Isolation of Yeast Strains with Higher Proline Uptake and Their Applications to Beer Fermentation.

Although proline is the most or second most abundant amino acid in wort and grape must, it is not fully consumed by the yeast Saccharomyces cerevisiae during alcoholic fermentation, unlike other amino acids. Our previous studies showed that arginine, the third most abundant amino acid in wort, inhibits the utilization of proline in most strains of S. cerevisiae. Furthermore, we found that some non-Saccharomyces yeasts utilized proline in a specific artificial medium with arginine and proline as the only nitrogen source, but these yeasts were not suitable for beer fermentation due to their low alcohol productivity. For yeasts to be useful for brewing, they need to utilize proline and produce alcohol during fermentation. In this study, 11 S. cerevisiae strains and 10 non-Saccharomyces yeast strains in the Phaff Yeast Culture Collection were identified that utilize proline effectively. Notably, two of these S. cerevisiae strains, UCDFST 40-144 and 68-44, utilize proline and produce sufficient alcohol in the beer fermentation model used. These strains have the potential to create distinctive beer products that are specifically alcoholic but with a reduction in proline in the finished beer.

Production of high protein yeast using enzymatically liquefied almond hulls.

Animal feed ingredients, especially those abundant in high quality protein, are the most expensive component of livestock production. Sustainable alternative feedstocks may be sourced from abundant, low value agricultural byproducts. California almond production generates nearly 3 Mtons of biomass per year with about 50% in the form of hulls. Almond hulls are a low-value byproduct currently used primarily for animal feed for dairy cattle. However, the protein and essential amino acid content are low, at ~30% d.b.. The purpose of this study was to improve the protein content and quality using yeast. To achieve this, the almond hulls were liquefied to liberate soluble and structural sugars. A multi-phase screening approach was used to identify yeasts that can consume a large proportion of the sugars in almond hulls while accumulating high concentrations of amino acids essential for livestock feed. Compositional analysis showed that almond hulls are rich in polygalacturonic acid (pectin) and soluble sucrose. A pectinase-assisted process was optimized to liquefy and release soluble sugars from almond hulls. The resulting almond hull slurry containing solubilized sugars was subsequently used to grow high-protein yeasts that could consume nutrients in almond hulls while accumulating high concentrations of high-quality protein rich in essential amino acids needed for livestock feed, yielding a process that would produce 72 mg protein/g almond hull. Further work is needed to achieve conversion of galacturonic acid to yeast cell biomass.

Large-scale screening of yeast strains that can utilize proline.

Proline contributes to the taste and flavor of foods. The yeast Saccharomyces cerevisiae poorly assimilates proline during fermentation processes, resulting in the accumulation of proline in fermentative products. We performed here a screening of in total 1138 yeasts to obtain strains that better utilize proline. Our results suggest that proline utilization occurs in the genera of Zygoascus, Galactomyces, and Magnusiomyces.

The Cdc25/Ras/cAMP-dependent protein kinase A signaling pathway regulates proline utilization in wine yeast Saccharomyces cerevisiae under a wine fermentation model.

Proline is a predominant amino acid in grape must, but it is poorly utilized by the yeast Saccharomyces cerevisiae in wine-making processes. This sometimes leads to a nitrogen deficiency during fermentation and proline accumulation in wine. In this study, we clarified that a glucose response is involved in an inhibitory mechanism of proline utilization in yeast. Our genetic screen showed that strains with a loss-of-function mutation on the CDC25 gene can utilize proline even under fermentation conditions. Cdc25 is a regulator of the glucose response consisting of the Ras/cAMP-dependent protein kinase A (PKA) pathway. Moreover, we found that activation of the Ras/PKA pathway is necessary for the inhibitory mechanism of proline utilization. The present data revealed that crosstalk exists between the carbon and proline metabolisms. Our study could hold promise for the development of wine yeast strains that can efficiently assimilate proline during the fermentation processes.

