Accuracy and Precision of Three Acceleromyographs, Three Electromyographs, and a Mechanomyograph Measuring the Train-of-four Ratio in the Absence of Neuromuscular Blocking Drugs.

BACKGROUND: The accuracy and precision of currently available, widely used acceleromyograph and electromyograph neuromuscular blockade monitors have not been well studied. In addition, the normalization of the train-of-four ratio from acceleromyography (train-of-four ratio [T4/T1] divided by the baseline train-of-four ratio) has not been validated in comparison to mechanomyography. METHODS: Enrolled patients had surgery under general anesthesia with a supraglottic airway and without any neuromuscular blocking drugs. Three acceleromyograph monitors, three electromyograph monitors, and a mechanomyograph built in the authors' laboratory were tested. Most patients had an electromyograph and the mechanomyograph on one arm and a third monitor on the contralateral arm. Train-of-four ratios were collected every 12 to 20 s for the duration of the anesthetic. At least 1,000 train-of-four ratios were recorded for each device. Gauge repeatability and reproducibility analysis was performed. RESULTS: Twenty-eight patients were enrolled. In total, 9,498 train-of-four ratio measurements were collected. Since no neuromuscular blocking drugs were used, the expected train-of-four ratio was 1.0. All of the acceleromyograph monitors produced overshoot in the train-of-four ratio (estimated means, 1.10 to 1.13) and substantial variability (gauge SDs, 0.07 to 0.18). Normalization of the train-of-four ratio measured by acceleromyography improved the estimated mean for each device (0.97 to 1.0), but the variability was not improved (gauge SDs, 0.06 to 0.17). The electromyograph and the mechanomyograph monitors produced minimal overshoot (estimated means, 0.99 to 1.01) and substantially less variation (gauge SDs, 0.01 to 0.02). For electromyography and mechanomyography, 0.3% of all train-of-four ratios were outside of the range 0.9 to 1.1. For acceleromyography, 27 to 51% of normalized train-of-four ratios were outside the range of 0.9 to 1.1. CONCLUSIONS: Three currently available acceleromyograph monitors produced overshoot and substantial variability that could be clinically significant. Normalization corrected the overshoot in the average results but did not reduce the wide variability. Three electromyograph monitors measured the train-of-four ratio with minimal overshoot and variability, similar to a mechanomyograph.

Evolution of a laboratory mechanomyograph.

Mechanomyography is currently the accepted laboratory reference standard for quantitative neuromuscular blockade monitoring. Mechanomyographs are not commercially available. Previously, a mechanomyograph was built by our laboratory and used in several clinical studies. It was subsequently redesigned to improve its usability and functionality and to accommodate a wider range of hand sizes and shapes using an iterative design process. Each version of the redesigned device was initially tested for usability and functionality in the lab with the investigators as subjects without electrical stimulation. The redesigned devices were then assessed on patients undergoing elective surgery under general anesthesia without neuromuscular blocking drugs. Since the patients were not paralyzed, the expected train-of-four ratio was 1.0. The device accuracy and precision were represented by the train-of-four ratio mean and standard deviation. If issues with the device's useability or functionality were discovered, changes were made, and the redesign processes repeated. The final mechanomyograph design was used to collect 2,362 train-of-four ratios from 21 patients. The mean and standard deviation of the train-of-four ratios were 0.99 ± 0.030. Additionally, the final mechanomyograph design was easier to use and adjust than the original design and fit a wider range of hand sizes. The final design also reduced the frequency of adjustments and the time needed for adjustments, facilitating data collection during a surgical procedure.

Reducing airborne transmissible diseases in perioperative environments.

The COVID-19 pandemic has transformed our understanding of aerosol transmissible disease and the measures required to minimise transmission. Anaesthesia providers are often in close proximity to patients and other hospital staff for prolonged periods while working in operating and procedure rooms. Although enhanced ventilation provides some protection from aerosol transmissible disease in these work areas, close proximity and long duration of exposure have the opposite effect. Surgical masks provide only minimal additional protection. Surgical patients are also at risk from viral and bacterial aerosols. Despite having recently experienced the most significant pandemic in 100 yr, we continue to lack adequate understanding of the true risks encountered from aerosol transmissible diseases in the operating room, and the best course of action to protect patients and healthcare workers from them in the future. Nevertheless, hospitals can take specific actions now by providing respirators for routine use, encouraging staff to utilise respirators routinely, establishing triggers for situations that require respirator use, educating staff concerning the prevention of aerosol transmissible diseases, and providing portable air purifiers for perioperative spaces with low levels of ventilation.

Comparative performance of stimpod electromyography with mechanomyography for quantitative neuromuscular blockade monitoring.

