[Examination of Analytical Method for Tris(2,3-dibromopropyl)phosphate and Bis(2,3-dibromopropyl)phosphate to Revise the Official Methods Based on "Act on the Control of Household Products Containing Harmful Substances"].

In Japan, the use of frame retardants [tris(2,3-dibromopropyl)phosphate: TDBPP and bis(2,3-dibromopropyl)phosphate: BDBPP] in several household textile products is banned under the "Act on the Control of Household Products Containing Harmful Substances." As the official analytical methods for testing these substances have not been revised for over 42 years, several issues such as the using of harmful reagents, have been pointed out. Therefore, we developed a new method to revise the official method in our previous study. In this study, the validity of the developed test method is evaluated at six laboratories using two types of textile samples spiked with TDBPP and BDBPP at three concentrations (4, 8, and 20 µg/g). TDBPP and BDBPP are extracted under reflux using methanol containing hydrochloric acid. TDBPP is analyzed using GC-MS, and BDBPP is also analyzed using GC-MS after methylation with trimethylsilyl diazomethane. Although the accuracy (70-120%), repeatability (<10%), and reproducibility (<15%) of a few samples, mainly low concentration samples, are out of range, overall, the concentration level of detection limits of TDBPP and BDBPP (8 and 10 µg/g) in official analytical methods are quantifiable with sufficient precision using the proposed method. Furthermore, harmful reagents are not used in this method. Thus, the method validated in this study is effective as a revised method for the testing of TDBPP and BDBPP in household textile products.

GC-MS Analysis of Primary Aromatic Amines Originated From Azo Dyes in Commercial Textile or Leather Products Using Helium Alternative Carrier Gases.

BACKGROUND: In recent years, due to the global shortage of helium gas, the development of gas chromatography (GC) analytical methods using alternatives to helium carrier gases is necessary. OBJECTIVE: The objective of this study was to examine the applicability of hydrogen and nitrogen as alternative carrier gases using the test method for azo compounds in the Act on Control of Household Products Containing Harmful Substances of Japan. METHOD: The gas chromatograph mass spectrometer (GC-MS) analytical method using hydrogen and nitrogen as alternative carrier gases was compared with a method using helium for 26 primary aromatic amines (PAAs) originated from azo dyes. RESULTS: When hydrogen and nitrogen were used as carrier gases under the same conditions used during analysis using helium (same column, gas flow rate, oven temperature conditions, etc.), sufficient peak separation of 26 PAAs was obtained. The sensitivities of the methods using helium and hydrogen were comparable, whereas the sensitivity was lower when nitrogen was used, with the detection limits ranging from 1/220 to 1/25. However, all carrier gases achieved quantification at concentrations below the standard value (30 µg/g) of the Act on Control of Household Products Containing Harmful Substances, and the results were in agreement with the standard value for the target product. CONCLUSIONS: Our results indicated that hydrogen or nitrogen can be used as alternative carrier gases to helium for GC-MS analysis of azo compounds producing specific aromatic amines. HIGHLIGHTS: Using hydrogen or nitrogen as an alternative carrier gas to helium, azo compounds could be quantified with excellent accuracy.

Analysis of patch testing with cocamidopropyl betaine and its impurities in patients with intractable scalp dermatitis in a single clinic in Japan.

BACKGROUND: The allergen responsible for cocamidopropyl betaine (CAPB) allergies has been debated. OBJECTIVES: To investigate the sensitizing agents of CAPB, the patch test positivity rates of impurities were examined in Japanese patients with CAPB-related allergic contact dermatitis. MATERIALS AND METHODS: Thirty patients with scalp dermatitis and positive patch tests for CAPB and/or lauramidopropyl betaine (LAPB) were enrolled in this study. They were patch tested with the detergents that they had been using at the time of their first visit and with the impurities dimethylaminopropylamine (DMAPA) and lauramidopropyl dimethylamine (LAPDMA). RESULTS: The positivity rate in patch tests of the 37 detergents that the patients had been using was 78.4% (29/37). The positivity rates of DMAPA 1% pet., 1% aq. and 0.2% aq. were 32.1% (9/28), 14.3% (4/28) and 13.3% (4/30), respectively, whereas those of LAPDMA 0.1% and 0.05% were 30.0% (9/30) and 16.7% (5/30), respectively. Among the 30 patients, 6 exhibited positive results for both DMAPA and LAPDMA, 3 showed positive results for DMAPA alone and 6 produced positive results for LAPDMA alone. CONCLUSION: Patch tests produced an overall positivity rate for DMAPA, LAPDMA or both of 50.0% (15/30) in patients with scalp dermatitis and positive patch test results for CAPB and/or LAPB.

