Flexible, high mobility short-channel organic thin film transistors and logic circuits based on 4H-21DNTT.

The low mobility and large contact resistance in organic thin-film transistors (OTFTs) are the two major limiting factors in the development of high-performance organic logic circuits. Here, solution-processed high-performance OTFTs and circuits are reported with a polymeric gate dielectric and 6,6 bis (trans-4-butylcyclohexyl)-dinaphtho[2,1-b:2,1-f]thieno[3,2-b]thiophene (4H-21DNTT) for the organic semiconducting layer. By optimizing and controlling the fabrication conditions, a high saturation mobility of 8.8 cm2 V-1 s-1 was demonstrated as well as large on/off ratios (> 106) for relatively short channel lengths of 15 µm and an average carrier mobility of 10.5 cm2 V-1 s-1 for long channel length OTFTs (> 50 µm). The pseudo-CMOS inverter circuit with a channel length of 15 µm exhibited sharp switching characteristics with a high signal gain of 31.5 at a supply voltage of 20 V. In addition to the inverter circuit, NAND logic circuits were further investigated, which also exhibited remarkable logic characteristics, with a high gain, an operating frequency of 5 kHz, and a short propagation delay of 22.1 µs. The uniform and reproducible performance of 4H-21DNTT OTFTs show potential for large-area, low-cost real-world applications on industry-compatible bottom-contact substrates.

Efficient production of Trastuzumab Fab antibody fragments in Brevibacillus choshinensis expression system.

The Brevibacillus expression system has been successfully employed for the efficient productions of a variety of recombinant proteins, including enzymes, cytokines, antigens and antibody fragments. Here, we succeeded in secretory expression of Trastuzumab Fab antibody fragments using B. choshinensis/BIC (Brevibacillus in vivocloning) expression system. In the fed-batch high-density cell culture, recombinant Trastuzumab Fab with amino-terminal His-tag (His-BcFab) was secreted at high level, 1.25 g/liter, and Fab without His-tag (BcFab) at ∼145 mg/L of culture supernatant. His-BcFab and BcFab were purified to homogeneity using combination of conventional column chromatographies with a yield of 10-13%. This BcFab preparation exhibited native structure and functions evaluated by enzyme-linked immunosorbent assay, surface plasmon resonance, circular dichroism measurements and size exclusion chromatography. To our knowledge, this is the highest production of Fab antibody fragments in gram-positive bacterial expression/secretion systems.

Galvanic Tongue Stimulation Inhibits Five Basic Tastes Induced by Aqueous Electrolyte Solutions.

Galvanic tongue stimulation (GTS) modulates taste sensation. However, the effect of GTS is contingent on the electrode polarity in the proximity of the tongue. If an anodal electrode is attached in the proximity of the tongue, an electrical or metallic taste is elicited. On the other hand, if only cathodal electrode is attached in the proximity of the tongue, the salty taste, which is induced by electrolyte materials, is inhibited. The mechanism of this taste inhibition is not adequately understood. In this study, we aim to demonstrate that the inhibition is cause by ions, which elicit taste and which migrate from the taste sensors on the tongue by GTS. We verified the inhibitory effect of GTS on all five basic tastes induced by electrolyte materials. This technology is effective for virtual reality systems and interfaces to support dietary restrictions. Our findings demonstrate that cathodal-GTS inhibits all the five basic tastes. The results also support our hypothesis that the effects of cathodal-GTS are caused by migrating tasting ions in the mouth.

Production of Recombinant CCN Proteins by Brevibacillus choshinensis.

Brevibacillus choshinensis is an excellent host for the production of secretory proteins. This host has also been applied successfully to efficient production of CCN proteins. Described herein are methods of constructing plasmids for CCN protein production (IGFBP-, VWC-, TSP-, and CT-domain) with Brevibacillus as a host, cultivation methods for protein production, and methods of purification for domain proteins using his-tag.

Highly efficient production of VHH antibody fragments in Brevibacillus choshinensis expression system.

