht and s.c. vaccination or 18 h and i.o. vaccination groups. In conclusion, the effects of pht and MD vaccine moa on VCR were dependent on the use of either the VCLR or VCAR method of measurement. However, regardless of method, s.c. injection overall led to a higher VCR through 4 h poh in Ross 708 broilers, and the effects of moa on VCLR at 168 h were influenced by pht.

Effects of in ovo injection of different doses of coccidiosis vaccine and turn-out times on broiler performance,.

Inovocox EM1 vaccine (EM1) is hatchery-applied via in ovo injection for the control of coccidiosis in broiler chickens. Effects of 3 in ovo injection treatments (INT) and 2 turn-out times (TOT) on the hatching chick quality variables and 35 d posthatch performance of Ross × Ross 708 broilers were investigated. In a single-stage incubator, 1,440 hatching eggs were randomly distributed among 3 INT groups on each of 8 tray levels. At 19 d of incubation (doi), embryonated eggs were subjected to one of the following INT by in ovo injection: noninjected control; 1 × dose of EM1; 10 × dose of EM1. On 21 doi, hatchability of injected eggs (HI), hatching body weight (HBW), and hatching chick quality variables were determined. Additionally, for the grow-out phase, birds belonging to each INT were randomly subjected to a 7 or 10 d TOT. Twenty chicks were initially placed in each of 48 floor pens (6 INT × TOT combination groups × 8 replications) for growth performance evaluation from 0 to 35 d posthatch. The main effect of INT on hatching chick quality variables, as well as the main and interactive effects of INT and TOT on various grow-out performance variables were determined. Although there was no significant INT effect on HI or HBW, significant INT effects on chick total BW, yolk-free BW, and yolk sac weight were observed. There were significant INT effects on BWG and FCR in the 21- to 28-d posthatch interval, as well as on BWG and FCR in the 0- to 35-d posthatch interval. There was no main effect of TOT or interactive effect of INT and TOT on BW and other performance variables from 0 to 35 d posthatch. There was a significant main effect of INT on relative intestine weight at 28 d posthatch. In conclusion, the injection of EM1 vaccine at a 10 × dose may affect hatching chick quality variables and growth performance up to 35 d posthatch.

Comparison of two methods for determination of intestinal villus to crypt ratios and documentation of early age-associated ratio changes in broiler chickens,.

The determination of intestinal villus to crypt ratios (VCR) is a common method utilized to evaluate effects of various diet regimens on gut microanatomy and for the histologic quantification of intestinal responses to disease processes. Two methods for the determination of small intestinal VCR were compared in early age chickens. A standard method for VCR determination based on 10 villus and crypt length measurements in the jejunal region of the small intestine was employed for the calculation of villus to crypt length ratio (VCLR). That method was compared to a new approach based on a single histomorphometric determination of the crypt and total mucosal areas using image analysis software. Subtraction of the crypt area from the total area provided the villus area and allowed for the subsequent calculation of villus to crypt area ratio (VCAR). At 4 and 18 h posthatch, VCLR was higher than that of VCAR, but there was no significant difference between VCLR and VCAR at 0 h (hatch) and at 168 h (d 7) posthatch. Nevertheless, the pattern of age-associated changes for VCLR and VCAR were comparable throughout the early posthatch period. Furthermore, the new method used in determining VCAR is subject to less human error, allows for an appreciable reduction in the number of measurements required, and facilitates a larger intestinal segment evaluation. Standard linear measurements require the selection of variable numbers of villi and crypts, whereas the area method only requires selection of a single region that incorporates numerous villi and crypts of variable sizes in providing a less subjective approach. This is particularly advantageous in studies on intestinal disease conditions resulting in marked multifocal variation in villus stature. This study further documented age-associated changes occurring in the VCR of the small intestine during the early posthatch period. Across the 2 methods used for VCR determination, a major and highly significant reduction in the VCR was observed to occur between 18 h and 168 h posthatch.

Comparative effects of in ovo versus subcutaneous administration of the Marek's disease vaccine and pre-placement holding time on the processing yield of Ross 708 broilers.

