Percutaneous absorption of aromatic amines - a contribution for human health risk assessment.

Several aromatic amines (AA) are human carcinogens. AA are widely-used, e.g., in the rubber industry. The uptake of AA at the workplace occurs by inhalation and percutaneous absorption. At present there are no risk assessment studies for percutaneous AA absorption using occupationally relevant concentrations. We conducted diffusion cell experiments for aniline (ANI), o-toluidine (OT), 4,4'-methylenedianiline (MDA) and N-phenyl-2-naphthylamine (PBNA). Excised human skin was exposed to different AA concentrations in vehicles containing water and solvents. Recovery for ANI in receptor fluid was about 20-38% and for MDA 15% over 24h. PBNA could not be detected in the receptor fluid. Further data for OT and beta-naphthylamine (BNA) were considered from our recent study. A semi-quantitative percutaneous absorption ranking for AA was derived: BNA>OT>ANI>MDA>PBNA. For aqueous ANI solutions up to saturation a linear relationship of exposed dose and penetrated amount was observed. However, a linear extrapolation of the flux of neat compounds, as often recommended for risk assessment policies, underestimates considerably the percutaneous uptake. The in vitro data support our recent findings in rubber industry workers that the percutaneous absorption may significantly contribute to overall exposure of AA.

Percutaneous absorption of aromatic amines in rubber industry workers: impact of impaired skin and skin barrier creams.

BACKGROUND: Several aromatic amines (AA) could cause bladder cancer and are an occupational hygiene problem in the workplace. However, little is known about the percutaneous absorption of chemicals via impaired skin and about the efficacy of skin protection measures to reduce internal exposure. AIMS: To determine the impact of skin status and of skin protection measures on the internal exposure to AA in workers manufacturing rubber products. METHODS: 51 workers occupationally exposed to aniline and o-toluidine were examined. The workplace conditions, risk factors for skin and the use of personal protective equipment were assessed by means of a self-administered questionnaire. The skin of hands and forearms was clinically examined. Exposure to aniline and o-toluidine was assessed by ambient air and biological monitoring (analyses of urine samples and of haemoglobin adducts). RESULTS: Haemoglobin-AA-adduct levels in workers with erythema (73%) were significantly higher (p<0.04) than in workers with healthy skin (mean values: aniline 1150.4 ng/l vs 951.7 ng/l, o-toluidine 417.9 ng/l vs 118.3 ng/l). The multiple linear regression analysis showed that wearing gloves significantly reduced the internal exposure. A frequent use of skin barrier creams leads to a higher internal exposure of AA (p<0.03). However, the use of skincare creams at the workplace was associated with a reduced internal exposure (p<0.03). From these findings we assume that internal exposure of the workers resulted primarily from the percutaneous uptake. CONCLUSIONS: The study demonstrates a significantly higher internal exposure to AA in workers with impaired skin compared with workers with healthy skin. Daily wearing of gloves efficiently reduced internal exposure. However, an increased use of skin barrier creams enhances the percutaneous uptake of AA. Skincare creams seem to support skin regeneration and lead to reduced percutaneous uptake.

Investigations on safety of hyperthermic intraoperative intraperitoneal chemotherapy (HIPEC) with Mitomycin C.

AIMS: Previous safety monitoring of hyperthermic intraoperative intraperitoneal chemotherapy (HIPEC) with Mitomycin C (MMC) did not demonstrate any detectable safety hazard to the personnel. Nevertheless, those results have been discussed controversially because of the methodological problems employed in the evaluation of potential exposure. We re-evaluated possible safety hazards of HIPEC by applying different monitoring strategies. METHODS: We monitored air samples in the operation room during HIPEC. In addition, we measured MMC in plasma of the surgeon with a newly developed analytical method. All samples were analysed by HPLC-UV at 360nm. The permeability of the gloves was tested using two in vitro techniques: diffusion cells and a glass cell chamber. In-use and worst-case exposure scenarios were imitated for in vitro experiments. RESULTS: The analysis of the air samples (n=3) could not detect any MMC. We found no drug above the limit of detection (1microg MMC/L) in the plasma samples of the surgeons (n=5). A breakthrough of latex glove material was detected in only one (worst-case exposure scenario) of 40 diffusion cell experiments. CONCLUSIONS: Established methods of safety monitoring could not reveal any detectable risk on in-use exposure conditions. The wearing of doubled latex gloves should prevent the surgeon from dermal exposure to MMC during HIPEC.

In vitro predictions of skin absorption of caffeine, testosterone, and benzoic acid: a multi-centre comparison study.

To obtain better insight into the robustness of in vitro percutaneous absorption methodology, the intra- and inter-laboratory variation in this type of study was investigated in 10 European laboratories. To this purpose, the in vitro absorption of three compounds through human skin (9 laboratories) and rat skin (1 laboratory) was determined. The test materials were benzoic acid, caffeine, and testosterone, representing a range of different physico-chemical properties. All laboratories performed their studies according to a detailed protocol in which all experimental details were described and each laboratory performed at least three independent experiments for each test chemical. All laboratories assigned the absorption of benzoic acid through human skin, the highest ranking of the three compounds (overall mean flux of 16.54+/-11.87 microg/cm(2)/h). The absorption of caffeine and testosterone through human skin was similar, having overall mean maximum absorption rates of 2.24+/-1.43 microg/cm(2)/h and 1.63+/-1.94 microg/cm(2)/h, respectively. In 7 out of 9 laboratories, the maximum absorption rates of caffeine were ranked higher than testosterone. No differences were observed between the mean absorption through human skin and the one rat study for benzoic acid and testosterone. For caffeine the maximum absorption rate and the total penetration through rat skin were clearly higher than the mean value for human skin. When evaluating all data, it appeared that no consistent relation existed between the diffusion cell type and the absorption of the test compounds. Skin thickness only slightly influenced the absorption of benzoic acid and caffeine. In contrast, the maximum absorption rate of testosterone was clearly higher in the laboratories using thin, dermatomed skin membranes. Testosterone is the most lipophilic compound and showed also a higher presence in the skin membrane after 24 h than the two other compounds. The results of this study indicate that the in vitro methodology for assessing skin absorption is relatively robust. A major effort was made to standardize the study performance, but, unlike in a formal validation study, not all variables were controlled. The variation observed may be largely attributed to human variability in dermal absorption and the skin source. For the most lipophilic compound, testosterone, skin thickness proved to be a critical variable.