Ionic Liquid Tolerance of Yeasts in Family Dipodascaceae and Genus Wickerhamomyces.

In previous studies of ionic liquid (IL) tolerance of numerous species of ascomycetous yeasts, two strains of Wickerhamomyces ciferrii and Galactomyces candidus had unusually high tolerance in media containing up to 5% (w/v) of the 1-ethyl-3-methylimidazolium acetate ([C2C1Im][OAc]). The study aimed at investigating whether additional strains of these species, and additional species in the Dipodascaceae family, also possess IL tolerance, and to compare sensitivity to the acetate and chloride versions of the ionic liquid. Fifty five yeast strains in the family Dipodascaceae, which encompasses genera Galactomyces, Geotrichum, and Dipodascus, and seven yeast strains of species Wickerhamomyces ciferrii were tested for ability to grow in laboratory medium containing no IL, 242 mM [C2C1Im][OAc], or 242 mM [C2C1Im]Cl, and in IL-pretreated switchgrass hydrolysate. Many yeasts exhibited tolerance of one or both ILs, with higher tolerance of the chloride anion than of the acetate anion. Different strains of the same species exhibited varying degrees of IL tolerance. Galactomyces candidus, UCDFSTs 52-260, and 50-64, had exceptionally robust growth in [C2C1Im][OAc], and also grew well in the switchgrass hydrolysate. Identification of IL tolerant and IL resistant yeast strains will facilitate studies of the mechanism of IL tolerance, which could include superior efflux, metabolism or exclusion.

Identification of oleaginous yeasts that metabolize aromatic compounds.

The valorization of lignin is critical for the economic viability of the bioeconomy. Microbial metabolism is advantageous for handling the myriad of aromatic compounds resulting from lignin chemical or enzymatic depolymerization. Coupling aromatic metabolism to fatty acid biosynthesis makes possible the production of biofuels, oleochemicals, and other fine/bulk chemicals derived from lignin. Our previous work identified Cutaneotrichosporon oleaginosus as a yeast that could accumulate nearly 70% of its dry cell weight as lipids using aromatics as a sole carbon source. Expanding on this, other oleaginous yeast species were investigated for the metabolism of lignin-relevant monoaromatics. Thirty-six oleaginous yeast species from the Phaff yeast collection were screened for growth on several aromatic compounds representing S-, G-, and H- type lignin. The analysis reported in this study suggests that aromatic metabolism is largely segregated to the Cutaenotrichosporon, Trichosporon, and Rhodotorula clades. Each species tested within each clade has different properties with respect to the aromatics metabolized and the concentrations of aromatics tolerated. The combined analysis suggests that Cutaneotrichosporon yeast are the best suited to broad spectrum aromatic metabolism and support its development as a model system for aromatic metabolism in yeast.

Laboratory Screening Protocol to Identify Novel Oleaginous Yeasts.

Oleaginous microbes, which contain over 20% intracellular lipid, predominantly triacylglycerols (TG), by dry weight, have been discovered to have high oil content by many different protocols, ranging from simple staining to more complex chromatographic methods. In our laboratory, a methodical process was implemented to identify high oil yeasts, designed to minimize labor while optimizing success in identifying high oil strains among thousands of candidates. First, criteria were developed to select candidate yeast strains for analysis. These included observation of buoyancy of the yeast cell mass in 20% glycerol, and phylogenetic placement near known oleaginous species. A low-labor, semiquantitative Nile red staining protocol was implemented to screen numerous yeast cultures for high oil content in 96-well plates. Then, promising candidates were selected for more quantitative analysis. A more labor-intensive and quantitative gravimetric assay was implemented that gave consistent values for intracellular oil content for a broad range of yeast species. Finally, an LC-MS protocol was utilized to quantify and identify yeast triacylglycerols. This progressive approach was successful in identifying 30 new oleaginous yeast species, out of over 1000 species represented in the Phaff Yeast Culture Collection.