Effects of the in ovo (i.o.) or subcutaneous (s.c.) method of administration (moa) of the Marek's disease (MD) vaccine and 4 or 18 h pre-placement holding time (pht) on the processing yield of male broilers through 49 d of age (doa) were investigated. Ross 708 broiler hatching eggs (3,900) were either i.o.-vaccinated at 18 d of incubation or chicks from eggs that were not i.o.-vaccinated were s.c.-vaccinated at hatch. The i.o. injections (50 µL) were delivered by a commercial multi-egg injector and s.c. injections (200 µL) were delivered by an automatic pneumatic s.c. injector. The pht was imposed on chicks after vaccination. Sixteen birds were initially assigned to each of 15 replicate floor pens belonging to each of the moa and pht combination groups and were grown out through 48 doa. At 48 doa, 6 birds were randomly selected from each replicate pen and were weighed and fasted for 16 h before being processed. At 49 doa, whole carcass, fat pad, breast muscle, and tenders muscles weights were recorded. Whole carcass weight as a percentage of live BW, and fat pad, breast muscle, and tenders muscles weights as percentages of both live and whole carcass weights were calculated. Upon subjection of the data to a 2 × 2 factorial analysis, only a main effect due to moa was observed for tenders muscles weight as a percentage of live and whole carcass weights. Tenders muscles weight as a percentage of both live (P ≤ 0.010) and whole carcass (P ≤ 0.004) weight was higher in birds hatched from eggs that received i.o. rather than s.c. vaccinations. In conclusion, in comparison to s.c. vaccination, i.o. vaccination increased relative tenders weight yield, whether or not broilers were held for 4 or 18 h prior to placement. Therefore, with regard to broiler processing yield, i.o. and s.c. vaccinations were safe for the administration of the MD vaccine, with i.o. vaccination displaying a slight potential advantage.

Layer chicken embryo survival to hatch when administered an in ovo vaccination of strain F Mycoplasma gallisepticum and locations of bacteria prevalence in the newly hatched chick.

Mycoplasma gallisepticum (MG) is a bacterial pathogen that causes production losses in layer chickens. To combat MG, multiage layer facilities vaccinate pullets by either spray or eye-drop vaccination. The objective in this study was to evaluate the use of in ovo vaccination as a potential alternative for MG vaccination. Layer embryos at 18 d of incubation were either not-injected (control), or were hand-injected with either commercial Marek's disease vaccine diluent alone or with a high, medium, low, or very low dosage of a live attenuated strain F (FMG) vaccine suspended in the commercial diluent. Hatch success and residual egg embryonic mortality were determined after 23 d of incubation. Six hatched chicks per treatment were swabbed for the detection of FMG at 4 different sites (trachea, mouth and esophagus, yolk sac membrane, and the lumen of the duodenal loop) via real-time PCR. Embryos were found to be administered 106 CFU per dose in the high treatment, 104 CFU/dose in the medium treatment, 102 CFU/dose in the low treatment, and between 5.06 and 5.93 CFU/dose in the very low treatment. Hatch of embryonated eggs was decreased by the medium and high doses (P = 0.02). These embryos died while pipping. No FMG was detected in the control and diluent-injected chicks. In the FMG treatments, FMG was found in all sites and dosages, with a greater number of positive chicks found in the higher FMG dosage treatments. These findings indicate the potential practicality of vaccinating layer embryos with FMG by in ovo injection based on the observed hatch success at lower dosages. Also, once injected into the amnion, the bacteria are present in the upper respiratory and gastrointestinal tracts as well the yolk sac membrane and the small intestine of hatchlings. Future research will need to ascertain the effects of FMG administered by in ovo injection on posthatch immunity and mortality.

Comparative effects of in ovo versus subcutaneous administration of the Marek's disease vaccine and pre-placement holding time on the post-hatch performance of Ross 708 broilers1,2,3.

Effects of 2 types of methods of administration (moa; in ovo or s.c.) of the Marek's disease (MD) vaccine and 4 and 18 h pre-placement holding times (pht) on the performance of male broilers through 48 d of age were investigated. Ross 708 broiler hatching eggs (3,900) were either in ovo-vaccinated at 18 d of incubation or chicks from eggs that were not in ovo-injected were vaccinated s.c. at hatch, and chicks from each moa group were held for one of the 2 pht. In ovo injections (50 µL) were delivered by a commercial multi-egg injector and s.c. injections (0.2 mL) were delivered by an automatic pneumatic s.c. injector. Sixteen birds were assigned to each of 15 replicate floor pens belonging to each of the 4 moa and pht combination groups. Mortality and BW gain were determined at weekly intervals, and feed consumption and conversion were determined in the zero to 14, 14 to 28, 28 to 42, and 42 to 48 d age intervals. No interactive effects between moa and pht were observed for any variable, and mortality was not significantly affected by moa or pht. The 14 to 28 d feed consumption and 14 to 21 d BW gain of s.c.-vaccinated birds were lower than that of in ovo-vaccinated birds, and the increase in pht from 4 to 18 h decreased feed consumption through 28 d post hatch and BW gain through 35 d post hatch. Overall, the performances of male Ross 708 broilers through 48 d of age in response to in ovo and s.c. injections of the MD vaccine were comparable, and delays in hatchling placement should be less that 18 h in duration. Furthermore, despite the decrease in BW gain through 35 d associated with the reduction in feed consumption through 28 d in response to the 14 h increase in pht, in ovo injection did not exacerbate the effect of the increase in pht.

