Review for special issue: Corneal lamellar surgery: Present outcomes and future perspectives.

Since the establishment of the first eye bank in the 1940s, their role has evolved to face new challenges. With the recent development of lamellar keratoplasties, eye banks play an even bigger role in the selection and preparation of donor tissues. The increasing number of keratoplasty techniques and the high demand for "ready-to-use" tissues are challenging eye banks to improve and develop new preparation techniques. Besides necessary examinations, new approaches of tissue analysis in eye banks allow a better/optimized selection of corneal tissues. These new challenges in tissue preservation, preparation, and selection are propelling eye banks into a new era of modern eye banking.

P23-A137†Cross-border cooperation for corneal donation between lions eye bank Saar-Lor-Lux, Trier/Westpfalz in Homburg/Saar and Luxembourg.

PURPOSE: With the increasing demand for corneas, eye banks must optimize and extend their sources of tissue donation. On the other hand, corneal transplantation is a specialized procedure performed in hospitals with high quality standards and ideally an integrated eye bank. In this report we would like to focus on an international win-win-win agreement between the Department of Ophthalmology at Saarland University Medical Center (Homburg/Saar, Germany), the LIONS Eye Bank Saar-Lor-Lux, Trier/Westpfalz and the four major non-university hospitals without corneal transplantation competence in Luxembourg. METHODS: In 2012, at the initiative of the Luxembourgish Ministry of Health and Department of Ophthalmology (Homburg/Saar, Germany), an international agreement was established with the Centre Hospitalier du Luxembourg (Luxembourg). Administrative and legislative rules were developed. Luxembourgish nursing personnel attended a practical training program for corneal excision at the Department of Ophthalmology in Homburg/Saar allowing them to harvest the two first corneal donors on site by themselves during the first year. In the following years two more hospitals, the Centre Hospitalier Emile Mayrisch (Esch-sur-Alzette, Luxembourg) and the Hôpitaux Robert Schuman (Kirchberg, Luxembourg), joined the cooperation. RESULTS: From 2012 until 2021, three hospitals in Luxembourg donated 779 corneas to the LIONS Eye Bank of the Saarland University Medical Center in Homburg/Saar (Germany). In return, 308 Luxembourgish patients have received a corneal transplantation at the Department of Ophthalmology in Homburg/Saar. In 2022, the extension continued and an agreement with a fourth hospital in Luxembourg at the Centre Hospitalier du Nord (Ettelbruck, Luxembourg) was signed providing even more donations. CONCLUSION: The cross-border collaboration for corneal donation and patient treatment has proven to be successful with both numbers of harvested donors and transplanted patients rising. However, international legislation for tissue donation needs to be accurately respected and a quality management system established to provide continuous quality of the donor tissue.

P42-A105†Sterile donor tomography for improvement of refractive results after keratoplasty.

PURPOSE: To evaluate the efficiency of using anterior segment optical coherence tomography (AS-OCT) as a non-invasive and sterile screening method in the eye bank to detect corneal grafts with curvature and/or thickness anomalies, thus improving the graft selection for corneal transplantation. METHODS: 1222 donor corneal tissues mounted in sterile organ culture flasks were imaged using an AS-OCT (CASIA 2 - Tomey, Nagoya, Japan) between January 2018 and September 2022. The corneal tissues were preserved at least 12 hours in organ culture medium 2 (containing 6% dextran T-500) before the measurement in order to allow deswelling prior to the examination. Depth scans were performed sterilely through the organ culture flask from the posterior surface of the corneal tissues within a 7 mm central zone to create 3D volume data. The volume data set was imported to MATLAB (MathWorks Inc., Natick, Massachusetts, USA) and, after preprocessing the data and defining the region of interest (ROI), the edge of the front and back surfaces of the corneal tissues was detected. Subsequently, the adaptation of a sphero-cylindrical surface model was carried out with raytracing. The radii of curvature for the front and back surfaces and the central corneal thickness were determined according to the method proposed by Mäurer, Eppig, Langenbucher et al at the Institute of Experimental Ophthalmology, Homburg/Saar, Germany. RESULTS: The mean steep/flat front surface radius was 7.46 ± 0.29 (6.07 - 9.29)/7.69 ± 0.24 (6.70 - 9.50) mm, the corresponding values for the back surface being 6.48 ± 0.32 (5.30 - 8.00)/6.80 ± 0.31 (5.81 - 8.00) mm and the mean central thickness was 611.5 ± 85.6 (378.5 - 1457.2) µm. Anomalies (beyond ± 2 or ± 3 standard deviations SD) were found in 111 or 41 corneas (9.1% or 3.4%) for anterior surface curvature, 135 or 38 for corneas (11.0% or 3.1%) for the posterior surface, and 53 or 15 corneas (4.3% or 1.2%) for central corneal thickness. CONCLUSION: The AS-OCT provides an objective, sterile and semi-automated screening method to identify corneal morphological and refractive alterations (e.g. keratoconus, status post keratorefractive surgery) to further optimize corneal donor selection in the eye bank. Corneal donors with curvature or thickness anomalies +/- 3 SD (eminence-based) do not have to be discarded but can be used for posterior lamellar keratoplasty, especially DMEK in Germany.

