Chemical and sensorial profile of Tempranillo wines elaborated with toasted vine-shoots of different varieties and micro-oxygenation.

The positive impact of use SEGs ("Shoot from vines - Enological - Granule") in winemaking for wines of the same variety has been extensively demonstrated, but their combination with different SEGs varieties and micro-oxygenation (MOX) remains unstudied. In this study, Tempranillo wines were in contact along 35 days with two doses of Tempranillo and Cabernet Sauvignon SEGs (12 and 24 g/L) and two fixed doses of MOX (LOTR, 6.24 mg/L·month, and HOTR, 11.91 mg/L·month). Chemical composition and sensory profiles were analyzed after SEGs-MOX treatments. Results indicated a greater impact of MOX on volatile composition when Cabernet Sauvignon SEGs were used, with similar results for CS12-HOTR and CS24-LOTR wines. Phenolic compounds showed a total concentration decrease in all treated wines, though trans-resveratrol increased in all cases, particularly with the highest MOX dose. In sensory evaluation, MOX accelerated the integration of characteristic SEGs aromas into the wine, reducing the required bottle time for round them.

Application of near-infrared spectroscopy for the estimation of volatile compounds in Tempranillo Blanco grape berries during ripening.

BACKGROUND: The knowledge of volatile compounds concentration in grape berries is very valuable information for the winemaker, since these compounds are strongly involved in the final wine quality, and in consumer acceptance. In addition, it would allow to set the harvest date according to aromatic maturity, to classify grape berries according to their quality and to make wines with different characteristics, among other implications. However, so far, there are no tools that allow the volatile composition to be measured directly on intact berries, either in the vineyard or in the winery. RESULTS: In this work, the use of near-infrared (NIR) spectroscopy to estimate the aromatic composition and total soluble solids (TSS) of Tempranillo Blanco grape berries during ripening was evaluated. For this purpose, the spectra in the NIR range (1100-2100 nm) of 240 intact berry samples were acquired in the laboratory. From these same samples, the concentration of volatile compounds was analyzed by thin film-solid-phase microextraction-gas chromatography-mass spectrometry (TF-SPME-GC-MS), and the TSS were quantified by refractometry. These two methods were used as reference methods for model building. Calibration, cross-validation and prediction models were built from spectral data using partial least squares (PLS). Determination coefficients of cross-validation (R2 CV ) above 0.5 were obtained for all volatile compounds, their families, and TSS. CONCLUSIONS: These findings support that NIR spectroscopy can be successfully use to estimate the aromatic composition as well as the TSS of intact Tempranillo Blanco berries in a non-destructive, fast, and contactless form, allowing simultaneous determination of technological and aromatic maturities. © 2023 The Authors. Journal of The Science of Food and Agriculture published by John Wiley & Sons Ltd on behalf of Society of Chemical Industry.

Influence of Oxygen Management on Color and Phenolics of Red Wines.

Winemaking involves contact at different stages with atmospheric oxygen, the consumption of which determines its final properties. The chemical analysis of red wines subjected to consecutive cycles of air saturation has been extensively researched; however, the capacity to consume different doses of oxygen before bottling is an aspect that has been little studied. In this work, the effect of saturation of different levels of oxygen on the final characteristics of different wines made from Tempranillo and Garnacha grape extracts was studied. For this purpose, the wines were subjected to controlled oxygen saturation levels to simulate their possible oxygenation before bottling. The only difference was the phenolic composition of grape extracts that were reconstituted under the same conditions to avoid the interferences inherent to the fermentation process and the additives added in the winery. The kinetics of oxygen consumption was then evaluated and its effect on the color, antioxidant capacity, and phenols of three different wines was analyzed. This work shows the relationship between the oxidation state of wine and changes in its chemical composition. In addition, it provides insight into the effect of oxygen consumption before bottling on the properties of wines subjected to high and single doses of oxygen.

