Sunflower and rapeseed meal as alternative feed materials to soybean meal for sustainable egg production, using aged laying hens.

1. This study assessed the impact of replacing two thirds of a soybean meal (SBM) based diet with an alternative protein (AP) based diet (sunflower and rapeseed meal), when fed to end of production Hy-Line Brown laying hens.2. Diets were fed in seven cages, each containing six birds aged from 75 to 83 weeks old. Measured variables included bird performance, egg production, quality variables of fresh eggs, total tract digestibility of dry matter (DMD), neutral detergent fibre (NDFD), fat (FD), and nitrogen corrected apparent metabolisable energy (AMEn).3. No significant differences were observed (P > 0.05) for egg production, egg composition or egg quality. However, birds fed the AP diet had darker yolks (P < 0.05), possibly linked to natural pigments in AP.4. The SBM diet had higher AMEn, DMD and NDFD (P < 0.05), although FD was higher in the AP diet (P < 0.05).5. Diets based on AP sources can be fed to aged laying hens without deteriorating productive performance, providing care is taken in formulating diets (e.g. amino acid levels, balance etc). Using AP sources may reduce reliance on SBM associated with land use change, contributing towards sustainability for the egg industry.

Broiler chicken response to xylanase and fermentable xylooligosaccharide supplementation.

A study was conducted to determine the effect of dietary fiber (DF), xylanase (XYL), xylooligosaccharides (XOS), and a combination of XYL and xylooligosaccharides (STBIO) on chicken growth performance, N-corrected apparent metabolizable energy (AMEn), and nutrient availability, characteristics of the gastrointestinal tract (GIT), and cecal content of short-chain fatty acids (SCFA). A 35-day experiment was performed on 1,920 as hatched Ross 308 broiler chicks, reared in 96 pens and fed ad libitum. Experimental diets were split into 2 phases: starter (0-21 d) and finisher (22-35 d). There were 2 basal diets, first contained 54% maize and in the second, 5% of the maize was replaced by wheat bran as DF. The diets were split into 4 batches: one of them was used as a control, and each of the others were supplemented either with XYL or XOS or with the STBIO. Each diet was fed to 12 pens following randomization. The data were analyzed in GenStat (20th edition) by ANOVA using a 2 × 4 factorial design. The addition of STBIO improved feed conversion ratio (FCR) and increased weight gain (WG) from 21 to 35 d and from 0 to 35 d (P < 0.05). The inclusion of DF had a negative effect on N and fat retention coefficients at 35 d as well as AMEn and dry matter retention at 21 and 35 d. At 21 d, neutral detergent fiber (NDF) retention was increased when xylanase and STBIO were added to the diet (P < 0.001) and at d 35 the highest retention was noted when the diet was supplemented with DF and XYL or STBIO (P = 0.001). There was no dietary effect on jejunum histomorphometry (P > 0.05). The addition of DF increased the concentration of cecal SCFA in particular valeric and propionic acid at 35-day-old birds (P < 0.05). It can be concluded that addition of STBIO in diet could provide benefits in terms of fiber degradation, WG, and feed efficiency.

Refining the metabolisable energy value of field beans for turkeys.

1. This study examined the feeding value of ten UK grown field bean (Vicia faba L. var. minor) cultivar samples from the same harvest year on nitrogen corrected apparent metabolisable energy (AMEn) and nutrient retention coefficients when fed to young female turkeys.2. A balancer feed (BF) was formulated to contain 12.39 MJ/kg ME and 269 g/kg crude protein. Ten nutritionally complete, mash diets were prepared by mixing 200 g/kg of each ground field bean cultivar with 800 g/kg of the BF, totalling eleven diets. Diets were fed to female BUT Premium turkeys from 40 to 50 d of age. Each diet was fed to eight raised floor pens, housing two birds, following randomisation. The AMEn was determined by the total collection technique over the last 4 d of the study. Relationships were examined between AMEn, chemical composition and quality variables of the field bean samples.3. The overall determined AMEn value of the beans ranged from 7.72 MJ/kg DM to 9.87 MJ/kg DM, giving an average AMEn of 8.80 MJ/kg DM (P < 0.05). The soluble non-starch polysaccharide (NSP) content of the beans negatively correlated with their determined AMEn (r = -0.730; P < 0.05). Bean flour lightness-darkness degree (L*) correlated positively with the AMEn (r = -0.643; P < 0.05)4. A positive correlation was observed between the degree of yellowness-blueness of bean flour and condensed tannins content (r = 0.696; P < 0.05). Step-wise regression indicated that soluble NSP + L* of field beans provided explanatory variables suitable for estimating the AMEn value for turkeys (r2 = 0.737; P < 0.05).

