Comparing tryptophan:lysine ratios in dried distillers grains with solubles-based diets with and without a dried distillers grains with solubles withdrawal strategy on growth, carcass characteristics, and carcass fat iodine value of growing-finishing pigs.

A total of 6,240 finishing pigs (DNA 600 × PIC 1050; initially 22.5 ±â€…1.00 kg), divided into two groups, were used in a 119 or 120 d study comparing increasing Trp:Lys ratio in diets containing dried distillers grains with solubles (DDGS) or a DDGS withdrawal strategy (removing all DDGS from the last phase before marketing) on growth performance and carcass fat iodine value (IV). Pigs were randomly allotted to one of seven dietary treatments with 30 to 36 pigs per pen and 26 replications per treatment. Diets were fed in four phases, approximately 23 to 44, 44 to 71, 71 to 100, and 100 kg to market. Diets included a control corn-soybean meal-based diet (no DDGS) formulated to a 19% standardized ileal digestibility (SID) Trp:Lys ratio, four diets with 30% DDGS fed in all four phases and formulated to provide SID Trp:Lys ratios of 16%, 19%, 22%, or 25%, and two DDGS withdrawal strategy diets: 19% SID Trp:Lys with 30% DDGS in phases 1 through 3 and then 0% DDGS in phase 4 with either a 19% or 25% Trp:Lys ratio. Overall, body weight (BW), average daily gain (ADG), average daily feed intake (ADFI), and gain:feed ratio (G:F) increased (linear, P < 0.05) as SID Trp:Lys ratio increased in diets with 30% DDGS fed in all phases. Simultaneously, hot carcass weight (quadratic, P = 0.014), carcass yield (quadratic, P = 0.012), and backfat depth (linear, P = 0.040) increased with increasing Trp:Lys ratio. Pigs fed the 19% SID Trp:Lys ratio withdrawal strategy diet had similar ADG and ADFI as those fed the control diet, the 25% Trp:Lys withdrawal diet, or the 30% DDGS diets with 25% Trp:Lys ratio throughout the study. Pigs fed the control diet had decreased (P < 0.05) carcass fat IV compared to pigs fed the DDGS diets throughout the study, with pigs fed the two DDGS withdrawal strategy diets intermediate. In summary, increasing the SID Trp:Lys ratio in diets with 30% DDGS resulted in a linear increase in ADG, ADFI, G:F, and BW but did not influence carcass fat IV, with most of the benefits observed as diets increased from 16% to 19% Trp:Lys. Removing DDGS from the diet in the last period reduced carcass fat IV and increased growth rate during the withdrawal period compared to pigs fed with 30% DDGS throughout, indicating value in a withdrawal strategy.

Feeding high levels of dried distillers grains with solubles (DDGS) up to marketing has been found to have negative impacts on growth performance and carcass characteristics of finishing pigs, specifically carcass yield. High inclusion of DDGS has also been shown to increase iodine value (IV), a measurement of fat quality, due to increased deposition of unsaturated fatty acids. However, recent data suggested that when feeding finishing pigs diets containing DDGS, increasing the standardized ileal digestible Trp:Lys ratio well above the NRC requirement estimates can prevent or lessen some of these negative effects. This study compared removing DDGS from the final dietary phase with two levels of Trp:Lys ratio, commonly referred to as a withdrawal strategy, to increasing levels of Trp:Lys in diets containing 30% DDGS. The results of this study indicate that increasing the Trp:Lys ratio in diets containing DDGS to a 25% Trp:Lys ratio resulted in growth performance similar to the control diet and the withdrawal strategy, with most of the benefits observed when Trp:Lys is increased from a deficient to adequate status. However, feeding diets with DDGS up to market resulted in increased IV.

Evaluation of increasing digestible threonine to lysine ratio in corn-soybean meal diets without and with distillers dried grains with solubles on growth performance of growing-finishing pigs.