A step-by-step approach for assessing acute oral toxicity without animal testing for additives of quasi-drugs and cosmetic ingredients.

Animal testing of cosmetic ingredients and products has been banned in the European Union since 2013. However, in Japan, the application of new quasi-drugs requires the generation of data on acute oral toxicity through animal testing. A weight of evidence approach for assessing oral toxicity was challenged. This approach used a combination of safety data, including a neutral red uptake cytotoxicity assay using BALB/c3T3 cells (3T3-NRU cytotoxicity assay), which can assess the acute oral toxicity of quasi-drugs or cosmetic ingredients. We conclude that the step-by-step approach can be used to assess test substances that cause low acute oral toxicity, such as the median lethal dose (LD 50) > 2000 mg/kg, thereby avoiding animal testing.

A cell-based evaluation of human tyrosinase-mediated metabolic activation of leukoderma-inducing phenolic compounds.

BACKGROUND: Chemical leukoderma is a skin depigmentation disorder induced through contact with certain chemicals, most of which have a p-substituted phenol structure similar to the melanin precursor tyrosine. The tyrosinase-catalyzed oxidation of phenols to highly reactive o-quinone metabolites is a critical step in inducing leukoderma through the production of melanocyte-specific damage and immunological responses. OBJECTIVE: Our aim was to find an effective method to evaluate the formation of o-quinone by human tyrosinase and subsequent cellular reactions. METHODS: Human tyrosinase-expressing 293T cells were exposed to various phenolic compounds, after which the reactive o-quinones generated were identified as adducts of cellular thiols. We further examined whether the o-quinone formation induces reductions in cellular GSH or viability. RESULTS: Among the chemicals tested, all 7 leukoderma-inducing phenols/catechol (rhododendrol, raspberry ketone, monobenzone, 4-tert-butylphenol, 4-tert-butylcatechol, 4-S-cysteaminylphenol and p-cresol) were oxidized to o-quinone metabolites and were detected as adducts of cellular glutathione and cysteine, leading to cellular glutathione reduction, whereas 2-S-cysteaminylphenol and 4-n-butylresorcinol were not. In vitro analysis using a soluble variant of human tyrosinase revealed a similar substrate-specificity. Some leukoderma-inducing phenols exhibited tyrosinase-dependent cytotoxicity in this cell model and in B16BL6 melanoma cells where tyrosinase expression was effectively modulated by siRNA knockdown. CONCLUSION: We developed a cell-based metabolite analytical method to detect human tyrosinase-catalyzed formation of o-quinone from phenolic compounds by analyzing their thiol-adducts. The detailed analysis of each metabolite was superior in sensitivity and specificity compared to cytotoxicity assays for detecting known leukoderma-inducing phenols, providing an effective strategy for safety evaluation of chemicals.

Oral Exposure to Lead Acetate for 28 Days Reduces the Number of Neural Progenitor Cells but Increases the Number and Synaptic Plasticity of Newborn Granule Cells in Adult Hippocampal Neurogenesis of Young-Adult Rats.