Commentary on Baverstock; the gene; an appraisal.

I argue that Baverstock's demotion of the gene in favour of the cellular phenotype is still too limited, and that phenotypes must be considered at multiple irreducible levels. I emphasise process thinking and the significance of agency in living systems.

Effects of different dietary starch sources on growth and glucose metabolism of geese.

This experiment investigated the effects of different dietary starch sources on the growth and glucose metabolism of geese. A total of 240 healthy 35-day-old male geese were selected and randomly divided into 4 groups, with 6 replicates per group and 10 geese per replicate. Four types of diets were prepared, with glutinous rice (rapidly-digestible starch), corn, indica rice and high amylose as their starch sources, and fed for 28 d. Results showed that after consuming different feeds, the blood glucose of geese first increased and then decreased, reaching its maximum value 0.5 h after feeding, and there were significant differences between the groups (P < 0.05). The body weight of the corn and indica rice group geese at 63 d was higher than that of the high amylose group (P < 0.05). The serum total cholesterol (TCHO) content in the glutinous rice and corn groups was higher than in the high amylose group (P < 0.05). The serum insulin content in the glutinous rice group was lower than in the corn and high amylose groups (P < 0.05), while the glucagon content was higher (P < 0.05). The α-amylase activities of the pancreas, jejunal chyme, and jejunal mucosa in the glutinous rice group were higher than in the indica rice and high amylose groups (P < 0.05). The liver glycogen content in the glutinous rice group was higher than the other groups (P < 0.05). The liver glucose-6-phosphate dehydrogenase (G-6-PD) content in the glutinous rice group was higher than the high amylose group's (P < 0.05), but the glycogen synthase kinase-3 ß (GSK-3ß) content was lower (P < 0.05). In conclusion, the corn and indica rice diets had a positive effect on the growth performance of the geese, while the high amylose diet had a negative effect. The glutinous rice diet leads to rapid release of glucose, strengthening glucose metabolism pathways such as glycogen synthesis and the pentose phosphate pathway, and further influencing lipid metabolism.

Rapeseed meal processing and dietary enzymes modulate excreta inositol phosphate profile, nutrient availability, and production performance of broiler chickens.

This study aimed to assess the effect of rapeseed meal (RSM) processing method, where solvent extraction occurred under standard industry conditions (ST) or cold-pressed hexane extraction was employed (MT), and exogenous enzyme supplementation (phytase [PHY] and xylanase [XYL]) alone or in combination on key nutritional factors of broiler chickens. A randomized control experiment was performed using 144 male Ross 308 broilers in a 2 × 2 × 3 factorial arrangement. Three diets including a nutritionally complete wheat-based basal diet (BD), a diet containing 200 g/kg of RSM extracted under ST and another diet containing 200 g/kg of RSM extracted under MT were produced. Each diet was then split into 4 parts and was fed as is, or supplemented with PHY at 1,500 FTU/kg or XYL at 16,000 BXU/kg, alone or in combination, resulting in 12 diets in total. Response criteria: feed intake (FI), weight gain (WG), and feed conversion ratio (FCR), from 7 to 21 d age, AMEn, retention coefficients for dry matter (DMR), nitrogen (NR), fat (FR), and the profile of inositol phosphate esters (IP2-6) and myo-inositol (MI) in excreta. Diets containing MT had higher AMEn compared to ST diets (P < 0.05). There was RSM by PHY interaction for FI, as only birds fed MT diet responded to PHY supplementation with reduced FI and FCR (P < 0.001). Feeding XYL reduced overall FI and FCR (P < 0.05). Feeding PHY reduced IP6 and increased MI in excreta (P < 0.001). Feeding XYL and PHY in combination reduced MI in excreta compared to PHY only (P = 0.05). Compared to BD, birds fed RSM diets had an increased IP6 (P < 0.05) and MI concentration in excreta (P < 0.01). This may be due to IP ester differences in RSM and BD.

Feeding dihydroquercetin in wheat-based diets to laying hens: impact on egg production and quality of fresh and stored eggs.

