Life cycle assessment and cost-benefit analysis of small-scale anaerobic digestion system treating food waste onsite under different operational conditions.

This study employed life cycle assessment and cost-benefit analysis to evaluate the environmental and economic profile of a real decentralized small-scale anaerobic digestion (AD) system treating food waste (FW). Different operational conditions, including temperature, biochar addition, biogas engine efficiency, and FW loading, were compared via scenario analysis. Biochar addition could potentially obtain carbon reduction and save fossil fuel. Moreover, at high FW loading and biogas engine efficiency, biochar addition achieved 1-3190% better performance than the system without biochar in all the nine impact categories. The system under mesophilic conditions performed worse than ambient conditions due to high energy demand. All the current scenarios resulted in a monetary loss at US$ 480 k-681 k, while profit was possible if the capital cost and operator salary decreased significantly. Overall, operating the small-scale AD system under ambient temperature with biochar addition was preferred due to its potential environmental benefits and economic profits.

A closed loop case study of decentralized food waste management: System performance and life cycle carbon emission assessment.

Food waste (FW) has become a worldwide issue, while anaerobic digestion (AD) has appeared as a widely adopted technology to recover energy and resources from FW. Compared to many existing case studies of centralized AD system, the comprehensive study of decentralized micro-AD system from both system energy efficiency and carbon emission perspective is still scanty, particularly system operated under ambient temperature conditions. In this study, an actual decentralized micro-AD system with treating capacity of 300 kg FW/d for a local hawker center in Singapore was reported and evaluated. The results showed that 1894.5 kg of FW was treated and 173 m3 biogas with methane content of 53 % was produced during the experimental period of 75 days. The methane yield results showed a high FW degradation efficiency (87.87 %). However, net energy consumption and net carbon emission were observed during the experimental period. Nevertheless, energy self-efficiency and carbon neutrality, even net energy output and carbon reduction, can be achieved by increasing daily FW loading and biogas engine efficiency. Specifically, the FW loading for system energy self-efficiency was identified as 159 kg/d for engine efficiency of 35 % at a high kitchen waste/table waste ratio (63 %/37 %, with covid-19 dine-in restrictions); while they were 112 and 58 kg/d for engine efficiency of 25 % and 35 %, respective, at a low kitchen waste/table waste ratio (31 %/69 %, without covid-19 dine-in restrictions). The carbon emission ranged from 156.08 kg CO2-eq/t FW to -77.35 kg CO2-eq/t FW depending on the FW loading quantity and engine efficiency. Moreover, the sensitivity analysis also showed that the used electricity source for substitution influenced the carbon emission performance significantly. The obtained results imply that the decentralized micro-AD system could be a feasible FW management solution for energy generation and carbon reduction when the FW loading and engine electrical efficiency are carefully addressed.

Startup performance and microbial communities of a decentralized anaerobic digestion of food waste.

The aim of this work was to evaluate the feasibility of treating food waste generated from a hawker centre in a pilot-scale anaerobic digester operating on site in an urban area of Singapore. For this purpose, a 10.4 m3 digester was housed within two 20 feet containerized systems and sited adjacent to the hawker centre. The system reported in this work was during the startup phase, for over 71 days of real and varying food wastes loading rate. The results demonstrated that the decentralized system had an average specific methane yield of 0.55 ± 0.04 m3CH4/kgVS, with methane concentrations of 56.6 ± 2.3%. For the power generation output, the energy assessment revealed an average of 2.05 ± 0.57 m3/kW h consumption rate. Accordingly, on the last day of startup phase, the inoculum of the digester was richer in organisms from the phylum Thermoplasmatota, i.e., genera Candidatus_Methanogranum and Candidatus_Methanoplasma, alongside with other dominant abundance from phyla Bacteroidota, Firmicutes, Synergistota, and Verrucomicrobiota. This study provides new insights into pilot scale decentralized anaerobic digestion with varying food waste relate to the characterizations of digester microbial communities, as well as turning in a typical integrated anaerobic digestion of food waste-to-energy system a reality.