Inducer-free recombinant protein production in Trichoderma reesei: secretory production of endogenous enzymes and heterologous nanobodies using glucose as the sole carbon source.

BACKGROUND: The filamentous fungus Trichoderma reesei has been used as a host organism for the production of lignocellulosic biomass-degrading enzymes. Although this microorganism has high potential for protein production, it has not yet been widely used for heterologous recombinant protein production. Transcriptional induction of the cellulase genes is essential for high-level protein production in T. reesei; however, glucose represses this transcriptional induction. Therefore, cellulose is commonly used as a carbon source for providing its degraded sugars such as cellobiose, which act as inducers to activate the strong promoters of the major cellulase (cellobiohydrolase 1 and 2 (cbh1 and cbh2) genes. However, replacement of cbh1 and/or cbh2 with a gene encoding the protein of interest (POI) for high productivity and occupancy of recombinant proteins remarkably impairs the ability to release soluble inducers from cellulose, consequently reducing the production of POI. To overcome this challenge, we first used an inducer-free biomass-degrading enzyme expression system, previously developed to produce cellulases and hemicellulases using glucose as the sole carbon source, for recombinant protein production using T. reesei. RESULTS: We chose endogenous secretory enzymes and heterologous camelid small antibodies (nanobody) as model proteins. By using the inducer-free strain as a parent, replacement of cbh1 with genes encoding two intrinsic enzymes (aspartic protease and glucoamylase) and three different nanobodies (1ZVH, caplacizumab, and ozoralizumab) resulted in their high secretory productions using glucose medium without inducers such as cellulose. Based on signal sequences (carrier polypeptides) and protease inhibitors, additional replacement of cbh2 with the nanobody gene increased the percentage of POI to about 20% of total secreted proteins in T. reesei. This allowed the production of caplacizumab, a bivalent nanobody, to be increased to 9.49-fold (508 mg/L) compared to the initial inducer-free strain. CONCLUSIONS: In general, whereas the replacement of major cellulase genes leads to extreme decrease in the degradation capacity of cellulose, our inducer-free system enabled it and achieved high secretory production of POI with increased occupancy in glucose medium. This system would be a novel platform for heterologous recombinant protein production in T. reesei.

Inducer-free cellulase production system based on the constitutive expression of mutated XYR1 and ACE3 in the industrial fungus Trichoderma reesei.

Trichoderma reesei is a widely used host for producing cellulase and hemicellulase cocktails for lignocellulosic biomass degradation. Here, we report a genetic modification strategy for industrial T. reesei that enables enzyme production using simple glucose without inducers, such as cellulose, lactose and sophorose. Previously, the mutated XYR1V821F or XYR1A824V was known to induce xylanase and cellulase using only glucose as a carbon source, but its enzyme composition was biased toward xylanases, and its performance was insufficient to degrade lignocellulose efficiently. Therefore, we examined combinations of mutated XYR1V821F and constitutively expressed CRT1, BGLR, VIB1, ACE2, or ACE3, known as cellulase regulators and essential factors for cellulase expression to the T. reesei E1AB1 strain that has been highly mutagenized for improving enzyme productivity and expressing a ß-glucosidase for high enzyme performance. The results showed that expression of ACE3 to the mutated XYR1V821F expressing strain promoted cellulase expression. Furthermore, co-expression of these two transcription factors also resulted in increased productivity, with enzyme productivity 1.5-fold higher than with the conventional single expression of mutated XYR1V821F. Additionally, that productivity was 5.5-fold higher compared to productivity with an enhanced single expression of ACE3. Moreover, although the DNA-binding domain of ACE3 had been considered essential for inducer-free cellulase production, we found that ACE3 with a partially truncated DNA-binding domain was more effective in cellulase production when co-expressed with a mutated XYR1V821F. This study demonstrates that co-expression of the two transcription factors, the mutated XYR1V821F or XYR1A824V and ACE3, resulted in optimized enzyme composition and increased productivity.