1. This study assessed the impact of dietary dihydroquercetin (DHQ) in wheat-based diets on egg production, composition and quality when fed to laying hens. A total of 80 Hy-Line Brown hens were allocated to 20 enriched layer cages, over two tiers, in groups of four birds.2. Two wheat-based diets were used in the study. A basal diet, meeting the nutrient requirement of the hens, containing 11.56 MJ/kg AME and 172 g/kg crude protein, was mixed and split into two parts. One part was fed as prepared to the control group of birds. The second diet was made by adding 1.5 g DHQ per kg basal diet and fed to the treatment group of birds. This level was relatively high and extended the data on levels normally fed. The diets were fed in a meal form and did not contain any coccidiostat, antimicrobial growth promoters or other similar additives. Each diet was fed to hens in 10 replicate cages for 4 weeks, from 22 to 26 weeks of age, following randomisation.3. Subsequently, eggs were investigated to determine the impact of dietary DHQ on the quality variables of fresh and 28-d stored eggs.4. Overall, feeding 1.5 g/kg dietary DHQ for 4 weeks did not affect (P > 0.05) egg production or the quality of fresh and stored eggs. Any observed egg quality changes (P < 0.05) confirmed the expected effects of egg storage.

Dietary amylose and amylopectin ratio changes starch digestion and intestinal microbiota diversity in goslings.

1. Research has confirmed that amylopectin (AP) is more easily digested than amylose (AM) because AP polymers have more intramolecular hydrogen bonds and less surface area. Studying the relationship between the amylose:amylopectin (AM:AP) ratio and intestine digestion in goslings can provide useful information for effective utilisation of starch.2. A total of 288 healthy male Jiangnan White Goslings, aged three days old, were randomly allotted to four groups, which included six pen replicates per treatment with 12 goslings per replicate. Four diets were formulated with maize, long-grained rice and glutinous rice as starch sources, with AM:AP ratios of 0.12, 0.23, 0.34, and 0.45. In vitro starch digestion of the four diets was measured, as well as the effect of AM:AP ratio on growth performance, serum amino-acid concentration and intestinal microbiota diversity of goslings.3. In terms of in vitro starch digestion, the increase in dietary AM:AP ratio resulted in a decrease followed by an increase in both rapidly and slowly digestible starch. The glucose release rate at an AM:AP ratio of 0.34 showed a steady upward trend.4. The in vivo study showed that increasing the AM:AP ratio resulted in a quadratic increase in body weight (BW) and average daily feed intake (ADFI; P < 0.05). Goslings fed diets with an AM:AP ratio of 0.34 had lower (P < 0.05) histidine and valine serum concentrations compared with the other three starch sources. Higher AM was beneficial to jejunal microbial and diversity. The species colonisation level of the jejunum microbiota samples at an AM:AP ratio of 0.34 was higher than that in the other groups.5. The results indicated that diets with an AM:AP ratio of 0.34 improved the growth performance and intestinal microbiota diversity of goslings. This may have been due to the higher level of resistant starch in amylose, which resulted in a slow release of intestinal glucose that acted as a substrate for the microbial species, thus providing conditions that were more conducive to growth.

Feeding guanidinoacetic acid to broiler chickens can compensate for low dietary metabolisable energy formulation.

1. This study compared the responses of broilers to diets supplemented with the same level of guanidinoacetic acid (GAA) but formulated to have different N-corrected apparent metabolisable energy (AMEn) contents. The study involved 1280, one-day-old Ross 308 broilers, in 64 pens comprising 32 pens of males and 32 pens females, (20 birds in each) aged from 0 to 42 d.2. Commercial AME levels of 12.55 MJ/kg, 12.97 MJ/kg and 13.18 MJ/kg in the starter, grower and finisher diets, respectively, were set for the positive control (PC) feed. Four dietary treatments were prepared: PC (as above); negative control 1 (NC; PC - 0.21 MJ ME /kg); NC1 + 0.06% GAA; NC2 (PC - 0.42 MJ ME/kg + 0.06% GAA). Each diet was provided in 16 pens (eight male and eight female), following randomisation.3. Overall, birds fed NC1 had lower feed intakes (FI) compared to birds fed the PC and NC2+ GAA, lower weight gain (WG) compared to all the other diets and lower final body weight than birds fed the GAA diets (P < 0.05). There was a diet x sex interaction (P = 0.039), whereby feeding NC+GAA to female birds improved feed efficiency compared to being fed NC2 and NC1+ GAA, but not in males. Birds fed diets with GAA had a higher poultry efficiency factor (P < 0.001) than those fed NC1.4. There were no effects of treatment or sex on litter moisture, footpad score, white striping, wooden breast, AMEn, dry matter and fat retention (P > 0.05). However, the diet NC1+ GAA had 11.2% higher nitrogen retention coefficient compared to the NC1 diet (P = 0.038).5. Overall, the results implied that lower performance induced by a reduction of dietary AMEn in the range of 0.21 to 0.42 MJ/kg was more than compensated by supplementing 600 g/t GAA to the feed.