Corn distillers dried grains with solubles (DDGS) is commonly available and often can lower diet cost for swine diets. This corn co-product is recognized to be a source of dietary insoluble fiber, which can not only increase the villous length of the gut mucosa but also increase intestinal production of mucin. Mucin structure, functions, and synthesis are correlated to Thr intake; consequently, the dietary Thr level may need to be increased when feeding an insoluble fiber source such as corn-DDGS. Thus, the objective of this study was to evaluate if feeding standardized ileal digestible (SID) Thr:Lys ratio at or above the estimated requirement in diets without and with DDGS would influence growth performance in finishing pigs. A total of 2,160 pigs (PIC 337 × 1,050; initially 35.1 ± 0.5 kg) were used in a 112-d growth trial. Pigs were randomly assigned to pens (27 pigs per pen) in a randomized complete block design by body weight (BW) with 20 replications per treatment. Pens of pigs were allotted to one of four dietary treatments that were arranged in a 2 × 2 factorial with main effects of dietary Thr level (normal vs. high) and DDGS (without or with). Treatment diets were formulated in four phases from 34 to 57, 57 to 79, 79 to 104, and 104 to 130 kg BW. Diets with high DDGS were formulated to include 40% DDGS in phases 1 and 2, 30% in phase 3, and 15% in phase 4. The normal Thr diets were formulated to contain 61%, 62%, 63%, and 65% SID Thr:Lys ratios for the four dietary phases, respectively. High Thr diets had SID Thr:Lys ratios of 67%, 68%, 69%, and 72%, respectively. There were no interactions (P > 0.10) observed in any phase or overall between Thr level and added DDGS. For the overall period (day 0 to 112), pigs fed diets without DDGS had increased (P < 0.001) average daily gain (ADG) but reduced (P < 0.001) average daily feed intake (ADFI), leading to increased (P < 0.001) feed efficiency (gain-to-feed ratio [G:F]). There was no evidence for difference (P > 0.10) between pigs fed diets formulated at normal or high SID Thr:Lys ratio. In summary, feeding high levels of DDGS decreased ADG and increased ADFI, which resulted in decreased G:F and lower final BW, regardless of the dietary SID Thr:Lys ratio level. In the current study, increasing the level of digestible Thr in a diet that contained a highly insoluble fiber source did not increase the growth performance of grow-finish pigs.

Effects of reducing the standardized ileal digestible lysine and tryptophan to lysine ratio to slow growth of finishing pigs.

The COVID-19 global pandemic greatly affected pork processing plants in the United States. These pork processing plants were forced to either temporarily close or operate at reduced capacity due to the increased number of health-related employee absences. Because finishing pigs could not be timely marketed, methods to reduce growth performance were required to keep pigs from becoming too heavy at slaughter weight. Therefore, our objective was to determine the extent that reducing dietary standardized ileal digestible (SID) Lys and tryptophan-to-lysine ratio (Trp:Lys) ratio would slow finishing pig average daily gain (ADG) in a commercial setting. A total of 1,080 finishing pigs (327 × 1050, PIC; initially 32.3 kg) were used in a 119-d growth trial. Pigs were allotted by initial body weight (BW) and randomly assigned to 1 of 4 dietary treatments in a completely randomized block design with 27 pigs per pen and 10 pens per treatment. Three dietary regimes were formulated to contain either 100%, 90%, or 80% of the estimated SID Lys requirement for pigs in this facility, with a SID Trp:Lys ratio of 19%, with the exception of the last dietary phase formulated to 17% SID Trp:Lys. Seven different dietary phases were fed. The SID Lys concentrations in the 100% diets were: 1.10%, 1.01%, 0.91%, 0.83%, 0.79%, 0.71%, or 0.67% SID Lys from 32 to 40, 40 to 51, 51 to 72, 72 to 85, 85 to 98, 98 to 112, and 112 to 130 kg, respectively. A fourth regime was formulated to 80% SID Lys with a SID Trp:Lys ratio of 16% (80-16% SID Trp:Lys) throughout all phases. Overall from d 0 to 119, ADG (linear, P < 0.001), final BW (linear, P < 0.001), and gain-to-feed (G:F) decreased (linear, P = 0.087) as SID Lys decreased from 100% to 80% of the estimated requirement. Pigs fed the 80-16% SID Trp:Lys diets had an additional decrease in ADG (P < 0.05) and G:F (P < 0.10) compared with pigs fed 80% of the SID Lys requirement with the normal Trp:Lys ratio. The reduction in SID Lys (from 100% to 80%) and reduction in SID Lys and Trp:Lys ratio resulted in an 8.6 and 11.7 kg, respectively, decrease in final BW compared with pigs fed Lys and Trp at the requirement (100%). This study provides alternatives for pork producers to reduce growth rate of finishing pigs.