Lead (Pb) causes developmental neurotoxicity. Developmental exposure to Pb acetate (PbAc) induces aberrant hippocampal neurogenesis by increasing or decreasing neural progenitor cell (NPC) subpopulations in the dentate gyrus (DG) of rats. To investigate whether hippocampal neurogenesis is similarly affected by PbAc exposure in a general toxicity study, 5-week-old Sprague-Dawley rats were orally administered PbAc at 0, 4000, and 8000 ppm (w/v) in drinking water for 28 days. After exposure to 4000 or 8000 ppm PbAc, Pb had accumulated in the brains. Neurogenesis was suppressed by 8000 ppm PbAc, which was related to decreased number of type-2b NPCs, although number of mature granule cells were increased by both PbAc doses. Gene expression in the 8000 ppm PbAc group suggested suppressed NPC proliferation and increased apoptosis resulting in suppressed neurogenesis. PbAc exposure increased numbers of metallothionein-I/II+ cells and GFAP+ astrocytes in the DG hilus, and upregulated Mt1, antioxidant genes (Hmox1 and Gsta5), and Il6 in the DG, suggesting the induction of oxidative stress and neuroinflammation related to Pb accumulation resulting in suppressed neurogenesis. PbAc at 8000 ppm also upregulated Ntrk2 and increased the number of CALB2+ interneurons, suggesting the activation of BDNF-TrkB signaling and CALB2+ interneuron-mediated signals to ameliorate suppressed neurogenesis resulting in increased number of newborn granule cells. PbAc at both doses increased the number of ARC+ granule cells, suggesting the facilitation of synaptic plasticity of newborn granule cells through the activation of BDNF-TrkB signaling. These results suggest that PbAc exposure during the young-adult stage disrupted hippocampal neurogenesis, which had a different pattern from developmental exposure to PbAc. However, the induction of oxidative stress/neuroinflammation and activation of identical cellular signals occurred irrespective of the life stage at PbAc exposure.

Determination of Carcinogenic Primary Aromatic Amines Contained as Impurities in Synthetic Organic Colorants.

BACKGROUND: Several primary aromatic amines (PAAs) have been designated carcinogenic or suspected of carcinogenicity. Several kinds of PAAs may occur either via the reduction of azo compounds or as impurities in azo colorants or other agents. OBJECTIVE: An analytical method was developed and applied to determine whether certain PAAs are present as impurities in synthetic organic colorants. METHOD: Target chemicals were analyzed by the ultrasound extraction of the synthetic organic colorant with a hydrochloric acid solution containing 20% methanol, followed by conversion from an acidic to alkaline solution, and then extraction using a diatomaceous earth column. RESULTS: We analyzed certain PAAs in 38 synthetic organic colorants, resulting in the detection of 2,4-dimethylaniline in four samples at 1.2 to 19 µg/g, o-toluidine in three samples at 1.0 to 3.4 µg/g, p-phenylazoaniline in two samples at 74 to 305 µg/g, and, in one sample each, 2,4,5-trimethylaniline (13 µg/g), 5-nitro-o-toluidine (12 µg/g), and 2-methyl-4-(2-tolylazo)aniline (13 µg/g). Nearly all PAAs were determined to be starting materials for colorant synthesis, although p-phenylazoaniline in Yellow No. 407 was apparently a byproduct formed during synthesis. For Red No. 225, in which high concentrations of p-phenylazoaniline were detected, additional samples were purchased from five companies, and p-phenylazoaniline was detected at concentrations of 88 to 370 µg/g in all samples. CONCLUSIONS: A method to analyze certain PAAs contained as impurities in synthetic organic colorants was developed, and the actual status of them in colorants was clarified. HIGHLIGHTS: The analytical method developed in this study for the determination of certain PAAs contained as impurities in synthetic organic colorants may be used to improve the safety of colorants.

[Investigation of Foreign Particles in Moderna COVID-19 Vaccine].

Particular batches of Moderna mRNA Coronavirus Disease 2019 (COVID-19) vaccine were recalled after foreign particles were found in some vaccine vials at the vaccination site in Japan in August 2021. We investigated the foreign particles at the request of the Ministry of Health, Labour and Welfare. Energy dispersive X-ray spectroscopy analysis suggested that the foreign particles found in the vials recalled from the vaccination sites were from stainless steel SUS 316L, which was in line with the findings of the root cause investigation by the manufacturer. The sizes of the observed particles ranged from <50 µm to 548 µm in the major axis. Similar foreign particles were also detected in 2 of the 5 vaccine vials of the same lot stored by the manufacturer, indicating that the foreign particles have already been administered to some people via vaccine. Observation of the vials of the same lot by digital microscope found smaller particles those were not detected by visual inspection, suggesting that more vials were affected. Contrarily, visual inspection and subvisible particulate matter test indicated no foreign particles in the vials of normal lots. Possible root cause and strategies to prevent such a deviation were discussed from technical and regulatory aspects.

Characterization of synthetic turf rubber granule infill in Japan: Rubber additives and related compounds.