Variability of amino acid digestibility in different field bean cultivars for broilers.

1. The amino acid composition of 10 different UK-grown field bean cultivar samples from the same harvest year were determined.2. Diets included each bean sample at a level of 200 g/kg feed compared against a control diet formulated with only soyabean sources, whereby the beans replaced the soyabean meal, and were used to compare ileal amino acid digestibility. The amino acid digestibility coefficients for the bean samples were obtained via substitution method.3. The data showed that one field bean sample, cultivar Sultan, had a lower amino acid digestibility (P < 0.05) than that of the other nine . This sample had a higher tannin content that may have affected amino acid digestibility.

Dietary microbial muramidase improves feed efficiency, energy and nutrient availability and welfare of broilers fed commercial type diets containing exogenous enzymes.

1. The aim of this study was to evaluate the effect of graded levels of the microbially derived feed lysozyme, muramidase (MUR) on feed intake (FI), weight gain (WG), feed conversion ratio (FCR), European Performance Index (EPI), dietary N-corrected apparent metabolisable energy (AMEn), footpad dermatitis score (FPD) and other welfare variables, when fed to broilers from 0 to 42d age. 2. A four-phase dietary programme and four experimental pelleted diets were used; a control diet (following breeder recommendations without MUR supplementation), and three diets based on the control diet supplemented with 25,000, 35,000 and 45,000 LSU (F)/kg of MUR, respectively. In addition, all experimental diets contained exogenous xylanase, phytase and a coccidiostat. Each diet was fed to birds in 24 pens (20 male Ross 308 chicks in each pen) following randomisation. Dietary AMEn was determined at 21 d of age, and FPD was evaluated at the end of the study. Data were analysed by ANOVA, using orthogonal polynomials for assessing linear and quadratic responses to MUR activity. 3. The inclusion of MUR did not change FI (P > 0.05), but increased WG in a linear manner (P < 0.05) and reduced FCR in a quadratic manner, with optimum WG and FCR observed in birds fed approximately 35 000 LSU (F)/kg. In accordance with the improvement in FCR, 35 000 LSU (F)/kg MUR supplementation produced the highest EPI (P < 0.05). FPD score was linearly decreased with increased addition of MUR (P < 0.05). Dietary AMEn responded in a quadratic fashion to the MUR inclusion, as the highest values were obtained with the highest inclusion rate (P < 0.05). 4. In conclusion, the results showed that inclusion of MUR improved feed efficiency and the foot health of birds.

The effect of selenium source on the oxidative status and performance of broilers reared at standard and high ambient temperatures.

1. This study investigated the oxidative status of broilers fed diets containing selenium (Se) from 14 to 35 d of age and reared at two different constant temperatures. Measurements of oxidative status included blood glutathione peroxidase (GSH-Px) and plasma total antioxidant status (TAS). Other variables included feed intake (FI), weight gain (WG), feed conversion ratio (FCR), Se levels in breast and liver tissue, jejunal villus morphometry, percentage weight of organs in relation to body weight; apparent metabolisable energy adjusted for nitrogen (AMEn); dry matter retention (DMR); fat retention (FR) and nitrogen retention (NR).2. The experiment started at 14 d of age, when 240 birds were randomly allocated to 48 pens (12 pens in four rooms). Treatments included a control diet 1 (SFC; 209.4 g/kg CP and 12.98 MJ/kg ME and no added Se containing saturated fat); diet 2 (SFSe) the control plus 12.605 mg/kg Se additive; diet 3 (USFC) was a second control diet (208.2 g/kg CP and 13.10 MJ/kg ME with no added Se containing unsaturated fat as rapeseed oil); diet 4 (USFSe) was the latter control plus 12.605 mg/kg Se additive. Two rooms were kept at a standard temperature of 20°C (ST) and two rooms were kept at high temperature of 35°C (HT).3. A temperature x Se interaction existed for GSH-Px in birds reared at ST (P < 0.05), and these birds had the highest levels of Se in liver tissue (P < 0.05). Fat x Se interactions were evident in breast tissue with highest levels in USFSe (P < 0.05). Adding Se improved jejunal VH: CD in USFSe fed birds (P < 0.001).4. Birds reared at ST had higher FI and WG than those reared at HT (P < 0.001), and had lower FCR than those reared at HT (P < 0.05). AMEn (MJ/kg DM) and FR were higher in birds fed USF diets, and lowest in birds fed SF (P < 0.50 and P < 0.001 respectively). NR was highest in birds raised at ST (P < 0.50).5. Broiler growth performance was reduced by HT. Oxidative status and Se in liver tissue was improved by adding Se in both diets.