Extracellular fungal polyol lipids: A new class of potential high value lipids.

Extracellular fungal glycolipid biosurfactants have attracted attention because productivities can be high, cheap substrates can be used, the molecules are secreted into the medium and the downstream processing is relatively simple. Three classes of extracellular fungal glycolipid biosurfactants have provided most of the scientific advances in this area, namely sophorolipids, mannosylerythritol lipids and cellobioselipids. Polyol lipids, a fourth class of extracellular fungal glycolipid biosurfactants, comprise two groups of molecules: liamocins produced by the yeast-like fungus Aureobasidium pullulans, and polyol esters of fatty acids, produced by some Rhodotorula yeast species. Both are amphiphilic, surface active molecules with potential for commercial development as surfactants for industrial and household applications. The current knowledge of polyol lipids highlights an emerging group of extracellular fungal glycolipid biosurfactants and provides a perspective of what next steps are needed to harness the benefits and applications of this novel group of molecules.

1-Ethyl-3-methylimidazolium tolerance and intracellular lipid accumulation of 38 oleaginous yeast species.

Pretreatment with ionic liquids (IL) such as 1-ethyl-3-methylimidazolium chloride or acetate is an effective method for aiding deconstruction of lignocellulosic biomass; however, the residual IL remaining in hydrolysates can be inhibitory to growth of ethanologenic or oleaginous yeasts that have been examined in the literature. The aim of this study was to identify oleaginous yeasts that are tolerant of the IL [C2C1Im][OAc] and [C2C1Im]Cl using 45 strains belonging to 38 taxonomically diverse species within phyla Ascomycota and Basidiomycota. Yeasts were cultivated in laboratory medium supplemented with 0, 2, or 4% IL in 96-well plates. The eight most tolerant strains were then cultivated in 10-mL media with no IL, 242mM [C2C1Im][OAc], or 242mM [C2C1Im]Cl. The effects of [C2C1Im]+ exposure on cell mass production and lipid accumulation varied at the species and strain level. The acetate salt decreased cell biomass and lipid production more severely than did the chloride ion for six strains. Lipid output was not markedly different (2.1 vs. 2.3 g/L) in Yarrowia lipolytica UCDFST 51-30, but decreased from 5 to 65% in other yeasts. An equimolar concentration of the chloride salt resulted in much milder effects, from 25% decrease to 66% increase in lipid output. The highest lipid outputs in this media were 8.3 and 7.9 g/L produced by Vanrija humicola UCDFST 10-1004 and UCDFST 12-717, respectively. These results demonstrated substantial lipid production in the presence of [C2C1Im]Cl at concentrations found in lignocellulosic hydrolysates, and thus, these two strains are ideal candidates for further investigation.

Simultaneous production of intracellular triacylglycerols and extracellular polyol esters of fatty acids by Rhodotorula babjevae and Rhodotorula aff. paludigena.

Microbial oils have been analyzed as alternatives to petroleum. However, just a handful of microbes have been successfully adapted to produce chemicals that can compete with their petroleum counterparts. One of the reasons behind the low success rate is the overall economic inefficiency of valorizing a single product. This study presents a lab-scale analysis of two yeast species that simultaneously produce multiple high-value bioproducts: intracellular triacylglycerols (TG) and extracellular polyol esters of fatty acids (PEFA), two lipid classes with immediate applications in the biofuels and surfactant industries. At harvest, the yeast strain Rhodotorula aff. paludigena UCDFST 81-84 secreted 20.9 ± 0.2 g L-1 PEFA and produced 8.8 ± 1.0 g L-1 TG, while the yeast strain Rhodotorula babjevae UCDFST 04-877 secreted 11.2 ± 1.6 g L-1 PEFA and 18.5 ± 1.7 g L-1 TG. The overall glucose conversion was 0.24 and 0.22 g(total lipid) g (glucose)-1 , respectively. The results present a stable and scalable microbial growth platform yielding multiple co-products.