Effect of drying and warming piglets at birth on preweaning mortality.

Piglets are susceptible to hypothermia early after birth, which is a major predisposing factor for preweaning mortality (PWM). Drying and warming piglets at birth has been shown to reduce early postnatal temperature decline. This study evaluated the effect of drying and warming piglets at birth on PWM and weaning weight (WW) under commercial conditions. A completely randomized design was used with 802 sows/litters (10,327 piglets); sows/litters were randomly allotted at start of farrowing to one of two Intervention Treatments (applied at birth): Control (no drying or warming); Drying+Warming (dried with a cellulose-based desiccant and placed in a box under a heat lamp for 30 min). Piglets were weighed at birth and weaning; PWM was recorded. Rectal temperature was measured at 0 and 30 min after birth on all piglets in a subsample of 10% of litters. The effect of farrowing pen temperature (FPT) on WW and PWM was evaluated by comparing litters born under COOL (<25°C) to those born under WARM (≥25°C) FPT. The effect of birth weight on WW and PWM was evaluated by comparing three birth weight categories (BWC; Light: <1.0 kg, Medium: 1.0 to 1.5 kg, or Heavy: >1.5 kg). PROC GLIMMIX and MIXED of SAS were used to analyze mortality and other data, respectively. Litter was the experimental unit; piglet was a subsample of litter. The model included fixed effects of Intervention Treatment, and FPT or BWC as appropriate, the interaction, and the random effects of litter. Piglet rectal temperature at 30 min after birth was greater (P ≤ 0.05) for the Drying+Warming than the Control treatment (+2.33°C). Overall, there was no effect (P > 0.05) of Intervention Treatment on PWM or WW, and there were no Intervention Treatment by BWC interactions (P > 0.05) for these measurements. There was an Intervention Treatment by FPT interaction (P ≤ 0.05) for PWM. Drying and warming piglets reduced (P ≤ 0.05) PWM under COOL (by 2.4 percentage units) but not WARM FPT. In addition, WW were lower (P ≤ 0.05) under WARM (by 0.79 kg) than COOL FPT; however, there was no interaction (P > 0.05) with Intervention Treatment. In conclusion, this study suggests that drying and warming piglets at birth increases rectal temperature and may reduce PWM under cooler conditions, which are typically experienced in temperate climates during the majority of the year.

A Meta-Analysis to Understand the Relationship between Pig Body Weight and Variation from Birth to Market.

This meta-analysis aims to understand the changes in pig body weight (BW) variation from birth to market and develop prediction equations for coefficient of variation (CV) and standard deviation (SD) as a function of BW. Standard deviation is the measure of dispersion of a set of values from the mean and CV is the SD expressed as a percentage of the mean. Data collected from 16 papers and data sets yielded 117,268 individually weighed pigs with sample size ranging from 120 to 4108 pigs. Polynomial regression analysis was conducted separately for each variation measurement. The resulting prediction equations (CV (%) = 20.04 - 0.135 × (BW) + 0.00043 × (BW)2, R2 = 0.79; SD = 0.41 + 0.150 × (BW) - 0.00041 × (BW)2, R2 = 0.95) suggest that there is a quadratic decreasing relationship between the CV of a population and BW, the slope gets smaller as mean BW increases from birth to market. A quadratic increasing relationship is observed for SD, with slope being smaller as mean BW of pigs increases from birth to market. These prediction equations can be used by swine producers to estimate expected CV and SD of BW among a population of pigs.

Effects of drying and providing supplemental oxygen to piglets at birth on rectal temperature over the first 24 h after birth.