Variation in the chemical composition and the nutritive quality of different field bean UK-grown cultivar samples for broiler chicks.

1. The chemical composition and physical characteristics of 10 different UK-grown field bean cultivar samples from the same harvest year were determined.2. Diets included each bean sample at a level of 200 g/kg, and were used to compare broiler growth performance and determine N-corrected apparent metabolisable energy (AMEn) and nutrient utilisation. The AMEn and nutrient retention coefficients for the bean samples were obtained via the slope-ratio method. The relationships were examined between variation in nutritive value for broilers and the laboratory analysis of the bean samples.3. The data showed significant differences (P < 0.05) among the bean cultivar samples for feed conversion ratio, AMEn and dry matter retention (DMR) coefficients. Further analysis showed that the feeding quality of different field bean cultivar samples, measured as AMEn, was highly correlated to crude protein (CP) (P < 0.05) and colour (P < 0.001) of the samples. Thus, beans with higher CP and pale colour had superior feeding value for broilers.

The effect of feeding different sources and levels of selenium on growth performance and antioxidant status of broilers raised at two different temperatures.

1. This study examined the effects of different dietary sources and levels of selenium (Se) on growth performance, hepatic and breast meat Se content, glutathione peroxidase (GSH-Px) activity and total antioxidant status (TAS) in blood, when fed to broilers from 14 to 35 d of age and reared at two different temperatures (20°C and 35°C). 2. Five hundred and sixty male Ross 308 broilers were reared in a single floor pen and fed the same proprietary starter diet from 0 to 14 d age (229.9 g/kg CP and 12.67 MJ/kg ME, without Se supplementation). 3. The experiment started at 14 d age, and the birds randomly assigned to 112 raised-floor pens (0.36 m2 area, 5 birds/pen). Each of the seven experimental diets were offered to birds in 16 pens within four rooms. Two rooms were at 20°C and two rooms were maintained at 35°C. The experimental diets were fed from 14 to 35 d age and contained 214.9 g/kg CP and 13.11 MJ/kg ME. The experimental diets were as follows; control diet containing background Se only (0.189 mg/kg; C); low level sodium selenite (0.376 mg/kg; LSS): high level sodium selenite (0.558 mg/kg; HSS); low level commercial B Traxim® Se (0.244 mg/kg) (LBT); high level B Traxim® Se (0.448 mg/kg; HBT); low level selenised yeast (0.290 mg/kg; LSY); high level selenised yeast (0.487 mg/kg; HSY). 4. Birds consumed more when raised at 20°C compared to birds reared at 35°C (P ≤ 0.05). Birds fed lower Se level reared at 35°C had higher weight gain versus those fed higher Se level (P < 0.05). Birds fed SY had the lowest feed intake, weight gain and FCE (P < 0.05). The greatest GSH-Px activity was observed in birds fed SS diets (P < 0.001). There were interactions between diet x level for TAS, which were highest in birds fed LBT compared to birds fed HBT (P < 0.05). Breast Se content was higher in birds fed HSY compared to LSY (P < 0.001). The highest hepatic Se was seen in birds fed SY and lowest in C (P < 0.001). 5. Birds fed BT diets showed similar levels of Se to those birds fed inorganic Se, and similar levels of GSH-Px to birds fed SY. Further comparative work with broilers fed BT and other Se supplemented diets may elucidate the findings from this report.