We have conducted several studies with an overall goal of assessing the effects of rubber granules in synthetic turf on the health of athletes, other players, and children in Japan. As part of these studies, the investigation reported herein was aimed at analyzing the concentrations of rubber additives (vulcanization accelerators, antioxidants, and cross-linking agents) and related chemicals in 46 rubber infills prior to their use in synthetic turf fields in Japan. Of the 36 chemicals selected for targeted analysis, 26 were detected and quantified. Nontargeted analyses further identified and quantified 16 compounds derived from vulcanization accelerators, plasticizers, and other additives. The types and concentrations of the detected compounds varied both between products and within the same product; in the case of rubber infill products made from recycled rubber, this variation was caused by the different types of rubber products recycled as raw materials. Elution tests with four simulated biofluids (gastric juice, intestinal juice, saliva, and perspiration) revealed that the elution rates varied between compounds and were affected by the presence of coatings. Most compounds had low elution rates in all the simulated biofluids, with many at or below the limit of quantification. The data reported herein will be utilized in the risk characterization part of our subsequent study on the health risk assessment of rubber infill.

Characterization of synthetic turf rubber granule infill in Japan: Total content and migration of metals.

We evaluated the total content of 28 metals in synthetic turf rubber granule infill and performed extraction tests using four types of simulated biofluids to assess the health effects of synthetic turf crumb rubbers used in Japan. The highest median metal concentration was obtained for Zn, with median concentrations above 100 µg/g, followed by Al, Fe, and Mn. The highest median Pb concentration was 19.9 µg/g. The metal concentrations of the samples were different depending on the origin/material. Among high-concentration metals, Al, Fe, and Mn were higher in ethylene propylene diene monomer rubber, and Zn was higher in tires. Significantly higher Sb and Sr concentrations were observed in other materials, including industrial rubber, synthetic rubber, and thermoplastic elastomer, compared with tires. However, significantly higher Sn, Co, Pb, and Cd concentrations were detected in tires compared with other materials. Metals with high concentrations independent of the origin/material were considered derived from materials added during the manufacturing process. To evaluate the bioaccessibility, extraction tests were conducted using simulated biofluids. In gastric fluid, many metals were detected in higher concentrations than in other biofluids, intestinal fluid, saliva, and sweat, and the extraction rate of most metals exceeded 10% in artificial gastric fluid. Because the amount of metals leached into the simulated biofluids was much lower than several standards on the amount of certain metals that have the potential to be extracted from the object if ingested, the risk related to the exposure to metals from synthetic turf rubber granule infill is considered low.

Characterization of synthetic turf rubber granule infill in Japan: Volatile organic compounds.

There has been extensive studies on the composition of tires and industrial rubber. However, there is insufficient information on volatile organic compounds (VOCs) emitted from rubber granule products used to fill synthetic turf fields. In this study, we applied a passive sampling method for assessing the VOCs emitted from rubber granule products used for filling synthetic turf fields. We also performed a quantitative component analysis using a gas chromatography-mass spectrometer (GC-MS). The component analysis results of 46 rubber granule-based products showed the predominant presence of benzothiazole and methyl isobutyl ketone. The level of benzene, which the International Agency for Research on Cancer classifies as a substance with sufficient evidence for carcinogenicity to humans, was below the lower quantification limit in the products tested in this study. Our study included most of the rubber granule products used for synthetic turf fields in Japan (>95% of the products in the current domestic market of Japan). Therefore, we obtained a comprehensive overview of the VOCs emitted from the rubber granule-based products used in Japan's synthetic turf fields. Estimating the exposure to these airborne VOCs is essential to evaluate the adverse health effects of the VOCs emitted from these rubber granule-based products. Our sampling method and results can help provide key data for such risk assessment studies in the future.

Survival of SARS-CoV-2 and bovine coronavirus on common surfaces of living environments.