P08-A131†Comparison of sterile donor tomography in the eye bank and previous keratometric measurements during the donor's lifetime.

PURPOSE: Sterile donor tomography in the eye bank can be used to minimise refractive surprises after corneal transplantation.The aim of this study was to compare sterile tomography of donor corneas in the eye bank with keratometric measurements of the same donors performed prior their death. METHODS: Since 2018, 1246 donor sclerocorneal discs have been routinely measured using donor tomography, taken sterilely through their cell culture flask in medium II using the anterior segment optical coherence tomograph Casia 2 (Tomey Corp., Nagoya, Japan) and a custom-made Matlab software (The MathWorks Inc., Natick, Massachusetts, USA). Of all these donor corneas, 19 (1.5%) appeared to have been measured with Pentacam (Oculus Optikgeräte GmbH, Wetzlar, Germany) in the donors before death. Both measurements, taken at a mean interval of 35 ± 26 months, were compared using a Wilcoxon signed-rank test. RESULTS: The mean steepest/flattest front surface radius and anterior astigmatism of the corneas measured with Pentacam amounted 7.66±0.35/7.93±0.37 mm, and 0.27±0.43 mm. Corresponding values of sterile donor tomography were respectively 7.48±0.31 [p<0.01]/7.77±0.25 [p=0.01] mm, and 0.29±0.35 [p=0.78] mm.At the posterior corneal surface, the Pentacam measured a mean steepest/flattest surface radius and astigmatism of 6.27±0.33/6.72±0.48 mm and 0.45±0.47 mm, whereas values of sterile donor tomography amounted 6.55±0.30 [p<0.01]/6.94±0.33 [p=0.04] mm and 0.39±0.26 [p=0.63] mm, respectively.The central corneal thickness amounted 575±52 µm with Pentacam, and 597±80 µm [p=0.20] with sterile donor tomography. CONCLUSION: The front and back surface astigmatism as well as the central corneal thickness remained statistically unchanged after corneal excision and preservation in organ culture in comparison to measurement of the donor prior death. The statistically non-similar anterior and posterior radius of curvature between both methods must be seen in light of the known differing corneal topography between swept-source anterior segment optical coherence tomography and Scheimpflug imaging. These results suggest a merely minimal deformation caused by the storage and attachment of donor corneas to their holder in the cell culture flask for sterile donor tomography, causing a steeper anterior surface curvature but leaving the astigmatism still congruent with previous in situ conditions.

In situ donor keratometry in deceased patients as a novel screening technique for eye banking.