Effect of age on the relationship between metabolizable energy and digestible energy for broiler chickens.

A total of 960 male Ross 308 chicks (day-old) were used to investigate the effect of age on the relationship between metabolizable energy (ME) and digestible energy (DE) for broiler chickens. Bird growth variables, nitrogen retention (NR), nitrogen digestibility (ND), as well as the relative weight of liver, pancreas, and the gastrointestinal tract were determined. Practical diets that compared 2 cereals (corn and wheat) and exogenous xylanase (0 or 16,000 BXU/kg) were evaluated at 5 ages (7, 14, 21, 28, and 35 D) in a 2 × 2 × 5 factorial arrangement of treatments with 8 replicates per treatment and started with 30 birds per replicate. A randomized block ANOVA analysis of repeated measures was performed, and a 2 × 2 × 5 factorial structure was used to investigate the 2 dietary treatment factors (cereal type and the presence of xylanase) within the 5 bird ages (7, 14, 21, 28, and 35 D), and their interactions. Apparent metabolizable energy (AME) increased linearly from 7 until 28 D of age, but (P < 0.05) decreased at 35 D of age. Digestible energy was high at 7 D of age, then dropped and remained similar (P > 0.05) from 14 to 35 D of age. The AME: DE ratio was lowest (P < 0.05) at 7 D of age but there were no (P > 0.05) differences thereafter. Cereal type and xylanase supplementation did not (P > 0.05) change the ME: DE ratio. The results indicate that determining ME before 14 D of age may give absolute values that are lower than would be obtained with older birds. ME values that are determined on older broiler chickens may overestimate the energy availability of practical feeds used in broiler starter feeds.

Effect of feeding different sources of selenium on growth performance and antioxidant status of broilers.

1. This study was conducted to determine the effect of different sources of selenium (Se) on breast and liver tissue deposition, apparent metabolisable energy (AME), growth performance and antioxidant status of broilers, measured as Se content in liver and breast tissues and glutathione peroxidase (GSH-Px) in blood, when used in 0-35 d broiler chicken diets. 2. A total of 200 male Ross 308 broilers were used in the feeding trial, which comprised two dietary phases, a starter from 0 to 21 d and finisher from 21 to 35 d of age. Four treatments with 10 replications each were used. A control diet (C) was formulated that was sufficient in protein and energy (230 and 215 g/kg of crude protein and 12.67 and 13.11 MJ/kg of metabolisable energy, respectively), for both phases, but contained background Se only from the feed ingredients. Diet 2 (IS) was supplemented with 10.35 g/t inorganic, elemental source of Se. Diet 3 (SY) was supplemented with 136.36 g/t selenised yeast, an organic source derived from Saccharomyces cerevisiae. Diet 4 (SS) was supplemented with 0.666 g/t sodium selenite, an inorganic source. 3. Birds fed the SY diet consumed less and weighed less than those fed IS or C (P < 0.05; 0-35 d of age), but there was no difference compared to birds fed SS diets. There were no differences in FCR or dietary AME between broilers fed different Se sources. All diets containing supplementary Se increased concentrations in the liver and breast muscle, and for GSH-Px levels in blood compared to birds fed the C diet (P < 0.001). Birds fed SY diets had greater Se levels in liver and breast tissues compared to birds fed any of the other diets (P < 0.001). 4. Diets supplemented with Se had variable effects on broiler growth performances and antioxidant status. Feeding Se from a yeast source has higher transfer into breast tissues. Feeding different sources and levels of Se to birds in a more challenging situation to induce oxidative stress may bring more conclusive results.

Nutrient content and digestibility of different batches of wheat distillers dried grains with solubles for laying hens.

1. Four batches of wheat distillers dried grains with solubles (DDGS) produced by a single production plant were used to investigate variation in digestible energy (DE) and nutrient digestibility for laying hens. 2. A total of 144 Hy-Line Brown laying hens were allocated to eight treatment groups in replicates of six. Experimental diets were prepared by replacing the basal feed with either 150 g/kg or 300 g/kg of each batch of DDGS. 3. Chemical analysis of the DDGS showed variation between the different batches. Largest coefficients of variation were observed for starch (0.546) and total soluble non-starch polysaccharides (NSP; 0.276). 4. Digestible energy and the nutrient digestibility of each diet was measured using the ileal collection technique. Data were statistically analysed as a blocked 2 × 4 factorial design analysis of variance (ANOVA). 5. Variability between the different diets were observed for digestible energy and the digestibility of certain nutrients (P < 0.05). 6. The observed differences in energy utilisation and nutrient digestibility in laying hens suggested that the feeding quality of diets containing different wheat DDGS batches produced by a single production plant may still have large variation.

