RESUMO
Food waste is one of the important reservoirs of antibiotic resistance genes ï¼ARGsï¼, and its resource utilization has potential environmental risks. Anaerobic digestion ï¼ADï¼ technology can concurrently achieve resource recovery and ARGs removal, which is one of the popular resource technologies for food waste management. However, the removal efficiency of ARGs during the AD process is limited, and thus the safety of digestate for agricultural use is still questioned. Therefore, how to improve the performance of ARGs removal during the AD process is critical for efficient and environmentally friendly bioconversion of food waste. This study summarized the transmission pathways and mechanisms of ARGs in food wasteï¼ discussed the effects of different operation parameters on the transmission of ARGs in food waste during the AD processï¼ described the research progress of exogenous addition of conductive materials, feedstock pretreatment, etc., strategies to enhance the removal of ARGsï¼ and analyzed the migration regularity and removal mechanism of ARGs in food waste during the AD process, which mainly included microbial community structure evolution, mobile genetic element changes, and environmental factor changes. Finally, this study prospected the future improvement of methane yield and ARGs removal in the AD process of food waste based on the existing research.
Assuntos
Resistência Microbiana a Medicamentos , Anaerobiose , Resistência Microbiana a Medicamentos/genética , Eliminação de Resíduos/métodos , Reatores Biológicos/microbiologia , Alimentos , Biodegradação Ambiental , Perda e Desperdício de AlimentosRESUMO
Low methane production and long retention time are the main dilemmas in current anaerobic digestion (AD) of waste activated sludge (WAS). This work used WAS as only substrate to prepare oriented multi-enzyme (ME) that directly used for WAS pretreatment. Under the optimal parameters, the highest activities of protease and amylase in ME could respectively reach 16.5 U/g and 580 U/g, and the corresponding methane production attained 197 mLCH4/g VS, which was increased by 70.4% compared to blank group. It was found that ME pretreatment could strengthen WAS disintegration and organic matters dissolution, lead to the soluble chemical oxygen demand (SCOD) was increased from the initial 486 mg/L to 2583 mg/L, and the corresponding volatile suspended solid (VSS) and extracellular polymeric substances (EPS) were reduced by 27% and 73.8%, respectively. The results of three-dimensional excitation-emission matrix (3D-EEM) and Fourier transform infrared spectroscopy (FTIR) indicated that protein disintegration may be the critical step during the process of WAS hydrolysis with ME, of which the release of tyrosine-like proteins achieved the better biodegradability of WAS, while the results of X-ray photoelectron spectroscopy (XPS) showed that the formation of protein derivatives was the main harmful factor that could extend the lag phase of AD process. Microbial communities analysis further suggested that ME pretreatment facilitated the enrichment of acetogenic bacteria and acetotrophic methanogens, which caused the transition of the methanogenesis pathway from hydrogenotrophic to acetotrophic. This study is expected to furnish valuable insight for ME pretreatment on enhancing WAS disintegration and methane production.
Assuntos
Biodegradação Ambiental , Metano , Esgotos , Anaerobiose , Metano/metabolismo , Análise da Demanda Biológica de Oxigênio , Eliminação de Resíduos Líquidos/métodos , Espectroscopia de Infravermelho com Transformada de Fourier , Reatores BiológicosRESUMO
With the drastic growth of the economic and population, the global energy requirement is on the rise, and massive human and material resources have been put into the development of alternative and renewable energy sources. Biodiesel has been recognized as a green and sustainable alternative energy, but the raw materials-associated source and cost makes it difficult to achieve large-scale commercial production. Microbial lipids (ML) produced by oleaginous microbes have attracted more and more topics as feedstocks for biodiesel production because of their unique advantages (fast growth cycle, small footprint and so on). However, there are still many problems and challenges ahead towards commercialization of ML-based biodiesel, especially the cost of feedstock for ML production. Food waste (FW) rich in organic matters and nutrients is an excellent and almost zero-cost feedstock for ML production. However, current biological routes of FW-based ML production have some defects, which make it impossible to achieve full industrialization at present. Therefore, this review intends to provide a critical and comprehensive analysis of current biological routes of FW-based ML production with the focus on the challenges and solutions forward. The biological routes towards future FW-based ML production must be able to concurrently achieve economic feasibility and environmental sustainability. On this condition, an innovative integrated biological route for FW-based ML production has thus been put forward, which is also elucidated on its economic and environmental sustainability. Moreover, the prospective advantages, limitations and challenges for future scale-up of FW-based ML production have also been outlined, together with the perspectives and directions forward.
