An investigation into the influence of fermented cottonseed meal on the productive performance, egg quality, and gut health in laying hens.

The present study investigates the effects of replacing soybean meal (SBM) with either cottonseed meal (CSM) or fermented cottonseed meal (FCSM) on the productive performance, egg quality, blood biochemistry parameters, gut bacterial population, and small intestinal morphology of laying hens. A total of 648 Hy-Line W36 laying hens aged 40 weeks were randomly assigned to 9 treatments, with 6 replicates each and 12 birds per replicate. The feeding trial lasted 12 weeks. The treatments consisted of a control diet based on corn and SBM, as well as 8 experimental diets in which 7.5, 15, 22.5, and 30% of the SBM in the control diet was replaced with either CSM or FCSM. Laying hens fed diets with different levels of FCSM had higher egg production and egg mass than those fed with CSM diets at weeks 46 to 51 (P < 0.05). Diets containing FCSM also significantly improved the feed conversion ratio at weeks 40 to 45 and 46 to 51 (P < 0.05). Eggshell strength was significantly greater in birds fed diets containing FCSM than those fed other dietary treatments at 51 weeks of age (P < 0.05). Hens fed diets containing FCSM had higher calcium and lower cholesterol in serum than those on other diets (P < 0.05). Replacing SBM with FCSM decreased the egg yolk cholesterol content (P < 0.05). Additionally, feeding diets containing different levels of FCSM increased villus height and villus height to crypt depth in the jejunum (P < 0.05). Diets containing FCSM also reduced pH and coliform population in the ileum, and ceca and increased lactic acid bacteria count in the crop and ceca (P < 0.05). Overall, the present data showed that including FCSM in the diet of laying hens can positively affect productive performance compared to CSM. Moreover, substituting SBM with FCSM, can improve eggshell quality, promote gut health, and reduce egg yolk cholesterol concentration.

Synergistic effects of fermented soybean meal and mannan-oligosaccharide on growth performance, digestive functions, and hepatic gene expression in broiler chickens.

This study investigated the effects of fermented soybean meal (FSBM) with or without mannan-oligosaccharide (MOS) prebiotic on growth performance, digestive functions, and hepatic IGF-1 gene expression of broiler chicken. A total of 480 day-old male broiler chickens were fed with 4 experimental diets for 6 wk. Experimental diets included corn-soybean meal diet (CON); corn-soybean meal diet + MOS prebiotic [0.2%, ActiveMOS; Biorigin, Brazile]; corn-FSBM diet [soybean meal (SBM) was totally replaced by FSBM]; and corn-FSBM + MOS prebiotic (MIX). Replacing dietary SBM with FSBM with or without MOS improved body weight gain and feed efficiency for the total grow-out period. However, the addition of MOS to the FSBM diet exhibited a greater body weight gain than other experimental diets. Villus height and villus height to crypt depth of the duodenum and jejunum were increased by feeding FSBM, MOS, and MIX diets. The ileal crude protein and energy digestibilities, as well as the activities of intestinal amylase and protease, and pancreatic protease, were improved by replacing SBM with FSBM, with or without MOS. The concentration of plasma 3-methylhistidine was reduced by FSBM and MOS, and synergistically by their combination. The MOS and FSBM diets upregulated the hepatic IGF-1 gene expression. However, there was an evident synergistic effect of FSBM supplemented with MOS in the upregulation of the hepatic IGF-1 gene expression. The outcomes of the current study indicate the FSBM and MOS had the potential to improve growth performance, hepatic IGF-1 expression, and intestinal morphology of broilers. Overall, the fermented products could be considered as functional feed that exhibits probiotic effects and the synergistic effects of prebiotics added to the fermented feeds may further improve the growth performance and gut health and functionality in broiler chicken.

Evaluation of in situ valine production by Bacillus subtilis in young pigs.

Mutants of Bacillus subtilis can be developed to overproduce Val in vitro. It was hypothesized that addition of Bacillus subtilis mutants to pig diets can be a strategy to supply the animal with Val. The objective was to investigate the effect of Bacillus subtilis mutants on growth performance and blood amino acid (AA) concentrations when fed to piglets. Experiment 1 included 18 pigs (15.0±1.1 kg) fed one of three diets containing either 0.63 or 0.69 standardized ileal digestible (SID) Val : Lys, or 0.63 SID Val : Lys supplemented with a Bacillus subtilis mutant (mutant 1). Blood samples were obtained 0.5 h before feeding and at 1, 2, 3, 4, 5 and 6 h after feeding and analyzed for AAs. In Experiment 2, 80 piglets (9.1±1.1 kg) were fed one of four diets containing 0.63 or 0.67 SID Val : Lys, or 0.63 SID Val : Lys supplemented with another Bacillus subtilis mutant (mutant 2) or its parent wild type. Average daily feed intake, daily weight gain and feed conversion ratio were measured on days 7, 14 and 21. On day 17, blood samples were taken and analyzed for AAs. On days 24 to 26, six pigs from each dietary treatment were fitted with a permanent jugular vein catheter, and blood samples were taken for AA analysis 0.5 h before feeding and at 1, 2, 3, 4, 5 and 6 h after feeding. In experiment 1, Bacillus subtilis mutant 1 tended (P<0.10) to increase the plasma levels of Val at 2 and 3 h post-feeding, but this was not confirmed in Experiment 2. In Experiment 2, Bacillus subtilis mutant 2 and the wild type did not result in a growth performance different from the negative and positive controls. In conclusion, results obtained with the mutant strains of Bacillus subtilis were not better than results obtained with the wild-type strain, and for both strains, the results were not different than the negative control.

