Systemic inflammatory effects of zinc oxide particles: is a re-evaluation of exposure limits needed?

Exposure to airborne substances such as gases, vapours, and particles remains a relevant health risk in many workplaces. A current topic and cause for discussion is the investigation of the health effects of particles containing zinc oxide (ZnO). Among other data, those collected from our study on human exposure data of ZnO in 2018 prompted the National Research Centre for the Working Environment 2021 to formulate a new, sharply lowered proposed occupational exposure limit (OEL) for zinc in workplaces. Since the publication of the Danish report, further studies have been conducted with ZnO. In the following text, all arguments for deriving this new limit value for zinc from the report are discussed, extended with the more recent data since 2018. It should be noted that especially the application of time extrapolation factors needs further discussion and harmonization between regulatory authorities. From our point of view, the data situation can justify a higher OEL for zinc than that proposed by the Danish National Research Centre for the Working Environment.

Hypersensitivity pneumonitis due to metal working fluids: Detection of specific IgG antibodies to microbial antigens.

Occupational exposure to microbially contaminated metal working fluids (MWF) can cause hypersensitivity pneumonitis (HP). An important step in the diagnosis of HP is to identify the triggering antigen by detection of corresponding specific IgG antibodies (sIgG). As commercial sIgG tests are currently not available, protein antigens were prepared from MWF-workplace samples and from MWF-typical bacterial isolates. In 57 % of suspected HP-cases (n = 30) elevated sIgG concentrations were measured to at least one MWF-relevant antigen, of which Mycobacterium immunogenum was most prominent (88 %), followed by Pseudomonas oleovorans and Pseudomonas spec (82 % each), MWF-antigen mix and Pseudomonas alcaliphila (65 % each). Elevated sIgG concentrations to other microorganisms were measured to Micropolyspora faeni (82 %) and Aureobasidium pullulans (77 %). Correlation of sIgG values of all tested microbial antigens showed a significant relationship of MWF-antigen mixture to Pseudomonas antigens, but a low correlation to moulds. These newly prepared MWF-antigens are useful tools for the diagnosis of patients with suspected MWF-HP and are available for further investigations.

No inflammatory effects after acute inhalation of barium sulfate particles in human volunteers.

BACKGROUND: Most threshold limit values are based on animal experiments. Often, the question remains whether these data reflect the situation in humans. As part of a series of investigations in our exposure lab, this study investigates whether the results on the inflammatory effects of particles that have been demonstrated in animal models can be confirmed in acute inhalation studies in humans. Such studies have not been conducted so far for barium sulfate particles (BaSO4), a substance with very low solubility and without known substance-specific toxicity. Previous inhalation studies with zinc oxide (ZnO), which has a substance-specific toxicity, have shown local and systemic inflammatory respones. The design of these human ZnO inhalation studies was adopted for BaSO4 to compare the effects of particles with known inflammatory activity and supposedly inert particles. For further comparison, in vitro investigations on inflammatory processes were carried out. METHODS: Sixteen healthy volunteers were exposed to filtered air and BaSO4 particles (4.0 mg/m3) for two hours including one hour of ergometric cycling at moderate workload. Effect parameters were clinical signs, body temperature, and inflammatory markers in blood and induced sputum. In addition, particle-induced in vitro-chemotaxis of BaSO4 was investigated with regard to mode of action and differences between in vivo and in vitro effects. RESULTS: No local or systemic clinical signs were observed after acute BaSO4 inhalation and, in contrast to our previous human exposure studies with ZnO, no elevated values of biomarkers of inflammation were measured after the challenge. The in vitro chemotaxis induced by BaSO4 particles was minimal and 15-fold lower compared to ZnO. CONCLUSION: The results of this study indicate that BaSO4 as a representative of granular biopersistent particles without specific toxicity does not induce inflammatory effects in humans after acute inhalation. Moreover, the in vitro data fit in with these in vivo results. Despite the careful and complex investigations, limitations must be admitted because the number of local effect parameters were limited and chronic toxicity could not be studied.

What should be tested in patients with suspected mold exposure? Usefulness of serological markers for the diagnosis.