Relationships of eggshell, air cell, and cloacal temperatures of embryonated broiler hatching eggs during incubation.

The relationships of eggshell, air cell, and embryo cloacal temperatures in Ross × Ross 708 broiler hatching eggs were determined. Twenty eggs were weighed and set on each of 3 tray levels of a single incubator. Eggshell temperature (EST) of the eggs were recorded once in the morning (AM) and afternoon (PM) between 0 and 19 d of incubation (DOI) using an infrared thermometer (IRT). All eggs were candled and a transponder was implanted in the air cell of eggs containing live embryos (12 per tray level) at 12 DOI. At 19 DOI, transponders were implanted in the cloaca of live embryos from those same eggs. Air cell temperature (ACT) and EST readings were recorded once in the AM and PM between 12 and 19 DOI, and ACT and cloaca temperature (CLT) readings were recorded every 6 h between 19 and 21 DOI. The EST and ACT readings between 13 and 19 DOI were positively correlated. However, their respective mean temperatures between 13 and 19 DOI differed. The EST and ACT were not significantly influenced by tray level. Nevertheless, a main effect due to location (eggshell vs. air cell), and an interaction between DOI and time of day (AM and PM) in the 13 to 19 DOI interval were observed. Furthermore, an interaction was observed between location (air cell and cloaca) and the 6 h sequential time periods in the 19 to 21 DOI interval. However, across the entire 19 to 21 DOI interval, mean ACT and CLT were not significantly different, and were positively correlated. These data suggest that ACT readings are higher than those of EST during the last half of incubation, and that between 13 and 19 DOI, ACT readings may have the potential for use as a minimally invasive method by which to more accurately estimate the true core body temperature of broiler embryos. The effects of this method on hatchability and post-hatch performance need determination to better establish its practicality.

Effects of different vaccine combinations against Mycoplasma gallisepticum on the digestive and reproductive organ characteristics of commercial egg-laying hens.

Mycoplasma gallisepticum (MG) is a major and economically significant pathogen of avian species. When administered before lay, F-strain MG (FMG) can reduce egg production during lay, but the ts-11 strain of MG (ts11MG) does not exert this effect. Two trials were conducted to determine the effects of pre-lay vaccinations of ts11MG, MG-Bacterin (MGBac), or their combination, in conjunction with an FMG vaccination overlay after peak production on the digestive and reproductive organ characteristics of Hy-Line W-36 layers housed in biological isolation units (4 units per treatment, 10 birds per unit). The following vaccination treatments were administered at 10 wk of age (woa): 1) Control (no vaccinations); 2) MGBac; 3) ts11MG; and 4) ts11MG and MGBac combination (ts11MG+MGBac). At 45 woa, half of the birds were vaccinated with a laboratory stock of high passage FMG. In both trials, parameters determined in 4 birds per unit at 55 woa included: BW; fatty liver hemorrhagic syndrome incidence; mean number of mature ovarian follicles; ovarian, oviduct, and small intestine weights; and the weights and lengths of the various portions of the oviduct and small intestine. Treatment effects were observed for the weights of the entire small intestine and the duodenum, jejunum, and ileum, as percentages of BW; and for vagina weight as a percentage of total oviduct weight. In general, the weights of the small intestine and its 3 components were increased in response to the FMG vaccine that was administered at 45 woa. An FMG vaccination at 45 woa may increase relative intestine weight in layers; however, use of a prelay MGBac vaccine alone or in combination with ts11MG, with or without an FMG overlay, does not affect the gross characteristics of their digestive and reproductive organs, and may be used without having an adverse effect on their performance, as was observed in a previous companion study.

Effects of in ovo injection of organic trace minerals and post-hatch holding time on broiler performance and bone characteristics.

Effects of the in ovo injection of organic Mn, Zn, and Cu in association with post-hatch (POH) feed and water restriction on the performance and physical-chemical bone parameters of male Ross × Ross 708 broilers were examined. On 17 d of incubation, a total of 1,872 eggs were subjected to in ovo injection using a commercial multi-egg injector. Treatments (TRT) includingd non-injected and diluent-injected controls. The respective Zn, Mn, and Cu levels (mg/mL) added to the diluent of the low (LMD) and high mineral (HMD) TRT groups were 0.181, 0.087, and 0.010, and 0.544, 0.260, and 0.030, respectively. The 4 TRT groups were then sub-divided into 2 POH holding time (HT) groups, with 15 birds randomly allocated to each of 6 replicate pens in each of the 8 groups. The first HT group (0HT) had immediate access to water and feed, and the second HT group (24HT) contained birds that were kept in transport baskets for 24 h before being released. Performance was determined and selected birds were subsequently necropsied and their tibiae extracted for analysis. In comparison to birds from 24HT group, those in the 0HT group had a higher BW gain and feed intake, and a lower FCR through 21 d POH. The percentage of bone ash of the birds belonging to the HMD group was higher than all other TRT on d 1 POH and was higher than the non-injection control group on d 21 POH. On d 1, the LMD and HMD groups had higher tibial Mn concentrations than those of the control groups. On d 7, bones from the HMD group had a higher concentration of Mn than did the non-injected control group, and likewise, on d 21 POH, had a higher concentration of Zn than did the control groups. In conclusion, a 24HT negatively affected the performance of the birds during the first 2 wk POH; however, the LMD and HMD TRT had a positive influence on bone mineralization.