Aerosols or saliva containing severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) can contaminate living environments, and viruses can be indirectly transmitted. To understand the survival potential of the virus, the viral titers of bovine coronavirus (BCoV), as a model virus, and SARS-CoV-2 were measured on porous and non-porous surfaces. The amount of infectious BCoV recovered remained relatively high on non-porous substrates. However, it quickly decreased on several non-porous surfaces such as nitrile rubber. The time taken to reach the limit of detection on non-woven masks, as a porous substrate, was longer than that of non-porous substrates. On porous substrates other than non-woven masks, the amount of virus recovered quickly decreased, and then remained at a low level. Representative substrates were tested with SARS-CoV-2. The decrease in the amount of infectious virus recovered was similar to that of BCoV, although that of SARS-CoV-2 was more rapid. RNA derived from SARS-CoV-2 was also detected using real-time PCR, and it remained on surfaces much longer than infectious virus, on all substrates. Therefore, it is important to measure the viral titer to avoid the overestimation of infectious virus contamination in the environments. Our results suggest that the surface structure was not directly related to viral survivability.

Characterization of synthetic turf rubber granule infill in Japan: Polyaromatic hydrocarbons and related compounds.

Although the health effects of artificial turf fillings have been investigated in Europe and the United States, the actual situation in Japan is unclear. To address this issue, the concentrations of 46 polyaromatic hydrocarbons (PAHs) and related compounds in rubber infills were analyzed prior to their use in synthetic turf fields in Japan. Based on information obtained from the sample suppliers, the investigated samples were divided into five categories: discarded tires, industrial rubber, combinations of these products or unidentified components (mixture/unknown), synthetic rubber specifically manufactured for synthetic turf, and special-purpose thermoplastic elastomers (TPEs). The industrial rubber samples were mixtures of styrene butadiene rubber, natural rubber, and ethylene propylene diene rubber (EPDM). The synthetic rubber samples consisted only of EPDM. A few or none of the PAHs were detected in the synthetic rubber and TPE samples. However, in the discarded tire and industrial rubber samples, benzo[a]pyrene, cyclopenta[cd]pyrene, and 30 other compounds were detected. A comparison between these two categories indicated that the discarded tire samples exhibited higher concentrations of the target compounds than the industrial rubber samples. This finding can be attributed to the presence of EPDM in almost all of the industrial rubber samples, which were not present in the discarded tire samples. The maximum PAH concentrations obtained in the present study were equivalent to or lower than the previously reported PAH concentrations. The total concentrations of the eight PAHs included in the European Chemical Agency (ECHA) assessment of health risks were lower in the present study than those reported by the ECHA. Furthermore, elution testing was performed with four simulated biofluids (gastric and intestinal juices, saliva, and perspiration). The actual elution amounts of all compounds were less than the limits. This report provides basic data for the risk assessment of PAHs in rubber infills.

Free formaldehyde in non-medical face masks purchased from the Japanese market since the COVID-19 outbreak.

Since the Coronavirus Disease 2019 (COVID-19) pandemic began, people have been wearing face masks for many hours every day. As these face masks are in contact with the skin, it is important to pay more attention to their quality and safety. This study examined the concentration of free formaldehyde in 90 non-medical face masks and related products (33 nonwoven, 30 woven cloth, 12 polyurethane, and 15 related products) because formaldehyde is a common contact allergen in textile products. For products consisting of mixed materials, each material was sampled, resulting in 103 samples for analysis. Free formaldehyde (34-239 µg/g) was found in three cloth masks, which consisted of cotton and polyester, with antibacterial and antiviral labeling. It was confirmed that the detected formaldehyde originated from the mask-finishing treatment by a hydrochloric acid extraction discrimination test. These masks may elicit contact dermatitis if the consumers have already been sensitized to formaldehyde. However, the risk of contact dermatitis caused by formaldehyde in masks may be considered low since the frequency of formaldehyde detection in masks in Japan is low.

Induction of cellular senescence as a late effect and BDNF-TrkB signaling-mediated ameliorating effect on disruption of hippocampal neurogenesis after developmental exposure to lead acetate in rats.