Monitorization of Varietal Aroma Composition Dynamics during Ripening in Intact Vitis vinifera L. Tempranillo Blanco Berries by Hyperspectral Imaging.

The measurement of aromatic maturity during grape ripening provides very important information for determining the harvest date, particularly in white cultivars. However, there are currently no tools that allow this measurement to be carried out in a noninvasive and rapid way. For this reason, in the present work, we have studied the use of hyperspectral imaging (HSI)) to estimate the aromatic composition of Vitis vinifera L. Tempranillo Blanco berries during ripening. A total of 236 spectra in the VIS+short wave near-infrared (VIS+SW-NIR) range (400-1000 nm) of intact berries were acquired contactless under laboratory conditions. As gold standard values, a total of 20 volatile compounds were quantified by gas chromatography-mass spectrometry (GC-MS), and the concentration of total soluble solids (TSS) was measured by refractometry. Calibration, cross-validation, and prediction models were built using partial least squares (PLS). Values of RCV2 ≥ 0.70 were obtained for α-terpineol, p-cymene, ß-damascenone, ß-ionone, benzaldehyde, benzyl alcohol, hexanal, citral, linalool, 2-phenylethanol, octanoic acid, nonanoic acid, 2-hexenal, 2-hexen-1-ol, (Z)-3-hexen-1-ol, total C13 norisoprenoids, total C6 compounds, total positive compounds (i.e., the sum of all families except C6 compounds), total benzenoids, and total soluble solids (TSS). Therefore, it can be affirmed that HSI in the VIS + SW-NIR range could be a good tool to estimate the aromatic composition of Tempranillo Blanco grape berries in a contactless, fast, and nondestructive way.

Chemical exchange in the vine shoots-wine system when used as an innovative enological procedure.

BACKGROUND: Pruned vine shoots prepared as toasted fragments (SEGs) have recently been proposed as enological additives capable of producing differentiated quality wines. In this work, the composition of phenolic and volatile compounds of SEGs, before and after contact with wines, has been studied. RESULTS: SEGs from Tempranillo and Cabernet Sauvignon were used, which were kept in contact for 30 days with red wines made with the same varieties. Phenolic compounds were the ones with the highest sorption in SEGs, but a variety-dependent behavior was observed in anthocyanins and flavonols, with an increase in some malvidin derivatives only in Tempranillo wine and an increase in (-)-epicatechin in SEGs and Cabernet Sauvignon wine. trans-Resveratrol was transferred from SEGs to wine but also increased in SEGs regardless of the variety used. The volatile compounds that were most retained in SEGs were phenylethyl alcohol and ethyl lactate, but in lower proportions than the phenolic compounds and without important changes in wines. CONCLUSION: The high content of phenolic compounds in SEGs after their use as enological additives suggests that they could be considered as a source of anthocyanins and as raw materials for phenolic compounds with recognized antioxidant properties. © 2022 The Authors. Journal of The Science of Food and Agriculture published by John Wiley & Sons Ltd on behalf of Society of Chemical Industry.

Development of a New Strategy for Studying the Oxygen Consumption Potential of Wine through the Grape Extract Evaluation.

The development of a method to determine the aging potential of wine at the time of harvest, through the evaluation of its oxygen avidity, is a potential tool for the winemaking sector. To this end, it is necessary to formulate a potential wine with this grape prior to alcoholic fermentation. The main objective of this method was to optimize a formulation of the potential wine, based on the grape extracts (GEs), to subsequently evaluate its oxygen consumption kinetics, guaranteeing maximum differentiation between the different GEs. The optimization was carried out with a Taguchi orthogonal matrix design, which optimized the variables to be used in the GE reconstitution. The variables studied were pH, Fe2+, Cu2+, Mn2+, alcohol content and acetaldehyde. The evaluation of the characteristic parameters of the consumption kinetics of each of the GEs allowed us to know the different reconstitution conditions that most influence the differentiation of the oxygen consumption kinetics of very similar GEs. The reconstitution conditions chosen were pH 3.3; 1 mg/L Fe2+; 0.1 mg/L Cu2+; 1 mg/L Mn2+; 12% (v/v) alcoholic strength and 10 mg/L acetaldehyde, with pH, Fe2+ and Mn2+ being the significant conditions. The kinetics of reconstituted GE could be a tool for the classification and evaluation of grapes according to their aging potential or shelf life of the wine made.

