Freeze-dried live attenuated smallpox vaccine prepared in cell culture "LC16-KAKETSUKEN": Post-marketing surveillance study on safety and efficacy compliant with Good Clinical Practice.

BACKGROUND: In Japan, production of smallpox vaccine LC16m8 (named LC16-KAKETSUKEN) was restarted and was determined to be maintained as a national stockpile in March 2002. OBJECTIVE: To conduct a post-marketing surveillance study of the vaccination of freeze-dried live attenuated smallpox vaccine prepared in cell culture LC16-KAKETSUKEN using attenuated vaccinia strain LC16m8. The study complied with Good Clinical Practice, focusing on a comparison between primary vaccinees and re-vaccinees. METHOD: 268 personnel (261 males and 7 females) of the Japan Ground Self-Defense Force were inoculated with LC16-KAKETSUKEN and thereafter adverse events and efficacy were evaluated. RESULTS: Among 268 vaccinee participants, the following vaccinees showed adverse events, none serious: 53 of 196 primary vaccinees (without previous smallpox vaccination), 4 of 71 re-vaccinees (with previous smallpox vaccination) and 1 vaccinee with unknown previous vaccination history. A breakdown of adverse events observed in this study (total 268 vaccinees) showed the following minor or mild adverse events: 52 (19.4%) swelling of axillary lymph node, 4 (1.5%) fever, 2 (0.7%) fatigue, 1 (0.4%) of rash, 14 (5.2%) erythema at the inoculation site, 1 (0.4%) swelling at the inoculation site and 1 (0.4%) autoinoculation. The incidence of adverse events for primary vaccinees (53/196; 27.0%) was significantly higher than for re-vaccinees (4/71; 5.6%). However, the proportion of vaccine take was significantly higher for primary vaccinees (185/196; 94.4%) than for re-vaccinees (58/71; 81.7%). Although the proportion of vaccine take of re-vaccinees was significantly lower than for primary vaccinees due to preexisting immunity by previous vaccination, no significant difference was found in neutralizing antibody titers between primary vaccinees and re-vaccinees at 1, 4 and 7 months after LC16-KAKETSUKEN vaccination. CONCLUSION: The present post-marketing surveillance study compliant with Good Clinical Practice demonstrated the efficacy and safety of the smallpox vaccine LC16-KAKETSUKEN in an adult population. LC16-KAKETSUKEN is the sole currently available licensed smallpox vaccine for both adult and pediatric populations.

Vaccinia virus strain LC16m8 defective in the B5R gene keeps strong protection comparable to its parental strain Lister in immunodeficient mice.

BACKGROUND: Attenuated vaccinia virus strain, LC16m8, defective in the B5R envelope protein gene, is used as a stockpile smallpox vaccine strain in Japan against bioterrorism: the defect in the B5R gene mainly contributes to its highly attenuated properties. METHODS: The protective activity of LC16m8 vaccine against challenge with a lethal dose of vaccinia Western Reserve strain was assessed in wild-type and immunodeficient mice lacking CD4, MHC class I, MHC class II or MHC class I and II antigens. RESULTS: The immunization with LC16m8 induced strong protective activity comparable to that of its parent strain, Lister (Elstree) strain, in wild-type mice from 2 days to 1 year after vaccination, as well as in immunodeficient mice at 2 or 3 weeks after vaccination. These results implicated that the defect in the B5R gene hardly affected the potential activity of LC16m8 to induce innate, cell-mediated and humoral immunity, and that LC16m8 could be effective in immunodeficient patients. CONCLUSION: LC16m8 with truncated B5 protein has an activity to induce immunity, such as innate immunity and subsequent cell-mediated and humoral immunity almost completely comparable to the activity of its parental strain Lister.

Safety of attenuated smallpox vaccine LC16m8 in immunodeficient mice.

Freeze-dried live attenuated smallpox vaccine LC16m8 prepared in cell culture has been the sole smallpox vaccine licensed in Japan since 1975 and was recently recommended as a WHO stockpile vaccine. We evaluated the safety of recently remanufactured lots of LC16m8 using a series of immunodeficient mouse models. These models included suckling mice, severe combined immunodeficiency disease (SCID) mice, and wild-type mice treated with cyclosporine. LC16m8 showed extremely low virulence in each of the three mouse models compared with that of its parental strains, Lister and LC16mO. These results provide further evidence that LC16m8 is one of the safest replication-competent smallpox vaccines in the world and may be considered for use in immunodeficient patients.

Further development of a new transgenic mouse test for the evaluation of the immunogenicity and protective properties of inactivated poliovirus vaccine.

