A lesson from polybutylene succinate plastisphere to the discovery of novel plastic degrading enzyme genes in marine vibrios.

Polybutylene succinate (PBS) is an eco-friendly green plastic. However, PBS was shown as being non-biodegradable in marine environments, and up until now, only a limited number of PBS-degrading marine microbes have been discovered. We first set up in vitro PBS- and PBSA (polybutylene succinate adipate)-plastispheres to characterize novel PBS-degrading marine microbes. Microbial growth and oxygen consumption were observed in both PBS- and PBSA-plastispheres enriched with natural seawater collected from Usujiri, Hokkaido, Japan, and Vibrionaceae and Pseudoalteromonadaceae were significantly enriched on these films. Further gene identification indicated that vibrios belonging to the Gazogenes clade possess genes related to a PBS degrading enzyme (PBSase). The PBS degradation assay for six Gazogenes clade vibrios identified Vibrio ruber, Vibrio rhizosphaerae, and Vibrio spartinae as being capable of degrading PBS. We further identified the gene responsible for PBSase from the type strain of V. ruber, and the purified recombinant vibrio PBSase was found to have low-temperature adaptation and was active under high NaCl concentrations. We also provided docking models between the vibrio PBSase and PBS and PBSA units to show how vibrio PBSase interacts with each substrate compared to the Acidovorax PBSase. These results could contribute to a more sustainable society through further utilization of PBS in marine environments and plastic recycling.

Optimized culture conditions for the efficient production of porcine adenylate kinase in recombinant Escherichia coli.

Temperature shift cultivations with amino acid supplementation were optimized to produce porcine adenylate kinase (ADK) in recombinant Escherichia coli harboring a pUC-based recombinant plasmid under the control of the trp promoter. With regard to temperature control, the culture condition was initially maintained at 35 degrees C for cellular growth, but ADK expression was suppressed until the late logarithmic growth phase; subsequently, a temperature shift was applied (from 35 degrees C to 42 degrees C), which resulted in maximal ADK production. In addition, supplementation of amino acids, especially valine and leucine, during the temperature shift stimulated ADK expression from 3.5% to 9.2% and 8.6% of the total protein, respectively. After optimization, 1 g ADK per liter was produced within 16 h of cultivation with a dry cell weight of 21.8 g/l. In this system, there was no loss of the recombinant plasmid during cultivation without selective pressure.

A wheat embryo cell-free protein synthesis system not requiring an exogenous supply of GTP.

Most in vitro protein synthesis systems require a supply of GTP for the formation of translation initiation complexes, with two GTP molecules per amino acid needed as an energy source for a peptide elongation reaction. In order to optimize protein synthesis reactions in a continuous-flow wheat embryo cell-free system, we have examined the influence of adding GTP and found that the system does not require any supply of GTP. We report here the preparation of a wheat embryo extract from which endogenous GTP was removed by gel filtration, and the influence of adding GTP to the system on protein synthesis reactions. Using Green Fluorescent Protein (GFP) as a reporter, higher levels of production were observed at lower concentrations of GTP, with the optimal level of production obtained with no supply of GTP. A HPLC-based analysis of the extract and the translation mixture containing only ATP as an energy source revealed that GTP was not detectable in the extract, however, 35 microM of GTP was found in the translation mixture. This result suggests that GTP could be generated from other compounds, such as GDP and GMP, using ATP. A similar experiment with a C-terminally truncated form of human protein tyrosine phosphatase 1B (hPTP1B(1-320)) gave almost the same result. The wheat embryo cell-free translation system worked most efficiently without exogenous GTP, producing 3.5 mg/mL of translation mixture over a 48-h period at 26 degrees C.

In vitro selection of scFv and its production: an application of mRNA display and wheat embryo cell-free and E. coli cell production system.

Synthetic DNA libraries encoding human antibody V(L) and V(H) fragments were designed, constructed, and enriched using mRNA display. The enriched libraries were then combined to construct a scFv library for mRNA display. Sequencing revealed that 46% of the library coded for full-length scFvs. Considering the number of molecules used in mRNA display, the size of the library displayed was calculated to be >10(10). To verify this, we tried to isolate a scFv against human RANK. A scFv was successfully isolated in the sixth round of panning and was synthesized in wheat embryo cell-free (WE) and Escherichia coli cell systems. In the WE system, even though the production level was high, the product was almost soluble. However, in the E. coli system, it was over-produced as inclusion bodies. The inclusion bodies were successfully refolded and showed approximately the same binding affinity as the WE product. These results demonstrate that using mRNA display with synthetic libraries and WE and E. coli cell production systems, a system for in vitro selection and small- to large-scale production of scFvs has been established.

High cell density cultivation of recombinant E. coli for hirudin variant 1 production by temperature shift controlled by pUC18-based replicative origin.