Efficient monoacylglycerol synthesis by carboxylesterase EstGtA2 from Geobacillus thermodenitrificans in a solvent-free two-phase system.

The present study investigated high-yield monoacylglycerol (MAG) synthesis by bacterial lipolytic enzymes in a solvent-free two-phase system. Esterification by monoacylglycerol lipase from Bacillus sp. H-257 (H257) required a high glycerol/fatty acid molar ratio for efficient MAG synthesis. Screening of H257 homologues revealed that carboxylesterase derived from Geobacillus thermodenitrificans, EstGtA2, exhibited a higher esterification rate than H257. Moreover, neutralizing the pH of the acidic reaction solution by adding potassium hydroxide (KOH) solution further increased the esterification rate. The esterification rate by EstGtA2 reached 75% under conditions of equivalent molar amounts of glycerol and fatty acid, and the MAG rate (MAG/total glyceride) was 97%. The neutralized pH of the reaction solution likely affected the thermal stability of EstGtA2 during the esterification reaction. Screening for thermal-tolerant variants revealed that the EstGtA2S26I variant was stable at 75 °C for 30 min, a condition under which wild-type EstGtA2 was completely inactivated. The esterification rate by the EstGtA2S26I variant reached 90%, and the MAG rate was 96%. The addition of alkali and the use of a thermal-tolerant enzyme were important for obtaining high-yield MAG in a solvent-free two-phase system utilizing EstGtA2.

Gene manipulation in the Mucorales fungus Rhizopus oryzae using TALENs with exonuclease overexpression.

The Mucorales fungal genus Rhizopus is used for the industrial production of organic acids, enzymes and fermented foods. The metabolic engineering efficiency of Rhizopus could be improved using gene manipulation; however, exogenous DNA rarely integrates into the host genome. Consequently, a genetic tool for Mucorales fungi needs to be developed. Recently, programmable nucleases that generate DNA double-strand breaks (DSBs) at specific genomic loci have been used for genome editing in various organisms. In this study, we examined gene disruption in Rhizopus oryzae using transcription activator-like effector nucleases (TALENs), with and without exonuclease overexpression. TALENs with an overexpressing exonuclease induced DSBs, followed by target site deletions. Although DSBs are repaired mainly by nonhomologous end joining in most organisms, our results suggested that in R. oryzae microhomology-mediated end joining was the major DSB repair system. Our gene manipulation method using TALENs coupled with exonuclease overexpression contributes to basic scientific knowledge and the metabolic engineering of Rhizopus.

Disruption of alpha-tubulin releases carbon catabolite repression and enhances enzyme production in Trichoderma reesei even in the presence of glucose.

BACKGROUND: Trichoderma reesei is a filamentous fungus that is important as an industrial producer of cellulases and hemicellulases due to its high secretion of these enzymes and outstanding performance in industrial fermenters. However, the reduction of enzyme production caused by carbon catabolite repression (CCR) has long been a problem. Disruption of a typical transcriptional regulator, Cre1, does not sufficiently suppress this reduction in the presence of glucose. RESULTS: We found that deletion of an α-tubulin (tubB) in T. reesei enhanced both the amount and rate of secretory protein production. Also, the tubulin-disrupted (ΔtubB) strain had high enzyme production and the same enzyme profile even if the strain was cultured in a glucose-containing medium. From transcriptome analysis, the ΔtubB strain exhibited upregulation of both cellulase and hemicellulase genes including some that were not originally induced by cellulose. Moreover, cellobiose transporter genes and the other sugar transporter genes were highly upregulated, and simultaneous uptake of glucose and cellobiose was also observed in the ΔtubB strain. These results suggested that the ΔtubB strain was released from CCR. CONCLUSION: Trichoderma reesei α-tubulin is involved in the transcription of cellulase and hemicellulase genes, as well as in CCR. This is the first report of overcoming CCR by disrupting α-tubulin gene in T. reesei. The disruption of α-tubulin is a promising approach for creating next-generation enzyme-producing strains of T. reesei.