Air saturation methodology proposal for the analysis of wine oxygen consumption kinetics.

The great heterogeneity currently present when characterizing wine consumption kinetics means that a saturation method, as well as different parameters that allow comparison between wines, need to be established. The aim of this work was to establish a robust method for a wine saturation protocol and compare different fitting models to approximate the oxygen consumption kinetics. To differentiate wines, parameters extracted from the oxygen consumption curves were studied and proposed. 72 young commercial wines (red, white and rosé) from different Spanish appellations of origin, varieties and vintages were used. The results revealed that 5 min was enough to saturate wines up to the maximum level for each one at 35 °C. The inverse curve fitting model showed the best results for all wines. Oxygen at half consumption time (Omid) and time required to consume from 90% to 10% of the oxygen initially available (ΔtO_90_10) were the parameters that differentiated wines the most.

Vine-Shoots as Enological Additives. A Study of Acute Toxicity and Cytotoxicity.

Toasted vine-shoots have been recently proposed as enological additives that can be used to improve the sensorial profile of wines. However, the possible toxicity of this new winery practice has not been studied so far. The aim of this study was to evaluate the toxicity of Tempranillo, Cencibel, and Cabernet Sauvignon toasted vine-shoots when used in winemaking. First, vine-shoots were characterized in terms of minerals and phenolic and furan compounds, and then their acute toxicity and cytotoxicity were studied using Microtox® and the metabolic reduction of 3-(4,5-dimethylthiazol-2-yl)-2,5-diphenyltetrazolium bromide (MTT) assays. High EC50 values were obtained when the Microtox® assay was applied to vine-shoot aqueous extracts, similar to the case of herbal infusions. When the MTT assay was used, a cell viability above 70% was observed in all the wines made with those vine-shoots, and an even greater viability was observed in the case of Cabernet Sauvignon. Therefore, it was concluded that those vine-shoots have no cytotoxic potential.

Volatile composition of oak wood from different customised oxygenation wine barrels: Effect on red wine.

The compounds that the wood releases to the wine and the oxygen transmission rate (OTR) of the barrel define the final wine. The new possibility of choosing the OTR of the barrel allows the winemaker to globally control the ageing process. The aim of this work was to study the volatile composition of woods classified according to their OTR, which are used to build barrels for wine ageing. The results showed that volatile composition differs depending on wood OTR and the temperature reached during toasting. On the toasted side of the stave in contact with the wine, low OTR wood had a statistically higher content in furan compounds (5-hydroxymethylfurfural, furfural and 5-methylfurfural), acetovanillone and phenolic aldehydes (vanillin and syringaldehyde), while 4-ethylguaiacol and trans-ß-methyl-γ-octalactone were significantly higher in staves with a high OTR. The same red wine aged first for three months in high and low oxygenation barrels presents different characteristics.

Study of the role of oxygen in the evolution of red wine colour under different ageing conditions in barrels and bottles.

Wine ageing in barrels is conditioned, among other factors, by the amount of oxygen received during this process, which thus impacts its final properties. The aim of this study was to evaluate the effect of oxygen on wine colour during ageing in barrels and bottles during different times. The use of barrels with different and known rates of oxygenation allows the effect of different oxygenation conditions throughout the process in barrels and its later evolution in bottles. A simulation process of ageing in bottles was used to study the impact of bottling in wines after differing ageing periods in barrels. The study of winés oxygen consumption capacity has been tied to colour modifications during ageing in barrels and bottles. Wines aged in barrels with a high oxygenation rate showed greater avidity to consume oxygen taking less time to consume that available, which is reflected in a greater increase in colour intensity.