The copy number of a plasmid, pUC-based vector, was previously shown to be affected by culture temperature. In this study, intracellular hirudin variant 1 (f-HV1) fused to porcine adenylate kinase protein was produced using recombinant Escherichia coli by temperature shift cultivation coupled with a high cell density cultivation technique for E. coli JM109. The optimal temperature for cellular growth suppressing f-HV1 production was 33 degrees C, resulting in a final dried cell concentration of 45.7 g/l, with a specific growth rate of 0.54 1/h. Optimizing the temperature-shift conditions (temperature shifted to an OD660 nm of 15 from 33 degrees C to 37 degrees C) resulted in the production of f-HV1 up to 4763 mg/l as an inclusion body with dried cell concentration of 44 g/l in 18 h.

High cell density cultivation of recombinant Escherichia coli for hirudin variant 1 production.

A synthetic medium, TK-25, for high cell density cultivation (HCDC) of Escherichia coli K-12 was modified to support HCDC of strain JM109. By optimizing the culture conditions, the cell concentration of 65 g/l in 14 h was obtained in the optimized medium, namely TK-10, with glucose-fed batch cultivation. When these conditions were further applied for HCDC of E. coli JM109 harboring pUC-based recombinant plasmid which expresses a hirudin variant, HV-1-fused protein under the control of trp promoter, it grew to 24 g/l of dried cells expressed as an inclusion body as 15.9% of the total protein, corresponding to 1908 mg/l hirudin-fused protein.

Crystal structure of human dual specificity phosphatase, JNK stimulatory phosphatase-1, at 1.5 A resolution.

Human JNK stimulatory phosphatase-1 (JSP-1) is a novel member of dual specificity phosphatases. A C-terminus truncated JSP-1 was expressed in Escherichia coli and was crystallized using the sitting-drop vapor diffusion method. Thin-plate crystals obtained at 278 K belong to a monoclinic space group, C2, with unit-cell parameters a = 84.0 A, b = 49.3 A, c = 47.3 A, and beta = 119.5 degrees , and diffract up to 1.5 A resolution at 100 K. The structure of JSP-1 has a single compact (alpha/beta) domain, which consists of six alpha-helices and five beta-strands, and shows a conserved structural scaffold in regard to both DSPs and PTPs. A cleft formed by a PTP-loop at the active site is very shallow, and is occupied by one sulfonate compound, MES, at the bottom. In the binary complex structure of JSP-1 with MES, the conformations of three important segments in regard to the catalytic mechanism are not similar to those in PTP1B. JSP-1 has no loop corresponding to the Lys120-loop of PTP1B, and tryptophan residue corresponding to the substrate-stacking in PTP1B is substituted by alanine residue in JSP-1.

On-column refolding and characterization of soluble human interleukin-15 receptor alpha-chain produced in Escherichia coli.

Interleukin-15 receptor alpha-chain (IL-15Ralpha) is a member of the new cytokine receptor family, which possesses the sushi domain. To investigate the biochemical and biophysical characteristics of soluble human IL-15Ralpha (shIL-15Ralpha), shIL-15Ralpha was recombinantly expressed in Escherichia coli. The shIL-15Ralpha containing a six histidine-tag was expressed as inclusion bodies, which were solubilized with urea, immobilized on a Ni-nitrilotriacetic acid column, and refolded by a decreasing gradient of urea concentration. The refolded shIL-15Ralpha exhibited a highly flexible structure, neutralized human interleukin-15-induced cell proliferation effectively, and bound to its ligand with the same affinity as human IL-15Ralpha on the cell surface, as demonstrated by circular dichroism, a cell proliferation assay, and surface plasmon resonance, respectively. Thus, we succeeded in refolding shIL-15Ralpha to an active form on an affinity column.

Immobilized oxidoreductase as an additive for refolding inclusion bodies: application to antibody fragments.

Three foldases--the apical domain of GroEL (mini-chaperone) and two oxidoreductases (DsbA and DsbC) from Escherichia coli--were studied in refolding a protein with immunoglobulin fold (immunoglobulin-folded protein) that had been produced as inclusion bodies in E.coli. The foldases promoted the refolding of single-chain antibody fragments from denaturant-solubilized and reduced inclusion bodies in vitro, and also effectively functioned as alternatives for labilizing agent and oxidizing reagent in the stepwise dialysis system. Immobilization of the oxidoreductases enhanced refolding and recovery of functional single-chain antibody in the dialysis system, suggesting that immobilized oxidoreductases can be used as an effective additive for refolding immunoglobulin-folded proteins in vitro.

Finding of an isoleucine derivative of a recombinant protein for pharmaceutical use.