In vitro evaluation of the efficacy of skin barrier creams and protective gloves on percutaneous absorption of industrial solvents.

OBJECTIVES: The aim of the experiments was to evaluate the efficacy of skin barrier creams (SBCs) and protective gloves and its potential for reduction of percutaneous absorption of industrial solvents. METHODS: We assessed percutaneous absorption of ethylene glycol (EG), isopropyl alcohol (IA) and 1,2,4-trimethylbenzene (TMB), using static diffusion cells. These solvents were applied neat (EG, TMB) as well as in 10% and 50% aqueous solution (EG, IA) or in 10% and 50% ethanol-diluted solution (TMB). Furthermore, we tested the percutaneous absorption of IA mixed in one cleaning agent (CA), used in newspaper printing shops to clean the rollers of printing machines. Additionally, the penetration behaviour of 10% and 50% solutions of EG, IA and TMB was tested. The experiments were carried out on untreated and on SBC-treated excised human skin from one donor, and on protective gloves. Saline was used as receptor fluid for EG and IA, and neat ethanol for TMB. RESULTS: The penetration of 50% EG, IA and TMB solutions through SBC-treated skin was higher than in untreated skin (factor 3.9 for EG, 0.32 for IA and 0.06 for TMB). The penetration of IA in the IA-CA mixture was five-times higher through untreated skin as for the single compound in 10% aqueous solution. In skin, treated with SBC, we found a 17-fold penetration enhancement of IA in the IA-CA mixture. No appreciable penetration of EG and IA was observed through nitrile rubber gloves. CONCLUSIONS: Our in vitro experiments could not demonstrate an efficacy of SBC to protect skin penetration for the tested solvents. The percutaneous absorption of all solvents in 50% solution was increased through skin treated with SBCs. Furthermore, SBCs enhance the penetration rates of solvents from complex mixtures compared with the single solvents. The tested gloves showed sufficient protection for the hydrophilic solvents, but not for TMB.

Cardiovascular function of workers exposed to carbon disulphide.

OBJECTIVES: The aim of the study was to verify that exposure to carbon disulphide (CS(2)) up to 10 ppm results in a negative inotropic effect on cardiovascular function. METHODS: In a cross-sectional study a total of 325 workers exposed to CS(2) in the rayon-producing industry and 179 controls from the same plants were examined. The exposure assessment was based on personal air sampling and biological monitoring (2-thiothiazolidine-4-carboxylic acid (TTCA) in urine) for all persons. The examination consisted of a standardised questionnaire, physical examination, assessment of body fat mass, ergometric test with the determination of work capacity at heart rates of 100, 130, 150 and 170 beats/min, and electrocardiography. RESULTS: The mean external exposure was 6.04 ppm CS(2) (range: 0.03-91.08); the mean internal exposure was 1.14 mg TTCA/g creatinine (range: 0.02-11.50). The workers exposed to CS(2) showed better physical fitness. The diameters of the left heart chamber of the exposed persons were not significantly different when compared with occupationally non-exposed workers, but there was a tendency of increasing diameters for the exposed employees. In the multiple linear regression the diameters showed physiologically plausible correlations with the body mass index, body fat mass, alcohol consumption, and physical fitness, but not, however, with the exposure, neither with the exposure group in all persons nor with the internal or external exposure within the exposed workers. CONCLUSIONS: In this study, differences in the heart chamber diameters between exposed persons and controls could not be confirmed. Differences in physical fitness and constitution can explain differences in heart chamber diameters.

Skin strain and its influence on systemic exposure to a glycol ether in offset printing workers.

Under workplace conditions, it is difficult to prove the influence of skin lesions on skin penetration by chemical substances. The aim of the present study was to show whether systemic exposure to glycol ether increases due to lesions of the skin in printing workers. 28 male printers, exposed to 2-(2-butoxyethoxy)ethanol (BEE), were interviewed about the workplace exposure by a standardized questionnaire. The systemic exposure in printers was determined by biological monitoring of the main metabolite of BEE butoxyethoxyacetic acid (BEAA) in urine. Furthermore, clinical examination of the skin, transepidermal water loss, capacitance and skin surface pH measurements were carried out. Erythema and scaliness were the most important factors showing an effect on dermal absorption. The mean urinary BEAA excretions for printers with skin lesions on the hands were higher (20.62 mg/l for scaliness and 14.40 mg/l for erythema) compared to that for printers without detectable skin lesions (12.08 mg/l for scaliness and 13.03 mg/l for erythema). Bioengineering measurements to predict skin strain and percutaneous absorption were only supportive. We were able to show that by using a multiple spectrum of methods an enhancement of percutaneous absorption of BEE could be demonstrated in workers with skin lesions.