Effects of in ovo injection of organic zinc, manganese, and copper on the hatchability and bone parameters of broiler hatchlings.

Effects of the in ovo injection of commercial diluent containing supplemental microminerals (Zn, Mn, and Cu) on hatchability and hatching chick quality variables in Ross × Ross 708 broilers were examined. On 17 d of incubation (doi) eggs were subjected to 1 of 4 treatments using a commercial multi-egg injector. Treatments included non-injected (treatment 1) and diluent-injected (treatment 2) control groups. Those in treatment 3 received diluent containing 0.181, 0.087, and 0.010 mg/mL of Zn, Mn, and Cu, respectively, and those in treatment 4 received diluent containing 0.544, 0.260, and 0.030 mg/mL of Zn, Mn, and Cu, respectively. A total of 1,872 eggs were distributed among 4 treatment groups on each of 6 replicate tray levels. Hatchability of fertile eggs set (HF) was determined on 20.5 and 21.5 doi. On 21.5 doi, HF and mean hatching chick weight (MHW) were determined. One bird from each treatment replicate group was randomly selected, weighed, and necropsied for the extraction of their livers and tibiae. The tibiae fresh and dry weight, length, width, bone breaking strength (BBS), and percentage of bone ash (PBA) were determined. The dry livers were weighed and ashed. Injection treatment had no significant effect on HF at 20.5 doi. However, there was a significant injection treatment effect on HF at 21.5 doi. The HF of eggs at 21.5 doi in treatment 4 was significantly lower than that of the non-injected control group, with treatment 3 being intermediate. Furthermore, there were no significant treatment effects noted for MHW fresh and dry tibia weights, tibia length and width, tibia length to weight ratio, BBS, liver ash content, or percentage of minerals (Ca, P, Mg, Mn, and Zn) in the tibia ash. However, embryos from eggs that received treatment 4 had a significantly higher PBA in comparison to all other treatments. In conclusion, although treatment 4 negatively affected HF, the injection of diluent containing the high micromineral concentration has the potential to improve bone mineralization.

Effect of temperature and concentration on benzoyl peroxide bleaching efficacy and benzoic acid levels in whey protein concentrate.

Much of the fluid whey produced in the United States is a by-product of Cheddar cheese manufacture and must be bleached. Benzoyl peroxide (BP) is currently 1 of only 2 legal chemical bleaching agents for fluid whey in the United States, but benzoic acid is an unavoidable by-product of BP bleaching. Benzoyl peroxide is typically a powder, but new liquid BP dispersions are available. A greater understanding of the bleaching characteristics of BP is necessary. The objective of the study was to compare norbixin destruction, residual benzoic acid, and flavor differences between liquid whey and 80% whey protein concentrates (WPC80) bleached at different temperatures with 2 different benzoyl peroxides (soluble and insoluble). Two experiments were conducted in this study. For experiment 1, 3 factors (temperature, bleach type, bleach concentration) were evaluated for norbixin destruction using a response surface model-central composite design in liquid whey. For experiment 2, norbixin concentration, residual benzoic acid, and flavor differences were explored in WPC80 from whey bleached by the 2 commercially available BP (soluble and insoluble) at 5 mg/kg. In liquid whey, soluble BP bleached more norbixin than insoluble BP, especially at lower concentrations (5 and 10 mg/kg) at both cold (4°C) and hot (50°C) temperatures. The WPC80 from liquid whey bleached with BP at 50°C had lower norbixin concentration, benzoic acid levels, cardboard flavor, and aldehyde levels than WPC80 from liquid whey bleached with BP at 4°C. Regardless of temperature, soluble BP destroyed more norbixin at lower concentrations than insoluble BP. The WPC80 from soluble-BP-bleached wheys had lower cardboard flavor and lower aldehyde levels than WPC80 from insoluble-BP-bleached whey. This study suggests that new, soluble (liquid) BP can be used at lower concentrations than insoluble BP to achieve equivalent bleaching and that less residual benzoic acid remains in WPC80 powder from liquid whey bleached hot (50°C) than cold (4°C), which may provide opportunities to reduce benzoic acid residues in dried whey ingredients, expanding their marketability.