Discovery of synthesis and secretion of polyol esters of fatty acids by four basidiomycetous yeast species in the order Sporidiobolales.

Polyol esters of fatty acids (PEFA) are amphiphilic glycolipids produced by yeast that could play a role as natural, environmentally friendly biosurfactants. We recently reported discovery of a new PEFA-secreting yeast species, Rhodotorula babjevae, a basidiomycetous yeast to display this behavior, in addition to a few other Rhodotorula yeasts reported on the 1960s. Additional yeast species within the taxonomic order Sporidiobolales were screened for secreted glycolipid production. PEFA production equal or above 1 g L-1 were detected in 19 out of 65 strains of yeast screened, belonging to 6 out of 30 yeast species tested. Four of these species were not previously known to secrete glycolipids. These results significantly increase the number of yeast species known to secrete PEFA, holding promise for expanding knowledge of PEFA synthesis and secretion mechanisms, as well as setting the groundwork towards commercialization.

Multiplatform Mass Spectrometry-Based Approach Identifies Extracellular Glycolipids of the Yeast Rhodotorula babjevae UCDFST 04-877.

A multiplatform mass spectrometry-based approach was used for elucidating extracellular lipids with biosurfactant properties produced by the oleaginous yeast Rhodotorula babjevae UCDFST 04-877. This strain secreted 8.6 ± 0.1 g/L extracellular lipids when grown in a benchtop bioreactor fed with 100 g/L glucose in medium without addition of hydrophobic substrate, such as oleic acid. Untargeted reversed-phase liquid chromatography-quadrupole/time-of-flight mass spectrometry (QTOFMS) detected native glycolipid molecules with masses of 574-716 Da. After hydrolysis into the fatty acid and sugar components and hydrophilic interaction chromatography-QTOFMS analysis, the extracellular lipids were found to consist of hydroxy fatty acids and sugar alcohols. Derivatization and chiral separation gas chromatography-mass spectrometry (GC-MS) identified these components as d-arabitol, d-mannitol, (R)-3-hydroxymyristate, (R)-3-hydroxypalmitate, and (R)-3-hydroxystearate. In order to assemble these substructures back into intact glycolipids that were detected in the initial screen, potential structures were in-silico acetylated to match the observed molar masses and subsequently characterized by matching predicted and observed MS/MS fragmentation using the Mass Frontier software program. Eleven species of acetylated sugar alcohol esters of hydroxy fatty acids were characterized for this yeast strain.

Eighteen new oleaginous yeast species.

Of 1600 known species of yeasts, about 70 are known to be oleaginous, defined as being able to accumulate over 20 % intracellular lipids. These yeasts have value for fundamental and applied research. A survey of yeasts from the Phaff Yeast Culture Collection, University of California Davis was performed to identify additional oleaginous species within the Basidiomycota phylum. Fifty-nine strains belonging to 34 species were grown in lipid inducing media, and total cell mass, lipid yield and triacylglycerol profiles were determined. Thirty-two species accumulated at least 20 % lipid and 25 species accumulated over 40 % lipid by dry weight. Eighteen of these species were not previously reported to be oleaginous. Triacylglycerol profiles were suitable for biodiesel production. These results greatly expand the number of known oleaginous yeast species, and reveal the wealth of natural diversity of triacylglycerol profiles within wild-type oleaginous Basidiomycetes.

The United States Culture Collection Network (USCCN): Enhancing Microbial Genomics Research through Living Microbe Culture Collections.

The mission of the United States Culture Collection Network (USCCN; http://usccn.org) is "to facilitate the safe and responsible utilization of microbial resources for research, education, industry, medicine, and agriculture for the betterment of human kind." Microbial culture collections are a key component of life science research, biotechnology, and emerging global biobased economies. Representatives and users of several microbial culture collections from the United States and Europe gathered at the University of California, Davis, to discuss how collections of microorganisms can better serve users and stakeholders and to showcase existing resources available in public culture collections.