PURPOSE: To investigate the potential role of keratometry on whole globes in situ of deceased patients by assessing its repeatability and comparing it with sterile donor tomography after excision and preservation in organ culture. METHODS: A sequence of 5 measurements was taken from 40 eyes in situ of deceased patients < 24 h after death using the portable Retinomax K-plus 3 (Bon, Tokyo, Japan). Keratometry of whole globes in situ, from which sclerocorneal discs were taken for organ culture, was compared to those obtained after measuring these sclerocorneal disks through their cell culture flask in medium I after 5 ± 4 days using the anterior segment optical coherence tomograph Casia 2 (Tomey Corp., Nagoya, Japan), and to 964 different donor corneas in medium II. RESULTS: Cronbach's alpha of the in situ keratometry was 0.891 and 0.942 for the steepest and flattest corneal power (P). The steepest (44.5D) and flattest (41.1D) P as well as the astigmatism (3.4D) of in situ corneas remained unchanged after preserving sclerocorneal discs in medium I (respectively 44.7D [p = 0.09]; 41.4D [p = 0.17]; 3.3D [p = 0.09]). The comparison of the in situ values with the 964 measured different donor corneas in medium II showed significantly (p < 0.001) higher P at the steep (45.4D) and flat (43.9D) meridian and smaller astigmatism (1.4D) for sterile donor tomography. CONCLUSIONS: Measuring deceased patients' eyes in situ with the portable Retinomax K-plus 3 represents a feasible and reliably repeatable screening method in the eye bank. In comparison to donor tomography in medium I, it measures a similar power and astigmatism.

Corneal epithelial ingrowth after perforating corneal injury: a case report.

BACKGROUND: Epithelial ingrowth is a rare complication after ocular perforation and can become manifest many years after the primary trauma. CASE PRESENTATION: A 49-year-old patient presented with a positive Seidel test of unclear origin at her left eye, as well as a sharply defined anterior-stromal corneal scar at both eyes. Prior operations included a bilateral laser-assisted blepharoplasty 3 months earlier. The patient indicated to have been on holiday to France 5 months earlier, during an ongoing oak processionary moth caterpillars infestation. The examination using confocal microscopy confirmed a corneal perforation at the left eye and revealed corneal epithelial ingrowth capped with scarred stroma in both eyes. We performed a penetrating keratoplasty at the left eye. The scarred and perforated host cornea was divided into 4 pieces for further investigation: microbiology (negative), virology (negative), histology and transmission electron microscopy (TEM). Histology revealed differently structured epithelium, centrally inverted into the stroma through defects in Bowman's layer. TEM revealed full thickness corneal perforation with an epithelial plug extending to the lower third of the cornea, but without evidence of epithelial cell migration into the anterior chamber. Our differential diagnosis of the unclear positive Seidel test with epithelial ingrowth was as follows: (1) corneal perforation by hairs of the oak processionary moth caterpillar, although no hairs could be found histologically; (2) corneal perforation during laser-assisted blepharoplasty, which may be supported by the presence of pigmented cells on the posterior surface of Descemet´s membrane, pointing to a possible iris injury. CONCLUSION: Consequently, we highlighted that contact lenses can be useful, safe and inexpensive protective devices in upper eyelid procedures to protect the cornea against mechanical iatrogenic trauma.

Epidemic keratoconjunctivitis: efficacy of outbreak management.

PURPOSE: Epidemic keratoconjunctivitis (EKC) is one of the most severe ocular viral infections. The aim of this interruptive time series study was to quantitatively evaluate the effectiveness of a hygienic EKC outbreak management concept developed in our ophthalmological department. METHODS: All patients with suspected EKC in the period from August to November 2018 were included in the study. Data were retrospectively collected from the patient's medical documents and records. The disease was diagnosed clinically and confirmed by virus detection through polymerase chain reaction (PCR) from conjunctival swabs. With the beginning of the epidemic, an outbreak management plan was implemented to reduce the nosocomial spread. RESULTS: The outbreak lasted 77 days (20th August 2018 to 4th November 2018) and affected a total of 120 patients. This corresponds to a mean of 1.5 patients per outbreak day. The median age was 58 [1-92] years. Of all patients, 61 (50.8%) were female. Conjunctival swabs were collected in 100/120 (83.3%) cases, the adenovirus being detected in all positive smears (63/63, 100%). The implementation of our outbreak management plan reduced significantly the number of EKC cases per outbreak day and resulted in a reduction of the basic reproduction number by a factor of 2.2. CONCLUSION: The detection of EKC together with the immediate implementation of hygienic outbreak measures can significantly reduce the spread of infection. The implementation of a strict outbreak management concept can significantly reduce the number of EKC cases, thus avoiding possible complications and therefore unnecessary health-related costs.