The associations of mold exposure, IgE-mediated sensitization, inflammatory markers, and respiratory symptoms were analyzed in 46 exposed and 23 non-exposed individuals. Both exposure and clinical symptoms were assessed by questionnaire. Specific (s)IgE to mold mixture (mx1) was significantly higher and found more frequently in exposed (41%) than non-exposed individuals (17%), which was not observed for sIgG to mold mix (Gmx6). Notably, exposed asthmatics were more frequently sensitized to molds (55%) compared to exposed non-asthmatics (18%). In addition, the serum concentrations of club cell protein (CC16) were significantly lower in exposed subjects, especially in asthmatics. Positive associations were observed among mold sensitization, asthma, and mold exposure, but not in subjects with predominantly environmental sensitizations without mold sensitization. Thus, sIgE to mx1 but not sIgG to Gmx6 is a useful diagnostic marker to verify mold-associated respiratory symptoms.

Workplace-related inhalation test - Specific inhalation challenge: S2k Guideline of the German Society for Occupational and Environmental Medicine e.V. (DGAUM), the German Society for Pneumology and Respiratory Medicine e.V. (DGP) and the German Society for Allergology and Clinical Immunology e.V. (DGAKI).

Not available.

Occupational immediate type allergy to soapnut and quillaja bark.

A 58-year-old non-atopic chemical worker complained about work-related asthma and rhinoconjunctivitis about 4 years after exposure to quillaja bark and soapnut. Bronchial hyperresponsiveness was demonstrated after withdrawal of medication for 12 hours. Skin prick tests with extracts from quillaja bark and soapnut from the workplace were positive, but ImmunoCAP was positive only with quillaja bark, probably due to the low protein content of the extract from soapnut. Sensitizations to quillaja bark and soapnut, but not to saponin were demonstrated by immunoblot. An inhalation test with a dosimeter was positive with the soapnut extract. A link between disease and exposure was documented by serial measurements of exhaled nitric oxide at and off work, despite preventive measures. A diagnosis of occupational allergy due to quillaja bark and soapnut was made. Further exposure reduction was recommended.

Health effects after inhalation of micro- and nano-sized zinc oxide particles in human volunteers.

Inhalation of ZnO particles can cause inflammation of the airways and metal fume fever. It is unclear if different sizes of the particles alter these effects. However, various studies report higher biological activity of other nano-sized particles compared to microparticles. No effects at all were observed after inhalation of micro- and nano-sized zinc oxide (ZnO) particle concentrations of 0.5 mg/m3. Studies with different particle sizes of ZnO at higher exposures are not available. Accordingly, we hypothesized that inhalation of nano-sized ZnO particles induces stronger health effects than the inhalation of the same airborne mass concentration of micro-sized ZnO particles. 16 healthy volunteers (eight men, eight women) were exposed to filtered air and ZnO particles (2.0 mg/m3) for 2 h (one session with nano- and one with micro-sized ZnO) including 1 h of cycling at moderate workload. Effect parameters were symptoms, body temperature, inflammatory markers in blood and in induced sputum. Induced sputum was obtained at baseline examination, 22 h after exposure and at the end of the final test. The effects were assessed before, immediately after, about 22 h after, as well as two and three days after each exposure. Neutrophils, monocytes and acute-phase proteins in blood increased 22 h after micro- and nano-sized ZnO exposure. Effects were generally stronger with micro-sized ZnO particles. Parameters in induced sputum showed partial increases on the next day, but the effect strengths were not clearly attributable to particle sizes. The hypothesis that nano-sized ZnO particles induce stronger health effects than micro-sized ZnO particles was not supported by our data. The stronger systemic inflammatory responses after inhalation of micro-sized ZnO particles can be explained by the higher deposition efficiency of micro-sized ZnO particles in the respiratory tract and a substance-specific mode of action, most likely caused by the formation of zinc ions.

Occupational diisocyanate asthma of a female professional driver - the importance of allergological diagnostics.

Diisocyanates continue to be one of the most frequent causes of occupational asthma worldwide. They are still indispensable in industrial use as components of coatings, glues, and polyurethane foams. In Germany, respiratory diseases due to diisocyanates can be compensated by the statutory accident insurance (according to BK-Nr. 1315). The present case report shows a rare case of sensitization against diisocyanates verified by skin prick test and serological testing. Due to these findings, a modified inhalation test with an extremely low initial diisocyanate concentration in the laboratory was performed, and a positive reaction could be detected already after an extremely low diisocyanate concentration. In addition, increases of fractional exhaled nitric oxide (FeNO) and eosinophils in induced sputum after inhalation testing were seen. The present case constellation underlines the particular importance of allergological tests for diagnostic clarification of the diagnosis of diisocyanate asthma.