Alternative Woods in Enology: Characterization of Tannin and Low Molecular Weight Phenol Compounds with Respect to Traditional Oak Woods. A Review.

Wood is one of the most highly valued materials in enology since the chemical composition and sensorial properties of wine change significantly when in contact with it. The need for wood in cooperage and the concern of enologists in their search for new materials to endow their wines with a special personality has generated interest in the use of other Quercus genus materials different from the traditional ones (Q. petraea, Q. robur and Q. alba) and even other wood genera. Thereby, species from same genera such as Q. pyrenaica Willd., Q. faginea Lam., Q. humboldtti Bonpl., Q. oocarpa Liebm., Q. stellata Wangenh, Q. frainetto Ten., Q. lyrata Walt., Q. bicolor Willd. and other genera such as Castanea sativa Mill. (chestnut), Robinia pseudoacacia L. (false acacia), Prunus avium L. and P. cereaus L. (cherry), Fraxinus excelsior L. (European ash) and F. americana L. (American ash) have been studied with the aim of discovering whether they could be a new reservoir of wood for cooperage. This review aims to summarize the characterization of tannin and low molecular weight phenol compositions of these alternative woods for enology in their different cooperage stages and compare them to traditional oak woods, as both are essential to proposing their use in cooperage for aging wine.

Effect of size, seasoning and toasting level of Quercus pyrenaica Willd. wood on wine phenolic composition during maturation process with micro-oxygenation.

Seasoning and toasting treatments carried out in cooperage influence the chemical composition of the oak, and these treatments affect different oak species in different ways. For this reason, numerous studies have focused on the evaluation of both the oak wood materials and the resulting aged wines in order to optimize the different cooperage processes. Seasoning involves immobilizing the wood for long periods of time, leading to an increase in the price of the final product. When using alternative products instead of barrels, in addition to the seasoning and toasting of the wood, the size of the wood pieces is a determining factor in the characteristics of the final wine. Therefore, the objective of this work was to evaluate the polyphenolic composition of the same red wine aged with different alternative products and a small amount of oxygen for 120 days. Specifically, the effect of 2 types of seasoning and 3 types of toasting of chips and staves made from the wood of Q. pyrenaica Willd. was studied. The results showed that the size of the alternative product was the factor that determines the phenolic composition of the wines over the entire ageing process, independent of the seasoning or toasting method carried out on the wood.

Winemaking with vine-shoots. Modulating the composition of wines by using their own resources.

Vine-shoots from two important Vitis vinifera, Airén and Cencibel, have been prepared in two different formats (chip and granule) and added (12 g/L) in their own wines in different winemaking steps. Results have shown significant differences depending in all conditions tested, and wine chemical composition was modulated while in contact with vine-shoots. Compounds such as trans-resveratrol, increased its concentration up to 4 mg/L in Airén white wines. In Cencibel red wines, vanillin was found in a concentration four times above its odor threshold and independently of the vine-shoot variety, format and moment of addition, compounds such as (-)-epicatechin and (+)-catechin increased the concentration with respect to the control wine. When vine-shoots were added after fermentation, ß-ionol appeared for first time in all wines. In case of guaiacol, the higher increment was observed for Airén wines. Therefore, it is possible to elaborate distinctive wines using their own resources.

Toasted vine-shoot chips as enological additive.

Different ways of vine-shoots revalorization have been proposed, but not in wine yet, as for example in the same way as oak chips are being used. In this work, vine-shoot samples were submitted to a thermogravimetric analysis to establish the temperature range for its lignin structure decomposition, resulting between 160 and 180 °C. Then, vine-shoot chips from Airén and Cencibel cultivars, with a particle size around 2.5-3.5 cm, were submitted to six toasting conditions: 160 °C and 180 °C for 45, 60 and 75 min. Their volatile composition was very similar to oak chips, being vanillin the most important compound. Moreover, such vine-shoots have an interesting content of prodelphinidins that together with the stilbenes may contribute to wine antioxidant activity. The toasting conditions at 180 °C/45 min were the most suitable one for releasing the mentioned valuable compounds in order to propose vine-shoots as new enological additive similar to oak chips.