Recently, we developed and optimized a new method for the evaluation of the protective properties of serotype 2 inactivated poliovirus vaccines (IPV). The method is based on the immunization and subsequent challenge of transgenic (Tg) mice susceptible to poliovirus. We describe a similar method for the assessment of the protectiveness of serotype 1 IPV and demonstrate that experimental IPV produced from attenuated Sabin strain (sIPV) of serotype 1 poliovirus induced serum neutralizing antibodies, immunoglobulin (Ig) G, IgM, and salivary IgA at titers comparable to those induced by conventional IPV (cIPV) produced from the wild-type Mahoney strain. In contrast to our previous results with serotype 2 sIPV, serotype 1 sIPV provided even better protection of Tg mice than cIPV against challenge with wild-type Mahoney strain.

Isolation of vaccine-derived type 1 polioviruses displaying similar properties to virulent wild strain Mahoney from sewage in Japan.

Type 1, 2, and 3 vaccine-derived polioviruses were isolated from a sewage disposal plant located downstream of the Oyabe River in Toyama Prefecture, Japan, between October 1993 and September 1995. Neurovirulence was analyzed in 13 type 1 vaccine-derived strains, using mutant analysis by polymerase chain reaction and restriction enzyme cleavage (MAPREC). Nine strains (69%) were estimated to have marked neurovirulence. Some of the neutralizing antigenic sites, temperature sensitivity, and plaque-forming ability of two virulent vaccine-derived poliovirus strains were similar to Mahoney strain. The neutralizing activity of human sera obtained after oral poliomyelitis vaccine (OPV) administration against one of the virulent vaccine-derived polioviruses was examined. Although all human sera showed sufficient neutralizing activity for the prevention of poliomyelitis by vaccine-derived poliovirus strains, a lower titer than that against Sabin type 1 strain was observed. Vaccination against virulent vaccine-derived poliovirus will be effective. However, the environmental presence of viruses that have properties similar to those Mahoney strain is a threat. The introduction of inactivated poliovirus vaccine (IPV), and well-maintained herd immunity, together with reinforced environmental surveillance is important for the final phase of the polio eradication program by the World Health Organization (WHO).

Prevalence of vaccine-derived polioviruses in the environment.

A survey of poliovirus in river and sewage water was conducted from October 1993 to September 1995 in Toyama Prefecture, Japan. In this study, 25 isolates differentiated as type 2 vaccine-derived polioviruses (VDPVs) were characterized using mutant analysis by PCR and restriction-enzyme cleavage (MAPREC) to estimate the ratio of 481-G revertants correlated to neurovirulence in a virus population. Of these isolates, 23 (92%) comprised between 44 and 96% 481-G revertants by MAPREC. The other two isolates had revertant percentages close to the 0.6% of the attenuated reference strain. It was presumed that these 23 isolates would be variant with potential neurovirulence by MAPREC analysis. Of the 23 isolates, three were isolated from river water. Moreover, our results by MAPREC showed that type 2 poliovirus was phenotypically more variable than type 1 (69%) or type 3 (55%), as determined in previous studies. The prevalence of virulent-type VDPVs in river and sewage water suggested that the oral poliovaccine itself had led to wide environmental pollution in nature. To terminate the cycle of virus transmission in nature, the ecology of VDPVs should be studied further. A hygiene programme, inactivated poliovirus vaccine immunization and well-maintained herd immunity may play key roles in reducing the potential risk of infection by virulent VDPVs.

Neurovirulence of type 1 polioviruses isolated from sewage in Japan.

Sixteen type 1 poliovirus strains were isolated from a sewage disposal plant located downstream of the Oyabe River in Japan between October 1993 and September 1995. The isolates were intratypically differentiated as vaccine-derived strains. Neutralizing antigenicity analysis with monoclonal antibodies and estimation of neurovirulence by mutant analysis by PCR and restriction enzyme cleavage (MAPREC) were performed for 13 type 1 strains of these isolates. The isolates were classified into three groups. Group I (five strains) had a variant type of antigenicity and neurovirulent phenotype. Group II (four strains) had the vaccine type of antigenicity and neurovirulent phenotype. Group III (four strains) had the vaccine type of antigenicity and an attenuated phenotype. Furthermore, it was demonstrated that the virulent isolates were neutralized by human sera obtained after oral poliomyelitis vaccine (OPV) administration, and the sera of rats immunized with inactivated poliovirus vaccine. Although vaccination was effective against virulent polioviruses, virulent viruses will continue to exist in the environment as long as OPV is in use.