Anti-IZUMO1PFF VHH (variable domain of camelid heavy chain antibody) clones, N6 and N15, from immunized alpaca (Lama pacos) phage library were efficiently expressed and their VHH products were secreted into the culture medium of Brevibacillus choshinensis HPD31-SP3, e.g., at a level of 26-95mg in 100ml conventional flask culture. With a 3-L scale fed-batch culture for 65h, the N15 VHH protein with C-terminal His-tag was produced at ∼3g/l culture medium. The N6 and N15 proteins were easily purified to apparent homogeneity by cation exchange and Ni-affinity chromatographies. Both proteins showed specific antigen-binding activity by ELISA and high antigen binding affinity, KD=6.0-8.6nM, by surface plasmon resonance analysis. Size exclusion chromatography-multi-angle laser light scattering analysis revealed that N6 and N15 proteins purified were exclusively monomeric form in phosphate buffered saline. CD spectrum showed beta-sheet rich structure, consistent with a typical antibody structure and also suggested aromatic-aromatic interactions, as indicated by a positive peak at 232nm. Thermal melting analysis of the N15 protein with C-terminal His-tag demonstrated a clear thermal transition with a Tm at 67°C. The heat-denatured sample recovered antigen binding activity upon cooling, indicating a reversible denaturation.

Fully-printed high-performance organic thin-film transistors and circuitry on one-micron-thick polymer films.

Thin, ultra-flexible devices that can be manufactured in a process that covers a large area will be essential to realizing low-cost, wearable electronic applications including foldable displays and medical sensors. The printing technology will be instrumental in fabricating these novel electronic devices and circuits; however, attaining fully printed devices on ultra-flexible films in large areas has typically been a challenge. Here we report on fully printed organic thin-film transistor devices and circuits fabricated on 1-µm-thick parylene-C films with high field-effect mobility (1.0 cm(2) V(-1) s(-1)) and fast operating speeds (about 1 ms) at low operating voltages. The devices were extremely light (2 g m(-2)) and exhibited excellent mechanical stability. The devices remained operational even under 50% compressive strain without significant changes in their performance. These results represent significant progress in the fabrication of fully printed organic thin-film transistor devices and circuits for use in unobtrusive electronic applications such as wearable sensors.

Fully solution-processed flexible organic thin film transistor arrays with high mobility and exceptional uniformity.

Printing fully solution-processed organic electronic devices may potentially revolutionize production of flexible electronics for various applications. However, difficulties in forming thin, flat, uniform films through printing techniques have been responsible for poor device performance and low yields. Here, we report on fully solution-processed organic thin-film transistor (TFT) arrays with greatly improved performance and yields, achieved by layering solution-processable materials such as silver nanoparticle inks, organic semiconductors, and insulating polymers on thin plastic films. A treatment layer improves carrier injection between the source/drain electrodes and the semiconducting layer and dramatically reduces contact resistance. Furthermore, an organic semiconductor with large-crystal grains results in TFT devices with shorter channel lengths and higher field-effect mobilities. We obtained mobilities of over 1.2 cm(2) V(-1) s(-1) in TFT devices with channel lengths shorter than 20 µm. By combining these fabrication techniques, we built highly uniform organic TFT arrays with average mobility levels as high as 0.80 cm(2) V(-1) s(-1) and ideal threshold voltages of 0 V. These results represent major progress in the fabrication of fully solution-processed organic TFT device arrays.

syn-/anti-Anthradithiophene derivative isomer effects on semiconducting properties.

Isomerically pure syn-/anti-anthradithiophene derivatives have been developed in the past few years. Although anti-isomers showed higher field-effect mobilities than mixture of isomers have been reported, a detailed comparison of syn-isomer and anti-isomer molecules has not been carried out. In this study, we took newly synthesized pure unsubstituted syn-/anti-anthradithiophenes (ADTs) and compared their single crystal structures, physical properties and semiconducting behavior with a previously studied syn-/anti-dimethylanthradithiophenes (DMADTs). Although the both isomers were typical herringbone packing structures with similar parameters, anti-isomers involved less disordered atoms in the crystal packing. The results from thermal analysis, UV-vis spectra, photo luminescence spectra and cyclic voltammograms of syn-/anti-anthradithiophenes were nearly the in the solid state as well as in solution. However, field-effect transistors showed obvious differences with mobilities of 0.12 cm(2) V(-1) s(-1) for anti-anthradithiophene and 0.02 cm(2) V(-1) s(-1) for syn-anthradithiophene. Because the crystallinity of thin-films measured by X-ray diffraction (XRD) and atomic force microscopy (AFM) seems to be better in syn-isomers, the differences in transistor performance are likely attributed to local defects affecting intermolecular interactions, such as disorder in the crystal packing and charge-dipole interactions.