Reliability and efficiency of corneal thickness measurements using sterile donor tomography in the eye bank.

To evaluate the reliability and efficiency of sterile pachymetric measurements of donor corneas based on tomographic data using two different methods: a "manual" and a "(semi-)automated" method. Twenty-five (25) donor corneas (50%) stored in MI and 25 (50%) in MII were imaged 5 times consecutively using an anterior segment OCT (AS-OCT). The central corneal thickness (CCT) was measured both with the manual measurement tool of the AS-OCT (= CCTm) and with a MATLAB self-programmed software allowing (semi-)automated analysis (= CCTa). We analyzed the reliability of CCTm and CCTa using Cronbach´s alpha (α) and Wilcoxon signed-Rank Test. Concerning CCTm, 68 measurements (54.4%) in MI and 46 (36.8%) in MII presented distortions in the imaged 3D-volumes and were discarded. Concerning CCTa, 5 (4%) in MI and 1 (0.8%) in MII were not analyzable. The mean (± SD) CCTm was 1129 ± 6.8 in MI and 820 ± 5.1 µm in MII. The mean CCTa was 1149 ± 2.7 and 811 ± 2.4 µm, respectively. Both methods showed a high reliability with a Cronbach´s α for CCTm of 1.0 (MI/MII) and for CCTa of 0.99 (MI) and 1.0 (MII). Nevertheless, the mean SD of the 5 measurements was significantly higher for CCTm compared to CCTa in MI (p = 0.03), but not in MII (p = 0.92). Sterile donor tomography proves to be highly reliable for assessment of CCT with both methods. However, due to frequent distortions regarding the manual method, the (semi-)automated method is more efficient and should be preferred.

16†Reliability and efficiency of corneal thickness measurements using sterile donor tomography in the eye bank.

PURPOSE: To evaluate the reliability and efficiency of sterile corneal thickness measurements of donor corneas stored in a plastic culture flask filled with organ culture medium I (MI) or II (MII) based on tomographic data using two different software: the built-in software of the anterior segment OCT (AS-OCT) and a MATLAB self-programmed software. METHODS: Twenty-five (25) donor corneas (50%) stored in MI and 25 (50%) in MII were imaged 5 times consecutively using an AS-OCT. The central corneal thickness (CCT) was measured both with the manual measurement tool of the AS-OCT (=CCTm) and with a MATLAB self-programmed software allowing (semi-)automated analysis (=CCTa). We analyzed the reliability of CCTm and CCTa using Cronbach´s alpha (α) and Wilcoxon signed-rank test. RESULTS: Concerning CCTm, 68 measurements (54.4%) in MI and 46 (36.8%) in MII presented distortions in the imaged 3D-volumes and were discarded. Concerning CCTa, 5 (4%) in MI and 1 (0.8%) in MII were not analyzable. The mean (± SD) CCTm was 1129 ± 6.8 in MI and 820 ± 5.1 µm in MII. The mean CCTa was 1149 ± 2.7 and 811 ± 2.4 µm, respectively. Both methods showed a high reliability with a Cronbach´s α for CCTm of 1.0 (MI/MII) and for CCTa of 0.99 (MI) and 1.0 (MII). Nevertheless, the mean SD of the 5 measurements was significantly higher for CCTm compared to CCTa in MI (p = 0.03), but not in MII (p = 0.92). CONCLUSIONS: Sterile donor tomography proves to be highly reliable for assessment of CCT with both methods. However, due to frequent distortions regarding the manual method, the (semi-)automated method seems to be more efficient and should be preferred.

OCT Application for Sterile Corneal Graft Screening in the Eye Bank. / OCT-Einsatz für das sterile Spender-Screening in der Hornhautbank.