Vine-Shoot Tannins: Effect of Post-pruning Storage and Toasting Treatment.

For the first time vine-shoot tannin composition was carried out by means of HPLC-DAD-ESI-MS/MS. Two vine-shoot cultivars (Airén and Cencibel) with different post-pruning storage times were submitted to a toasting process and assayed. There were no traces of gallotannins nor ellagitannins, but a high proanthocyanidin content and a mean degree of polymerization (mDP) close to 3 were characterized. The higher concentration of proanthocyanidins corresponded to Airén after 6 months post-pruning storage and at 3 months for Cencibel. Procyanidins were the most abundant fraction (70-95%), which decreased with storage, and especially significant was the contribution of B1, B2, and B4 dimers. Prodelphinidins were also found (8-24%), increasing their % with storage time. Toasting produced a considerable reduction of proanthocyanidin content and a loss of a monomer mDP unit, suggesting that if used as oenological tannins, then they may be more bitter and less astringent when compared with the nontoasted vine-shoot samples.

The Microvine, a plant model to study the effect of vine-shoot extract on the accumulation of glycosylated aroma precursors in grapes.

BACKGROUND: The Microvine plant model displays unique reproductive organ behavior and is suitable for grapevine fruit physiological studies, allowing one to undertake studies up to five times more rapidly than the current situation with grapevines. Recently, vine-shoot aqueous extracts, which have an interesting phenolic and aroma composition, have been proposed as viticultural biostimulants, since their post-veraison foliar application to grapevines impacts the wine aroma profile. Using Microvines, the aim of this study was to determine the effect of vine-shoot extract foliar application on 21 stages of grape development. The application was carried out from BBCH 53 (inflorescences clearly visible) to BBCH 85 (softening of berries) to reveal stage-specific responses of the accumulation of glycosylated aroma precursors at BBCH 89 (berries ripe for harvest), the phenological stage selected to study the treatment effect. RESULTS: Microvine use made it possible to carry out 15 sampling time points during 86 days of the experiment, which were established by the cumulative degree days (CDD) parameter. The results confirmed that vine-shoot extract treatment had a positive impact on total glycosylated compounds, especially aglycones such as alcohols, terpenes and C13 -norisoprenoids, with a higher effect when the treatment was applied during ripening. CONCLUSION: Extrapolation of the results to grapevines suggests that vine-shoot extract treatment could modulate the synthesis of grape glycosylated aroma precursors. © 2017 Society of Chemical Industry.

Vine-shoot waste aqueous extracts for re-use in agriculture obtained by different extraction techniques: phenolic, volatile, and mineral compounds.

Vine-shoots are an important waste in all viticulture areas that should be re-used with innovative applications. The aim of this work was to produce Airén waste vine-shoot aqueous extracts by four solid-liquid extraction techniques such as conventional solid-liquid extraction (CSLE), solid-liquid dynamic extraction (SLDE-Naviglio), microwave extraction (ME), and pressurized solvent extraction (PSE). Their chemical composition was studied in terms of phenolic, volatile, and mineral compounds. The highest concentrated extracts corresponded to CSLE and SLDE-Naviglio, independent of the conditions tested. The CSLE extracts had the highest flavanols, phenolic acids, and stilbenes contents. The volatile composition, quantified for first time in this work, shows that furanic compounds were the most abundant. All extracts showed an interesting mineral content, which may be assimilated by plants. These results show the agricultural potential of Airén vine-shoot waste aqueous extracts to be used as grape biostimulants and/or foliar fertilizer.