Comparison of Areal Productivity of Nannochloropsis oceanica Between Lab-Scale and Industrial-Scale Raceway Pond.

The areal biomass productivities (g-1 m-2 day-1) of Nannochloropsis oceanica between different sizes of way ponds were compared. Sequential batch cultivation using 2-m2, 20-m2, and 200-m2 raceway ponds with an industrial scale 4000-m2 raceway as the main culture was conducted in summer and autumn during 2017 at Whyalla, Australia. Areal productivities of sequential batch cultivation during the same culture period were 8.4 g ± 0.9 g-1 m-1 day-1 in the 2-m2 ponds, 9.3 g-1 m-1 day-1 in the 20-m2 ponds, and 8.0 g-1 m-1 day-1 in the 200-m2 ponds respectively. In parallel with the operation of the main 4000-m2 pond, some smaller scale ponds of 2, 20, and 200 m2 were operated at the same site under the same conditions. Areal productivity data of dry biomass of Nannochloropsis oceanica in each pond are very similar between industrial 4000-m2 pond and other smaller ponds. In this work, the authors demonstrate that using the growth rate and productivities of Nannochloropsis from smaller scale open ponds with the same depth is valid to estimate for large-scale ponds in excess of 4000 m2.

The hydrophobicity of an amino acid residue in a flexible loop of KP-43 protease alters activity toward a macromolecule substrate.

KP-43, a 43-kDa alkaline serine protease, is resistant to chemical oxidants and surfactants, making it suitable for use in laundry detergents. An amino acid residue at position 195, in a unique flexible loop that binds a Ca2+ ion, dramatically affects the proteolytic activity and thermal stability of KP-43. In the present study, we obtained 20 variants with substitutions at position 195 and investigated how these residues affect hydrolytic activity toward a macromolecular substrate (casein) and a synthetic tetra-peptide (AAPL). At pH 10, the variant with the highest caseinolytic activity, Tyr195Gln, exhibited 4.4-fold higher activity than the variant with the lowest caseinolytic activity, Tyr195Trp. A significant negative correlation was observed between the hydrophobicity of the residue at position 195 and caseinolytic activity at pH 8-10. At pH 7, the correlation became weak; at pH 6, the correlation reversed to positive. Unlike casein, in the case of hydrolysis of AAPL, no correlation was observed at pH 10 or pH 6. Because the amino acid residue at position 195 is located on the protein surface and considered sufficiently far from the active cleft, the variation in caseinolytic activity between the 20 variants was attributed to changes in interaction efficiency with different states of casein at different pH values. To improve the enzymatic activity, we propose substituting amino acid residues on the protein surface to change the efficiency of interaction with the macromolecular substrates. KEY POINTS: • A single amino acid residue on the protein surface markedly changed enzyme activity. • The hydrophobicity of the amino acid residue and enzyme activity had a correlation. • The key amino acid residue for substrate recognition exists on the protein surface.

Elucidation of secondary alcohol metabolism in Starmerella bombicola and contribution of primary alcohol oxidase FAO1.

The yeast Starmerella bombicola NBRC10243 is an excellent producer of sophorolipids, which are among the most useful biosurfactants. The primary alcoholic metabolic pathway of S. bombicola has been elucidated using alcohol oxidase FAO1, but the secondary alcohol metabolic pathway remains unknown. Although the FAO1 mutant was unable to grow with secondary alcohols and seemed to be involved in the secondary alcohol metabolism pathway of S. bombicola, it had very low activity toward secondary alcohols. By analyzing the products of secondary alcohol metabolism, alkyl polyglucosides hydroxylated at the ω position in the alkyl chain of the secondary alcohol were observed in the FAO1 mutant, but not in the wild-type yeast. In the double mutant of FAO1 and UGTA1, accumulation of 1,13-tetradecandiol and 2,13-tetradecandiol was observed. The above results indicated that hydroxylation occurred first at the ω and ω-1 positions in the secondary alcohol metabolism of S. bombicola, followed by primary alcohol oxidation.

