Structural and functional characterization of B-domain deleted recombinant factor VIII.

A new high-purity recombinant factor VIII preparation has been developed for the treatment of hemophilia A. Structurally, this factor VIII preparation, B-domain deleted recombinant factor VIII (BDDrFVIII), differs from other recombinant and plasma-derived factor VIII preparations in that most of the B-domain has been deleted. To ensure that BDDrFVIII contains the requisite structural and functional features, it has been subjected to detailed biochemical and biophysical characterization in comparison to the plasma-derived form of factor VIII. Laboratory studies have shown that the primary, secondary, and tertiary structures of BDDrFVIII and the posttranslational modifications are similar to those of the [80 + 90]-kd form of plasma-derived factor VIII. In addition, BDDrFVIII has full biologic activity compared with full-length factor VIII preparations.

Measurement of factor VIII activity of B-domain deleted recombinant factor VIII.

The factor VIII activity of B-domain deleted recombinant factor VIII (BDDrFVIII) measured by activated partial thromboplastin time (APTT)-based one-stage assays is approximately 50% of the activity obtained by the chromogenic assay. Similar results have been reported for the two licensed full-length recombinant factor VIII products. In view of these findings, comprehensive studies have been undertaken to find the cause of the assay differences. Only the phospholipid reagent, used as a platelet substitute in the one-stage assay, proved to be crucial for explaining the assay difference. When platelet-rich plasma was used as the source of phospholipid in the one-stage assay, the factor VIII activity assay results correlated well with those measured by the chromogenic assay. Similar results were obtained when the platelets were replaced by liposomes prepared using platelet factor 3 (PF3) as a model that has a low content (5% to 10%) of phosphatidylserine (PS). In contrast, the use of liposomes with 20% to 30% PS, as in the crude lipid extracts used in ordinary APTT reagents, resulted in underestimation of the factor VIII activity. Antigen measurements using an enzyme-linked immunosorbent assay (ELISA) method demonstrated a good correlation between the antigen and chromogenic activity, but not always between antigen and one-stage activity results. Based on these findings and the clinical data, it can be concluded that the chromogenic assay most accurately measures the functional activity of BDDrFVIII. However, modifications of the one-stage assay, such as the use of a product-specific standard or development of a PF3-like phospholipid reagent, could address the observed assay discrepancies.

Structural and functional characteristics of the B-domain-deleted recombinant factor VIII protein, r-VIII SQ.

Recombinant factor VIII SQ (r-VIII SQ), ReFacto, is a recombinant factor VIII product similar to the smallest active factor VIII protein found in plasma-derived factor VIII (p-VIII) concentrates. The protein comprises two polypeptide chains of 80 and 90 kDa and lacks the major part of the heavily glycosylated B-domain i.e. amino acids Gln744 to Ser1637. r-VIII SQ retains six potential glycosylation sites for N-linked oligosaccharides at asparagine residues 41, 239, 582, 1685, 1810 and 2118. We describe a thorough comparison of the characteristics of r-VIII SQ with those of p-VIII. The primary and secondary structures of r-VIII SQ were in good agreement with that of B-domain-deleted p-VIII (p-VIII-LMW) as shown by SDS-PAGE, Western blotting with antifactor VIII antibodies, tryptic mapping, amino acid sequence analysis and circular dichroism spectroscopy. A few divergences also existed. Thus r-VIII SQ was shown to contain a small amount of the single chain primary translation product of 170 kDa and also the product specific sequence of 14 amino acids, the SQ-link, in the C-terminal end of the 90 kDa chain. It was shown that r-VIII SQ had a high specific activity of about 14,000 IU VIII:C/mg as determined by use of a chromogenic substrate assay. The r-VIII SQ protein was comparable to p-VIII forms with a retained B-domain, in terms of potency measured by a chromogenic substrate or a two-stage clotting assay, in interactions with thrombin, and with activated protein C (APC) in combination with Protein S. The ability of r-VIII SQ to participate as a cofactor in factor Xa generation in a mixture of factors IXa and X, phospholipid and calcium was in conformity with that of p-VIII. Furthermore r-VIII SQ had a good binding capacity for phospholipid vesicles and von Willebrand factor (vWF) as shown in gel filtration studies. The same kinetics in binding to von Willebrand factor was found for r-VIII SQ and p-VIII as determined by real-time biospecific interaction analysis (BIA) with use of the BIAcore instrument. The apparent association rate constant was 4 x 10(6) M(-1)s(-1). Two dissociation rate constants were found, 1 X 10(-2)s(-1) and 4 x 10(-4)s(-1). The results extend the present knowledge that the factor VIII B-domain is dispensable for the factor VIII cofactor function in hemostasis.