Yeast tolerance to the ionic liquid 1-ethyl-3-methylimidazolium acetate.

Lignocellulosic plant biomass is the target feedstock for production of second-generation biofuels. Ionic liquid (IL) pretreatment can enhance deconstruction of lignocellulosic biomass into sugars that can be fermented to ethanol. Although biomass is typically washed following IL pretreatment, small quantities of residual IL can inhibit fermentative microorganisms downstream, such as the widely used ethanologenic yeast, Saccharomyces cerevisiae. The aim of this study was to identify yeasts tolerant to the IL 1-ethyl-3-methylimidazolium acetate, one of the top performing ILs known for biomass pretreatment. One hundred and sixty eight strains spanning the Ascomycota and Basidiomycota phyla were selected for screening, with emphasis on yeasts within or closely related to the Saccharomyces genus and those tolerant to saline environments. Based on growth in media containing 1-ethyl-3-methylimidazolium acetate, tolerance to IL levels ranging 1-5% was observed for 80 strains. The effect of 1-ethyl-3-methylimidazolium acetate concentration on maximum cell density and growth rate was quantified to rank tolerance. The most tolerant yeasts included strains from the genera Clavispora, Debaryomyces, Galactomyces, Hyphopichia, Kazachstania, Meyerozyma, Naumovozyma, Wickerhamomyces, Yarrowia, and Zygoascus. These yeasts included species known to degrade plant cell wall polysaccharides and those capable of ethanol fermentation. These yeasts warrant further investigation for use in saccharification and fermentation of IL-pretreated lignocellulosic biomass to ethanol or other products.

Oleaginous yeasts for biodiesel: current and future trends in biology and production.

Production of biodiesel from edible plant oils is quickly expanding worldwide to fill a need for renewable, environmentally-friendly liquid transportation fuels. Due to concerns over use of edible commodities for fuels, production of biodiesel from non-edible oils including microbial oils is being developed. Microalgae biodiesel is approaching commercial viability, but has some inherent limitations such as requirements for sunlight. While yeast oils have been studied for decades, recent years have seen significant developments including discovery of new oleaginous yeast species and strains, greater understanding of the metabolic pathways that determine oleaginicity, optimization of cultivation processes for conversion of various types of waste plant biomass to oil using oleaginous yeasts, and development of strains with enhanced oil production. This review examines aspects of oleaginous yeasts not covered in depth in other recent reviews. Topics include the history of oleaginous yeast research, especially advances in the early 20th century; the phylogenetic diversity of oleaginous species, beyond the few species commonly studied; and physiological characteristics that should be considered when choosing yeast species and strains to be utilized for conversion of a given type of plant biomass to oleochemicals. Standardized terms are proposed for units that describe yeast cell mass and lipid production.

Identification of oleaginous yeast strains able to accumulate high intracellular lipids when cultivated in alkaline pretreated corn stover.

Microbial oil is a potential alternative to food/plant-derived biodiesel fuel. Our previous screening studies identified a wide range of oleaginous yeast species, using a defined laboratory medium known to stimulate lipid accumulation. In this study, the ability of these yeasts to grow and accumulate lipids was further investigated in synthetic hydrolysate (SynH) and authentic ammonia fiber expansion (AFEX™)-pretreated corn stover hydrolysate (ACSH). Most yeast strains tested were able to accumulate lipids in SynH, but only a few were able to grow and accumulate lipids in ACSH medium. Cryptococcus humicola UCDFST 10-1004 was able to accumulate as high as 15.5 g/L lipids, out of a total of 36 g/L cellular biomass when grown in ACSH, with a cellular lipid content of 40 % of cell dry weight. This lipid production is among the highest reported values for oleaginous yeasts grown in authentic hydrolysate. Preculturing in SynH media with xylose as sole carbon source enabled yeasts to assimilate both glucose and xylose more efficiently in the subsequent hydrolysate medium. This study demonstrates that ACSH is a suitable medium for certain oleaginous yeasts to convert lignocellullosic sugars to triacylglycerols for production of biodiesel and other valuable oleochemicals.