Variants of the industrially relevant protease KP-43 with suppressed activity under alkaline conditions developed using expanded genetic codes.

In the present study, we attempted to control the pH profile of the catalytic activity of the industrially relevant alkaline protease KP-43, by incorporating 3-nitro-l-tyrosine and 3-chloro-l-tyrosine at and near the catalytic site. Thirty KP-43 variants containing these non-natural amino acids at the specific positions were synthesized in Escherichia coli host cells with expanded genetic codes. The variant with 3-nitrotyrosine at position 205, near the substrate binding site, retained its catalytic activity at the neutral pH and showed a 60% activity reduction at pH 10.5. This reduction in the alkaline domain is desirable for enhancing the stability of the enzyme in the liquid laundary detergent, whereas the wild-type molecule showed a 20% increase in response to the same pH shift. The engineered pH dependency of the activity of the variant was ascribed partly to a lowered substrate affinity under the alkaline conditions, in which the incorporated 3-nitrotyrosine was probably charged negatively due to the phenolic pK a lower than that of tyrosine.

Effects of inactivation of the cyAbrB2 transcription factor together with glycogen synthesis on cellular metabolism and free fatty acid production in the cyanobacterium Synechocystis sp. PCC 6803.

Deletion of the cyAbrB2 (Sll0822) transcription factor in Synechocystis sp. PCC 6803 causes aberrant accumulation of glycogen. We previously tried to redirect the excess carbon stored as glycogen in the cyabrB2-disrupted (∆ cyabrB2) mutant by knockout of the glgC (slr1176) gene encoding glucose-1-phosphate adenylyltransferase. However, complete knockout could not be attained, suggesting that accumulation of glycogen is essential for the Δ cyabrB2 mutant. In this study, we introduced the cyabrB2 gene fused to the copper-inducible petE promoter into the ∆ cyabrB2 mutant. After complete knockout of glgC in the presence of copper, expression of P petE- cyabrB2 was turned off by copper removal to examine the effect of the double knockout of cyabrB2 and glgC. Metabolome analysis and electron microscopic observation revealed that the double knockout causes a large decrease of sugar phosphates in glycolytic and oxidative pentose phosphate pathways and an increase of organic acids in the tricarboxylic acid cycle, amino acids and storage compounds such as polyhydroxybutyrate. When the ability of production of free fatty acids was conferred, synergetic positive effects of knockout of cyabrB2 and glgC on productivity were observed by removal of both copper and nitrogen. The P petE- cyabrB2Δ glgC strain will further serve as a platform for studies on carbon allocation and metabolic engineering.

Poly-L-gamma-glutamic acid production by recombinant Bacillus subtilis without pgsA gene.

Poly-gamma-glutamic acid (PGA) is a promising bio-based polymer that shares many functions with poly (acrylic acid) and its derivatives. Thus, technologies for efficient production and molecular size control of PGA are required to expand the application of this useful biopolymer. In Bacillus strains, PGA is synthesized by the PgsBCA protein complex, which is encoded by the pgsBCA gene operon, otherwise is known as ywsC and ywtAB operons and/or capBCA operon. Hence, we investigated responsible components of the PgsBCA complex in B. subtilis for over-production of PGA. In particular, we constructed genomic pgsBCA gene-deletion mutants of B. subtilis. And also, we assembled high copy-number plasmids harboring σA-dependent promoter, leading to high-level expression of all combinations of pgsBCA, pgsBC, pgsBA, pgsCA, pgsB, pgsC, and/or pgsA genes. Subsequently, PGA production of the transformed B. subtilis mutant was determined in batch fermentation using medium supplemented with L-glutamate. PGA production by the transformants introduced with pgsBC genes (lacking the genomic pgsBCA genes) was 26.0 ± 3.0 g L-1, and the enantiomeric ratio of D- and L-glutamic acid (D/L-ratio) in the produced PGA was 5/95. In contrast, D/L-ratio of produced PGA by the transformants introduced with pgsBCA genes (control strains) was 75/25. In conclusion, B. subtilis without pgsA gene could over-produce PGA with an L-rich enantiomeric ratio.