PURPOSE: The purpose of this study was to compare the Stimpod electromyograph neuromuscular blockade monitor to mechanomyography, which is widely considered to be the reference standard. METHODS: The Stimpod electromyograph was used with its designated electrode array on the same hand as the mechanomyograph. Pairs of train-of-four measurements were recorded every 0.5-2 min. When the train-of-four count was zero on the electromyograph monitor, pairs of post tetanic count measurements were recorded every 2.5 min, instead of train-of-four measurements. Measurements were recorded from immediately after induction of anesthesia until just before emergence. Stimulation current was set to 60 mA with a duration of 200 microsec. The mechanomyography recording system recorded each twitch waveform for analysis. High resolution electromyograph waveforms were also recorded using a datalogger accessory provided by the manufacturer, facilitating inspection of individual waveforms. The administration of neuromuscular blocking drugs was left up to the discretion of the anesthesia care team. RESULTS: Twenty-three patients contributed 1,088 data pairs suitable for analysis. Bland-Altman analysis of 415 pairs of train-of-four ratios showed a bias of 0.028 and limits of agreement of -0.18 and 0.24. Two hundred seventy-three train-of-four count data pairs were compared by Cohen's quadratically weighted kappa which was calculated to be 0.44, indicating moderate agreement. Three hundred thirty-eight post tetanic count data pairs were compared by Cohen's quadradically weighted kappa which was calculated to be 0.80, indicating substantial agreement. CONCLUSION: The electromyograph produced results that were comparable to the mechanomyograph.

Lessons from aviation safety: pilot monitoring, the sterile flight deck rule, and aviation-style computerised checklists in the operating room.

Commercial aviation practices including the role of the pilot monitoring, the sterile flight deck rule, and computerised checklists have direct applicability to anaesthesia care. The pilot monitoring performs specific tasks that complement the pilot flying who is directly controlling the aircraft flight path. The anaesthesia care team, with two providers, can be organised in a manner that is analogous to the two-pilot flight deck. However, solo providers, such as solo pilots, can emulate the pilot monitoring role by reading checklists aloud, and utilise non-anaesthesia providers to fulfil some of the functions of pilot monitoring. The sterile flight deck rule states that flight crew members should not engage in any non-essential or distracting activity during critical phases of flight. The application of the sterile flight deck rule in anaesthesia practice entails deliberately minimising distractions during critical phases of anaesthesia care. Checklists are commonly used in the operating room, especially the World Health Organization surgical safety checklist. However, the use of aviation-style computerised checklists offers additional benefits. Here we discuss how these commercial aviation practices may be applied in the operating room.

A Low-power wearable acoustic device for accurate invasive arterial pressure monitoring.

BACKGROUND: Millions of catheters for invasive arterial pressure monitoring are placed annually in intensive care units, emergency rooms, and operating rooms to guide medical treatment decision-making. Accurate assessment of arterial blood pressure requires an IV pole-attached pressure transducer placed at the same height as a reference point on the patient's body, typically, the heart. Every time a patient moves, or the bed is adjusted, a nurse or physician must adjust the height of the pressure transducer. There are no alarms to indicate a discrepancy between the patient and transducer height, leading to inaccurate blood pressure measurements. METHODS: We present a low-power wireless wearable tracking device that uses inaudible acoustic signals emitted from a speaker array to automatically compute height changes and correct the mean arterial blood pressure. Performance of this device was tested in 26 patients with arterial lines in place. RESULTS: Our system calculates the mean arterial pressure with a bias of 0.19, inter-class correlation coefficients of 0.959 and a median difference of 1.6 mmHg when compared to clinical invasive arterial measurements. CONCLUSIONS: Given the increased workload demands on nurses and physicians, our proof-of concept technology may improve accuracy of pressure measurements and reduce the task burden for medical staff by automating a task that previously required manual manipulation and close patient surveillance.

Arterial catheters are commonly inserted in hospitalized, critically ill patients to measure blood pressure. For these systems to work properly, a device that measures pressure, called a pressure transducer, must be connected to the catheter, and maintained at the same height as a reference point, usually the heart. So, if the patient moves, the transducer must be manually adjusted by a nurse of physician, adding to the workload of busy clinicians. If not adjusted, this will lead to inaccurate blood pressure measurements. We built a low-power wearable tracking device that uses inaudible acoustic signals to track changes in the patient's position. These height differences can be used to calculate accurate blood pressure measurements automatically. This device can decrease clinician workload by removing the need to move the transducer by hand, allowing providers to focus on other tasks.

A Dose-finding Study of Sugammadex for Reversal of Rocuronium in Cardiac Surgery Patients and Postoperative Monitoring for Recurrent Paralysis.