Influence of phospholipids on the assessment of factor VIII activity.

In view of reported discrepancies between different factor VIII assays, the influence of phospholipids on the performance of one-stage clotting (OS) and chromogenic substrate (CS) assays was evaluated. The B domain deleted recombinant factor VIII, rVIII SQ, two full-length recombinant products and a plasma derived factor VIII concentrate were each diluted into severe haemophilia A plasma and assayed against a plasma standard. The one-stage activity was 50, 80, 75 and 106%, respectively, of the chromogenic result. Variations in the phospholipid concentration did not affect the chromogenic assay, except at very low levels where the apparent activity increased. In contrast, dilution of the phospholipid reagent had a substantial influence on the activity measured by OS assays, especially in the case of rVIII SQ. At low levels of phospholipid, the one-stage activity of rVIII SQ exceeded the chromogenic result. When mixtures of phosphatidylserine (PS) and phosphatidyl-choline (PC) were used as a source of phospholipid, the OS results for rVIII SQ agreed well with the CS activity as long as the content of PS was below 10%, i.e., closer to the physiological level. At higher levels of PS, as in most commercial APTT reagents, the OS activity decreased. When the APTT reagent was replaced by platelets in the OS assay, the results compared well with those obtained by the CS assay for both t-VIII SQ and full-length factor VIII products.

A simple and accurate microplate assay for the determination of factor VIII activity.

Based on the CoatestR Factor VIII kit, a simple and accurate microtiter plate assay has been developed. The method has been simplified through the combination of the bovine factors IXa + X, phospholipid and calcium chloride into one reagent. A further improvement was obtained by generating F Xa to a stable plateau level, thus minimizing influences from variations in time and temperature. The substrate hydrolysis was terminated with 1 M citrate buffer, pH 3.0, which reduced the environmental effects as compared to acetic acid. Overall a fourfold reduction in reagent consumption was achieved. A high correlation with clotting assays was obtained with various types of factor VIII concentrates as well as with plasma samples from blood donors and hemophilia A patients (r greater than 0.85). The accuracy was proven over the whole investigated range of factor VIII activities. Finally, the described microplate assay allows a high turnover of samples in a short period of time, still maintaining a coefficient of variation below 5%.

Human factor VIII: a calcium-linked protein complex.

The possible role of Ca2+ as an essential constituent part of the human factor VIII complex has been investigated by stability studies, metal determinations, and gel filtration experiments. In citrated plasma, the factor VIII coagulant activity (VIII:C) deteriorated during storage in a biphasic manner. Collection of blood in heparin, instead of chelating anticoagulants, or neutralization of citrate by addition of CaCl2 to heparinized citrate phosphate dextrose (CPD) plasma rendered VIII:C noticeably stable. At physiologic levels of ionized calcium, VIII:C was almost completely stable during incubation of plasma for 6 hr at 37 degrees C. The influence of other divalent ions was also studied. Highly purified factor VIII complex was subjected to atomic absorption spectrophotometric analysis and found to contain about 1.0 mole calcium per 220,000 daltons. This intrinsic calcium could be readily removed by EDTA. When heparin plasma and CPD plasma were chromatographed on Sepharose CL-6B at 37 degrees C, all the factor-VIII-related activities eluted together as large protein complexes. In contrast, factor VIII coagulant antigen (VIII:CAg) and factor-VIII-related antigen (VIIIR:Ag) were completely dissociated upon exposure to EDTA. From these observations it is concluded that human factor VIII circulates in normal plasma as a calcium-linked protein complex.