A novel GH10 xylanase from Penicillium sp. accelerates saccharification of alkaline-pretreated bagasse by an enzyme from recombinant Trichoderma reesei expressing Aspergillus ß-glucosidase.

BACKGROUND: Trichoderma reesei is considered a candidate fungal enzyme producer for the economic saccharification of cellulosic biomass. However, performance of the saccharifying enzymes produced by T. reesei is insufficient. Therefore, many attempts have been made to improve its performance by heterologous protein expression. In this study, to increase the conversion efficiency of alkaline-pretreated bagasse to sugars, we conducted screening of biomass-degrading enzymes that showed synergistic effects with enzyme preparations produced by recombinant T. reesei. RESULTS: Penicillium sp. strain KSM-F532 produced the most effective enzyme to promote the saccharification of alkaline-pretreated bagasse. Biomass-degrading enzymes from strain KSM-F532 were fractionated and analyzed, and a xylanase, named PspXyn10, was identified. The amino acid sequence of PspXyn10 was determined by cDNA analysis: the enzyme shows a modular structure consisting of glycoside hydrolase family 10 (GH10) and carbohydrate-binding module family 1 (CBM1) domains. Purified PspXyn10 was prepared from the supernatant of a recombinant T. reesei strain. The molecular weight of PspXyn10 was estimated to be 55 kDa, and its optimal temperature and pH for xylanase activity were 75 °C and pH 4.5, respectively. More than 80% of the xylanase activity was maintained at 65 °C for 10 min. With beechwood xylan as the substrate, the enzyme had a Km of 2.2 mg/mL and a Vmax of 332 µmol/min/mg. PspXyn10ΔCBM, which lacked the CBM1 domain, was prepared by limited proteolysis. PspXyn10ΔCBM showed increased activity against soluble xylan, but decreased saccharification efficiency of alkaline-pretreated bagasse. This result indicated that the CBM1 domain of PspXyn10 contributes to the enhancement of the saccharification efficiency of alkaline-pretreated bagasse. A recombinant T. reesei strain, named X2PX10, was constructed from strain X3AB1. X3AB1 is an Aspergillus aculeatus ß-glucosidase-expressing T. reesei PC-3-7. X2PX10 also expressed PspXyn10 under the control of the xyn2 promoter. An enzyme preparation from X2PX10 showed almost the same saccharification efficiency of alkaline-pretreated bagasse at half the enzyme dosage as that used for an enzyme preparation from X3AB1. CONCLUSIONS: Our results suggest that PspXyn10 promotes the saccharification of alkaline-pretreated bagasse more efficiently than TrXyn3, a GH10 family xylanase from T. reesei, and that the PspXyn10-expressing strain is suitable for enzyme production for biomass saccharification.

The LexA transcription factor regulates fatty acid biosynthetic genes in the cyanobacterium Synechocystis sp. PCC 6803.