BACKGROUND AND OBJECTIVE: Sterile donor tomography enables the detection of corneal tissues with refractive anomalies. The aim of this study was to determine the curvature and thickness of donor corneas to support proper selection in the eye bank. METHODS: 704 donor corneas (Klaus Faber Center, LIONS Eye Bank Saar-Lor-Lux, Trier/Westpfalz, in Homburg/Saar) were measured using the anterior segment optical coherence tomograph (AS-OCT) CASIA 2 (Tomey Corp., Nagoya, Japan). The corneoscleral discs were measured in their cell culture flask, which was positioned in a holder on the chin rest of the AS-OCT, after conversion to medium II (with 6% dextran T-500). The measured raw data were analysed and processed in MATLAB (MathWorks Inc., Natick, Massachusetts, USA), after which the refractive power of the steep and flat meridian at the anterior and posterior surface and the central corneal thickness (CCT) of the donor corneas were determined. Results values are expressed as mean x̅ ± standard deviation SD. RESULTS: The mean refractive power of the steep/flat meridian at the anterior surface was 45.4 ± 1.8 D/44.0 ± 1.3 D, the corresponding values for the posterior surface were - 6.2 ± 0.3 D/- 5.9 ± 0.2 D, and the mean CCT was 616.3 ± 85.1 µm. Of the 704 (100%) measured donor tissues, 590 (83.8%)/670 (95.2%) donor corneas showed no anomaly beyond respectively x̅ ± 2 SD/x̅ ± 3 SD among the 5 examined parameters. 72 (10.3%)/23 (3.3%) donor corneas had only 1 anomaly, 26 (3.7%)/10 (1.4%) had 2 anomalies, 10 (1.4%)/1 (0.1%), 3 anomalies, 5 (0.7%)/0 (0.0%), 4 anomalies, and 1 (0.1%)/0 (0.0%), 5 anomalies. CONCLUSIONS: AS-OCT provides an objective and sterile screening method to identify corneal tissues with curvature anomalies in order to further optimise donor selection in the eye bank. To avoid postoperative refractive surprises, donor corneas with a total refractive power that deviates > ± 3 SD from the mean should not be used for penetrating or anterior lamellar keratoplasty, but may be suitable for posterior lamellar keratoplasty (DMEK or DSAEK). In the future, sterile donor tomography could enable: (1) the harmonisation of donor and recipient tomography, which may minimise residual astigmatism for a particular donor-recipient pair; and (2) the improvement of IOL power calculation in a classical triple procedure by means of regression analysis between pre- and postoperative total refractive power of corneal grafts.

Thickness and Curvature Changes of Human Corneal Grafts in Dextran-Containing Organ Culture Medium Before Keratoplasty.

PURPOSE: To determine the changes of corneal thickness and curvature of human corneal grafts in organ culture medium II, containing dextran T500 6%, before keratoplasty. METHODS: We examined the tomography of 24 corneas from our eye bank transferred from medium I into medium II. Images were repeated hourly during 24 hours using an anterior segment optical coherence tomography. The central corneal thickness (CCT) was measured with the manual measurement tool of the anterior segment optical coherence tomography. The radii of curvature (anterior flat and steep and posterior flat and steep) were measured with a MATLAB self-programmed software for "sterile donor tomography." RESULTS: The mean CCT (±SD) at baseline (T0) was 727 ± 156 µm. It reached 581 ± 103, 506 ± 84, 472 ± 79, and 456±7 µm after 6, 12, 18, and 24 hours, respectively. After 12 hours, 83% of the final deswelling was achieved. The radii of curvature (±SD) at baseline (T0) were (posterior flat, posterior steep, anterior flat, and anterior steep) 6.6 ± 0.5, 6.2 ± 0.5, 7.7 ± 0.4, and 7.4 ± 0.4 mm, respectively. After 24 hours, the radii of curvature reached 6.8 ± 0.1, 6.6 ± 0.3, 7.6 ± 0.1, and 7.4 ± 0.2 mm, respectively. CONCLUSIONS: The kinetics of the deswelling process in medium II follow a hyperbolic curve. Considering a CCT of 506 µm at T12, we assume that a time interval of 12 hours in medium II might be enough for clinical purposes. This result might help to keep storage in medium II as short as possible to escape potential toxic effects of dextran in medium II. The radius of curvature does not seem to change within 24 hours for all measured surfaces.