Unusual allergen in a butcher with respiratory symptoms.

A 37-year-old butcher developed respiratory symptoms during sausage and chicken production in a large company. In addition to various spices, the enzyme transglutaminase was a possible cause. The lung function test showed mild partial reversible airway obstruction and severe bronchial hyperresponsiveness. The IgE test showed sensitizations to various spice mixtures, coriander (0.74 kU/L), and to the ImmunoCAP-bound transglutaminase preparation from the workplace (7.12 kU/L). The skin prick tests with this transglutaminase were also positive. In the immunoblot of this preparation, a 40-kD protein reacted with the patient's IgE and was identified as transglutaminase from Streptomyces mobaraensis by inhibition experiments. This is the first case of a butcher with an allergy to transglutaminase. After moving to a small enterprise without enzyme use, his symptoms improved. Sensitization and the course of the symptoms indicate a dominant role of transglutaminase in the patient's allergic asthma.

Heart rate variability and cardiac repolarization after exposure to zinc oxide nanoparticles in healthy adults.

BACKGROUND: Exposure to airborne zinc oxide (ZnO) particles occurs in many industrial processes, especially in galvanizing and welding. Systemic inflammation after experimental inhalation of ZnO particles has been demonstrated previously, but little is known about the impact on the cardiovascular system, particularly on the autonomic cardiac system and the risk of arrhythmias. In this study we investigated the short-term effects of ZnO nanoparticles on heart rate variability (HRV) and repolarization in healthy adults in a concentration-dependent manner at rest and during exercise in a controlled experimental set-up. METHODS: Sixteen healthy subjects were exposed to filtered air and ZnO particles (0.5, 1.0 and 2.0 mg/m3) for 4 h, including 2 h of cycling at low workloads. Parameters were assessed before, during, immediately after, and about 24 h after each exposure. For each subject, a total number of 46 10-min-sections from electrocardiographic records were analyzed. Various parameters of HRV and QT interval were measured. RESULTS: Overall, no statistically significant effects of controlled ZnO inhalation on HRV parameters and QT interval were observed. Additionally, a concentration-response was absent. CONCLUSION: Inhalation of ZnO nanoparticles up to 2.0 mg/m3 for 4 h does not affect HRV and cardiac repolarization in healthy adults at the chosen time points. This study supports the view that cardiac endpoints are insensitive for the assessment of adverse effects after short-term inhalation of ZnO nanoparticles.

Whole Blood Assay as a Tool to Describe the Effects of Zinc Oxide Exposure on Innate Immunity.

Inhalation of high concentrations of zinc oxide (ZnO) particles may cause metal fume fever. A useful tool to characterize the reactivity of innate immune cells of an individual, e.g., after in vivo exposure, is the whole blood assay (WBA). The measurable outcome of WBA is the release of cytokines, especially pro-inflammatory and pyrogenic cytokines induced by stimulation in vitro. The aim of the study was to evaluate whether inhalation of nano-sized zinc oxide particles modifies the results of WBA from healthy blood donors. Sixteen healthy subjects were exposed to filtered air and ZnO particles (0.5, 1.0, and 2.0 mg/m3) for 4 h on four different days. Blood was collected before and 24 h after exposure, and ex vivo stimulation of the whole blood was performed using different endotoxin concentrations. The release of interleukin (IL)-1ß and IL-8 after 22-h incubation was quantified with specific immunoassays. The dose-response relationship of ex vivo stimulation with different endotoxin concentrations was not affected by previous ZnO exposure. However, based on the previously established calculation models, changes due to ZnO exposure could be described. The range of cytokine release in WBA was calculated for the whole group of blood donors, for the subgroups of low and high responders (each n = 8), and on the individual level. Most changes were observed after 0.5 mg/m3 ZnO exposure. Higher ZnO exposure did not yield higher effects. We conclude that the effects of inhalation of nano-sized ZnO particles in blood of healthy donors using the WBA could be determined. However, it should be noted that cytokine release as outcome of WBA is not a marker of disease.