Carbon source utilization and inhibitor tolerance of 45 oleaginous yeast species.

Conversion of lignocellulosic hydrolysates to lipids using oleaginous (high lipid) yeasts requires alignment of the hydrolysate composition with the characteristics of the yeast strain, including ability to utilize certain nutrients, ability to grow independently of costly nutrients such as vitamins, and ability to tolerate inhibitors. Some combination of these characteristics may be present in wild strains. In this study, 48 oleaginous yeast strains belonging to 45 species were tested for ability to utilize carbon sources associated with lignocellulosic hydrolysates, tolerate inhibitors, and grow in medium without supplemented vitamins. Some well-studied oleaginous yeast species, as well as some that have not been frequently utilized in research or industrial production, emerged as promising candidates for industrial use due to ability to utilize many carbon sources, including Cryptococcus aureus, Cryptococcus laurentii, Hannaella aff. zeae, Tremella encephala, and Trichosporon coremiiforme. Other species excelled in inhibitor tolerance, including Candida aff. tropicalis, Cyberlindnera jadinii, Metschnikowia pulcherrima, Schwanniomyces occidentalis and Wickerhamomyces ciferrii. No yeast tested could utilize all carbon sources and tolerate all inhibitors tested. These results indicate that yeast strains should be selected based on characteristics compatible with the composition of the targeted hydrolysate. Other factors to consider include the production of valuable co-products such as carotenoids, availability of genetic tools, biosafety level, and flocculation of the yeast strain. The data generated in this study will aid in aligning yeasts with compatible hydrolysates for conversion of carbohydrates to lipids to be used for biofuels and other oleochemicals.

Accelerated degradation of exogenous indole by Burkholderia unamae strain CK43B exposed to pyrogallol-type polyphenols.

In modified Winogradsky's (MW) medium supplemented with excessive indole (1), Burkholderia unamae strain CK43B isolated from polyphenol-rich Shorea rhizosphere showed almost no cell growth, but it showed drastic cell growth given further supplementation of gallic acid, a simple plant polyphenol. This active cell growth of B. unamae CK43B was due to the stimulating effect of gallic acid on 1-degradation of bacterial cells, which acquired a nitrogen source in 1. Under aerobic culture conditions with appropriate concentrations (0.5-2.0 mM) of gallic acid, B. unamae CK43B started to decompose exogenous 1 in a dose-dependent manner, and finally accumulated catechol (5) via anthranilic acid (4). Pyrogallol also showed a cometabolic effect on decarboxylation-coupled oxidative deamination of B. unamae CK43B, producing 5 from 4, as gallic acid did. These results suggest that pyrogallol-type plant polyphenols act as stimulators on B. unamae CK43B, causing it to degrade an N-heterocyclic aromatic compound (NHAC) including nitrogen-containing humic substances.

Distinct metabolites for photoreactive L-phenylalanine derivatives in Klebsiella sp. CK6 isolated from rhizosphere of a wild dipterocarp sapling.

Photoaffinity labeling is a reliable analytical method for biological functional analysis. Three major photophores--aryl azide, benzophenone and trifluoromethyldiazirine--are utilized in analysis. Photophore-bearing L-phenylalanine derivatives, which are used for biological functional analysis, were inoculated into a Klebsiella sp. isolated from the rhizosphere of a wild dipterocarp sapling in Central Kalimantan, Indonesia, under nitrogen-limiting conditions. The proportions of metabolites were quite distinct for each photophore. These results indicated that photophores affected substrate recognition in rhizobacterial metabolic pathways, and differential photoaffinity labeling could be achieved using different photophore-containing L-phenylalanine derivatives.