Improved microbial and sensory quality of chicken meat by treatment with lactic acid, organic acid salts and modified atmosphere packaging.

Microbial contamination and growth play important roles in spoilage and quality loss of raw poultry products. We evaluated the suitability of three commercially available organic acid based antimicrobial compounds, Purac FCC80 (l-lactic acid), Verdad N6 (buffered vinegar fermentate) and Provian K (blend of potassium acetate and diacetate) to prevent growth of the innate microbiota, reduce spoilage and enhance the sensory quality of raw chicken under vacuum, high CO2 (60/40% CO2/N2), and high O2 (75/25% O2/CO2) modified atmosphere (MA) storage conditions. Solutions were applied warm (50 °C) or cold (4 °C) to reflect treatments prior to (Prechill) or after (Postchill) cooling of chicken carcasses, respectively. Single postchill treatments of raw chicken wings with 5% Verdad N6 or Provian K solutions and MA storage enabled complete growth inhibition during the first seven days of storage before growth resumed. Enhanced bacterial control was obtained by combining Prechill lactic acid and Postchill Verdad N6 or Provian K treatments which indicated initial reductions up to 1.1 log and where total bacterial increase after 20 days storage was limited to 1.8-2.1 log. Antibacterial effects were dependent on the concentration of the inhibiting salts used, pH and the storage conditions. Bacterial community analyses showed increased relative levels of Gram-positive bacteria and with reductions of potential spoilage organisms in samples treated with the organic acid salts Verdad N6 and Provian K. Sensory analyses of raw, treated wings showed prominent lower scores in several spoilage associated odour attributes when compared with untreated chicken wings after 13 days storage. For heat-treated chicken, only minor differences for 22 tested attributes were detected between seven antimicrobial treatments and untreated control chicken. Immersion in commercially available organic acid/salt solutions combined with MA storage can reduce bacterial levels, improve microbial and sensory quality, and potentially improve shelf life and reduce food waste of chicken products.

Biodegradable Active Packaging as an Alternative to Conventional Packaging: A Case Study with Chicken Fillets.

Innovative active packaging has the potential to maintain the food quality and preserve the food safety for extended period. The aim of this study was to discover the effect of active films based on commercially available polylactic acid blend (PLAb) and natural active components on the shelf life and organoleptic properties of chicken fillets and to find out; to what extent they can be used as replacement to the traditional packaging materials. In this study, commercially available PLAb was compounded with citral and cinnamon oil. Active films with 300 µm thickness were then produced on a blown film extruder. The PLAb-based films were thermoformed into trays. Fresh chicken breast fillets were packed under two different gas compositions, modified atmosphere packaging of 60% CO2/40% N2, and 75% O2/25% CO2 and stored at 4 °C. The effect of active packaging materials and gas compositions on the drip loss, dry matter content, organoleptic properties, and microbial quality of the chicken fillets were studied over a storage time of 24 days. The presence of active components in the compounded films was confirmed with FTIR, in addition the release of active components in the headspace of the packaging was established with GC/MS. Additionally, gas barrier properties of the packages were studied. No negative impact on the drip loss and dry matter content was observed. The results show that PLAb-based active packaging can maintain the quality of the chicken fillets and have the potential to replace the traditional packaging materials, such as APET/PE trays.

Temperature and light conditions at different latitudes affect sensory quality of broccoli florets (Brassica oleracea L. var. italica).

BACKGROUND: Broccoli (Brassica oleracea L. var. italica) is a popular vegetable grown at a wide range of latitudes. Plants were grown in 2009-2011 in pots with standardized soil, irrigation and nutrient supply under natural temperature and light conditions at four locations (42-70° N). A descriptive sensory analysis of broccoli florets was performed by a trained panel to examine any differences along the latitudinal gradient for 30 attributes within appearance, odour, taste/flavour and texture. RESULTS: Average results over three summer seasons in Germany, southern Norway and northern Norway showed that the northernmost location with low temperatures and long days had highest scores for bud coarseness and uniform colour, while broccoli from the German location, with high temperatures and shorter days, had highest intensity of colour hue, whiteness, bitter taste, cabbage flavour, stale flavour and watery flavour. Results from two autumn seasons at the fourth location (42° N, Spain), with low temperatures and short days, tended toward results from the two northernmost locations, with an exception for most texture attributes. CONCLUSION: Results clearly demonstrate that temperature and light conditions related to latitude and season affect the sensory quality of broccoli florets. Results may be used in marketing special quality regional or seasonal products. © 2016 Society of Chemical Industry.

Assessment of the action spectrum for photooxidation in full fat bovine milk.

The action spectrum for photooxidation in full fat bovine milk was measured. Samples of milk with air or argon in headspace were exposed to narrow wavelength bands of light in the range 400-700 nm. Photooxidation in terms of off-flavors was measured by a sensory panel, volatile compounds by headspace solid phase micro extraction (SPME-GC-MS), and photobleaching of photosensitizers in milk (riboflavin, protoporphyrin IX and a chlorophyllic compound) by front face fluorescence spectroscopy. The action spectrum deviated significantly from the absorption spectrum of milk. Significant oxidation was induced by wavelengths around 400 nm and 500-650 nm in milk with air in headspace. Argon in headspace gave significant oxidation also at 700 nm. It is suggested that protoporphyrin IX and chlorophyll are responsible for oxidation induced by wavelengths >500 nm, and that also riboflavin is contributing from 400 to 500 nm.

Effects of temperature and photoperiod on sensory quality and contents of glucosinolates, flavonols and vitamin C in broccoli florets.