Efficient production of anti-fluorescein and anti-lysozyme as single-chain anti-body fragments (scFv) by Brevibacillus expression system.

Expression of scFv in Brevibacillus choshinensis was tested using combinations of three different promoters and four different secretion signals. Two model scFv constructs, i.e., His-scFvFLU and His-scFvHEL, were successfully expressed with some of the combinations. Ni Sepharose column and size exclusion chromatography resulted in fairly pure preparations of these two proteins. The purified His-scFvFLU inhibited fluorescence from fluorescein, while the purified His-scFvHEL inhibited lysozyme activity. Relatively high yield of His-scFvFLU (∼40%) and His-scFvHEL (∼30%) was achieved with the expression and purification system described here.

Secretory production of single-chain antibody (scFv) in Brevibacillus choshinensis using novel fusion partner.

Halophilic ß-lactamase (BLA) has been successfully used as a novel fusion partner for soluble expression of aggregation-prone foreign proteins in Escherichia coli cytoplasm (Appl Microbiol Biotechnol 86:649-658, 2010b). This halophilic BLA fusion technology was applied here for secretory expression in Brevibacillus. The "Brevibacillus in vivo cloning" method, recently developed by Higeta Shoyu group, for the construction and transformation of Brevibacillus expression vectors facilitates efficient screening of the production conditions of Brevibacillus expression system. Two single-chain antibodies (scFv), HyHEL-10 single chain scFv (scFvHEL) and anti-fluorescein single chain scFv (scFvFLU), were successfully secreted to culture supernatant as a fusion protein with halophilic BLA. The scFvHEL-His, purified after cleavage of BLA portion with thrombin, was fully active: it formed a stoichiometric complex with the antigen, lysozyme, and inhibited the enzymatic activity. The scFvFLU-His, similarly expressed and purified, stoichiometrically inhibited fluorescence intensity of fluorescein. The molecular mass of scFvHEL-His was determined to be 27,800 Da by light scattering measurements, indicating its monomeric structure in solution.

Brevibacillus expression system: host-vector system for efficient production of secretory proteins.

Brevibacillus expression system is an effective bacterial expression system for secretory proteins. The host bacterium, Brevibacillus choshinensis, a gram-positive bacterium, has strong capacity to secrete a large amount of proteins (approximately 30 g/L), which mostly consist of cell wall protein. A host-vector system that utilizes such high expression capacity has been constructed for the production of secretory proteins and tested for various heterologous proteins, including cytokines, enzymes, antigens, and adjuvants.

Novel processing and localization of catA, ccdA associated thiol-disulfide oxidoreductase, in protein hyper-producing bacterium Brevibacillus choshinensis.

Previously, we have cloned ccdA and its associated thiol-disulfide oxidoreductase gene, catA, in Brevibacillus choshinensis. CcdA is known to be an integral membrane protein and its associated oxidoreductase homologues are believed to be membrane anchoring proteins, both providing reducing equivalents across the membrane to control correct disulfide bond formation. Here, we found that CatA is first localized as a membrane bound form and then slowly released into the cellular periphery and culture medium with cleavage at a novel processing site.

Expression and purification of thioredoxin (TrxA) and thioredoxin reductase (TrxB) from Brevibacillus choshinensis.

