Variability in the acid adaptation of ten different O157:H7 and non-O157 Escherichia coli strains in orange juice and the impact on UV radiation resistance.

This study aimed to assess the impact of adaptation of ten strains of O157:H7 and non-O157 Escherichia coli to low pH (acid shock or slow acidification) and the effects of this exposure or not on the resistance of E. coli strains to UV radiation in orange juice (pH 3.5). The acid-shocked cells were obtained through culture in tryptic soy broth (TSB) with a final pH of 4.8, which was adjusted by hydrochloric, lactic, or citric acid and subsequently inoculated in orange juice at 4 °C for 30 days. No significant differences (p > 0.05) in survival in orange juice were observed between the serotypes O157:H7 and non-O157:H7 for acid-shocked experiments. After slow acidification, where the cells were cultured in TSB supplemented with glucose 1% (TSB + G), a significant increase (p < 0.05) in survival was observed for all strains evaluated. The D-values (radiation dose (J/cm2) necessary to decrease the microbial population by 90%) were determined as the inverse of the slopes of the regressions (k) obtained by plotting log (N/N0). The results show that among the strains tested, E. coli O157:H7 (303/00) and O26:H11 were the most resistant and sensitive strains, respectively. According to our results, the method of acid adaptation contributes to increasing the UV resistance for most of the strains tested.

The fate of Salmonella enterica and Listeria monocytogenes in the pulp of eight native Brazilian and exotic fruits.

Despite the wide variety of native and exotic fruits in Brazil, there is limited understanding of their ability to support pathogens during storage. This study aimed to evaluate the behavior of Salmonella enterica and Listeria monocytogenes inoculated into the pulp of eight fruits native and exotic to Brazil: Jenipapo (Genipa americana L.), Umbu (Spondias tuberosa Arruda), Maná (Solanum sessiliflorum), Cajá-manga (Spondias dulcis), Physalis (Physalis angulata L.), Feijoa (Acca sellowiana), Cupuaçu (Theobroma grandiflorum) (average pH < 3.3) and in a low acidy fruit: Abiu (Pouteria caimito) (pH 6.11). The pathogens were inoculated into the different fruits and stored at 10, 20, 30 and 37 °C for up to 12 h and 6 days, respectively. Among the fruits evaluated, Abiu was the only one that allowed Salmonella growth, showing higher δ-values at 20 and 30 °C (5.6 log CFU/g for both temperatures). For Physalis and Feijoa, there was a small reduction in the pathogen concentration (<1 log-cycle), mainly at 10 and 20 °C, indicating its ability to remain in the matrices. For the other fruits, notable negative δ-values were obtained, indicating a tendency towards microbial inactivation. The survival potential was significantly affected by temperature in Abiu, Maná, Cupuaçu, and Cajá-manga (p < 0.05). The same phenomena regarding δ-value were observed for L. monocytogenes population, with the greatest survival potential observed at 20 °C in Abiu (3.3 log CFU/g). Regarding the exponential growth rates in Abiu, the highest values were observed at 30 and 37 °C, both for Salmonella (4.6 and 4.9 log (CFU/g)/day, respectively) and for L. monocytogenes (2.8 and 2.7 log (CFU/g)/day, respectively), with no significant difference between both temperatures. Regarding microbial inactivation, L. monocytogenes showed greater resistance than Salmonella in practically all matrices. Jenipapo and Umbu were the pulps that, in general, had the greatest effect on reducing the population of pathogens. Furthermore, the increase in storage temperature seems to favor the increase on inactivation rates. In conclusion, Salmonella and L. monocytogenes can grow only in Abiu pulp, although they can survive in some acidic tropical fruits kept at refrigeration and abusive temperatures.

Alicyclobacillus spp. in fruit-based products: Isolation, identification, quantitative assessment (SPME/GC-MS) of spoilage compounds and spore's resistance to thermal shocks.

