RESUMO
In this study, laboratory scale digesters were operated to simulate potential shocks to the Anaerobic Digestion (AD) process at a 350 ML/day wastewater treatment plant. The shocks included high (42 °C) and low (32 °C) temperature (either side of mesophilic 37 °C) and a 20% loading of fats, oil and grease (FOG; 20% w:v). These variables were explored at two sludge retention times (12 and 20 days) and two organic loading rates (2.0 and 2.5 kgTS/m(3)day OLR). Metagenomic and metabolomic approaches were then used to characterise the impact of operational shocks in regard to temperature and FOG addition, as determined through monitoring of biogas production, the microbial profile and their metabolism. Results showed that AD performance was not greatly affected by temperature shocks, with the biggest impact being a reduction in biogas production at 42 °C that persisted for 32 ± 1 days. The average biogas production across all digesters at the completion of the experiment was 264.1 ± 76.5 mL/day, with FOG addition observed to significantly promote biogas production (+87.8 mL/day). Metagenomic and metabolomic analyses of the digesters indicated that methanogens and methane oxidising bacteria (MOB) were low in relative abundance, and that the ratio of oxidising bacteria (methane, sulphide and sulphate) with respect to sulphate reducing bacteria (SRB) had a noticeable influence on biogas production. Furthermore, increased biogas production correlated with an increase in short chain fatty acids, a product of the addition of 20% FOG. This work demonstrates the application of metagenomics and metabolomics to characterise the microbiota and their metabolism in AD digesters, providing insight to the resilience of crucial microbial populations when exposed to operational shocks.
Assuntos
Reatores Biológicos/microbiologia , Metabolômica/métodos , Metagenômica/métodos , Consórcios Microbianos/fisiologia , Eliminação de Resíduos Líquidos/métodos , Anaerobiose , Archaea/genética , Archaea/metabolismo , Bactérias/genética , Bactérias/metabolismo , Biocombustíveis , Sequenciamento de Nucleotídeos em Larga Escala , Metano/metabolismo , Sulfatos/metabolismo , Eliminação de Resíduos Líquidos/instrumentaçãoRESUMO
Precipitation in the Mg-Ca-NH3-PO4 system has been explored to improve understanding of likely phases recoverable from complex wastewaters. Over a range of Mg/Ca combinations (0-100%) and pH 5-11, at least seven identifiable crystalline phases could be precipitated from artificial wastewater including: struvite, hydroxylapatite, newberyite, brushite, merrilite/whitlockite, octocalcium phosphate, and monetite. This experimental study has outlined the physicochemical conditions required to produce various phosphate products from synthetic wastewater, and found that large differences exist between experimentally formed phases and thermodynamical predictions. Struvite formation is the most desirable precipitate for the recovery of phosphate based upon purity, growth characteristics, dewatering properties, phosphate removal efficiency, and its ability to simultaneously remove ammonia. This study has also demonstrated that in specific cases the preliminary precipitation of brushite is a possible means of decreasing calcium content such that subsequent struvite formation could achieve higher-purity. Utilising experimental results and information on current commodity prices, discussion on the choice of Mg and Ca sources for phosphorus recovery provides guidance on appropriate means to optimise the formation and yield of high quality cost-optimised products.