BACKGROUND: The dose of sugammadex recommended by the manufacturer for reversal of rocuronium is 2 mg/kg when the train-of-four count is 2 or more and 4 mg/kg when it is less than 2 but there is a posttetanic count of at least 1. The purpose of this dose-finding study was to titrate sugammadex to produce a train-of-four ratio 0.9 or greater at the conclusion of cardiac surgery, and to continue monitoring neuromuscular blockade in the intensive care unit to identify recurrent paralysis. The hypothesis was that many patients would require less than the recommended dose of sugammadex, but that some would require more, and that recurrent paralysis would not occur. METHODS: Neuromuscular blockade was monitored using electromyography during cardiac surgery. Administration of rocuronium was at the discretion of the anesthesia care team. During sternal closure, sugammadex was titrated in 50-mg increments every 5 min until a train-of-four ratio 0.9 or greater was obtained. Neuromuscular blockade was monitored with electromyography in the intensive care unit until sedation was discontinued before extubation or for a maximum of 7 h. RESULTS: Ninety-seven patients were evaluated. The dose of sugammadex required to achieve a train-of-four ratio of 0.9 or greater varied from 0.43 to 5.6 mg/kg. There was a statistically significant relationship between the depth of neuromuscular blockade and the sugammadex dose required for reversal, but there was a large variation in dose required at any depth of neuromuscular blockade. Eighty-four of 97 patients (87%) required less than the recommended dose, and 13 (13%) required more. Two patients required additional sugammadex administration for recurrent paralysis. CONCLUSIONS: When sugammadex was titrated to effect, the dose was usually less than the recommended dose, but it was more in some patients. Therefore, quantitative twitch monitoring is essential for ascertaining that adequate reversal has taken place after sugammadex administration. Recurrent paralysis was observed in two patients.

Comparison of a Modern Digital Mechanomyograph to a Mechanomyograph Utilizing an Archival Grass Force Transducer.

BACKGROUND: Mechanomyography is the traditional gold standard research technique for quantitative assessment of neuromuscular blockade. Mechanomyography directly measures the isometric force generated by the thumb in response to ulnar nerve stimulation. Researchers must construct their own mechanomyographs since commercial instruments are no longer available. A mechanomyograph was constructed, and its performance was compared against an archival mechanomyography system from the 1970s that utilized an FT-10 Grass force transducer, hypothesizing that train-of-four ratios recorded on each device would be equivalent. METHODS: A mechanomyograph was constructed using 3D-printed components and modern electronics. An archival mechanomyography system was assembled from original components, including an FT-10 Grass force transducer. Signal digitization for computerized data collection was utilized instead of the original paper strip chart recorder. Both devices were calibrated with standard weights to demonstrate linear voltage response curves. The mechanomyographs were affixed to opposite arms of patients undergoing surgery, and the train-of-four ratio was measured during the onset and recovery from rocuronium neuromuscular blockade. RESULTS: Calibration measurements exhibited a positive linear association between voltage output and calibration weights with a linear correlation coefficient of 1.00 for both mechanomyography devices. The new mechanomyograph had better precision and measurement sensitivity than the archival system: 5.3 mV versus 15.5 mV and 1.6 mV versus 5.7 mV, respectively (P < 0.001 for both). A total of 767 pairs of train-of-four ratio measurements obtained from eight patients had positive linear association (R 2 = 0.94; P < 0.001). Bland-Altman analysis resulted in bias of 3.8% and limits of agreement of -13% and 21%. CONCLUSIONS: The new mechanomyograph resulted in similar train-of-four ratio measurements compared to an archival mechanomyography system utilizing an FT-10 Grass force transducer. These results demonstrated continuity of gold standard measurement of neuromuscular blockade spanning nearly 50 yr, despite significant changes in the instrumentation technology.

The Association Between Hypophosphatemia and Lactic Acidosis After Cardiac Surgery With Cardiopulmonary Bypass: A Retrospective Cohort Study.

OBJECTIVES: The clinical significance of hypophosphatemia in cardiac surgery has not been investigated extensively. The aim of this study was to evaluate the association of postoperative hypophosphatemia and lactic acidosis in cardiac surgery patients at the time of intensive care unit (ICU) admission. DESIGN: A retrospective cohort study. SETTING: At a single academic center. PARTICIPANTS: Patients who underwent nontransplant cardiac surgery with cardiopulmonary bypass between August 2009 and December 2020. INTERVENTIONS: None. MEASUREMENTS AND MAIN RESULTS: Serum phosphate and lactate levels were measured upon ICU admission in patients undergoing nontransplant cardiac surgery with cardiopulmonary bypass. There were 681 patients in the low-phosphate (<2.5 mg/dL) group and 2,579 patients in the normal phosphate group (2.5-4.5 mg/dL). A higher proportion of patients in the low phosphate group (26%; 179 of 681; 95% CI: 23-30) had severe lactic acidosis compared to patients in the normal phosphate group (16%; 417 of 2,579; 95% CI: 15-18). In an unadjusted logistic regression model, patients in the low phosphate group had 1.9-times the odds of having severe lactic acidosis (serum lactate ≥4.0 mmol/L) when compared to patients in the normal phosphate group (95% CI: 1.5-2.3), and still 1.4-times the odds (95% CI: 1.1-1.7) after adjusting for several possible confounders. CONCLUSIONS: Hypophosphatemia is associated with lactic acidosis in the immediate postoperative period in cardiac surgery patients. Future studies will need to investigate it as a potential treatment target for lactic acidosis.

Take action now to prevent medication errors: lessons from a fatal error involving an automated dispensing cabinet.

An error in the administration of an anaesthetic medication related to an automated dispensing cabinet resulted in a patient fatality and a highly publicised criminal prosecution of a healthcare worker, which concluded in 2022. Urgent action is required to re-engineer systems and workflows to prevent such errors. Exhortation, blame, and criminal prosecution are unlikely to advance the cause of patient safety.