Assuntos
Biocombustíveis , Biocombustíveis/economia , Lipídeos , Perda e Desperdício de AlimentosRESUMO
The artificial regulation of the Three Gorges Reservoir (TGR) creates large water level fluctuation zones (WLFZ) that may change the behavior of metals and metalloid in sediment, particularly redox sensitive elements. Mobilization of As, Fe and Mn across the sediment-water interface (SWI) in the TGR as a function of different water depth (periodically and permanently submerged sediments, respectively) was in situ determined by diffusive gradients in thin films (DGT) and high-resolution dialysis technique (HR-Peeper), respectively. The results showed that the mobilization of As was significantly affected by Fe/Mn especially Mn, across the SWI. Duo to the oxic-anoxic transitional state in near bottom water, the reduced Fe and Mn in sediment pore water could be oxidized and precipitated again, leading to the co-precipitation of As with Fe/Mn oxides (hydroxides). Consequently, concentrations of As, Fe and Mn in labile phases and pore water were generally low across the SWI, then they sharply increased at a few centimeters below the SWI. Considering different water depth, various trends were found in labile phase, whereas concentrations of As, Fe and Mn in pore water in permanently submerged sediments were significantly higher than those in periodically submerged sediments. The dry-re-wetting alternation processes in the WLFZ may play vital roles in the resupply capacity of sediments as it was found that periodically submerged sediments with longer re-wetting time had higher Fe/Mn resupply capacity than those with shorter re-wetting times and permanently submerged sediments.
Assuntos
Arsênio , Monitoramento Ambiental , Sedimentos Geológicos , Poluentes Químicos da Água , Sedimentos Geológicos/química , Poluentes Químicos da Água/análise , Arsênio/análise , Monitoramento Ambiental/métodos , China , Ferro/análise , Ferro/química , Manganês/análise , Oxirredução , Lagos/químicaRESUMO
This research conducted an environmental life cycle assessment (LCA) to evaluate an anaerobic digestion-co-pyrolysis (ADCo-Py) system in which pyrolysis was added to traditional food waste (FW) anaerobic digestion (AD) systems to treat the solid fraction and impurities separated from FW. The solid fraction, including impurities such as wooden chopsticks, plastics, eggshells, and bones, is usually incinerated, while pyrolysis can be a viable alternative to optimize FW treatment. The environmental impact of ADCo-Py was compared with stand-alone AD, pyrolysis, and ADCo-INC (AD with incineration of separated solids). The results indicated that both ADCo-Py (-1.726 kg CO2-Eq/kgFW) and ADCo-INC (-1.535 kg CO2-Eq/kgFW) outperform stand-alone AD (-0.855 kg CO2-Eq/kgFW) and pyrolysis (-0.181 kg CO2-Eq/kgFW) in mitigating global warming potential (GWP). Additionally, pretreatments were found to have the most significant influence on GWP, ecotoxicity potential (ETP), and acidification potential (AP). The two-step pretreatment in ADCo-Py, including the separation of solids and drying, significantly improved the environmental sustainability of the system when compared with standalone pyrolysis.
Assuntos
Eliminação de Resíduos , Gerenciamento de Resíduos , Eliminação de Resíduos/métodos , Gerenciamento de Resíduos/métodos , Perda e Desperdício de Alimentos , Dióxido de Carbono , Pirólise , Anaerobiose , AlimentosRESUMO
Harmless and resourceful treatment of waste activated sludge (WAS) have been the crucial goal for building environmental-friendly and sustainable society, while the synergistic realization approach is currently limited. This work skillfully utilized the disinfectant sodium dichloroisocyanurate (NaDCC) to simultaneously achieve the pathogenic potential inactivation (decreased by 60.1 %) and efficient volatile fatty acids (VFAs) recovery (increased by 221.9 %) during WAS anaerobic fermentation in rather cost-effective way (Chemicals costs:0.4 USD/kg VFAs versus products benefits: 2.68 USD/kg chemical). Mechanistic analysis revealed that the C=O and NCl bonds in NaDCC could spontaneously absorb sludge (binding energy -4.9 kJ/mol), and then caused the sludge disintegration and organic substrates release for microbial utilization due to the oxidizability of NaDCC. The disruption of sludge structure along with the increase of bioavailable fermentation substrates contributed to the selectively regulation of microbial community via enriching VFAs-forming microorganisms (e.g., Pseudomonas and Streptomyces) and reducing VFAs-consuming microorganisms, especially aceticlastic methanogens (e.g., Methanothrix and Methanospirillum). Correspondingly, the metabolic functions of membrane transport, substrate metabolism, pyruvate metabolism, and fatty acid biosynthesis locating in the central pathway of VFAs production were all upregulated while the methanogenic step was inhibited (especially acetate-type methanogenic pathway). Further exploration unveiled that for those enriched functional anaerobes were capable to activate the self-adaptive systems of DNA replication, SOS response, oxidative stress defense, efflux pump, and energy metabolism to counteract the unfavorable NaDCC stress and maintain high microbial activities for efficient VFAs yields. This study would provide a novel strategy for synergistic realization of harmless and resourceful treatment of WAS, and identify the interrelations between microbial metabolic regulations and adaptive responses.