Alicyclobacillus spp. is the cause of great concern for the food industry due to their spores' resistance (thermal and chemical) and the spoilage potential of some species. Despite this, not all Alicyclobacillus strains can spoil fruit juices. Thus, this study aimed to identify Alicyclobacillus spp. strains isolated from fruit-based products produced in Argentina, Brazil, and Italy by DNA sequencing. All Alicyclobacillus isolates were tested for guaiacol production by the peroxidase method. Positive strains for guaiacol production were individually inoculated at concentration of 103 CFU/mL in 10 mL of orange (pH 3.90) and apple (pH 3.50) juices adjusted to 11°Brix, following incubation at 45 °C for at least 5 days to induce the production of the following spoilage compounds: Guaiacol, 2,6-dichlorophenol (2,6-DCP) and 2,6-dibromophenol (2,6-DBP). The techniques of micro-solid phase extraction by headspace (HS-SPME) and gas-chromatography with mass spectrometry (GC-MS) were used to identify and quantify the spoilage compounds. All GC-MS data was analyzed by principal component analysis (PCA). The effects of different thermal shock conditions on the recovery of Alicyclobacillus spores inoculated in orange and apple juice (11°Brix) were also tested. A total of 484 strains were isolated from 48 brands, and the species A. acidocaldarius and A. acidoterrestris were the most found among all samples analyzed. In some samples from Argentina, the species A. vulcanalis and A. mali were also identified. The incidence of these two main species of Alicyclobacillus in this study was mainly in products from pear (n = 108; 22.3 %), peach (n = 99; 20.5 %), apple (n = 86; 17.8 %), and tomato (n = 63; 13 %). The results indicated that from the total isolates from Argentina (n = 414), Brazil (n = 54) and Italy (n = 16) were able to produce guaiacol: 107 (25.8 %), 33 (61.1 %) and 13 (81.2 %) isolates from each country, respectively. The PCA score plot indicated that the Argentina and Brazil isolates correlate with higher production of guaiacol and 2,6-DCP/2,6-DBP, respectively. Heatmaps of cell survival after heat shock demonstrated that strains with different levels of guaiacol production present different resistances according to spoilage ability. None of the Alicyclobacillus isolates survived heat shocks at 120 °C for 3 min. This work provides insights into the incidence, spoilage potential, and thermal shock resistance of Alicyclobacillus strains isolated from fruit-based products.

Prioritization of vegetable-borne biological hazards in Argentina using a multicriteria decision analysis tool.

Vegetables, especially those eaten raw, have been implicated in several foodborne disease outbreaks. Since multiple vegetable matrices and hazards are involved, risk managers have to prioritize those with the greatest impact on public health to design control strategies. In this study, a scientific-based risk ranking of foodborne pathogens transmitted by leafy green vegetables in Argentina was performed. The prioritization process included hazard identification, evaluation criteria identification and definition, criteria weighting, expert survey design and selection and call for experts, hazard score calculation, hazard ranking and variation coefficient, and result analysis. Regression tree analysis determined four risk clusters: high (Cryptosporidum spp., Toxoplasma gondii, Norovirus), moderate (Giardia spp., Listeria spp., Shigella sonnei), low (Shiga toxin-producing Escherichia coli, Ascaris spp., Entamoeba histolytica, Salmonella spp., Rotavirus, Enterovirus) and very low (Campylobacter jejuni, hepatitis A virus and Yersinia pseudotuberculosis). Diseases caused by Norovirus, Cryptosporidium spp. and T. gondii do not require mandatory notification. Neither viruses nor parasites are included as microbiological criteria for foodstuff. The lack of outbreak studies did not allow to accurately identify vegetables as a source of Norovirus disease. Information on listeriosis cases or outbreaks due to vegetable consumption was not available. Shigella spp. was the main responsible for bacterial diarrhea, but it has not been epidemiologically associated with vegetable consumption. The quality of the available information for all hazards studied was very low and low. The implementation of good practice guidelines throughout the entire vegetable production chain could prevent the presence of the identified hazards. The current study allowed the identification of vacancy areas and could help reinforce the need for performing epidemiological studies on foodborne diseases potentially associated with vegetable consumption in Argentina.

Comprehensive evaluation and implementation of improvement actions in bovine abattoirs to reduce pathogens exposure.