Phenotyping Occupational Asthma Caused by Acrylates in a Multicenter Cohort Study.

BACKGROUND: While acrylates are well-known skin sensitizers, they are not classified as respiratory sensitizers although several cases of acrylate-induced occupational asthma (OA) have been reported. OBJECTIVE: To evaluate the characteristics of acrylate-induced OA in a large series of cases and compare those with OA induced by other low-molecular-weight (LMW) agents. METHODS: Jobs and exposures, clinical and functional characteristics, and markers of airway inflammation were analyzed in an international, multicenter, retrospective cohort of subjects with OA ascertained by a positive inhalation challenge to acrylates (n = 55) or other LMW agents (n = 418) including isocyanates (n = 125). RESULTS: Acrylate-containing glues were the most prevalent products, and industrial manufacturing, dental work, and beauty care were typical occupations causing OA. Work-related rhinitis was more common in acrylate-than in isocyanate-induced asthma (P < .001). The increase in postchallenge fractional exhaled nitric oxide was significantly greater in acrylate-induced OA (26.0; 8.2 to 38.0 parts per billion [ppb]) than in OA induced by other LMW agents (3.0; -1.0 to 10.0 ppb; P < .001) or isocyanates (5.0; 2.0 to 16.0 ppb; P = .010). Multivariable models confirmed that OA induced by acrylates was significantly and independently associated with a postchallenge increase in fractional exhaled nitric oxide (≥17.5 ppb). CONCLUSIONS: Acrylate-induced OA shows specific characteristics, concomitant work-related rhinitis, and exposure-related increases in fractional exhaled nitric oxide, suggesting that acrylates may induce asthma through different immunologic mechanisms compared with mechanisms through which other LMW agents may induce asthma. Our findings reinforce the need for a reevaluation of the hazard classification of acrylates, and further investigation of the pathophysiological mechanisms underlying their respiratory sensitizing potential.

Serial fractional exhaled nitric oxide measurements off and at work in the diagnosis of occupational asthma.

BACKGROUND: Fractional exhaled nitric oxide (FeNO) before and after specific inhalation challenge has been postulated as an additional tool in the diagnosis of occupational asthma (OA), but little is known about serial FeNO measurements at home and at work. The aim of the present study was to assess the contribution of serial measurements of FeNO off and at work toward the diagnosis of OA. METHODS: Forty-one subjects with suspected (n = 35) or diagnosed (n = 6) OA performed FeNO measurements once daily during a 2-week holiday and a subsequent 2-week work period. A work-related increase in FeNO by 20 ppb (parts per billion) or more was considered positive. Subjects with negative or doubtful specific inhalation challenge but a FeNO increase of 20 ppb or more were evaluated individually by an overall expert rating taking into account all available information. RESULTS: Seven of 35 subjects (20%) with suspected and three of six subjects (50%) with diagnosed OA showed a work-related FeNO increase of 20 ppb or more. Six of the seven with suspected OA were reclassified as having an OA diagnosis by the overall expert rating which also considered these FeNO changes. CONCLUSIONS: Serial FeNO measurements off and at work provide complementary information in the diagnosis in about one-fifth of cases with suspected OA, especially if specific inhalation challenges are negative or cannot be performed.

Non-invasive tools beyond lung function before and after specific inhalation challenges for diagnosing occupational asthma.

PURPOSE: Increases of fractional exhaled nitric oxide (FeNO), sputum eosinophils, and methacholine responsiveness have been described after specific inhalation challenges (SIC) with occupational allergens, but limited information is available about their comparative performance. It was the aim of the study to assess the diagnostic accuracy of these non-invasive tests before and after SIC for the diagnosis of occupational asthma (OA). METHODS: A total of 122 subjects with work-related shortness of breath were included. The 'gold standard' was defined as airway obstruction (pulmonary responders) and/or an increase of FeNO of at least 13 ppb after SIC. The results were compared with those obtained using the pulmonary responder status alone as 'gold standard'. RESULTS: If the pulmonary responder status and/or an increase of FeNO was used as 'gold standard' for SIC, 28 out of 39 positives (72%), but also 20 out of 83 negatives (24%) showed an increase of sputum eosinophils and/or bronchial hyperresponsiveness after SIC. If the pulmonary responder status alone was used as 'gold standard', an increase of FeNO with a sensitivity of 0.57 and a specificity of 0.82 showed a higher accuracy than increases of sputum eosinophils (0.52/0.75) or bronchial hyperresponsiveness (0.43/0.87). Individual case analyses suggest that a few cases of OA may be detected by increases of sputum eosinophils or bronchial hyperresponsiveness alone, but probably false-positive tests dominate. CONCLUSION: It is recommended to use both lung function and increase of FeNO as primary effect parameters of SIC. Changes of sputum eosinophils and bronchial hyperresponsiveness after SIC have a low additional diagnostic value, but may be useful in individual cases.