Specific transcription factors have been identified in various heterotrophic bacterial species that regulate the sets of genes required for fatty acid metabolism. Here, we report that expression of the fab genes, encoding fatty acid biosynthetic enzymes, is regulated by the global regulator LexA in the photoautotrophic cyanobacterium Synechocystis sp. PCC 6803. Sll1626, an ortholog of the well-known LexA repressor involved in the SOS response in heterotrophic bacteria, was isolated from crude extracts of Synechocystis by DNA affinity chromatography, reflecting its binding to the upstream region of the acpP-fabF and fabI genes. An electrophoresis mobility shift assay revealed that the recombinant LexA protein can bind to the upstream region of each fab gene tested (fabD, fabH, fabF, fabG, fabZ and fabI). Quantitative RT-PCR analysis of the wild type and a lexA-disrupted mutant strain suggested that LexA acts as a repressor of the fab genes involved in initiation of fatty acid biosynthesis (fabD, fabH and fabF) and the first reductive step in the subsequent elongation cycle (fabG) under normal growth conditions. Under nitrogen-depleted conditions, downregulation of fab gene expression is partly achieved through an increase in LexA-repressing activity. In contrast, under phosphate-depleted conditions, fab gene expression is upregulated, probably due to the loss of repression by LexA. We further demonstrate that elimination of LexA largely increases the production of fatty acids in strains modified to secrete free fatty acids.

RNA-seq Profiling Reveals Novel Target Genes of LexA in the Cyanobacterium Synechocystis sp. PCC 6803.

LexA is a well-established transcriptional repressor of SOS genes induced by DNA damage in Escherichia coli and other bacterial species. However, LexA in the cyanobacterium Synechocystis sp. PCC 6803 has been suggested not to be involved in SOS response. In this study, we performed RNA-seq analysis of the wild-type strain and the lexA-disrupted mutant to obtain the comprehensive view of LexA-regulated genes in Synechocystis. Disruption of lexA positively or negatively affected expression of genes related to various cellular functions such as phototactic motility, accumulation of the major compatible solute glucosylglycerol and subunits of bidirectional hydrogenase, photosystem I, and phycobilisome complexes. We also observed increase in the expression level of genes related to iron and manganese uptake in the mutant at the later stage of cultivation. However, none of the genes related to DNA metabolism were affected by disruption of lexA. DNA gel mobility shift assay using the recombinant LexA protein suggested that LexA binds to the upstream region of pilA7, pilA9, ggpS, and slr1670 to directly regulate their expression, but changes in the expression level of photosystem I genes by disruption of lexA is likely a secondary effect.

Free fatty acid production in the cyanobacterium Synechocystis sp. PCC 6803 is enhanced by deletion of the cyAbrB2 transcriptional regulator.

The cyAbrB2 (Sll0822) transcriptional regulator in Synechocystis sp. PCC 6803 is involved in coordination of carbon and nitrogen metabolism and its deletion causes distinct phenotypes such as decreased expression levels of nitrogen-regulated genes and high accumulation of glycogen granules. From the viewpoint of metabolic engineering, the highly accumulated glycogen granules in the ΔcyabrB2 mutant could be a valuable source for the production of biofuels. Here, by disruption of the aas gene (slr1609) encoding acyl-acyl carrier protein synthetase and introduction of a gene encoding thioesterase from Umbellularia californica (UcTE), we conferred the ability of production and secretion of free fatty acids on the ΔcyabrB2 mutant. Notable features of the resulting ΔcyabrB2Δaas::UcTE strain compared with ΔcyabrB2 by RNA-seq analysis were decrease in expression levels of genes related to uptake and subsequent metabolism of nitrogen and carbon and increase in the expression level of sigE encoding a group 2 sigma factor. These changes in gene expression profile were not observed when the same genetic modification was introduced in the wild-type background. The ΔcyabrB2Δaas::UcTE strain showed two-folds higher free fatty acid productivity on a per OD730 basis compared with the Δaas::UcTE strain, without expense of the accumulated glycogen granules. This shows the potential of the ΔcyabrB2 mutant as the platform of biofuel production. The effective utilization of the accumulated glycogen must be the next task to be pursued.

Achlorophyllous alga Prototheca zopfii oxidizes n-alkanes with different carbon-chain lengths through a unique subterminal oxidation pathway.

Some Prototheca spp. were previously reported to convert n-hexadecane to 5-hexadecanol and then to 5-hexadecanone through a unique subterminal oxidation pathway. Further analysis of derivatives derived from n-hexadecane indicated that Prototheca zopfii oxidized n-alkanes with C11 to C17 chain lengths at not only the 5th but also the 4th, 3rd and 2nd positions.