Assuntos
Esgotos , Triazinas , Esgotos/química , Regulação para Cima , Fermentação , Ácidos Graxos Voláteis/metabolismo , Concentração de Íons de Hidrogênio , AnaerobioseRESUMO
Bacteria in rural sewage collection systems have the important influences on operation and maintenance risks, such as sedimentation blockage and harmful gas accumulation, and pollutant pre-treatment ability. It is necessary to analyze and interpret the influence on bacterial communities caused by the location (sewage, biofilms, and deposits), season (winter and spring, summer and autumn), and system type (sewers and ditches) to better understand the bacterial characteristics in rural sewage collection systems. To achieve the above purpose, 96 samples obtained from practical rural sewage collection systems in eight villages were analyzed by 16S rRNA whole region sequencing methods. The results indicate that locations and seasons caused significant influences on the overall bacterial communities, which were mainly affected by temperature, sewage quality and bacterial survival preference, and 13 genera of sulfate-reducing bacteria (SRB), 2 genera of ammonia-oxidizing bacteria (AOB), 2 genera of nitrite-oxidizing bacteria (NOB), and 9 genera of water-related pathogenic bacteria (WPB) were detected in rural sewage collection systems. SRB, AOB, NOB, and WPB tended to inhabit in biofilms or deposits rather than in sewage. The total relative abundance of SRB in summer and autumn (â¼2.19%) was higher than in winter and spring (â¼0.41%), and the WPB distribution in different seasons showed significant distinction. Additionally, some of SRB, AOB, NOB, and WPB also showed significant differences in sewers and ditches. Overall, this study provided a deeper understanding of bacteria in rural sewage collection systems and could further provide the basic parameter for the operation and maintenance risk control.
RESUMO
This study developed a high efficiency compound enzyme (fungal mash) produced in situ from food waste (FW) used for improving hydrolysis and anaerobic digestion (AD) efficiency of FW. Results showed that the soluble COD and methane yield were respectively increased by 67.80% and 16.58% after 24 h in situ enzymatic hydrolysis of food waste by fungal mash. Furthermore, most of target ARGs in FW were also reduced by 45-94% after 24 h in situ enzymatic hydrolysis, while the total tested ARGs and intI1 were respectively further removed by 44-55% and 21-73% in subsequent AD process. In-depth analysis showed that fungal mash could effectively reduce potential hosts and control the horizontal transfer of ARGs during the in situ enzymatic hydrolysis and AD process. Ultimately, correlation analysis and redundancy analysis indicated that the evolution of bacterial communities and changes in intI1 where the common driving forces for the fate of ARGs.