Broccoli is grown around the world at a wide range of photoperiods and temperatures, which may influence both sensory quality and phytochemical contents. Florets produced in phytotron and at two semi-field sites (70 °N and 58 °N) were examined for effects of contrasting temperatures and photoperiods on sensory quality and contents of glucosinolates, flavonols and vitamin C. Growth conditions associated with high northern latitudes of low temperature and long photoperiods, produced bigger floral buds, and florets with sweeter taste and less colour hue than more southern conditions. The contents of vitamin C did not vary, while the response of individual glucosinolates varied with temperature and day length, and contents of quercetin and kaempferol were lower in phytotron than under semi-field conditions. Thus, our results show that contrasting temperatures and photoperiods influence the sensory quality of broccoli florets, while contents of different bioactive phytochemicals are not influenced in a unidirectional pattern.

From multispectral imaging of autofluorescence to chemical and sensory images of lipid oxidation in cod caviar paste.

The potential of multispectral imaging of autofluorescence to map sensory flavour properties and fluorophore concentrations in cod caviar paste has been investigated. Cod caviar paste was used as a case product and it was stored over time, under different headspace gas composition and light exposure conditions, to obtain a relevant span in lipid oxidation and sensory properties. Samples were divided in two sets, calibration and test sets, with 16 and 7 samples, respectively. A third set of samples was prepared with induced gradients in lipid oxidation and sensory properties by light exposure of certain parts of the sample surface. Front-face fluorescence emission images were obtained for excitation wavelength 382 nm at 11 different channels ranging from 400 to 700 nm. The analysis of the obtained sets of images was divided in two parts: First, in an effort to compress and extract relevant information, multivariate curve resolution was applied on the calibration set and three spectral components and their relative concentrations in each sample were obtained. The obtained profiles were employed to estimate the concentrations of each component in the images of the heterogeneous samples, giving chemical images of the distribution of fluorescent oxidation products, protoporphyrin IX and photoprotoporphyrin. Second, regression models for sensory attributes related to lipid oxidation were constructed based on the spectra of homogeneous samples from the calibration set. These models were successfully validated with the test set. The models were then applied for pixel-wise estimation of sensory flavours in the heterogeneous images, giving rise to sensory images. As far as we know this is the first time that sensory images of odour and flavour are obtained based on multispectral imaging.

Effects of storage atmosphere and heme state on the color and visible reflectance spectra of salmon ( Salmo salar ) fillets.

It has previously been observed that the color of mackerel muscle is dependent on the status of heme as myoglobin and hemoglobin and hence the storage atmosphere. This study gives strong indications of this being the case also in salmon. Three different storage conditions were used to promote the oxidized, reduced, and carbon monoxide (CO) bound forms of heme in salmon and mackerel fillets. Color determination (instrumental color analysis, imaging, and sensory evaluation) and spectroscopic measurements were performed to study how spectral changes corresponded to color variations. Storage in CO significantly increased the redness in mackerel. This was also seen in salmon to such a degree that it was visible over normal levels of salmon carotenoids. Air storage increased the yellowness and reduced the redness in mackerel, but this effect was partly concealed in salmon by the astaxanthin absorption. The spectral differences due to storage condition could be ascribed to the spectral features characterizing heme of different oxidation states and bound to different ligands. The status of heme should therefore always be considered when experiments related to salmon color are performed. The findings could help in the understanding, control, and prediction of color loss in salmon during processing, storage, and transport.

Effect of naturally occurring tetrapyrroles on photooxidation in cow's milk.

The objective of this work was to better understand the photosensitizing effect of riboflavin versus naturally occurring tetrapyrroles in cow's milk. This was done by exposure of milk samples to blue light (400-500 nm), which is absorbed by riboflavin and tetrapyrroles, orange light (575-750 nm), which is absorbed by tetrapyrroles but not riboflavin, and white light, which contains the entire visible region. The milk was exposed to about 1.6 W/m(2) in 20 h, and two different light sources were tested: HMI lamp and fluorescent light tubes used for commercial display. Sensory analysis showed that wavelengths longer than 575 nm induced significantly more off-flavors than wavelengths shorter than 500 nm. By fluorescence spectroscopy it was observed that tetrapyrroles, in particular, chlorophyllic compounds, were degraded more by orange light than by blue and that the degree of degradation correlated closely with the formation of sensory off-flavors. The fluorescent agent Singlet Oxygen Sensor Green (SOSG) was used to monitor the formation of singlet oxygen under the different light exposure conditions, and the method verified that singlet oxygen was formed in large proportions in milk exposed to wavelengths longer than 575 nm, presumably with minor or no involvement of riboflavin. The results suggest that cholorophyllic compounds are responsible for a major part of photooxidation in milk. It is also suggested that ß-carotene protects against photooxidation under blue light because it absorbs a major portion of the light below 500 nm and thereby reduces reactions with photosensitizers.

Assessment of the quality attributes of cod caviar paste by means of front-face fluorescence spectroscopy.

This paper describes the fluorescent behavior of cod caviar paste, stored under different conditions, in terms of light exposure and concentration of oxygen in the headspace. Multivariate curve resolution was employed to decompose the overall fluorescence spectra into pure fluorescent components and calculate the relative concentrations of these components in the different samples. Profiles corresponding to protoporphyrin IX, photoprotoporphyrin, and fluorescent oxidation products were identified. Sensory evaluation, TBARS, and analysis of volatiles are typical methods employed in the routine analysis and quality control of such food. Successful calibration models were established between fluorescence and those routine methods. Correlation coefficients higher than 0.80 were found for 79% and higher than 0.90 for 50% of the assessed odors and flavors. For instance, R values of 0.94, and 0.96 were obtained for fresh and rancid flavors respectively, and 0.89 for TBARS. On the basis of these data, it can be argued that front-face fluorescence spectroscopy can substitute all of these expensive and tedious methodologies.