Protein modification generally occurs by addition to the amino acid side-chains of protein at the post-translational stage, for example, by enzymatic or chemical reactions after polypeptide synthesis. Recently, the recombinant hirudin analog CX-397, a potent thrombin inhibitor, was found to contain methylated Ile residues when it was overproduced by Escherichia coli in the absence of amino acids in the culture medium. The Ile derivatives, deduced to be beta-methylnorleucine [betaMeNle; (2S, 3S)-2-amino-3-methylhexanoic acid] by systematic chromatographic analysis, do not appear to be normal post-translational modifications of the protein because Ile has no functional group in its side-chain. We, therefore, propose that betaMeNle is biosynthesized by E. coli, activated by E. coli isoleucyl-tRNA synthetase (IleRS), then incorporated into the overproduced recombinant hirudin analog. The biosynthesis of betaMeNle in E. coli is thought to occur as follows: alpha-ketovalerate is synthesized from alpha-ketobutyrate by three Leu biosynthetic enzymes, alpha-isopropylmalate synthase (IPMS) (EC 4.1.3.12), alpha-isopropylmalate isomerase (ISOM) (EC 4.2.1.33) and beta-isopropylmalate dehydrogenase (IPMD) (EC 1.1.1.85), which have broad substrate specificities. alpha-Ketovalerate is then converted to alpha-keto-beta-methylcaproate by three Ile and Val biosynthetic enzymes, acetohydroxy acid synthase (AS) (EC 4.1.3.18), acetohydroxy acid isomeroreductase (IR) (EC 1.1.1.86) and dihydroxy acid dehydratase (DH) (EC 4.2.1.9). Finally, this is converted to betaMeNle by branched-chain amino acid transaminase (EC 2.6.1.42), one of the Ile and Val biosynthetic enzymes.

Synthesis of potent and selective inhibitors against the proliferation of human coronary artery smooth muscle cells.

A series of diarylamide urea derivatives were synthesized and evaluated for their inhibitory activities against human coronary artery smooth muscle cells (SMCs) and human coronary artery endothelial cells (ECs). Compound 2h was much superior to Tranilast, in terms of both the potency of its inhibitory activity toward the proliferation of SMCs and the cell selectivity.

Synthesis and structure-activity relationship of diarylamide derivatives as selective inhibitors of the proliferation of human endothelial cells.

A series of diarylamide urea derivatives were synthesized and evaluated for their inhibitory activities against human coronary artery endothelial cells (ECs) and human coronary artery smooth muscle cells (SMCs). Compound was superior to Tranilast, in terms of both cell selectivity and the potency of its inhibitory activity toward the proliferation and angiogenesis of ECs.

Inhibition of hepatitis C virus NS3 protease by peptides derived from complementarity-determining regions (CDRs) of the monoclonal antibody 8D4: tolerance of a CDR peptide to conformational changes of a target.

We have synthesized and characterized peptides derived from complementarity-determining regions (CDRs) of 8D4, a mouse monoclonal antibody against NS3 protease domain of hepatitis C virus. 8D4 inhibits enzymatic activity without its cofactor, NS4A peptide. One of the synthetic peptides derived from CDRs, CDR1 of the heavy-chain (CDR-H1) peptide strongly inhibited NS3 protease activity competitively in the absence of NS4A and non-competitively in the presence of NS4A. Moreover, cyclic CDR-H1 peptides bridged by disulfide inhibited NS3 protease more potently. The chain length of the CDR-H1 peptide is critical for strong inhibition, even when the peptide is circularized. This finding suggests the importance of peptide conformation. In contrast to a cognate antibody molecule, CDR-derived peptides may provide good ligands for target molecules by having a tolerance to conformational changes of the targets caused by cofactor binding or mutation.

Synthesis and structure-activity relationship of diarylamide urea derivatives as selective inhibitors of the proliferation of human coronary artery smooth muscle cells.

A series of diarylamide urea derivatives were synthesized and evaluated for their inhibitory activities against human coronary artery smooth muscle cells (SMCs) and human coronary artery endothelial cells (ECs). Compound 2o was superior to the lead compound, Tranilast, in terms of its potency of the inhibitory activity and cell selectivity.

Existence of beta-methylnorleucine in recombinant hirudin produced by Escherichia coli.

A gene encoding for hirudin, a potent thrombin inhibitor, was expressed in Escherichia coli, which is the most widely used host. When the recombinant hirudin analog, CX-397, was overproduced by E. coli (600 mg l(-1)) in the absence of nutrient amino acids in the culture medium, the presence of two derivatives in the final product was observed with extremely increased retention times on reverse-phase high-performance liquid chromatography. Each derivative was due to methylation of an isoleucine residue at Ile29 or Ile59 in the CX-397. The structure was deducible as beta-methylnorleucine (beta MeNle; (2S,3S)-2-amino-3-methylhexanoic acid). The modification pathway of beta MeNle is not thought to be a post-translational modification of the protein because Ile has no functional group in its side-chain. Additionally, beta MeNle is synthesized by mutants of Serratia marcescens that belong to the same family, Enterobacteriaceae, as E. coli (J. Antibiot. 34 (1981a) 1278). These findings suggest that the lack of nutrient amino acids in the culture medium leads to the synthesis of beta MeNle in E. coli, which is then activated by E. coli isoleucyl-tRNA synthetase and incorporated into the overproduced recombinant protein.