Assuntos
Antibacterianos , Eliminação de Resíduos , Antibacterianos/farmacologia , Alimentos , Hidrólise , Anaerobiose , Resistência Microbiana a Medicamentos/genética , Genes Bacterianos , Esgotos/microbiologiaRESUMO
Experiments for simultaneous elimination and detoxification of microgram level of As(â ¢) in the presence of micromolar H2O2 and Fe(â ¡) which are frequently encountered in natural water were conducted. The results showed that the molar ratio of oxidant to As(III) plays important role in As(III) oxidation under the experimental conditions. The extent of As(â ¢) oxidation with single H2O2 or Fe(â ¡) ranged from 7.9 % to 60.3 % and 22.2-46.6 %, respectively. Treatments with H2O2/As(â ¢) molar ratios in the range 150: 1-750: 1 or Fe(â ¡)/As(â ¢) molar ratios in the range 37.5: 1-375: 1 were more favor for As(â ¢) oxidation respectively, and increasing oxidant concentration did not result in complete As(â ¢) oxidation. As(â ¢) was completely oxidized and eliminated following the precipitation of ferric hydroxides in 5 reaction minutes when H2O2 and Fe(â ¡) coexisted in the reaction system. The interface characterization for the reacted precipitates after the experiment were conducted by using a high-resolution field emission scanning electron microscopy (SEM) coupled with an EX-350 energy dispersive X-ray spectrometer (EDX) and X-ray photoelectron spectroscopy (XPS), respectively. The results showed that As(â ¤) was the merely arsenic species and As oxide primary situated in the subsurface layer of the reacted precipitates, whereas Fe was more concentrated in the outermost surface layer. Our research showed that H2O2 and Fe(â ¡) at natural level may exert significant influence on arsenic mobilization in natural water. Considering the much more toxic of As(â ¢) than that of As(â ¤), the research also provide us an environmental friendly choice in the elimination and detoxification of microgram As(â ¢) in drinking water.
Assuntos
Arsênio , Arsenitos , Poluentes Químicos da Água , Peróxido de Hidrogênio/química , Arsênio/química , Compostos Férricos/química , Oxirredução , Oxidantes , Água , Poluentes Químicos da Água/análise , Compostos Ferrosos/químicaRESUMO
BACKGROUND: The dramatic increase in greenhouse gas (GHG) emissions, which causes serious global environmental issues and severe climate changes, has become a global problem of concern in recent decades. Currently, native and/or non-native C1-utilizing microbes have been modified to be able to effectively convert C1-gases (biogas, natural gas, and CO2) into isobutanol via biological routes. Even though the current experimental results are satisfactory in lab-scale research, the techno-economic feasibility of C1 gas-derived isobutanol production at the industrial scale still needs to be analyzed and evaluated, which will be essential for the future industrialization of C1-gas bioconversion. Therefore, techno-economic analyses were conducted in this study with comparisons of capital cost (CAPEX), operating cost (OPEX), and minimum isobutanol selling price (MISP) derived from biogas (scenario #1), natural gas (scenario #2), and CO2 (scenario #3) with systematic economic assessment. RESULTS: By calculating capital investments and necessary expenses, the highest CAPEX ($317 MM) and OPEX ($67 MM) were projected in scenario #1 and scenario #2, respectively. Because of the lower CAPEX and OPEX from scenario #3, the results revealed that bioconversion of CO2 into isobutanol temporally exhibited the best economic performance with an MISP of $1.38/kg isobutanol. Furthermore, a single sensitivity analysis with nine different parameters was carried out for the production of CO2-derived isobutanol. The annual plant capacity, gas utilization rate, and substrate cost are the three most important economic-driving forces on the MISP of CO2-derived isobutanol. Finally, a multiple-point sensitivity analysis considering all five parameters simultaneously was performed using ideal targets, which presented the lowest MISP of $0.99/kg in a long-term case study. CONCLUSIONS: This study provides a comprehensive assessment of the bioconversion of C1-gases into isobutanol in terms of the bioprocess design, mass/energy calculation, capital investment, operating expense, sensitivity analysis, and minimum selling price. Compared with isobutanol derived from biogas and natural gas, the CO2-based isobutanol showed better economic feasibility. A market competitive isobutanol derived from CO2 is predicable with lower CO2 cost, better isobutanol titer, and higher annual capacity. This study will help researchers and decision-makers explore innovative and effective approaches to neutralizing GHGs and focus on key economic-driving forces to improve techno-economic performance.
RESUMO
In this study, waste cooking oil (WCO) co-fermentation with food waste by variable pH strategy was developed for microbial lipid production. Results showed that when WCO substitution rate within the range of 1.56-4.68% (corresponding to the WCO content in food waste), lipid production from Rhodosporidium toruloides 2.1389 could be increased by 7.2 g/kg food waste because of the better synergistic effect. Mechanism analysis revealed that the fatty acid salt produced from WCO under alkaline condition, as a surface active agent, could improve lipid production, but excessive WCO (29.2 g/L) would inhibit the lipid production due to its hindrance to the oxygen. The lipid composition analysis found that the produced lipid could be used as raw material for biodiesel production. It was estimated that 15.0 million tonnes of biodiesel could be produced from global food waste yearly by adopting the proposed WCO co-fermentation with variable pH strategy, together with reduction of about 0.31 million tonnes of CO2 equivalents and 1435 tonnes of SO2. It is expected that this study may lead to the paradigm shift in future biodiesel production from food waste.