The slaughter process plays an important role in animal welfare, meat quality, safety and public health through the meat production chain. In this study, we performed a three-stage evaluation: I) comprehensive evaluation, II) implementation of improvement actions and III) verification of the success of the actions implemented in three abattoirs from Argentina during 2016-2018. Risk was estimated using two checklists, quantified on a 1-100 scale and classified as high (1-40), moderate (41-70) and low (71-100). In stages I and III, Salmonella spp., E. coli O157:H7 and non-O157 STEC were detected and isolated in samples from carcasses (n = 252), the environment (n = 252); head meat (n = 21) and viscera washing and chilling water (n = 105). Carcass samples were analyzed for mesophilic aerobic organisms, coliforms and E. coli enumeration. Of 201 water samples taken, 42.0-75.6 % were non-potable quality. After the implementation of improvement actions in stage II (building, processes, systems for water purification and training), the estimation of risk of contamination was reduced from high to moderate in all three abattoirs, the count of indicator microorganisms decreased in two abattoirs, and the presence of pathogens significantly decreased. Salmonella spp. was not isolated from any of the samples collected in two abattoirs. Isolation of E. coli O157:H7 decreased in carcass and was not isolated from viscera washing and chilling water. Isolation of non-O157 STEC decreased in carcass but not in environmental samples. Finally, 75.0-95.0 % of water samples were of potable quality. Although this was only the first step in the process of change and improvement of abattoirs, the assessment of the situation and the proposal of solutions to correct deviations in a joint effort with the health authorities helped to implement a work model for enhancing food safety before meat reaches consumers.

Development and In-House Validation of a Real-Time Polymerase Chain Reaction for the Detection of Listeria monocytogenes in Meat.

Listeriosis is a foodborne disease caused by Listeria monocytogenes. The aims of this work were to develop and validate an in-house real-time polymerase chain reaction (RT-PCR) for the detection of L. monocytogenes, and to determine its prevalence in raw ground beef samples from 53 butcheries that also sell ready-to-eat foods. One set of primers and one hydrolysis probe were designed for hly gene detection and then challenged with pure strains. The detection was successful for all L. monocytogenes strains analyzed and negative for all non-L. monocytogenes strains (detection limit, 10 colony forming unit [CFU]/mL). Inclusivity, exclusivity, and analytical accuracy were 100%. L. monocytogenes was detected in 41.5% of raw ground beef samples from the 53 butcheries analyzed. This RT-PCR may be a valuable method for rapid detection of L. monocytogenes in meat.

Isolation and characterization of Shiga toxin-producing Escherichia coli from precooked sausages (morcillas).

The aim of the study was to establish the microbiological quality of morcillas, typical Argentine sausages, and to investigate the presence of Shiga toxin-producing Escherichia coli (STEC). Between October 2001 and October 2002, a total of 100 morcilla samples were analysed. Several samples showed high levels of total aerobic mesophilic bacteria counts, molds and yeasts. The samples analysed contained Enterobacteriaceae (100%) and fecal coliforms (81%), indicating inadequate application of the thermal treatment and deficient hygiene conditions during the elaboration of the product. STEC strains were isolated from three out of 100 (3%) morcilla samples. Two strains (2%) were characterized as E. coli O157:H7 stx2+stx2vh-a/eae/EHEC-hlyA and one strain (1%), as E. coli O26:H11 stx1/eae/EHEC-hlyA. Considering both the high microbial count in all tested samples and the presence of STEC strains in three of them, morcillas should be considered a food unsafe to consume when inadequately cooked.

Antimicrobial efficacy of UV radiation on Escherichia coli O157:H7 (EDL 933) in fruit juices of different absorptivities.

The efficacy of UV light for inactivating E. coli (ATCC 25922) and E. coli O157:H7 (EDL 933) was examined in fruit juices (orange, apple, and multifruit) with different absorptivities under several operating conditions (liquid film thickness and agitation rate). The juices were inoculated with two bacterial concentrations (10(5) and 10(7) CFU/ml) and were treated using a UV desinfection unit at 254 nm; UV doses ranged from 0 to 6 J/cm2. The effect of the culture medium, tryptone soy agar (TSA) and sorbitol MacConkey agar (SMAC), on the recovery of E. coli strains exposed to UV radiation was also analyzed. The most suitable culture medium for recovery of E. coli strains in juices exposed to UV radiation was TSA. Values of D (radiation dose [joules per square centimeter] necessary to decrease the microbial population by 90%) obtained in all juices assessed were higher in TSA than in SMAC. In the juices analyzed, stirring of the medium exposed to UV radiation and reducing liquid film thickness (to 0.7 mm) produced the highest bactericidal effect. A linear relationship was found between the D-values obtained and the absorptivity coefficients for all the juices. The higher the absorbance of the medium, the greater the values of D required to inactivate E. coli strains by UV radiation. An equation was developed to describe the relationship of the fraction of energy absorbed by the system (absorbed energy factor [AEF]), the thickness of the film exposed to UV radiation, and the absorptivity coefficient of the juices. A linear relationship was found between D and AEF in the different juices tested.