Subterminal oxidation of n-alkanes in achlorophyllous alga Prototheca sp.

Some Prototheca sp. are known to be involved in n-hexadecane degradation. Two derivatives derived from n-hexadecane in such Prototheca sp. were identified as 5-hexadecanone and 5-hexadecanol. n-Hexadecane was assumed to be converted to 5-hexadecanol and then to 5-hexadecanone through a unique subterminal oxidation pathway in such Prototheca sp.

Alkaliphilic Bacillus sp. strain KSM-LD1 contains a record number of subtilisin-like serine proteases genes.

The presence of 11 genes encoding subtilisin-like serine proteases was demonstrated by cloning from the genome of alkaliphilic Bacillus sp. strain KSM-LD1. This strain exoproduces the oxidatively stable alkaline protease LD-1 (Saeki et al. Curr Microbiol, 47:337-340, 2003). Among the 11 genes, six genes encoding alkaline proteases (SA, SB, SC, SD, SE, and LD-1) were expressed in Bacillus hosts. However, the other five genes for subtilisin-like proteases (SF, SG, SH, SI, and SJ) were expressed in neither Bacillus hosts nor Escherichia coli. The deduced amino acid sequences of SA, SB, SC, SF, SG, SH, SI, and SJ showed similarity to those of other subtilisin-like proteases from Bacillus strains with only 38 to 86% identity. The deduced amino acid sequence of SD was completely identical to that of an oxidatively stable alkaline protease from Bacillus sp. strain SD521, and that of SE was almost identical to that of a high-molecular mass subtilisin from Bacillus sp. strain D-6 with 99.7% identity. There are four to nine subtilisin-like serine protease genes in the reported genomes of Bacillus strains. At least 11 genes for the enzymes present in the genome of Bacillus sp. strain KSM-LD1, and this is the greatest number identified to date.

A new subtilisin family: nucleotide and deduced amino acid sequences of new high-molecular-mass alkaline proteases from Bacillus spp.

Six genes encoding high-molecular-mass subtilisins (HMSs) of alkaliphilic Bacillus spp. were cloned and sequenced. Their open reading frames of 2,394-2,424 bp encoded prosubtilisins of 798-808 amino acids (aa) consisting of the prepropeptides of 151-158 aa and the mature enzymes of 640-656 aa. The deduced aa sequences of the mature enzymes exhibited 60-95% identity to those of FT protease of Bacillus sp. strain KSM-KP43, a subtilisin-like serine protease, and a minor serine protease, Vpr, of Bacillus strains. Three of the six recombinant enzymes were susceptible to proteolysis, but the others were autodigestion resistant. All enzymes had optimal pH values of 10.5-11.0, optimal temperatures of 40-45 degrees C for hydrolysis of a synthetic substrate, and were heat labile. These alkaline proteases seem to form a new subtilisin family, as judged by their aa sequences and phylogenetic analysis.

Nucleotide and deduced amino acid sequences of a new subtilisin from an alkaliphilic Bacillus isolate.

The gene for a new subtilisin from the alkaliphilic Bacillus sp. KSM-LD1 was cloned and sequenced. The open reading frame of the gene encoded a 97 amino-acid prepro-peptide plus a 307 amino-acid mature enzyme that contained a possible catalytic triad of residues, Asp32, His66, and Ser224. The deduced amino acid sequence of the mature enzyme (LD1) showed approximately 65% identity to those of subtilisins SprC and SprD from alkaliphilic Bacillus sp. LG12. The amino acid sequence identities of LD1 to those of previously reported true subtilisins and high-alkaline proteases were below 60%. LD1 was characteristically stable during incubation with surfactants and chemical oxidants. Interestingly, an oxidizable Met residue is located next to the catalytic Ser224 of the enzyme as in the cases of the oxidation-susceptible subtilisins reported to date.