Neonatal piglets can experience both a decrease in body temperature and hypoxia, increasing risks for pre-weaning mortality. This research evaluated the effects of drying and providing supplemental oxygen to newborn piglets on rectal temperature (RT) over the first 24 h after birth. The study used a CRD with three Intervention Treatments (IT; applied at birth): Control (no intervention), Drying (dried using a desiccant), Oxygen [dried using a desiccant and placed in a chamber (at 40% oxygen concentration) for 20 min]. A total of 42 litters (485 piglets) were randomly allotted to treatments at the start of farrowing. At birth, each piglet was given a numbered ear tag, weighed, and the treatment was applied; RT was measured at 0, 20, 30, 45, 60, 120, and 1440 min after birth. Blood was collected from one piglet from each birth weight quartile within each litter at 24 h after birth to measure plasma immunocrit concentration. There was no effect (P > 0.05) of IT on piglet RT at 0 or 1440 min after birth. Between 20 and 60 min after birth, piglet RT was lower (P ≤ 0.05) for the Control than the Drying treatment, with the Oxygen treatment being intermediate and different (P ≤ 0.05) from the other two IT. The effect of piglet birth weight on responses to IT were evaluated by classifying piglets into Birth Weight Categories (BWC): Light (<1.0 kg), Medium (1.0 to 1.5 kg), or Heavy (>1.5 kg). There were IT by BWC interactions (P ≤ 0.05) for piglet RT at all measurement times between 20 and 120 min after birth. Relative to the Control, the effects of the Drying and Oxygen treatments on RT were greater (P ≤ 0.05) for Light than heavier piglets. Plasma immunocrit concentrations tended (P = 0.07) to be greater for piglets on the Control treatment compared to the other two IT and were lower (P ≤ 0.05) for Light than Heavy piglets, with Medium piglets being intermediate and different (P ≤ 0.05) to the other BWC. In conclusion, drying piglets at birth reduced the extent and duration of RT decline in piglets in the early postnatal period compared to undried piglets, especially for those of low birth weight. However, the combination of drying and placing piglets in an oxygen-rich environment provided no additional benefit over drying alone.

Effect of drying and/or warming piglets at birth under warm farrowing room temperatures on piglet rectal temperature over the first 24 h after birth.

Piglets experience a decline in body temperature immediately after birth, and both drying and warming piglets at birth reduce this. However, these interventions may be less effective at higher farrowing room temperatures. This study was carried out at a commercial facility to compare the effect of drying and/or warming piglets at birth on postnatal rectal temperature (RT) under relatively warm farrowing room temperatures (26.6 ± 2.09 °C). Forty-five sows/litters were used in a completely randomized design to compare three Intervention Treatments (applied at birth): Control (no treatment); Warming (piglets placed in a plastic box under a heat lamp for 30 min); and Drying+Warming (piglets dried with desiccant and warmed as above). Temperatures in the warming boxes over the study period averaged 37.7 ± 2.75 °C. At birth, piglets were weighed; RT temperature was measured at 0, 10, 20, 30, 45, 60, 120, and 1,440 min after birth. Blood samples were collected at 24 h after birth from a subsample of one piglet from each birth weight quartile within each litter to measure plasma immunocrit concentration. Data were analyzed using PROC MIXED of SAS with litter as the experimental unit, and piglet as a subsample of litter. The model for analysis of piglet rectal temperature included fixed effects of Intervention Treatment, measurement time (repeated measure), the interaction, and the random effect of sow. Compared with the Control, piglet RT were higher (P ≤ 0.05) for the Warming treatment between 10 and 60 min, and higher (P ≤ 0.05) for the Drying+Warming treatment between 10 and 120 min after birth. Rectal temperatures were higher (P ≤ 0.05) for the Drying+Warming than the Warming treatment between 20 and 120 min. Responses to drying and/or warming were greater for low-birth-weight piglets (<1.0 kg) than heavier littermates, but were generally less than observed in previous experiments with similar treatments carried out under cooler temperatures. Piglet immunocrit values were lower (P ≤ 0.05) for the Drying+Warming treatment compared to the other Intervention Treatments, which were similar (P > 0.05). Immunocrit values tended (P = 0.10) to be lower for light (<1.0 kg) compared with heavier birth weight piglets. In conclusion, drying and warming piglets at birth was more effective for reducing piglet RT decline after birth than warming alone, though the effect was less than observed in previous studies carried out under cooler farrowing room temperatures.