Assuntos
Alimentos , Eliminação de Resíduos , Biocombustíveis/análise , Carbono , Culinária , LipídeosRESUMO
Antibiotic fermentation residue (AFR) is a form of bioavailable matter, that represents a typical category of hazardous waste associated with drug production in China. The disposal of these residues seriously restricts the sustainable development of the pharmaceutical industry. In this study, the steam explosion and aerobic composting (SEA-CBS) system was developed to thoroughly convert neomycin fermentation residue to organic fertilizer. The results implied that the ultimate removal rate of antibiotics was as high as 99.9% in all cases, including macrolide (kitasamycin and spiramycin), lincosamide (lincomycin), and beta-lactam (cephalosporin and penicillin) antibiotic biowastes. Pot experiments were also conducted to study the attenuation rule of antibiotic residues in the soil, and the distribution of antibiotic resistant genes from trace antibiotics. The produced fertilizer presented the better performance on mustard growth than conventional fertilizers. The average plant height and biomass were increased by 14.33%-55.83% and 136.71%-326.83%, respectively, after SEA-CBS pretreatment. Moreover, neomycin was the primary selective pressure, and six antibiotic resistance genes (ARGs) correlated with neomycin were screened. The acc(6')ib gene was identified as the target ARGs, the main resistance mechanism was antibiotic inactivation, and the absolute and relative abundances were 1.06 × 105 ± 3.80 × 104 copies/g and 6.23 × 10-4 ± 1.75 × 10-4 copies/16 s in the NFR-amended soils. The microbial community analysis showed that the variation of the soil microbial community was not dominated by neomycin fermentation residue (NFR) at initial concentrations below 0.42 µg/kg soil. This work demonstrated that the SEA-CBS system not only functioned as an efficient technology for concurrent neomycin sulfate removal and NFR composting, but also applied to a wide range of other antibiotic bio-wastes, which may benefit the recycling of AFR, as well as the data provide a theoretical basis for future agricultural utilization and safe evaluation.
Assuntos
Antibacterianos , Neomicina , Antibacterianos/farmacologia , Resistência Microbiana a Medicamentos/genética , Fermentação , Genes Bacterianos , Esterco , Solo , Microbiologia do SoloRESUMO
BACKGROUND: As one of the major components of lignocellulosic biomass, lignin has been considered as the most abundant renewable aromatic feedstock in the world. Comparing with thermal or catalytic strategies for lignin degradation, biological conversion is a promising approach featuring with mild conditions and diversity, and has received great attention nowadays. RESULTS: In this study, a consortium of white rot fungi composed of Lenzites betulina and Trametes versicolor was employed to enhance the ligninolytic enzyme activity of laccase (Lac) and manganese peroxidase (MnP) under microbial synergism. The maximum enzymatic activity of Lac and MnP was individually 18.06 U mL-1 and 13.58 U mL-1 along with a lignin degradation rate of 50% (wt/wt), which were achieved from batch cultivation of the consortium. The activities of Lac and MnP obtained from the consortium were both improved more than 40%, as compared with monocultures of L. betulina or T. versicolor under the same culture condition. The enhanced biodegradation performance was in accordance with the results observed from scanning electron microscope (SEM) of lignin samples before and after biodegradation, and secondary-ion mass spectrometry (SIMS). Finally, the analysis of heteronuclear single quantum coherence (HSQC) NMR and gas chromatography-mass spectrometry (GC-MS) provided a comprehensive product mapping of the lignin biodegradation, suggesting that the lignin has undergone depolymerization of the macromolecules, side-chain cleavage, and aromatic ring-opening reactions. CONCLUSIONS: Our results revealed a considerable escalation on the enzymatic activity obtained in a short period from the cultivation of the L. betulina or T. versicolor due to the enhanced microbial synergistic effects, providing a potential bioconversion route for lignin utilization.