Lead (Pb) exposure causes cognitive deficits in children. The present study investigated the effect of developmental exposure to Pb acetate (PbAc) on postnatal hippocampal neurogenesis. Pregnant rats were administered drinking water containing 0, 2000, or 4000 ppm PbAc from gestational day 6 until day 21 post-delivery (weaning), and offspring were maintained without PbAc exposure until adulthood on postnatal day (PND) 77. There was a dose-related accumulation of Pb in the offspring brain at weaning, while Pb was mainly excreted in adulthood. In the hippocampus, metallothionein I/II immunoreactive (+) glia were increased through adulthood as a neuroprotective response to accumulated Pb, accompanied by increased astrocyte and microglia numbers in adulthood, suggesting sustained neural damage. Gene expression changes suggested elevated oxidative stress at weaning and suppression of the antioxidant system in adulthood, as well as continued neuroinflammatory responses. At weaning, granule cell apoptosis was increased and numbers of type-3 neural progenitor cells (NPCs) were decreased. By contrast, type-2a and type-2b NPCs were increased, suggesting suppressed differentiation to type-3 NPCs. In adulthood, there were increased numbers of immature granule cells. In the hilus of the dentate gyrus, somatostatin+ interneurons were increased at weaning, while calbindin-D-29K+ interneurons were increased throughout adulthood, suggesting a strengthened interneuron regulatory system against the suppressed differentiation at weaning. In the dentate gyrus, Bdnf, Ntrk2, and Chrna7 gene expression were upregulated and numbers of hilar TrkB+ interneurons increased at weaning. These findings suggest activation of BDNF-TrkB signaling to increase somatostatin+ interneurons and promote cholinergic signaling, thus increasing later production of immature granule cells. In adulthood, Pcna and Apex1 gene expression were downregulated and Chek1 and cyclin-dependent kinase inhibitor expression were upregulated. Furthermore, there was an increase in γ-H2AX+ SGZ cells, suggesting induction of cellular senescence of SGZ cells due to Pb genotoxicity.

[Examination of Analytical Methods for Methanol, Trichloroethylene, and Tetrachloroethylene to Revise the Official Methods Based on the Act on the Control of Household Products Containing Harmful Substances].

In Japan, the use of methanol, trichloroethylene, and tetrachloroethylene in aerosol household products is banned under the Act on the Control of Household Products Containing Harmful Substances. As the official analytical methods for testing for these substances have not been revised for over 35 years, several issues have been pointed out. Thus, we developed a new method to revise the official method in our previous study. In this study, validation of the proposed method for detecting the target substances was conducted using two aerosol-product samples (A and B), which contained methanol, trichloroethylene, and tetrachloroethylene. Sample A comprised regulated values of these compounds, while sample B comprised one-tenth of the regulated amounts. They also contained several volatile compounds that served as interfering substances. Subsequently, the samples were analyzed using head space/gas chromatography-mass spectrometry, and it was confirmed that the three target substances were separated from the other chemicals on chromatograms. Validation tests were conducted at seven laboratories to evaluate the proposed method using the prepared samples. In one laboratory, the recovery of trichloroethylene and tetrachloroethylene in sample B was slightly higher at 120%, while the recoveries obtained from the other tests were between 70% and 120%. Relative standard deviation at each laboratory was less than 10%. Furthermore, the relative standard deviations between the validation tests with respect to each chemical were less than 15%. Therefore, the method validated in this study was considered to be effective as a revised method for testing for methanol, trichloroethylene, and trichloroethylene in household aerosol products.

Evaluation of the sensitization potential of volatile and semi-volatile organic compounds using the direct peptide reactivity assay.

The purpose of this study was to evaluate the sensitization potential of 82 compounds classified as volatile and/or semi-volatile organic compounds using the direct peptide reactivity assay (DPRA), given that these chemical compounds have been detected frequently and at high concentrations in a national survey of Japanese indoor air pollution and other studies. The skin sensitization potential of 81 of these compounds was evaluable in our study; one compound co-eluted with cysteine peptide and was therefore not evaluable. Twenty-five of the evaluated compounds were classified as positive. Although all glycols and plasticizers detected frequently and at high concentrations in a national survey of Japanese indoor air pollution were negative, hexanal and nonanal, which are found in fragrances and building materials, tested positive. Monoethanolamine and 1,3-butanediol, which cause clinical contact dermatitis, and several compounds reported to have weak sensitization potential in animal studies, were classified as negative. Thus, it was considered that compounds with weak sensitization potential were evaluated as negative in the DPRA. Although the sensitization potential of the formaldehyde-releasing preservative bronopol has been attributed to the release of formaldehyde (a well-known contact allergen) by its degradation, its degradation products-bromonitromethane and 2-bromoethanol-were classified as positive, indicating that these degradation products also exhibit sensitization potential. The compounds that tested positive in this study should be comprehensively assessed through multiple toxicity and epidemiological studies.