Effect of method of drying piglets at birth on rectal temperature over the first 24 h after birth.

Piglets are born wet, and evaporation of that moisture decreases body temperature, increasing the risk of mortality. The objective of this study was to compare the effect of two commercially applicable methods for drying piglets at birth on piglet rectal temperature over 24 h after birth. The study was carried out in standard commercial farrowing facilities with 52 litters, using a completely randomized design with three Drying Treatments: Control (not dried); Desiccant (dried at birth using a cellulose-based desiccant); Paper Towel (dried at birth using paper towels). Litters were randomly allotted to treatments at the birth of the first piglet. At birth, piglets were individually identified, and the treatment was applied. Rectal temperature was measured at 0, 10, 20, 30, 45, 60, 120, and 1,440 min (24 h) after birth. Data were analyzed using a repeated measures model with PROC MIXED of SAS, with litter as the experimental unit and piglet a subsample of the litter. The model included the fixed effects of treatment and time (as a repeated measure), and the interaction. There was no effect (P > 0.05) of treatment on temperature at birth, or 10 or 1,440 min after birth. Piglet temperatures between 20 and 120 min after birth were similar (P > 0.05) for the Desiccant and Paper Towel treatments, but were greater (P ≤ 0.05) than the Control. The effect of birth weight on the response to Drying Treatment was evaluated by dividing the data into Light (<1.0 kg), Medium (1.0 to 1.5 kg), or Heavy (>1.5 kg) piglet Birth Weight Categories. Piglet rectal temperature data at each measurement time were analyzed using a model that included the fixed effects of Birth Weight Category, Drying Treatment, and the interaction. Temperatures of Light piglets were lower (P ≤ 0.05) than those of Heavy piglets between 20 and 120 min after birth, with Medium piglets being intermediate and generally different to the other two weight categories at these times. The difference in temperature between Light as compared with Medium or Heavy piglets was greater for the Control than the other two Drying Treatments at 60 min after birth. These results suggest that drying piglets at birth is an effective method to reduce rectal temperature decline in the early postnatal period, especially for low birth weight piglets.

Effect of drying and/or warming piglets at birth on rectal temperature over the first 24 h after birth.

Piglets experience a rapid decrease in body temperature immediately after birth, increasing the risk of mortality. The objective of this study was to determine the effect of drying and/or warming piglets at birth on rectal temperature over the first 24 h after birth. The study was carried out at a commercial sow facility using a completely randomized design with four treatments (applied to piglets at birth): Control (no drying or warming), Desiccant (dried using a desiccant), Warming Box (placed in a box under a heat lamp for 30 min), and Desiccant + Warming Box (both dried and warmed as above). Farrowing pens had one heat lamp, temperatures under which were similar to the warming box (35 °C). A total of 68 litters (866 piglets) were randomly allotted to a treatment at the birth of the first piglet. At birth, each piglet was identified with a numbered ear tag and weighed; rectal temperature was measured at 0, 10, 20, 30, 45, 60, 120, and 1,440 min after birth. Data were analyzed using a repeated-measures model using PROC MIXED of SAS. Litter was the experimental unit, piglet was a subsample of the litter; and the model included the fixed effects of treatment, time (the repeated measure), and the interaction. Rectal temperatures at birth and 1,440 min after birth were similar (P > 0.05) for all treatments. At all times between 10 and 120 min after birth, Control piglets had lower (P ≤ 0.05) temperatures than the other three treatments. The Desiccant and Warming Box treatments had similar (P > 0.05) temperatures at most measurement times, but the Desiccant + Warming Box treatment had the highest (P ≤ 0.05) rectal temperatures at most times between 10 and 60 min. In addition, for all treatments, light (<1.0 kg) birth weight piglets had lower (P ≤ 0.05) temperatures than medium (1.0-1.5 kg) or heavy (>1.5 kg) piglets at all times between 10 and 120 min. In addition, at these measurement times, the deviation in temperature between the Control and the other three treatments was greater for light than medium or heavy piglets. In conclusion, both drying and warming piglets at birth significantly increased rectal temperatures between 10 and 120 min after birth, with the combination of the two interventions having the greatest effect, especially for low birth weight piglets.