RESUMO
The disposal and reuse of cephalosporin mycelia dregs (CMDs) pose a great challenge to the biopharma industry, but it acts as the new source of antibiotic resistome, although agriculture intensification remains uncertain. Herein, two common cash crops (maize and soybean) were planted in the actual field, and the effects of the application of treated CMDs, chicken manure and chemical fertilizer served as control groups were both investigated according to comparison experiment. Amplicon-targeted 16S rRNA and high-throughput sequencing was analyzed for rhizosphere antibiotic resistome. Results showed that hydrothermal and spray-dried (HT + SD) CMDs could promote nutrients uptake and stabilize soil fertility indicator, and finally improved the crop yield (maximum, 119.68%). The numbers and relative abundances of total ARGs in soils were not significantly different from that of conventional fertilizer (p ï¼ 0.05), but crop type marked the differences in distribution. The overall economic benefits are predicted to be around $373-745 million annually, considering its application to the whole country. HT + SD-treated CMDs can be therefore used as a high-quality and safe alternative fertilizer for agriculture use. These findings are expected to offer a fresh perspective on the application of antibiotic fermentation residue (AFR) in the future.
Assuntos
Antibacterianos , Solo , Antibacterianos/farmacologia , Cefalosporinas , Resistência Microbiana a Medicamentos , Genes Bacterianos , Esterco , Nutrientes , RNA Ribossômico 16S/genética , Microbiologia do SoloRESUMO
To compare the effects of low- and high-temperature thermal-alkaline pretreatments (LTTAP, 60 ± 1 °C, pH 12.0 ± 0.1, 30 min and HTTAP, 160 ± 1 °C, pH 12.0 ± 0.1, 30 min, respectively) on anaerobic digestion (AD) of waste activated sludge, long-term and semi-continuous experiments were conducted in three laboratory continuous stirred tank reactors. The experimental results showed that the two pretreatments increased the methane yield of sludge from 89.20 ± 2.41 mL/g added volatile solids (VS) to 117.50 ± 5.27 mL/g added VS (LTTAP) and 156.40 ± 2.99 mL/g added VS (HTTAP). After AD, the reduction of sludge (volatile solid) increased from 32.91 ± 0.27% to 44.17 ± 1.53% (LTTAP), and 50.86 ± 1.18% (HTTAP), and the abundance of pathogenic bacteria decreased from 6.53% to 0.38% (LTTAP) and 0.14% (HTTAP). LTTAP enhanced both hydrogentrophic and acetoclastic methanogenis and HTTAP only enhanced acetoclastic methanogenis. Additionally, the energy efficiency of HTTAP and its subsequent AD was lower than that of LTTAP and its subsequent AD.
Assuntos
Metano , Esgotos , Anaerobiose , Temperatura Alta , Temperatura , Eliminação de Resíduos LíquidosRESUMO
Tetracycline has been frequently detected in municipal wastewater due to its extended use for various purposes. This study investigated the influence of tetracycline on non-aerated microalgal-bacterial granular sludge cultivated for municipal wastewater treatment. It was found that ammonia-N removal rate decreased at the tetracycline concentrations of 1 and 10 mg/L. A mass balance on nitrogen further revealed that the observed ammonia-N removal could be mainly attributed to microalgal assimilation which was inhibited by tetracycline at the concentrations studied. In fact, reduced production of chlorophyll in microalgae was observed in the presence of tetracycline, leading to decreased ammonia-N removal rate. Meanwhile, decreased dissolved oxygen (DO) concentration at high tetracycline concentration also indicated inhibition of microalgae. Furthermore, the relative abundances of microalgae containing green algae and cyanobacteria were inhibited by tetracycline. The results gathered in this study indicated the tetracycline-induced decoupling of symbiosis in microalgal-bacterial granular sludge. It is expected that this study can shed lights on the behaviors of non-aerated microalgal-bacterial granules in response to the presence of tetracycline during municipal wastewater treatment.