Severe Occupational Asthma: Insights From a Multicenter European Cohort.

BACKGROUND: Although sensitizer-induced occupational asthma (OA) accounts for an appreciable fraction of adult asthma, the severity of OA has received little attention. OBJECTIVE: The aim of this study was to characterize the burden and determinants of severe OA in a large multicenter cohort of subjects with OA. METHODS: This retrospective study included 997 subjects with OA ascertained by a positive specific inhalation challenge completed in 20 tertiary centers in 11 European countries during the period 2006 to 2015. Severe asthma was defined by a high level of treatment and any 1 of the following criteria: (1) daily need for a reliever medication, (2) 2 or more severe exacerbations in the previous year, or (3) airflow obstruction. RESULTS: Overall, 162 (16.2%; 95% CI, 14.0%-18.7%) subjects were classified as having severe OA. Multivariable logistic regression analysis revealed that severe OA was associated with persistent (vs reduced) exposure to the causal agent at work (odds ratio [OR], 2.78; 95% CI, 1.50-5.60); a longer duration of the disease (OR, 1.04; 95% CI, 1.00-1.07); a low level of education (OR, 2.69; 95% CI, 1.73-4.18); childhood asthma (OR, 2.92; 95% CI, 1.13-7.36); and sputum production (OR, 2.86; 95% CI, 1.87-4.38). In subjects removed from exposure, severe OA was associated only with sputum production (OR, 3.68; 95% CI, 1.87-7.40); a low education level (OR, 3.41; 95% CI, 1.72-6.80); and obesity (OR, 1.98; 95% CI, 0.97-3.97). CONCLUSIONS: This study indicates that a substantial proportion of subjects with OA experience severe asthma and identifies potentially modifiable risk factors for severe OA that should be targeted to reduce the adverse impacts of the disease.

Are high- and low-molecular-weight sensitizing agents associated with different clinical phenotypes of occupational asthma?

BACKGROUND: High-molecular-weight (HMW) proteins and low-molecular-weight (LMW) chemicals can cause occupational asthma (OA) although few studies have thoroughly compared the clinical, physiological, and inflammatory patterns associated with these different types of agents. The aim of this study was to determine whether OA induced by HMW and LMW agents shows distinct phenotypic profiles. METHODS: Clinical and functional characteristics, and markers of airway inflammation were analyzed in an international, multicenter, retrospective cohort of subjects with OA ascertained by a positive inhalation challenge response to HMW (n = 544) and LMW (n = 635) agents. RESULTS: Multivariate logistic regression analysis showed significant associations between OA caused by HMW agents and work-related rhinitis (OR [95% CI]: 4.79 [3.28-7.12]), conjunctivitis (2.13 [1.52-2.98]), atopy (1.49 [1.09-2.05]), and early asthmatic reactions (2.86 [1.98-4.16]). By contrast, OA due to LMW agents was associated with chest tightness at work (2.22 [1.59-3.03]), daily sputum (1.69 [1.19-2.38]), and late asthmatic reactions (1.52 [1.09-2.08]). Furthermore, OA caused by HMW agents showed a higher risk of airflow limitation (1.76 [1.07-2.91]), whereas OA due to LMW agents exhibited a higher risk of severe exacerbations (1.32 [1.01-1.69]). There were no differences between the two types of agents in the baseline sputum inflammatory profiles, but OA caused by HMW agents showed higher baseline blood eosinophilia and a greater postchallenge increase in fractional nitric oxide. CONCLUSION: This large cohort study describes distinct phenotypic profiles in OA caused by HMW and LMW agents. There is a need to further explore differences in underlying pathophysiological pathways and outcome after environmental interventions.