Brevibacillus choshinensis (formerly Bacillus brevis) is a protein-hyperproducing bacterium and has been used for commercial protein production. Here, we cloned thioredoxin (trxA) and thioredoxin reductase (trxB) genes from B. choshinensis, and expressed the gene products in Escherichia coli with an amino-terminal hexa-His-tag for purification and characterization. His-TrxA and His-TrxB were purified to homogeneity with one-step Ni-NTA affinity column chromatography, and the two recombinant proteins showed identical specific activity with or without removal of the amino-terminal His-tag, indicating that the extrasequence containing the hexa-His-tag did not affect their enzymatic activities. The E. coli expression system used here resulted in a 40-fold increase in production of His-TrxB protein compared to the level of native TrxB produced in non-recombinant B. choshinensis cells. TrxA and TrxB proteins with carboxy-terminal His-tag (TrxA-His and TrxB-His) were successfully expressed in B. choshinensis and were purified by Ni-NTA column chromatography. Co-expression of TrxA-His with recombinant human epidermal growth factor (hEGF) in B. choshinensis promoted the extracellular production of hEGF by up to about 200%.

Expression and purification of the Bacillus subtilis thioredoxin superfamily protein YkvV.

Bacillus subtilis YkvV protein, an extracellular thioredoxin superfamily protein, was successfully expressed both in Brevibacillus choshinensis culture medium using an efficient promoter and the secretion signal of its surface layer protein, and in Escherichia coli cytoplasm with the amino-terminal His-tag (His-YkvV). His-YkvV was purified to homogeneity by Ni-NTA column. Both secreted YkvV and purified His-YkvV exhibited thiol-disulfide oxidoreductase activity.

Cloning and expression of the ccdA-associated thiol-disulfide oxidoreductase (catA) gene from Brevibacillus choshinensis: stimulation of human epidermal growth factor production.

Brevibacillus choshinensis (Bacillus brevis) is a protein-hyperproducing bacterium with a useful host-vector system for the production of recombinant proteins. Here, we cloned the ccdA-catA (cmacr;cdA associated thioredoxin-like tmacr;hiol-disulfide oxidoreductase) locus of B. choshinensis HPD31-S5. CatA protein (molecular weight, 19664) contains a thioredoxin-like motif, Cys-Gly-Pro-Cys. It was successfully expressed in B. choshinensis extracellularly ( approximately 100 microg x ml(-1) culture) using the secretion vector pNCMO2, and in Escherichia coli intracellularly ( approximately 350 microg x ml(-1) culture) with an amino-terminal His-tag. Both recombinant proteins showed thiol-disulfide oxidoreductase activity. Incubation of non-native human epidermal growth factor (hEGF) containing incorrect disulfide bonds with B. choshinensis cells secreting CatA protein resulted in the stimulation of the conversion of non-native hEGF to the native form. Furthermore, co-expression of CatA protein with recombinant hEGF in the B. choshinensis production system increased the yield of native hEGF.

Importance of hydrophobic interaction between a SoxB-type cytochrome c oxidase with its natural substrate cytochrome c-551 and its mutants.

Cytochrome c-551, the electron donor of SoxB-type cytochrome c oxidase in thermophilic bacilli, can be over-expressed in Bacillus thermodenitrificans cells by tranformation with pSTEc551. Several mutant cytochromes c-551 were prepared by site-directed mutagenesis to this expression plasmid. Among them, several Lys residues were changed to Ala/Ser, and we found that these mutant cytochromes retained their activity as substrates, although their K(m) values were 0.04-0.12 microM, depending on the site replaced. In contrast, the C19A mutant cytochrome, which was produced in Brevibacillus choshinensis as a secretion protein, lost its activity as a substrate, suggesting that the fatty acyl-glyceryl residue covalently bound to the cysteine residue of the wild-type c-551 plays a very important role in the activity. The importance of the hydrophobic fatty acid residue for the binding of cytochrome c-551 to the oxidase was also shown by the loss of substrate activity in deacylated cytochrome c-551. These results show the importance of the hydrophobic interaction between this cytochrome and SoxB-type oxidase, despite the fact that the importance of an electrostatic interaction between cytochrome c and mitochondrial cytochrome aa(3) oxidase has already been established.