Requirement of standardized ileal digestible valine to lysine ratio for 8- to 14-kg pigs.

The objective was to define the Val requirement for weaned piglets in the context of reducing the dietary protein content. A dose-response experiment was conducted to estimate the standardized ileal digestible (SID) Val to Lys ratio required to support the optimum growth of post-weaned piglets. In this study, 96 pigs weighing 8 kg were allotted to one of six dietary treatments (16 pigs for each dietary treatment) and were housed individually. Diets were formulated to provide 0.58, 0.62, 0.66, 0.70, 0.74 and 0.78 SID Val : Lys by adding graded levels of crystalline l-Val to the 0.58 SID Val : Lys diet. Lysine was sub-limiting and supplied 90% of the recommendation (10.95 g SID Lys/kg equal to 11.8 g/kg total Lys). Average daily feed intake (ADFI), average daily gain (ADG) and gain to feed ratio (G : F) were determined during a 14-day period of ad libitum feeding. Blood and urine samples were taken at the end of each week (day 7 and 14 of the experiment) 3 h after feeding the experimental diets. The maximum ADFI and ADG were obtained in pigs fed the 0.78 SID Val : Lys diet; it was not different from the results of pigs fed 0.70 SID Val : Lys diet. The highest G : F was obtained in pigs fed 0.70 SID Val : Lys. The plasma concentration of Val increased linearly (P<0.001) as the dietary SID Val : Lys increased. The increasing dietary Val : Lys also resulted in a linear increase in Cys (P<0.001) and a quadratic increase in Arg (P=0.003), Lys (P=0.05) and Phe (P=0.009). The plasma Gly showed a quadratic decrease (P=0.05) as the dietary Val : Lys increased. Neither plasma nor urinary urea to creatinine ratio was affected by treatment. The minimum SID Val : Lys required to maximize ADFI, ADG and G : F was estimated at 0.67 SID Val : Lys by a broken-line model, and at 0.71 SID Val : Lys by a curvilinear plateau model. The Val deficiency caused a reduction in ADFI, and Val supplementation above the requirement did not impair animal performance. In conclusion, 0.70 SID Val : Lys is suggested as the Val requirement for 8 to 14 kg individually housed pigs.

The optimum ratio of standardized ileal digestible leucine to lysine for 8 to 12 kg female pigs.

The objective of the study was to estimate Leu requirement for weaned piglets to balance indispensable AA in reduced CP diets. A dose-response experiment was conducted to estimate the standardized ileal digestible (SID) Leu to Lys ratio required for the maximum growth of young pigs after weaning. In this study, 96 female pigs (initial BW of 8 kg) were allotted to 1 of 6 dietary treatments with 16 individually penned pigs per treatment. Graded levels of crystalline L-Leu were added to a basal diet to provide diets containing 0.70, 0.80, 0.90, 1.00, 1.10, and 1.20 SID Leu:Lys. Lysine was limiting and fulfilled 90% of the current recommendations. The ADFI, ADG, and G:F were determined during a 2 wk experimental period. Blood and urine samples were taken at the end of each wk. The ADFI increased linearly (P < 0.001) from 0.70 to 0.80 SID Leu:Lys and then remained constant from 0.90 to 1.20 SID Leu:Lys. The ADG showed a quadratic increase ( P= 0.02), as the SID Leu:Lys level increased from 0.70 to 0.90 SID Leu:Lys and did not change further from 0.90 to 1.20 SID Leu:Lys. The G:F increased quadratically (P < 0.001) with increasing SID Leu:Lys level, and the greatest G:F was achieved with pigs receiving the diet with 0.80 SID Leu:Lys. Increasing the dietary SID Leu:Lys resulted in a linear increase in plasma Leu concentration (P < 0.001) and quadratic increases (P < 0.001) in plasma Cys concentration. The plasma concentration of most of the other AA was lowest in pigs receiving the diets with 0.90 to 1.00 SID Leu:Lys. The plasma urea nitrogen concentration tended (P = 0.08) to be lowest in pigs receiving 1.00 SID Leu:Lys, suggesting a more balanced AA profile at this level. Using a curvilinear-plateau model, the SID Leu:Lys requirement was estimated at 0.93 to maximize growth in female pigs weighing 8 to 12 kg.