Wheat sample affects growth performance and the apparent metabolisable energy value for broiler chickens.

1. The aim of this study was to examine chemical composition, quality characteristics, apparent metabolisable energy (AME) and nutrient utilisation of wheat samples currently available to the UK poultry industry and their effect on broiler growth performance. 2. Seventeen current UK wheat samples were used to formulate 17 diets, all of which included 670 g/kg of each wheat sample and 330 g/kg of a balancer feed. Eight hundred 1-day-old male Ross 308 broilers were allocated randomly to 160 raised floor pens. Each diet was replicated eight times, fed ad libitum from 0 to 21d age in a randomised complete block design. Excreta were quantitatively collected during the last 3 days for AME determination. 3. The content of protein, ash and gross energy (GE) ranged from 97 to 143 g/kg DM, 12.8 to 19.6 g/kg DM and 17.81 to 18.24 MJ/kg DM, respectively. The amount of starch and total non-starch polysaccharides (NSP) ranged from 671 to 728 and 80.1 to 98.2 g/kg DM, respectively. The quality characteristics of wheat samples were in the expected range. 4. There were differences (P < 0.05) in AME and N-corrected AME (AMEn) of wheat samples. The AME of the wheat had a maximum range of 1.13 MJ/kg DM between samples. Dry matter retention (DMR) and fat digestibility (FD) were significantly different (P < 0.05) between wheat samples. 5. The daily feed intake (FI) and weight gain (WG) of broilers fed two wheat samples were significantly (P < 0.05) lower as compared to other samples and their low FI and WG were not related to their chemical composition and quality characteristics. 6. The ash content of wheat samples was negatively associated with AMEn (r = - 0.489, P < 0.05). The coefficient of FD was positively related to AMEn (r = 0.552, P < 0.05). 7. Chemical composition and quality characteristics of the wheat did not relate (P > 0.05) to FI and WG of broilers. There was no relationship between growth performance of broilers and AMEn of the wheat samples.

Effect of wheat distillers dried grains with solubles and exogenous xylanase on laying hen performance and egg quality.

Despite the rapid increase in the use of wheat distillers dried grains with solubles (DDGS) within the poultry sector, little information is available on how the long-term feeding of this by-product will affect the performance of laying hens. This experiment examined the effect of wheat DDGS, with and without exogenous xylanase on dietary apparent metabolizable energy (AME), total tract dry matter retention (DMR), nitrogen retention (NR), fat digestibility (FD) coefficients, feed intake (FI), bodyweight gain (BWG), eggs laid, mean egg weight, egg mass output, and egg quality characteristics including albumin height (AH), Haugh units (HU), yolk color, eggshell strength, and thickness. A total of 320 Hy-Line brown laying hens were randomly allocated to 80 enriched layer colonies (groups of 4). A total of 2 control wheat-soybean meal-based diets were formulated to contain 11.60 MJ/kg. One of the diets contained 300 g/kg wheat DDGS, while the other was DDGS free, with a respective crude protein content of 171.1 g/kg and 166.5 g/kg. Both diets were divided by 2 and half of them were supplemented with 2,500 U/kg of xylanase, resulting in 4 diets in total. Data was analyzed as a 2 × 2 factorial arrangement of treatments with analysis of variance (ANOVA). Diets were fed ad libitum from 17 to 43 wk of age and data was collected from 23 to 43 wk. The inclusion of wheat DDGS reduced (P < 0.001) dry matter retention (DMR), FI, BWG, eggs laid, mean egg weight, and egg mass. However, xylanase supplementation improved AME and NR in diets containing wheat DDGS and FD in diets without DDGS (DDGS × xylanase, P < 0.05) and tended to improve (P < 0.10) BWG and egg mass output. For egg quality measurements, the inclusion of DDGS improved (P = 0.046) HU values, eggshell strength (P < 0.001), and increased (P < 0.001) yolk color intensity. This experiment showed xylanase can be used to improve the AME and NR of DDGS-based diets. However, the long-term feeding of 300 g/kg wheat DDGS negatively impacts the productive performance of hens.