Assuntos
Microalgas , Esgotos , Biomassa , Reatores Biológicos , Nitrogênio , Simbiose , Tetraciclina/toxicidade , Águas ResiduáriasRESUMO
Rural sewers are applied widely to collect rural sewage and biofilm characteristics in rural sewers may be different with municipal sewers. The succession of bacteria communities, sulfate-reducing bacteria (SRB) and methanogenic archaea (MA) need to be studied since rural sewers have a potential risk of sulfide and methane accumulation. In this study, lab-scale rural sewer facilities were established to analyze the characteristics of sewer biofilm and the generation of sulfide and methane. The results indicate that the variation tendency of biofilm thickness in rural sewers was different with municipal sewers. Time-based bacterial succession existed in rural sewer biofilms and the predominant genus was changed from Acinetobacter (approximately 19.10%) to Pseudomonas (approximately 12.61%). SRB (mean 1.49 × 106dsrA copies/cm2) were abundant than MA (mean 2.57 × 105mcrA copies/cm2) while MA were eliminated gradually in rural sewer biofilms. The tendency of sulfide and methane generation was similar with the number variation of SRB and MA, indicating sulfide accumulation might be more serious trouble than methane accumulation in a long-run rural sewer. Overall, this study deeply analyzed the succession of rural sewer biofilms and found that MA and methane were automatically inhibited in rural sewers.
Assuntos
Archaea , Metano , Bactérias , Biofilmes , Características da Família , Esgotos , Sulfatos , SulfetosRESUMO
High cost of sewer systems usually restricts the sewage collection in rural areas. Many rural areas take traditional sewer scheme whose private-secondary-main sewer diameter is 110-200-300 mm without hydraulic calculation and increased the total cost of sewers. The rational utilization of small diameter sewers might contribute to sewer cost reduction. In this study, rural sewer length and cost models were established taking sewer diameter, household number, and length/width ratio of village as parameters to evaluate the cost benefits of using small diameter sewers. Hydraulic calculation of sewers was applied by Storm Water Management Model to ensure the small diameter sewers were feasible. The results indicate that household number and length/width ratio cause obvious impact on sewer length and cost. Main sewer with 200 mm diameter is suitable for the village with less than 1000 households. Using small diameter sewers can reduce the sewer cost by 6-15% compared with traditional sewer scheme and 110-110-200 might be the better scheme to rural areas because of the low cost (including construction cost and operation and maintenance cost) and high tolerance of sewage flow fluctuation. This study provided the suitable diameter of rural sewers based on cost model and hydraulic calculation which might be helpful for the application of rural sewers.
Assuntos
Esgotos , Águas Residuárias , ÁguaRESUMO
This study reported a "treating waste by waste" strategy to dispose waste activated sludge (WAS), i.e. reverse osmosis (RO) brine-enhanced anaerobic fermentation. RO brine was hazardous by-product from seawater desalination process, which contains numerous Na+. After 4-day RO brine-enhanced anaerobic fermentation at Na+ concentration of 0.33 mol/L, 5.0 g/L VSS reduction (37.9% of VSS) was achievable, leading to considerable soluble chemical oxygen demand (SCOD) release of 349.6 mg/g VSS. Acetic acid was predominant component in SCOD (31.1%), followed by propionic, butyric, valeric acids and proteins (14.0-17.6%). Sludge solubilization and SCOD composition in the enhanced anaerobic fermentation with RO brine and NaCl agent were similar, whereas less nutrient release and extracellular polymeric substance (EPS) disruption were achieved by RO brine, attributing to the Ca2+&Mg2+-caused skeleton strengthening on EPS matrix. Such RO brine-based strategy provided environmental and economic benefits, e.g. none chemical consumption, synchronous disposal of WAS and RO brine.
Assuntos
Matriz Extracelular de Substâncias Poliméricas , Esgotos , Anaerobiose , Fermentação , Concentração de Íons de Hidrogênio , Osmose , SaisRESUMO
This study developed an economical approach for enhancing short-chain fatty acids (SCFAs) production from waste activated sludge (WAS) by NaCl assistant anaerobic fermentation. With NaCl addition at 20 g/L, sludge disintegration with extracellular polymeric substance (EPS) disruption and cell lysis were induced owing to the attack of osmotic pressure, which facilitated WAS solubilization with release of biodegradable organic matters. The SCOD sharply increased to 4092 mg/L (SCOD/TCOD = 23.9%) after 2-day hydrolysis, against 1462 mg/L in the control. After 4-day anaerobic fermentation, considerable SCFAs production of 288.2 mg COD/g VSS was achievable. More than 60% of the SCFAs was composed of acetic and propionic acids. The feasibility of bio-electrogenesis in microbial fuel cell (MFC) utilizing fermentative liquid was assessed. As such, the produced SCFAs could be consumed with energy recovery, thereby the used NaCl was reusable, which created environmental and economic benefits, e.g. reduced NaCl consumption and cost, negligible residual NaCl.