Effect of Aloe vera gel coating on organoleptic and nutritional quality of minimally processed carrot.

Demand for fresh vegetables has led to development studies in postharvest area mainly focused on minimizing and look for alternatives to chemical additives for food preservation. The use of natural derived edible coatings emerges as a promising alternative for maintaining quality of vegetables. The objective of this study was to evaluate the effect of Aloe vera gel in minimally processed carrot during postharvest storage. Samples with different degrees of processing were immersed in Aloe vera gel, packaged polyolefin bags, and stored in refrigerated chambers at 5 °C for 12 days. Different organoleptic and quality parameters were evaluated. In general, the samples treated with Aloe vera gel showed less quality loss and a lower increment in the bleaching index. Moreover, sensory analysis allowed to establish that carrots processed in slices and shredded and coated with the gel had a more flavorful taste and higher moisture content. Aloe vera treatment did not influence the microbiological growth of bacteria and fungi during storage. Regarding nutritional quality, the treated samples showed a higher accumulation or lower degradation of phenols, flavonoids, and carotenoids, probably generating in this way, a higher antioxidant capacity in these samples. Finally, Aloe vera gel treatment did not influence sugar dynamics in any of the samples. It can be concluded that the treatment with Aloe vera gel allows maintaining a better organoleptic and nutritional quality of carrots with different degrees of processing during refrigerated storage.

Postharvest shelf life extension of minimally processed kale at ambient and refrigerated storage by use of modified atmosphere.

Kale is becoming an important vegetable worldwide, mainly due to its nutritional properties. Kale leaves can be marketed whole, although minimal processing is also in demand. In this article, it was analyzed the effect of packaging in a modified atmosphere of fresh-cut kale leaves stored at 20 °C and 4 °C. Kale leaves were cut into 4 × 4 cm strips and stored in low-density polyethylene bags. Samples processed in the same way but stored in PVC were used as controls. Leaves kept in a modified atmosphere showed a delay in color change with Hue values from about 130 to 120 under PMA against 130 to 100 in control group (CTR) leaves. Chlorophyll degradation was also delayed in both storage temperatures. Samples stored under PMA showed about two times the levels of total chlorophylls with respect to CTR samples at the end of the storage. No changes in total sugar content were detected during storage and no differences were detected between control and modified atmospheres stored samples. Samples maintained in a modified atmosphere showed a lower decrement in soluble proteins and a lower rate of RUBISCO degradation at both temperatures. The relation of RUBISCO content PMA/CTR ranged from 1 to about 3 toward the end of storage No changes in phenols content were found when comparing control and treated samples. However, flavonoid and the antioxidant contents increased in samples stored in modified atmospheres with respect to their controls. We demonstrated that storage in modified atmospheres could be an adequate and simple methodology to extend postharvest life of this minimally processed product at both ambient and refrigerated storage.